Day: September 22, 2024

---

INSTANT DOWNLOAD

---

Complete workshop repair service manual with electrical wiring diagrams for Infiniti G20 (P11) 1999-2002. It’s the same service manual used by dealers that guaranteed to be fully functional and intact without any missing page.

This Infiniti G20 (P11-series) 1999-2002 service repair manual (including maintenance, overhaul, disassembling & assembling, adjustment, tune-up, operation, inspecting, diagnostic & troubleshooting…) is divided into different sections. Each section covers a specific component or system with detailed illustrations. A table of contents is placed at the beginning of each section. Pages are easily found by category, and each page is expandable for great detail. The printer-ready PDF documents work like a charm on all kinds of devices.

TABLE OF CONTENTS
QR….2
ENGINE….2
A/T….5
M/T….7
HEATER / AC….10
SUSPENSION….13
BRAKES….16
ELECTRICAL….19
at….22
Table of Contents….22
TROUBLE DIAGNOSIS – INDEX….25
Alphabetical & P No. Index for DTC….25
PRECAUTIONS….27
Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….27
Precautions for On Board Diagnostic (OBD) System of A/T and Engine….27
Precautions….27
Service Notice or Precautions….29
Wiring Diagrams and Trouble Diagnosis….30
PREPARATION….31
Special Service Tools….31
Commercial Service Tools….33
OVERALL SYSTEM….35
A/T Electrical Parts Location….35
Circuit Diagram….36
Cross-sectional View – RE4F03B….37
Cross-sectional View – RE4F03W….38
Hydraulic Control Circuit….39
Shift Mechanism….40
Control System….49
Control Mechanism….50
Control Valve….55
ON BOARD DIAGNOSTIC SYSTEM DESCRIPTION….57
Introduction….57
OBD-II Function for A/T System….57
One or Two Trip Detection Logic of OBD-II….57
OBD-II Diagnostic Trouble Code (DTC)….57
Malfunction Indicator Lamp (MIL)….61
CONSULT-II….61
TROUBLE DIAGNOSIS – INTRODUCTION….77
Introduction….77
Work Flow….81
TROUBLE DIAGNOSIS – BASIC INSPECTION….83
A/T Fluid Check….83
Stall Test….83
Line Pressure Test….87
Road Test….88
TROUBLE DIAGNOSIS – GENERAL DESCRIPTION….107
Symptom Chart….107
TCM Terminals and Reference Value….120
TROUBLE DIAGNOSIS FOR POWER SUPPLY….125
Wiring Diagram – AT – MAIN….125
Diagnostic Procedure….126
DTC P0705 PARK/NEUTRAL POSITION (PNP) SWITCH….128
Description….128
Wiring Diagram – AT – PNP/SW….130
Diagnostic Procedure….131
Component Inspection….133
DTC P0710 A/T FLUID TEMPERATURE SENSOR CIRCUIT….134
Description….134
Wiring Diagram – AT – FTS….136
Diagnostic Procedure….137
Component Inspection….139
DTC P0720 VEHICLE SPEED SENSOR.A/T (REVOLUTION SENSOR)….140
Description….140
Wiring Diagram – AT – VSSA/T….142
Diagnostic Procedure….143
DTC P0725 ENGINE SPEED SIGNAL….145
Description….145
Wiring Diagram – AT – ENGSS….146
Diagnostic Procedure….147
DTC P0731 A/T 1ST GEAR FUNCTION….149
Description….149
Wiring Diagram – AT – 1ST….152
Diagnostic Procedure….153
Component Inspection….154
DTC P0732 A/T 2ND GEAR FUNCTION….156
Description….156
Wiring Diagram – AT – 2ND….159
Diagnostic Procedure….160
Component Inspection….161
DTC P0733 A/T 3RD GEAR FUNCTION….162
Description….162
Wiring Diagram – AT – 3RD….165
Diagnostic Procedure….166
Component Inspection….167
DTC P0734 A/T 4TH GEAR FUNCTION….168
Description….168
Wiring Diagram – AT – 4TH….172
Diagnostic Procedure….173
Component Inspection….177
DTC P0740 TORQUE CONVERTER CLUTCH SOLENOID VALVE….178
Description….178
Wiring Diagram – AT – TCV….180
Diagnostic Procedure….181
Component Inspection….183
DTC P0744 A/T TCC S/V FUNCTION (LOCK-UP)….184
Description….184
Wiring Diagram – AT – TCCSIG….187
Diagnostic Procedure….188
Component Inspection….194
DTC P0745 LINE PRESSURE SOLENOID VALVE….195
Description….195
Wiring Diagram – AT – LPSV….197
Diagnostic Procedure….198
Component Inspection….201
DTC P0750 SHIFT SOLENOID VALVE A….202
Description….202
Wiring Diagram – AT – SSV/A….204
Diagnostic Procedure….205
Component Inspection….207
DTC P0755 SHIFT SOLENOID VALVE B….208
Description….208
Wiring Diagram – AT – SSV/B….210
Diagnostic Procedure….211
Component Inspection….213
DTC P1705 THROTTLE POSITION SENSOR….214
Description….214
Wiring Diagram – AT – TPS….217
Diagnostic Procedure….218
Component Inspection….222
DTC P1760 OVERRUN CLUTCH SOLENOID VALVE….223
Description….223
Wiring Diagram – AT – OVRCSV….225
Diagnostic Procedure….226
Component Inspection….228
DTC BATT/FLUID TEMP SEN (A/T FLUID TEMP SENSOR CIRCUIT AND TCM POWER SOURCE)….229
Description….229
Wiring Diagram – AT – BA/FTS….231
Diagnostic Procedure….232
Component Inspection….235
DTC VHCL SPEED SEN.MTR VEHICLE SPEED SENSOR.MTR….236
Description….236
Wiring Diagram – AT – VSSMTR….238
Diagnostic Procedure….239
DTC CONTROL UNIT (RAM), CONTROL UNIT (ROM)….240
Description….240
Diagnostic Procedure….240
DTC CONTROL UNIT (EEP ROM)….242
Description….242
Diagnostic Procedure….243
TROUBLE DIAGNOSES FOR SYMPTOMS….244
Wiring Diagram – AT – NONDTC….244
1. O/D OFF Indicator Lamp Does Not Come On….246
2. Engine Cannot Be Started In "P" and "N" Position….249
3. In "P" Position, Vehicle Moves Forward Or Backward When Pushed….250
4. In "N" Position, Vehicle Moves….251
5. Large Shock. "N" -> "R" Position….253
6. Vehicle Does Not Creep Backward In "R" Position….255
7. Vehicle Does Not Creep Forward In "D", "2" Or "1" Position….258
8. Vehicle Cannot Be Started From D1….261
9. A/T Does Not Shift: D1 -> D2 Or Does Not Kickdown: D4 -> D2….264
10. A/T Does Not Shift: D2 -> D3….267
11. A/T Does Not Shift: D3 -> D4….270
12. A/T Does Not Perform Lock-up….273
13. A/T Does Not Hold Lock-up Condition….275
14. Lock-up Is Not Released….277
15. Engine Speed Does Not Return To Idle (Light Braking D4 -> D3)….278
16. Vehicle Does Not Start From D1….280
17. A/T Does Not Shift: D4 -> D3, When Overdrive Control Switch "ON" -> "OFF"….281
18. A/T Does Not Shift: D3 -> 22, When Selector Lever "D" -> "2" Position….282
19. A/T Does Not Shift: 22 -> 11, When Selector Lever "2" -> "1" Position….283
20. Vehicle Does Not Decelerate By Engine Brake….284
21. TCM Self-diagnosis Does Not Activate (PNP, Overdrive Control and Throttle Position Switches Circuit Checks)….284
A/T SHIFT LOCK SYSTEM….293
Description….293
Shift Lock System Electrical Parts Location….293
Wiring Diagram – SHIFT -….294
Diagnostic Procedure….295
KEY INTERLOCK CABLE….299
Components….299
Removal….299
Installation….300
ON-VEHICLE SERVICE….301
Control Valve Assembly and Accumulators….301
Control Cable Adjustment….302
Park/Neutral Position (PNP) Switch Adjustment….302
Differential Side Oil Seal Replacement….303
Revolution Sensor Replacement….303
REMOVAL AND INSTALLATION….304
Removal….304
Installation….305
OVERHAUL….307
Components….307
Oil Channel….310
Locations of Adjusting Shims, Needle Bearings, Thrust Washers and Snap Rings….311
DISASSEMBLY….312
REPAIR FOR COMPONENT PARTS….326
Manual Shaft….326
Oil Pump….329
Control Valve Assembly….333
Control Valve Upper Body….342
Control Valve Lower Body….346
Reverse Clutch….348
High Clutch….352
Forward Clutch and Overrun Clutch….357
Low & Reverse Brake….364
Rear Internal Gear, Forward Clutch Hub and Overrun Clutch Hub….368
Output Shaft, Idler Gear, Reduction Pinion Gear and Bearing Retainer….372
Band Servo Piston Assembly….377
Final Drive….382
ASSEMBLY….389
Assembly (1)….389
Adjustment (1)….390
Assembly (2)….395
Adjustment (2)….399
Assembly (3)….403
Assembly (4)….405
SERVICE DATA AND SPECIFICATIONS (SDS)….410
General Specifications….410
Shift Schedule….410
Stall Revolution….410
Line Pressure….410
Control Valves….411
Clutch and Brakes….411
Clutch and Brake Return Springs….413
Oil Pump….413
Input Shaft….414
Planetary Carrier….414
Final Drive….414
Reduction Pinion Gear….417
Output Shaft….419
Bearing Retainer….419
Total End Play….420
Reverse Clutch End Play….420
Accumulator….420
Band Servo….420
Removal and Installation….421
Shift Solenoid Valves….421
Solenoid Valves….421
A/T Fluid Temperature Sensor….421
Revolution Sensor….421
Dropping Resistor….421
ax….422
Table of Contents….422
FRONT AXLE….423
Precautions….423
PRECAUTIONS….423
Preparation….423
SPECIAL SERVICE TOOLS….423
COMMERCIAL SERVICE TOOLS….423
Noise, Vibration and Harshness (NVH) Troubleshooting….424
NVH TROUBLESHOOTING CHART….424
On-vehicle Service….424
FRONT AXLE PARTS….424
FRONT WHEEL BEARING….424
DRIVE SHAFT….425
Wheel Hub and Knuckle….426
COMPONENTS….426
REMOVAL….426
INSTALLATION….427
DISASSEMBLY….428
INSPECTION….429
ASSEMBLY….429
Drive Shaft….431
COMPONENTS….431
REMOVAL….432
INSTALLATION….433
DISASSEMBLY….434
INSPECTION….436
ASSEMBLY….436
Service Data and Specifications (SDS)….440
DRIVE SHAFT….440
WHEEL BEARING (FRONT)….440
REAR AXLE….441
Precautions….441
PRECAUTIONS….441
Preparation….441
COMMERCIAL SERVICE TOOLS….441
Noise, Vibration and Harshness (NVH) Troubleshooting….441
On-vehicle Service….441
REAR AXLE PARTS….441
REAR WHEEL BEARING….442
Wheel Hub….442
COMPONENTS….442
REMOVAL….442
INSTALLATION….443
Service Data and Specifications (SDS)….443
WHEEL BEARING (REAR)….443
br….444
Table of Contents….444
PRECAUTIONS….446
Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….446
Precautions for Brake System….446
Wiring Diagrams and Trouble Diagnosis….447
PREPARATION….448
Commercial Service Tools….448
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….449
NVH Troubleshooting Chart….449
ON-VEHICLE SERVICE….450
Checking Brake Fluid Level….450
Checking Brake Line….450
Changing Brake Fluid….450
Brake Burnishing Procedure….450
Bleeding Brake System….451
BRAKE HYDRAULIC LINE….452
Hydraulic Circuit….452
Removal….452
Inspection….452
Installation….453
DUAL PROPORTIONING VALVE….454
Inspection….454
BRAKE PEDAL AND BRACKET….455
Removal and Installation….455
Inspection….455
Adjustment….455
MASTER CYLINDER….457
Removal….457
Disassembly….457
Inspection….458
Assembly….458
Installation….459
BRAKE BOOSTER….460
On-vehicle Service….460
OPERATING CHECK….460
AIRTIGHT CHECK….460
Removal….460
Inspection….460
OUTPUT ROD LENGTH CHECK….460
Installation….461
VACUUM HOSE….462
Removal and Installation….462
Inspection….462
HOSES AND CONNECTORS….462
CHECK VALVE….462
FRONT DISC BRAKE….463
Component….463
Pad Replacement….463
Removal….464
Disassembly….464
Inspection….464
CALIPER….464
ROTOR….465
Assembly….466
Installation….466
REAR DISC BRAKE….467
Component….467
Pad Replacement….467
Removal….469
Disassembly….470
Inspection….471
CALIPER….471
ROTOR….471
Assembly….472
Installation….474
PARKING BRAKE CONTROL….475
Components….475
Removal and Installation….475
Inspection….476
Adjustment….476
ABS….477
DESCRIPTION….477
Purpose….477
ABS (Anti-Lock Brake System) Operation….477
ABS Hydraulic Circuit….477
System Components….478
System Description….478
SENSOR….478
CONTROL UNIT….478
ABS ACTUATOR AND ELECTRIC UNIT….478
Component Parts and Harness Connector Location….480
Schematic….481
Wiring Diagram – ABS -….482
ON BOARD DIAGNOSTIC SYSTEM DESCRIPTION….485
Self-diagnosis….485
FUNCTION….485
SELF-DIAGNOSIS PROCEDURE….485
HOW TO READ SELF-DIAGNOSTIC RESULTS (MALFUNCTION CODES)….485
HOW TO ERASE SELF-DIAGNOSTIC RESULTS (MALFUNCTION CODES)….486
CONSULT-II….487
CONSULT-II APPLICATION TO ABS….487
ECU (ABS CONTROL UNIT) PART NUMBER MODE….487
CONSULT-II Inspection Procedure….487
SELF-DIAGNOSIS PROCEDURE….487
SELF-DIAGNOSTIC RESULTS MODE….489
DATA MONITOR PROCEDURE….490
ACTIVE TEST PROCEDURE….491
DATA MONITOR MODE….492
ACTIVE TEST MODE….492
TROUBLE DIAGNOSIS – INTRODUCTION….493
How to Perform Trouble Diagnoses for Quick and Accurate Repair….493
INTRODUCTION….493
TROUBLE DIAGNOSIS – BASIC INSPECTION….494
Preliminary Check….494
Ground Circuit Check….497
ABS ACTUATOR AND ELECTRIC UNIT GROUND….497
TROUBLE DIAGNOSIS – GENERAL DESCRIPTION….498
Malfunction Code/Symptom Chart….498
TROUBLE DIAGNOSES FOR SELF-DIAGNOSTIC ITEMS….499
Wheel Sensor or Rotor….499
DIAGNOSTIC PROCEDURE….499
ABS Actuator Solenoid Valve or Solenoid Valve Relay….502
DIAGNOSTIC PROCEDURE….502
Motor Relay or Motor….505
DIAGNOSTIC PROCEDURE….505
Low Voltage….507
DIAGNOSTIC PROCEDURE….507
Control Unit….509
DIAGNOSTIC PROCEDURE….509
TROUBLE DIAGNOSES FOR SYMPTOMS….510
1. ABS Works Frequently….510
2. Unexpected Pedal Action….510
3. Long Stopping Distance….511
4. ABS Does Not Work….512
5. Pedal Vibration and Noise….513
6. ABS Warning Lamp Does Not Come On When Ignition Switch Is Turned On….514
7. ABS Warning Lamp Stays On When Ignition Switch Is Turned On….516
REMOVAL AND INSTALLATION….518
Front Wheel Sensors….518
Rear Wheel Sensors….519
ABS Actuator and Electric Unit….520
REMOVAL….520
INSTALLATION….520
Sensor Rotor….521
REMOVAL….521
INSTALLATION….521
SERVICE DATA AND SPECIFICATIONS (SDS)….522
General Specifications….522
Disc Brake….522
Brake Pedal….522
Parking Brake….522
bt….524
Table of Contents….524
PRECAUTIONS….526
Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….526
PREPARATION….527
Special Service Tools….527
Commercial Service Tool….527
SQUEAK AND RATTLE TROUBLE DIAGNOSES….528
Work Flow….528
CUSTOMER INTERVIEW….528
DUPLICATE THE NOISE AND TEST DRIVE….529
CHECK RELATED SERVICE BULLETINS….529
LOCATE THE NOISE AND IDENTIFY THE ROOT CAUSE….529
REPAIR THE CAUSE….529
CONFIRM THE REPAIR….530
Generic Squeak and Rattle Troubleshooting….530
INSTRUMENT PANEL….530
CENTER CONSOLE….530
DOORS….530
TRUNK….531
SUNROOF/HEADLINER….531
SEATS….531
UNDERHOOD….531
Diagnostic Worksheet….532
CLIP AND FASTENER….534
Description….534
BODY FRONT END….536
Removal and Installation….536
FRONT BUMPER ASSEMBLY….536
BODY REAR END AND OPENER….539
Removal and Installation….539
REAR BUMPER ASSEMBLY….539
TRUNK LID INSIDE RELEASE HANDLE….542
FRONT DOOR….543
Front Door Glass Limit Switch Reset (Driver side only)….543
RESET CONDITIONS….543
RESET PROCEDURES….543
Overhaul….544
REAR DOOR….545
Overhaul….545
INSTRUMENT PANEL ASSEMBLY….546
Removal and Installation….546
SIDE AND FLOOR TRIM….550
Removal and Installation….550
DOOR TRIM….552
Removal and Installation….552
ROOF TRIM….554
Removal and Installation….554
TRUNK ROOM TRIM….556
Removal and Installation….556
EXTERIOR….557
Removal and Installation….557
FRONT SEAT….563
Removal and Installation….563
POWER SEAT….564
HEATED SEAT….565
REAR SEAT….566
Removal and Installation….566
FOLDING SEAT….566
SUNROOF….567
Adjustment….567
Removal and Installation….568
Trouble Diagnoses….572
DIAGNOSTIC TABLE….572
WIND DEFLECTOR….572
ADJUSTMENT….573
DRAIN HOSES….574
WEATHERSTRIP….574
LINK AND WIRE ASSEMBLY….575
WINDSHIELD AND WINDOWS….576
Removal and Installation….576
REMOVAL….576
INSTALLATION….576
WINDSHIELD….577
DOOR MIRROR….578
Removal and Installation….578
REAR VIEW MIRROR….579
Removal and Installation….579
REMOVAL….579
INSTALLATION….579
BODY (ALIGNMENT)….580
Alignment….580
ENGINE COMPARTMENT….581
UNDERBODY….583
cl….586
Table of Contents….586
PRECAUTIONS….587
Precautions….587
PREPARATION….588
Special Service Tools….588
Commercial Service Tool….588
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….589
NVH Troubleshooting Chart….589
CLUTCH SYSTEM….590
Components….590
Inspection and Adjustment….591
ADJUSTING CLUTCH PEDAL….591
BLEEDING PROCEDURE….592
CLUTCH MASTER CYLINDER….593
Components….593
Removal….593
Installation….594
Disassembly….594
Inspection….594
Assembly….594
CLUTCH DAMPER….596
Components….596
Removal….596
Disassembly….596
Inspection….597
Assembly….597
Installation….597
OPERATING CYLINDER….598
Components….598
Removal….598
Disassembly….598
Inspection….599
Assembly….599
Installation….599
PIPING….600
Removal….600
Installation….600
CLUTCH RELEASE MECHANISM….601
Components….601
Removal….601
Inspection….601
Installation….601
CLUTCH DISC, CLUTCH COVER AND FLYWHEEL….604
Components….604
Inspection and Adjustment….604
CLUTCH DISC….604
CLUTCH COVER AND FLYWHEEL….604
FLYWHEEL INSPECTION….605
Installation….605
SERVICE DATA AND SPECIFICATIONS (SDS)….606
Clutch Control System….606
Clutch Master Cylinder….606
Clutch Operating Cylinder….606
Clutch Damper….606
Clutch Disc….606
Clutch Cover….606
Clutch Pedal….606
ec….608
Table of Contents….608
TROUBLE DIAGNOSIS – INDEX….615
Alphabetical & P No. Index for DTC….615
PRECAUTIONS….621
Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….621
Precautions for On Board Diagnostic (OBD) System of Engine and A/T….621
Engine Fuel & Emission Control System….622
Precautions….623
Wiring Diagrams and Trouble Diagnosis….624
PREPARATION….625
Special Service Tools….625
Commercial Service Tools….625
ENGINE AND EMISSION CONTROL OVERALL SYSTEM….627
Engine Control Component Parts Location….627
Circuit Diagram….631
System Diagram….633
Vacuum Hose Drawing….634
System Chart….635
ENGINE AND EMISSION BASIC CONTROL SYSTEM DESCRIPTION….636
Multiport Fuel Injection (MFI) System….636
Distributor Ignition (DI) System….638
Air Conditioning Cut Control….639
Fuel Cut Control (at no load & high engine speed)….640
Evaporative Emission System….640
On Board Refueling Vapor Recovery (ORVR)….646
Positive Crankcase Ventilation….655
BASIC SERVICE PROCEDURE….657
Fuel Pressure Release….657
Fuel Pressure Check….657
Fuel Pressure Regulator Check….658
Injector….658
Idle Speed/Ignition Timing/Idle Mixture Ratio Adjustment….660
Idle Air Volume Learning….672
ON BOARD DIAGNOSTIC SYSTEM DESCRIPTION….674
Introduction….674
Two Trip Detection Logic….674
Emission-related Diagnostic Information….675
Malfunction Indicator Lamp (MIL)….688
OBD System Operation Chart….690
CONSULT-II….695
Generic Scan Tool (GST)….708
TROUBLE DIAGNOSIS – INTRODUCTION….710
Introduction….710
Work Flow….712
TROUBLE DIAGNOSIS – BASIC INSPECTION….714
Basic Inspection….714
TROUBLE DIAGNOSIS – GENERAL DESCRIPTION….730
DTC Inspection Priority Chart….730
Fail-safe Chart….731
Symptom Matrix Chart….732
CONSULT-II Reference Value in Data Monitor Mode….736
Major Sensor Reference Graph in Data Monitor Mode….738
ECM Terminals and Reference Value….741
TROUBLE DIAGNOSIS – SPECIFICATION VALUE….749
Description….749
Testing Condition….749
Inspection Procedure….749
Diagnostic Procedure….750
TROUBLE DIAGNOSIS FOR INTERMITTENT INCIDENT….753
Description….753
Diagnostic Procedure….753
TROUBLE DIAGNOSIS FOR POWER SUPPLY….754
Main Power Supply and Ground Circuit….754
DTC P0100 MASS AIR FLOW SENSOR (MAFS)….761
Component Description….761
CONSULT-II Reference Value in Data Monitor Mode….761
ECM Terminals and Reference Value….761
On Board Diagnosis Logic….762
DTC Confirmation Procedure….762
Overall Function Check….764
Wiring Diagram….765
Diagnostic Procedure….766
Component Inspection….769
DTC P0105 ABSOLUTE PRESSURE SENSOR….770
Component Description….770
On Board Diagnosis Logic….770
DTC Confirmation Procedure….770
Diagnostic Procedure….771
DTC P0110 INTAKE AIR TEMPERATURE SENSOR….772
Component Description….772
On Board Diagnosis Logic….772
DTC Confirmation Procedure….772
Wiring Diagram….774
Diagnostic Procedure….775
Component Inspection….777
DTC P0115 ENGINE COOLANT TEMPERATURE SENSOR (ECTS) (CIRCUIT)….778
Component Description….778
CONSULT-II Reference Value in Data Monitor Mode….778
On Board Diagnosis Logic….778
DTC Confirmation Procedure….779
Wiring Diagram….780
Diagnostic Procedure….781
Component Inspection….783
DTC P0120 THROTTLE POSITION SENSOR….784
Component Description….784
CONSULT-II Reference Value in Data Monitor Mode….784
ECM Terminals and Reference Value….785
On Board Diagnosis Logic….785
DTC Confirmation Procedure….786
Wiring Diagram….790
Diagnostic Procedure….791
Component Inspection….795
DTC P0125 ENGINE COOLANT TEMPERATURE (ECT) SENSOR….797
Component Description….797
CONSULT-II Reference Value in Data Monitor Mode….797
On Board Diagnosis Logic….797
DTC Confirmation Procedure….798
Wiring Diagram….799
Diagnostic Procedure….800
Component Inspection….802
DTC P0130 HEATED OXYGEN SENSOR 1 (FRONT) (CIRCUIT)….803
Component Description….803
CONSULT-II Reference Value in Data Monitor Mode….803
ECM Terminals and Reference Value….803
On Board Diagnosis Logic….804
DTC Confirmation Procedure….804
Overall Function Check….805
Wiring Diagram….806
Diagnostic Procedure….807
Component Inspection….809
DTC P0131 HEATED OXYGEN SENSOR 1 (FRONT) (LEAN SHIFT MONITORING)….811
Component Description….811
CONSULT-II Reference Value in Data Monitor Mode….811
ECM Terminals and Reference Value….811
On Board Diagnosis Logic….812
DTC Confirmation Procedure….812
Overall Function Check….813
Diagnostic Procedure….813
Component Inspection….815
DTC P0132 HEATED OXYGEN SENSOR 1 (FRONT) (RICH SHIFT MONITORING)….817
Component Description….817
CONSULT-II Reference Value in Data Monitor Mode….817
ECM Terminals and Reference Value….817
On Board Diagnosis Logic….818
DTC Confirmation Procedure….818
Overall Function Check….819
Diagnostic Procedure….820
Component Inspection….822
DTC P0133 HEATED OXYGEN SENSOR 1 (FRONT) (RESPONSE MONITORING)….824
Component Description….824
CONSULT-II Reference Value in Data Monitor Mode….824
ECM Terminals and Reference Value….824
On Board Diagnosis Logic….825
DTC Confirmation Procedure….825
Overall Function Check….826
Wiring Diagram….827
Diagnostic Procedure….828
Component Inspection….831
DTC P0134 HEATED OXYGEN SENSOR 1 (FRONT) (HIGH VOLTAGE)….833
Component Description….833
CONSULT-II Reference Value in Data Monitor Mode….833
ECM Terminals and Reference Value….833
On Board Diagnosis Logic….834
DTC Confirmation Procedure….834
Wiring Diagram….835
Diagnostic Procedure….836
Component Inspection….837
DTC P0135 HEATED OXYGEN SENSOR 1 HEATER (FRONT)….839
Description….839
CONSULT-II Reference Value in Data Monitor Mode….839
ECM Terminals and Reference Value….839
On Board Diagnosis Logic….839
DTC Confirmation Procedure….840
Wiring Diagram….841
Diagnostic Procedure….842
Component Inspection….843
DTC P0137 HEATED OXYGEN SENSOR 2 (REAR) (MIN. VOLTAGE MONITORING)….844
Component Description….844
CONSULT-II Reference Value in Data Monitor Mode….844
ECM Terminals and Reference Value….844
On Board Diagnosis Logic….844
DTC Confirmation Procedure….845
Overall Function Check….845
Wiring Diagram….846
Diagnostic Procedure….847
Component Inspection….850
DTC P0138 HEATED OXYGEN SENSOR 2 (REAR) (MAX. VOLTAGE MONITORING)….852
Component Description….852
CONSULT-II Reference Value in Data Monitor Mode….852
ECM Terminals and Reference Value….852
On Board Diagnosis Logic….852
DTC Confirmation Procedure….853
Overall Function Check….853
Wiring Diagram….854
Diagnostic Procedure….855
Component Inspection….858
DTC P0139 HEATED OXYGEN SENSOR 2 (REAR) (RESPONSE MONITORING)….860
Component Description….860
CONSULT-II Reference Value in Data Monitor Mode….860
ECM Terminals and Reference Value….860
On Board Diagnosis Logic….860
DTC Confirmation Procedure….861
Overall Function Check….861
Wiring Diagram….862
Diagnostic Procedure….863
Component Inspection….866
DTC P0140 HEATED OXYGEN SENSOR 2 (REAR) (HIGH VOLTAGE)….868
Component Description….868
CONSULT-II Reference Value in Data Monitor Mode….868
ECM Terminals and Reference Value….868
On Board Diagnosis Logic….868
DTC Confirmation Procedure….869
Overall Function Check….869
Wiring Diagram….870
Diagnostic Procedure….871
Component Inspection….872
DTC P0141 HEATED OXYGEN SENSOR 2 HEATER (REAR)….874
Description….874
CONSULT-II Reference Value in Data Monitor Mode….874
ECM Terminals and Reference Value….874
On Board Diagnosis Logic….874
DTC Confirmation Procedure….875
Wiring Diagram….876
Diagnostic Procedure….877
Component Inspection….878
DTC P0171 FUEL INJECTION SYSTEM FUNCTION (LEAN SIDE)….879
On Board Diagnosis Logic….879
DTC Confirmation Procedure….879
Wiring Diagram….881
Diagnostic Procedure….882
DTC P0172 FUEL INJECTION SYSTEM FUNCTION (RICH SIDE)….886
On Board Diagnosis Logic….886
DTC Confirmation Procedure….886
Wiring Diagram….888
Diagnostic Procedure….889
DTC P0180 FUEL TANK TEMPERATURE SENSOR….893
Component Description….893
On Board Diagnosis Logic….893
DTC Confirmation Procedure….893
Wiring Diagram….895
Diagnostic Procedure….896
Component Inspection….897
DTC P0217 COOLANT OVERTEMPERATURE ENRICHMENT PROTECTION….898
System Description….898
CONSULT-II Reference Value in Data Monitor Mode….898
ECM Terminals and Reference Value….899
On Board Diagnosis Logic….899
Possible Cause….899
Overall Function Check….900
Wiring Diagram….903
Diagnostic Procedure (A/T Models)….905
Diagnostic Procedure (M/T Models)….916
Main 12 Causes of Overheating….928
DTC P0300 – P0304 NO. 4 – 1 CYLINDER MISFIRE, MULTIPLE CYLINDER MISFIRE….929
On Board Diagnosis Logic….929
DTC Confirmation Procedure….929
Diagnostic Procedure….930
Component Inspection….935
DTC P0325 KNOCK SENSOR (KS)….936
Component Description….936
ECM Terminals and Reference Value….936
On Board Diagnosis Logic….936
DTC Confirmation Procedure….936
Wiring Diagram….937
Diagnostic Procedure….938
Component Inspection….939
DTC P0335 CRANKSHAFT POSITION SENSOR (CKPS) (OBD)….940
Component Description….940
ECM Terminals and Reference Value….940
On Board Diagnosis Logic….940
DTC Confirmation Procedure….941
Wiring Diagram….942
Diagnostic Procedure….943
Component Inspection….945
DTC P0340 CAMSHAFT POSITION SENSOR (CMPS)….946
Component Description….946
ECM Terminals and Reference Value….946
On Board Diagnosis Logic….947
DTC Confirmation Procedure….947
Wiring Diagram….949
Diagnostic Procedure….950
Component Inspection….953
DTC P0400 EGR FUNCTION (CLOSE)….954
Description….954
CONSULT-II Reference Value in Data Monitor Mode….955
ECM Terminals and Reference Value….955
On Board Diagnosis Logic….955
Possible Cause….956
DTC Confirmation Procedure….956
Wiring Diagram….958
Diagnostic Procedure….959
DTC P0403 EGR VOLUME CONTROL VALVE (CIRCUIT)….964
Description….964
CONSULT-II Reference Value in Data Monitor Mode….965
ECM Terminals and Reference Value….965
On Board Diagnosis Logic….965
Possible Cause….966
DTC Confirmation Procedure….966
Wiring Diagram….967
Diagnostic Procedure….968
DTC P0420 THREE WAY CATALYST FUNCTION….971
On Board Diagnosis Logic….971
DTC Confirmation Procedure….971
Overall Function Check….972
Diagnostic Procedure….972
DTC P0440 EVAP CONTROL SYSTEM (SMALL LEAK) (NEGATIVE PRESSURE)….975
On Board Diagnosis Logic….975
Possible Cause….975
DTC Confirmation Procedure….976
Diagnostic Procedure….977
DTC P0443 EVAP CANISTER PURGE VOLUME CONTROL SOLENOID VALVE (CIRCUIT)….989
Description….989
CONSULT-II Reference Value in Data Monitor Mode….989
ECM Terminals and Reference Value….990
On Board Diagnosis Logic….990
Possible Cause….990
DTC Confirmation Procedure….991
Wiring Diagram….992
Diagnostic Procedure….993
DTC P0446 EVAPORATIVE EMISSION (EVAP) CANISTER VENT CONTROL VALVE (CIRCUIT)….996
Component Description….996
CONSULT-II Reference Value in Data Monitor Mode….996
ECM Terminals and Reference Value….996
On Board Diagnosis Logic….996
Possible Cause….997
DTC Confirmation Procedure….997
Wiring Diagram….998
Diagnostic Procedure….999
DTC P0450 EVAPORATIVE EMISSION (EVAP) CONTROL SYSTEM PRESSURE SENSOR….1003
Component Description….1003
CONSULT-II Reference Value in Data Monitor Mode….1003
ECM Terminals and Reference Value….1003
On Board Diagnosis Logic….1004
Possible Cause….1004
DTC Confirmation Procedure….1004
Wiring Diagram….1006
Diagnostic Procedure….1007
DTC P0455 EVAP CONTROL SYSTEM (GROSS LEAK)….1016
On Board Diagnosis Logic….1016
Possible Cause….1016
DTC Confirmation Procedure….1017
Diagnostic Procedure….1018
DTC P0460 FUEL LEVEL SENSOR FUNCTION (SLOSH)….1027
Component Description….1027
ECM Terminals and Reference Value….1027
On Board Diagnostic Logic….1027
Possible Cause….1027
DTC Confirmation Procedure….1028
Wiring Diagram….1029
Diagnostic Procedure….1030
DTC P0461 FUEL LEVEL SENSOR FUNCTION….1032
Component Description….1032
On Board Diagnostic Logic….1032
Possible Cause….1032
Overall Function Check….1032
DTC P0464 FUEL LEVEL SENSOR CIRCUIT….1034
Component Description….1034
ECM Terminals and Reference Value….1034
On Board Diagnostic Logic….1034
Possible Cause….1034
DTC Confirmation Procedure….1035
Wiring Diagram….1036
Diagnostic Procedure….1037
DTC P0500 VEHICLE SPEED SENSOR (VSS)….1039
Component Description….1039
ECM Terminals and Reference Value….1039
On Board Diagnosis Logic….1039
DTC Confirmation Procedure….1039
Overall Function Check….1040
Wiring Diagram….1041
Diagnostic Procedure….1042
DTC P0505 IDLE AIR CONTROL VALVE (IACV) – AUXILIARY AIR CONTROL (AAC) VALVE….1043
Description….1043
CONSULT-II Reference Value in Data Monitor Mode….1044
ECM Terminals and Reference Value….1044
On Board Diagnosis Logic….1044
DTC Confirmation Procedure….1044
Wiring Diagram….1046
Diagnostic Procedure….1047
DTC P0510 CLOSED THROTTLE POSITION SWITCH….1052
Component Description….1052
CONSULT-II Reference Value in Data Monitor Mode….1052
ECM Terminals and Reference Value….1052
On Board Diagnosis Logic….1052
DTC Confirmation Procedure….1053
Overall Function Check….1053
Wiring Diagram….1054
Diagnostic Procedure….1055
DTC P0600 A/T CONTROL….1060
System Description….1060
ECM Terminals and Reference Value….1060
On Board Diagnosis Logic….1060
DTC Confirmation Procedure….1060
Wiring Diagram….1061
Diagnostic Procedure….1062
DTC P0605 ECM….1063
Component Description….1063
On Board Diagnosis Logic….1063
DTC Confirmation Procedure….1063
Diagnostic Procedure….1064
DTC P1126 THERMOSTAT FUNCTION….1065
On Board Diagnosis Logic….1065
Possible Cause….1065
DTC Confirmation Procedure….1065
Diagnostic Procedure….1066
DTC P1148 CLOSED LOOP CONTROL….1067
On Board Diagnosis Logic….1067
DTC Confirmation Procedure….1067
Overall Function Check….1068
Diagnostic Procedure….1068
DTC P1217 ENGINE OVER TEMPERATURE (OVERHEAT)….1069
System Description….1069
CONSULT-II Reference Value in Data Monitor Mode….1069
ECM Terminals and Reference Value….1070
On Board Diagnosis Logic….1070
Overall Function Check….1071
Wiring Diagram….1072
Diagnostic Procedure (A/T Models)….1074
Diagnostic Procedure (M/T Models)….1085
Main 12 Causes of Overheating….1097
DTC P1336 CRANKSHAFT POSITION SENSOR (CKPS) (OBD) (COG)….1098
Component Description….1098
ECM Terminals and Reference Value….1098
On Board Diagnosis Logic….1098
DTC Confirmation Procedure….1099
Wiring Diagram….1100
Diagnostic Procedure….1101
Component Inspection….1103
DTC P1401 EGR TEMPERATURE SENSOR….1104
Component Description….1104
On Board Diagnosis Logic….1104
Possible Cause….1104
DTC Confirmation Procedure….1105
Wiring Diagram….1107
Diagnostic Procedure….1108
DTC P1402 EGR FUNCTION (OPEN)….1112
Description….1112
CONSULT-II Reference Value in Data Monitor Mode….1113
ECM Terminals and Reference Value….1113
On Board Diagnosis Logic….1113
Possible Cause….1114
DTC Confirmation Procedure….1114
Wiring Diagram….1116
Diagnostic Procedure….1117
DTC P1440 EVAP CONTROL SYSTEM (SMALL LEAK) (POSITIVE PRESSURE)….1122
On Board Diagnosis Logic….1122
Possible Cause….1122
DTC Confirmation Procedure….1123
Diagnostic Procedure….1123
DTC P1444 EVAP CANISTER PURGE VOLUME CONTROL SOLENOID VALVE….1124
Description….1124
CONSULT-II Reference Value in Data Monitor Mode….1124
ECM Terminals and Reference Value….1125
On Board Diagnosis Logic….1125
Possible Cause….1125
DTC Confirmation Procedure….1126
Wiring Diagram….1127
Diagnostic Procedure….1128
DTC P1446 EVAPORATIVE EMISSION (EVAP) CANISTER VENT CONTROL VALVE (CLOSE)….1136
Component Description….1136
CONSULT-II Reference Value in Data Monitor Mode….1136
ECM Terminals and Reference Value….1136
On Board Diagnosis Logic….1136
Possible Cause….1137
DTC Confirmation Procedure….1137
Wiring Diagram….1138
Diagnostic Procedure….1139
DTC P1447 EVAPORATIVE EMISSION (EVAP) CONTROL SYSTEM PURGE FLOW MONITORING….1144
System Description….1144
On Board Diagnosis Logic….1144
Possible Cause….1144
DTC Confirmation Procedure….1145
Overall Function Check….1145
Diagnostic Procedure….1147
DTC P1448 EVAPORATIVE EMISSION (EVAP) CANISTER VENT CONTROL VALVE (OPEN)….1156
Component Description….1156
CONSULT-II Reference Value in Data Monitor Mode….1156
ECM Terminals and Reference Value….1156
On Board Diagnosis Logic….1156
Possible Cause….1157
DTC Confirmation Procedure….1157
Overall Function Check….1158
Wiring Diagram….1159
Diagnostic Procedure….1160
DTC P1464 FUEL LEVEL SENSOR CIRCUIT (GROUND SIGNAL)….1165
Component Description….1165
ECM Terminals and Reference Value….1165
On Board Diagnostic Logic….1165
Possible Cause….1165
DTC Confirmation Procedure….1166
Wiring Diagram….1167
Diagnostic Procedure….1168
DTC P1490 VACUUM CUT VALVE BYPASS VALVE (CIRCUIT)….1169
Description….1169
CONSULT-II Reference Value in Data Monitor Mode….1169
ECM Terminals and Reference Value….1169
On Board Diagnosis Logic….1170
Possible Cause….1170
DTC Confirmation Procedure….1170
Wiring Diagram….1171
Diagnostic Procedure….1172
DTC P1491 VACUUM CUT VALVE BYPASS VALVE….1175
Description….1175
CONSULT-II Reference Value in Data Monitor Mode….1175
ECM Terminals and Reference Value….1175
On Board Diagnosis Logic….1176
Possible Cause….1176
DTC Confirmation Procedure….1176
Overall Function Check….1177
Wiring Diagram….1178
Diagnostic Procedure….1179
DTC P1605 A/T DIAGNOSIS COMMUNICATION LINE….1187
System Description….1187
ECM Terminals and Reference Value….1187
On Board Diagnosis Logic….1187
DTC Confirmation Procedure….1187
Wiring Diagram….1188
Diagnostic Procedure….1189
DTC P1706 PARK/NEUTRAL POSITION (PNP) SWITCH….1190
Component Description….1190
CONSULT-II Reference Value in Data Monitor Mode….1190
ECM Terminals and Reference Value….1190
On Board Diagnosis Logic….1190
DTC Confirmation Procedure….1190
Overall Function Check….1191
Wiring Diagram….1192
Diagnostic Procedure For M/T Models….1193
Diagnostic Procedure For A/T Models….1195
IGNITION SIGNAL….1197
Component Description….1197
CONSULT-II Reference Value in Data Monitor Mode….1197
ECM Terminals and Reference Value….1197
Wiring Diagram….1198
Diagnostic Procedure….1199
Component Inspection….1202
INJECTOR….1203
Component Description….1203
CONSULT-II Reference Value in Data Monitor Mode….1203
ECM Terminals and Reference Value….1203
Wiring Diagram….1204
Diagnostic Procedure….1205
START SIGNAL….1208
CONSULT-II Reference Value in Data Monitor Mode….1208
ECM Terminals and Reference Value….1208
Wiring Diagram….1209
Diagnostic Procedure….1210
FUEL PUMP….1212
System Description….1212
Component Description….1212
CONSULT-II Reference Value in Data Monitor Mode….1212
ECM Terminals and Reference Value….1213
Wiring Diagram….1214
Diagnostic Procedure….1215
Component Inspection….1220
POWER STEERING OIL PRESSURE SWITCH….1221
Component Description….1221
CONSULT-II Reference Value in Data Monitor Mode….1221
ECM Terminals and Reference Value….1221
Wiring Diagram….1222
Diagnostic Procedure….1223
Component Inspection….1225
REFRIGERANT PRESSURE SENSOR….1226
Description….1226
ECM Terminals and Reference Value….1226
Wiring Diagram….1227
Diagnostic Procedure….1228
ELECTRICAL LOAD SIGNAL….1231
CONSULT-II Reference Value in Data Monitor Mode….1231
ECM Terminals and Reference Value….1231
Wiring Diagram….1232
Diagnostic Procedure….1234
MIL & DATA LINK CONNECTORS….1238
Wiring Diagram….1238
SERVICE DATA AND SPECIFICATIONS (SDS)….1239
Fuel Pressure Regulator….1239
Idle Speed and Ignition Timing….1239
Ignition Coil….1239
Mass Air Flow Sensor….1239
Engine Coolant Temperature Sensor….1239
EGR Volume Control Valve….1239
EGR Temperature Sensor….1239
Fuel Pump….1240
IACV-AAC Valve….1240
Injector….1240
Resistor….1240
Throttle Position Sensor….1240
Heated Oxygen Sensor 1 Heater (Front)….1240
Calculated Load Value….1240
Intake Air Temperature Sensor….1240
EVAP Canister Purge Volume Control Valve….1240
Heated Oxygen Sensor 2 Heater (Rear)….1240
Crankshaft Position Sensor (OBD)….1240
Fuel Tank Temperature Sensor….1241
el….1242
Table of Contents….1242
PRECAUTIONS….1245
Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….1245
Wiring Diagrams and Trouble Diagnosis….1245
HARNESS CONNECTOR….1246
Description….1246
STANDARDIZED RELAY….1248
Description….1248
POWER SUPPLY ROUTING….1250
Schematic….1250
Wiring Diagram – POWER -….1251
Inspection….1258
GROUND….1259
Ground Distribution….1259
COMBINATION SWITCH….1267
Check….1267
Replacement….1268
STEERING SWITCH….1269
Check….1269
HEADLAMP (FOR USA)….1270
Component Parts and Harness Connector Location….1270
System Description….1270
Schematic….1273
Wiring Diagram – H/LAMP -….1274
Trouble Diagnoses….1277
Bulb Replacement….1280
Aiming Adjustment….1280
HEADLAMP (FOR CANADA) – DAYTIME LIGHT SYSTEM -….1282
Component Parts and Harness Connector Location….1282
System Description….1282
Schematic….1285
Wiring Diagram – DTRL -….1286
Trouble Diagnoses….1290
Bulb Replacement….1293
Aiming Adjustment….1293
PARKING, LICENSE AND TAIL LAMPS….1294
System Description….1294
Schematic….1295
Wiring Diagram – TAIL/L -….1296
Trouble Diagnoses….1299
STOP LAMP….1300
Wiring Diagram – STOP/L -….1300
BACK-UP LAMP….1301
Wiring Diagram – BACK/L -….1301
FRONT FOG LAMP….1302
System Description….1302
Wiring Diagram – F/FOG -….1304
Aiming Adjustment….1306
TURN SIGNAL AND HAZARD WARNING LAMPS….1307
System Description….1307
Wiring Diagram – TURN -….1309
Trouble Diagnoses….1311
Electrical Components Inspection….1311
ILLUMINATION….1312
System Description….1312
Schematic….1314
Wiring Diagram – ILL -….1315
INTERIOR ROOM LAMP….1319
System Description….1319
Wiring Diagram – ROOM/L -….1321
VANITY MIRROR AND TRUNK ROOM LAMPS….1323
System Description….1323
Wiring Diagram – INT/L -….1324
METERS AND GAUGES….1325
Component Parts and Harness Connector Location….1325
System Description….1325
Combination Meter….1327
Schematic….1329
Wiring Diagram – METER -….1330
Meter/Gauge Operation and Odo/Trip Meter Segment Check in Diagnosis Mode….1331
Trouble Diagnoses….1332
Electrical Components Inspection….1338
WARNING LAMPS….1339
Schematic….1339
Wiring Diagram – WARN -….1340
Electrical Components Inspection….1344
A/T INDICATOR….1345
Wiring Diagram – AT/IND -….1345
WARNING CHIME….1346
Component Parts and Harness Connector Location….1346
System Description….1346
Wiring Diagram – CHIME -….1348
Trouble Diagnoses….1350
FRONT WIPER AND WASHER….1355
System Description….1355
Wiring Diagram – WIPER -….1357
Removal and Installation….1358
Washer Nozzle Adjustment….1359
Washer Tube Layout….1359
HORN….1360
Wiring Diagram – HORN -….1360
CIGARETTE LIGHTER….1361
Wiring Diagram – CIGAR -….1361
REAR WINDOW DEFOGGER….1362
Component Parts and Harness Connector Location….1362
System Description….1362
Wiring Diagram – DEF -….1364
Trouble Diagnoses….1366
Electrical Components Inspection….1368
Filament Check….1368
Filament Repair….1369
AUDIO….1371
System Description….1371
Wiring Diagram – AUDIO -….1372
Trouble Diagnoses….1374
Inspection….1375
AUDIO ANTENNA….1376
System Description….1376
Wiring Diagram – P/ANT -….1377
Trouble Diagnoses….1378
Location of Antenna….1378
Antenna Rod Replacement….1379
TRUNK LID AND FUEL FILLER LID OPENER….1380
Wiring Diagram – TLID -….1380
POWER SUNROOF….1381
System Description….1381
Wiring Diagram – SROOF -….1382
DOOR MIRROR….1384
Wiring Diagram – MIRROR -….1384
POWER SEAT….1385
Wiring Diagram – SEAT -….1385
HEATED SEAT….1386
Wiring Diagram – HSEAT -….1386
AUTOMATIC SPEED CONTROL DEVICE (ASCD)….1387
Component Parts and Harness Connector Location….1387
System Description….1388
Schematic….1390
Wiring Diagram – ASCD -….1391
Fail-safe System….1395
Trouble Diagnoses….1396
Electrical Component Inspection….1405
ASCD Wire Adjustment….1406
POWER WINDOW….1407
System Description….1407
Schematic….1409
Wiring Diagram – WINDOW -….1410
Trouble Diagnoses….1414
POWER DOOR LOCK….1417
Component Parts and Harness Connector Location….1417
System Description….1417
Schematic….1418
Wiring Diagram – D/LOCK -….1419
Trouble Diagnoses….1422
MULTI-REMOTE CONTROL SYSTEM….1431
Component Parts and Harness Connector Location….1431
System Description….1431
Schematic….1434
Wiring Diagram – MULTI -….1435
Trouble Diagnoses….1438
ID Code Entry Procedure….1450
Remote Controller Battery Replacement….1454
VEHICLE SECURITY (THEFT WARNING) SYSTEM….1455
Component Parts and Harness Connector Location….1455
System Description….1456
Schematic….1459
Wiring Diagram – VEHSEC -….1460
Trouble Diagnoses….1464
SMART ENTRANCE CONTROL UNIT….1483
Description….1483
Schematic….1485
Smart Entrance Control Unit Inspection Table….1487
IVIS (INFINITI VEHICLE IMMOBILIZER SYSTEM – NATS)….1488
Component Parts and Harness Connetor Location….1488
System Description….1489
System Composition….1489
Wiring Diagram – NATS -….1490
CONSULT-II….1491
Trouble Diagnoses….1494
How to Replace IVIS (NATS) IMMU….1507
INTEGRATED HOMELINK TRANSMITTER….1508
Wiring Diagram – TRNSMT -….1508
Trouble Diagnoses….1509
ELECTRICAL UNITS LOCATION….1511
Engine Compartment….1511
Passenger Compartment….1513
HARNESS LAYOUT….1515
How to Read Harness Layout….1515
Outline….1516
Main Harness….1517
Engine Room Harness….1519
Engine Control Harness….1522
Body Harness….1523
Body No. 2 Harness….1524
Tail & Tail No. 2 Harness….1525
Engine Harness….1526
Room Lamp Harness….1527
Air Bag Harness….1528
Front Door Harness….1529
Rear Door Harness….1530
BULB SPECIFICATIONS….1531
Headlamp….1531
Exterior Lamp….1531
Interior Lamp….1531
WIRING DIAGRAM CODES (CELL CODES)….1532
em….1534
Table of Contents….1534
PRECAUTIONS….1536
Parts Requiring Angular Tightening….1536
Liquid Gasket Application Procedure….1536
PREPARATION….1537
Special Service Tools….1537
Commercial Service Tools….1539
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….1541
NVH Troubleshooting – Engine Noise….1542
OUTER COMPONENT PARTS….1543
Removal and Installation….1543
MEASUREMENT OF COMPRESSION PRESSURE….1546
OIL PAN….1547
Components….1547
Removal….1547
Installation….1549
TIMING CHAIN….1552
Components….1552
Removal….1553
Inspection….1556
Installation….1556
OIL SEAL….1561
Replacement….1561
VALVE OIL SEAL….1561
FRONT OIL SEAL….1561
REAR OIL SEAL….1562
CYLINDER HEAD….1563
Components….1563
Removal….1564
Disassembly….1567
Inspection….1569
CYLINDER HEAD DISTORTION….1569
CAMSHAFT VISUAL CHECK….1569
CAMSHAFT RUNOUT….1569
CAMSHAFT CAM HEIGHT….1569
CAMSHAFT JOURNAL CLEARANCE….1570
CAMSHAFT END PLAY….1570
CAMSHAFT SPROCKET RUNOUT….1571
VALVE GUIDE CLEARANCE….1571
VALVE GUIDE REPLACEMENT….1571
VALVE SEATS….1572
REPLACING VALVE SEAT FOR SERVICE PARTS….1573
VALVE DIMENSIONS….1574
VALVE SPRING….1574
HYDRAULIC LASH ADJUSTER….1574
ROCKER ARM, SHIM AND ROCKER ARM GUIDE….1575
Assembly….1575
Installation….1579
ENGINE ASSEMBLY….1585
Removal and Installation….1585
REMOVAL….1586
INSTALLATION….1587
CYLINDER BLOCK….1588
Components….1588
Removal and Installation….1589
Disassembly….1589
PISTON AND CRANKSHAFT….1589
Inspection….1589
PISTON AND PISTON PIN CLEARANCE….1589
PISTON RING SIDE CLEARANCE….1590
PISTON RING END GAP….1591
CONNECTING ROD BEND AND TORSION….1591
CYLINDER BLOCK DISTORTION AND WEAR….1591
PISTON-TO-BORE CLEARANCE….1592
CRANKSHAFT….1593
BEARING CLEARANCE….1593
CONNECTING ROD BUSHING CLEARANCE (SMALL END)….1596
REPLACEMENT OF CONNECTING ROD BUSHING (SMALL END)….1596
REPLACEMENT OF PILOT BUSHING (M/T) OR PILOT CONVERTER (A/T)….1596
FLYWHEEL/DRIVE PLATE RUNOUT….1597
Assembly….1597
PISTON….1597
CRANKSHAFT….1598
SERVICE DATA AND SPECIFICATIONS (SDS)….1601
General Specifications….1601
Compression Pressure….1601
Cylinder Head….1601
Valve….1602
VALVE….1602
VALVE SPRING….1602
HYDRAULIC LASH ADJUSTER (HLA)….1602
VALVE GUIDE….1603
VALVE SHIM CLEARANCE ADJUSTMENT….1603
AVAILABLE SHIM….1604
VALVE SEAT….1605
VALVE SEAT RESURFACE LIMIT….1606
Camshaft and Camshaft Bearing….1606
Cylinder Block….1607
Piston, Piston Ring and Piston pin….1608
PISTON….1608
PISTON RING….1608
PISTON PIN….1608
Connecting Rod….1609
Crankshaft….1610
Main Bearing….1611
STANDARD….1611
UNDERSIZE….1611
Connecting Rod Bearing….1611
STANDARD SIZE….1611
UNDERSIZE….1611
Bearing Clearance….1612
Miscellaneous Components….1612
fe….1614
Table of Contents….1614
PREPARATION….1615
Special Service Tool….1615
Commercial Service Tools….1615
ACCELERATOR CONTROL SYSTEM….1616
Removal and Installation….1616
Adjusting Accelerator Wire….1616
FUEL SYSTEM….1618
Removal and Installation….1618
FUEL PUMP AND GAUGE….1619
EXHAUST SYSTEM….1621
Removal and Installation….1621
foldout….1624
SUPER MULTIPLE JUNCTION (SMJ)….1624
FUSE BLOCK – JUNCTION BOX (J/B)….1626
FUSE AND FUSIBLE LINK BOX….1627
ELECTRICAL UNITS….1628
JOINT CONNECTOR (J/C)….1629
QUICK REFERENCE CHART….1630
fwd….1631
QUICK REFERENCE INDEX….1631
FOREWORD….1632
Comment Sheet….1633
Inch to Metric Conversion Table….1634
gi….1635
Table of Contents….1635
PRECAUTIONS….1637
Precautions….1637
PRECAUTIONS FOR SUPPLEMENTAL RESTRAINT SYSTEM (SRS) "AIR BAG" AND "SEAT BELT PRE-TENSIONER"….1637
PRECAUTIONS FOR IVIS (INFINITI VEHICLE IMMOBILIZER SYSTEM – NATS)….1637
GENERAL PRECAUTIONS….1638
PRECAUTIONS FOR MULTIPORT FUEL INJECTION SYSTEM OR ENGINE CONTROL SYSTEM….1640
PRECAUTIONS FOR THREE WAY CATALYST….1640
PRECAUTIONS FOR HOSES….1640
PRECAUTIONS FOR ENGINE OILS….1641
PRECAUTIONS FOR FUEL….1642
PRECAUTIONS FOR AIR CONDITIONING….1642
HOW TO USE THIS MANUAL….1643
HOW TO READ WIRING DIAGRAMS….1645
Sample/Wiring Diagram – EXAMPL -….1645
OPTIONAL SPLICE….1646
CONTROL UNIT TERMINALS AND REFERENCE VALUE CHART….1647
Description….1648
CONNECTOR SYMBOLS….1650
SWITCH POSITIONS….1651
DETECTABLE LINES AND NON-DETECTABLE LINES….1651
MULTIPLE SWITCH….1652
REFERENCE AREA….1653
HOW TO CHECK TERMINAL….1655
Connector and Terminal Pin Kit….1655
How to Probe Connectors….1655
PROBING FROM HARNESS SIDE….1655
PROBING FROM TERMINAL SIDE….1655
How to Check Enlarged Contact Spring of Terminal….1656
Waterproof Connector Inspection….1657
RUBBER SEAL INSPECTION….1657
WIRE SEAL INSPECTION….1657
Terminal Lock Inspection….1657
HOW TO PERFORM EFFICIENT DIAGNOSIS FOR AN ELECTRICAL INCIDENT….1658
Work Flow….1658
Incident Simulation Tests….1659
INTRODUCTION….1659
VEHICLE VIBRATION….1659
HEAT SENSITIVE….1660
FREEZING….1660
WATER INTRUSION….1661
ELECTRICAL LOAD….1661
COLD OR HOT START UP….1661
Circuit Inspection….1661
INTRODUCTION….1661
TESTING FOR "OPENS" IN THE CIRCUIT….1662
TESTING FOR "SHORTS" IN THE CIRCUIT….1663
GROUND INSPECTION….1664
VOLTAGE DROP TESTS….1664
CONTROL UNIT CIRCUIT TEST….1666
HOW TO FOLLOW TROUBLE DIAGNOSES….1668
How to Follow Test Groups in Trouble Diagnoses….1669
Harness Wire Color and Connector Number Indication….1670
TYPE 1: HARNESS WIRE COLOR AND CONNECTOR NUMBER ARE SHOWN IN ILLUSTRATION….1670
TYPE 2: HARNESS WIRE COLOR AND CONNECTOR NUMBER ARE SHOWN IN TEXT….1670
Key to Symbols Signifying Measurements or Procedures….1671
CONSULT-II CHECKING SYSTEM….1673
Function and System Application….1673
Nickel Metal Hydride Battery Replacement….1673
Checking Equipment….1674
CONSULT-II Data Link Connector (DLC) Circuit….1674
INSPECTION PROCEDURE….1674
IDENTIFICATION INFORMATION….1675
Model Variation….1675
Identification Number….1676
VEHICLE IDENTIFICATION NUMBER ARRANGEMENT….1676
IDENTIFICATION PLATE….1677
ENGINE SERIAL NUMBER….1677
AUTOMATIC TRANSAXLE NUMBER….1677
MANUAL TRANSAXLE NUMBER….1677
Dimensions….1678
Wheels & Tires….1678
LIFTING POINTS AND TOW TRUCK TOWING….1679
Preparation….1679
SPECIAL SERVICE TOOLS….1679
Board-on Lift….1679
Garage Jack and Safety Stand….1680
2-pole Lift….1681
Tow Truck Towing….1682
VEHICLE RECOVERY (FREEING A STUCK VEHICLE)….1683
TIGHTENING TORQUE OF STANDARD BOLTS….1684
SAE J1930 TERMINOLOGY LIST….1685
SAE J1930 Terminology List….1685
ha….1689
Table of Contents….1689
AUTO….1691
PRECAUTIONS….1691
Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….1691
Precautions for Working with HFC-134a (R-134a)….1691
General Refrigerant Precautions….1692
Precautions for Leak Detection Dye….1692
Identification….1693
Precautions for Refrigerant Connection….1693
Precautions for Servicing Compressor….1695
Precautions for Service Equipment….1695
Wiring Diagrams and Trouble Diagnosis….1697
PREPARATION….1698
Special Service Tools….1698
HFC-134a (R-134a) Service Tools and Equipment….1699
DESCRIPTION….1702
Refrigeration System….1702
Component Layout….1703
Introduction….1704
Features….1704
Overview of Control System….1707
Control Operation….1707
Discharge Air Flow….1709
TROUBLE DIAGNOSES….1711
Component Location….1711
Circuit Diagram….1713
Wiring Diagram – A/C, A -….1714
Auto Amp. Terminals and Reference Value….1717
Self-diagnosis….1719
How to Perform Trouble Diagnoses for Quick and Accurate Repair….1729
Operational Check….1730
A/C System….1733
Mode Door Motor….1736
Air Mix Door Motor….1742
Intake Door Motor….1746
Blower Motor….1753
Magnet Clutch….1761
Insufficient Cooling….1768
Insufficient Heating….1776
Noise….1777
Self-diagnosis….1778
Memory Function….1779
ECON (ECONOMY) Mode….1780
Ambient Sensor Circuit….1780
In-vehicle Sensor Circuit….1783
Sunload Sensor Circuit….1787
Intake Sensor Circuit….1790
Air Mix Door Motor PBR Circuit….1792
SERVICE PROCEDURE….1793
HFC-134a (R-134a) Service Procedure….1793
Maintenance of Lubricant Quantity in Compressor….1795
Compressor….1798
Compressor Clutch….1799
Thermal Protector….1802
Heater Unit (Heater Core)….1802
Blower Unit….1803
Cooling Unit (A/C Evaporator)….1804
Refrigerant Lines….1805
Belt….1810
Idle Air Control Valve (IACV) – Auxiliary Air Control (AAC) Valve….1810
Ventilation Air Filter….1810
SERVICE DATA AND SPECIFICATIONS (SDS)….1811
Auto….1811
MANUAL….1812
PRECAUTIONS….1812
Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….1812
Precautions for Working with HFC-134a (R-134a)….1812
General Refrigerant Precautions….1813
Precautions for Leak Detection Dye….1813
Identification….1814
Precautions for Refrigerant Connection….1814
Precautions for Servicing Compressor….1816
Precautions for Service Equipment….1816
Wiring Diagrams and Trouble Diagnosis….1818
PREPARATION….1819
Special Service Tools….1819
HFC-134a (R-134a) Service Tools and Equipment….1820
DESCRIPTION….1823
Refrigeration System….1823
Component Layout….1824
Control Operation….1825
Discharge Air Flow….1826
System Description….1827
TROUBLE DIAGNOSES….1828
Component Location….1828
Circuit Diagram – Air Conditioner….1830
Wiring Diagram – A/C, M -….1831
How to Perform Trouble Diagnoses for Quick and Accurate Repair….1835
Operational Check….1836
A/C System….1838
Intake Door….1840
Mode Door Motor….1844
Air Mix Door….1850
Blower Motor….1855
Magnet Clutch….1862
Insufficient Cooling….1870
Insufficient Heating….1877
Noise….1878
SERVICE PROCEDURE….1879
HFC-134a (R-134a) Service Procedure….1879
Maintenance of Lubricant Quantity in Compressor….1881
Compressor….1884
Compressor Clutch….1885
Thermal Protector….1888
Heater Unit (Heater Core)….1888
Blower Unit….1889
Cooling Unit (A/C Evaporator)….1890
Refrigerant Lines….1891
Belt….1896
Idle Air Control Valve (IACV) – Auxiliary Air Control (AAC) Valve….1896
Ventilation Air Filter….1896
SERVICE DATA AND SPECIFICATIONS (SDS)….1897
Manual….1897
idx….1899
lc….1907
Table of Contents….1907
ENGINE LUBRICATION SYSTEM….1908
Precautions….1908
LIQUID GASKET APPLICATION PROCEDURE….1908
Preparation….1908
SPECIAL SERVICE TOOLS….1908
Lubrication Circuit….1909
Oil Pressure Check….1910
Oil Pump….1910
REMOVAL….1910
DISASSEMBLY AND ASSEMBLY….1911
INSPECTION….1911
REGULATOR VALVE INSPECTION….1912
INSTALLATION….1913
Oil Filter….1913
Service Data and Specifications (SDS)….1913
OIL PRESSURE CHECK….1913
REGULATOR VALVE INSPECTION….1913
OIL PUMP INSPECTION….1913
ENGINE COOLING SYSTEM….1914
Precautions….1914
LIQUID GASKET APPLICATION PROCEDURE….1914
Preparation….1914
SPECIAL SERVICE TOOL….1914
Cooling Circuit….1915
System Check….1915
CHECKING COOLING SYSTEM HOSES….1915
CHECKING COOLING SYSTEM FOR LEAKS….1915
CHECKING RADIATOR….1916
CHECKING RADIATOR CAP….1916
Water Pump….1916
REMOVAL….1916
INSPECTION….1917
INSTALLATION….1917
Thermostat….1918
REMOVAL AND INSTALLATION….1918
INSPECTION….1919
Water Outlet….1919
INSPECTION….1919
INSTALLATION….1919
Radiator….1920
COMPONENTS….1920
Cooling Fan Control System….1920
Refilling Engine Coolant….1921
Overheating Cause Analysis….1921
Service Data and Specifications (SDS)….1922
THERMOSTAT….1922
RADIATOR….1922
ma….1923
Table of Contents….1923
PRECAUTIONS….1924
Precautions for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….1924
PREPARATION….1925
Special Service Tool….1925
Commercial Service Tool….1925
GENERAL MAINTENANCE….1926
PERIODIC MAINTENANCE….1928
Schedule 1….1929
EMISSION CONTROL SYSTEM MAINTENANCE….1929
CHASSIS AND BODY MAINTENANCE….1930
Schedule 2….1931
EMISSION CONTROL SYSTEM MAINTENANCE….1931
CHASSIS AND BODY MAINTENANCE….1932
RECOMMENDED FLUIDS AND LUBRICANTS….1933
Fluids and Lubricants….1933
SAE Viscosity Number….1933
GASOLINE ENGINE OIL….1933
Anti-freeze Coolant Mixture Ratio….1934
ENGINE MAINTENANCE….1935
Checking Drive Belts….1935
Changing Engine Coolant….1936
-DRAINING ENGINE COOLANT-….1936
-REFILLING ENGINE COOLANT-….1937
-FLUSHING COOLING SYSTEM-….1938
Checking Fuel Lines….1938
Changing Fuel Filter….1939
WITH CONSULT-II….1939
WITHOUT CONSULT-II….1939
Changing Air Cleaner Filter….1940
VISCOUS PAPER TYPE….1940
Changing Engine Oil….1940
Changing Oil Filter….1941
Changing Spark Plugs (Platinum-tipped type)….1941
Changing Spark Plugs (Conventional type)….1942
Checking EVAP Vapor Lines….1943
CHASSIS AND BODY MAINTENANCE….1944
Checking Exhaust System….1944
Checking Clutch Fluid Level and Leaks….1944
Checking M/T Oil….1944
Changing M/T Oil….1944
Checking A/T Fluid….1945
Changing A/T Fluid….1945
Balancing Wheels….1946
Tire Rotation….1946
Checking Brake Fluid Level and Leaks….1946
Checking Brake Lines and Cables….1946
Checking Disc Brake….1947
ROTOR….1947
CALIPER….1947
PAD….1947
Checking Steering Gear and Linkage….1947
STEERING GEAR….1947
STEERING LINKAGE….1947
Checking Power Steering Fluid and Lines….1947
Axle and Suspension Parts….1948
Drive Shaft….1948
Vacuum Hose….1948
Lubricating Locks, Hinges and Hood Latches….1949
Checking Seat Belts, Buckles, Retractors, Anchors and Adjusters….1949
SERVICE DATA AND SPECIFICATIONS (SDS)….1950
Engine Maintenance….1950
DRIVE BELT DEFLECTION AND TENSION….1950
SPARK PLUG TYPE….1950
Chassis and Body Maintenance….1950
WHEEL BALANCE….1950
mt….1951
Table of Contents….1951
PREPARATION….1952
Special Service Tools….1952
Commercial Service Tools….1954
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….1956
NVH Troubleshooting Chart….1956
DESCRIPTION….1957
Cross-sectional View….1957
DOUBLE-CONE SYNCHRONIZER….1958
ON-VEHICLE SERVICE….1959
Replacing Oil Seal….1959
DIFFERENTIAL OIL SEAL….1959
STRIKING ROD OIL SEAL….1959
Position Switch Check….1960
BACK-UP LAMP SWITCH….1960
PNP SWITCH….1960
Viscous Coupling Check….1961
REMOVAL AND INSTALLATION….1962
Removal….1962
Installation….1964
OVERHAUL….1965
Transaxle Gear Control….1965
Case Components….1966
Gear Components….1967
Shift Control Components….1968
Final Drive Components….1969
DISASSEMBLY….1970
Transaxle Case….1970
Clutch Housing….1972
REPAIR FOR COMPONENT PARTS….1976
Input Shaft and Gears….1976
DISASSEMBLY….1976
INSPECTION….1977
ASSEMBLY….1978
Mainshaft and Gears….1981
DISASSEMBLY….1981
INSPECTION….1982
ASSEMBLY….1984
Final Drive….1989
PRE-INSPECTION….1989
DISASSEMBLY….1990
INSPECTION….1991
ASSEMBLY….1992
Shift Control Components….1995
INSPECTION….1995
ASSEMBLY….1996
Clutch Housing….1996
Transaxle Case….2000
SERVICE DATA AND SPECIFICATIONS (SDS)….2006
General Specifications….2006
TRANSAXLE….2006
FINAL GEAR….2006
Gear End Play….2007
Clearance Between Baulk Ring and Gear….2007
3RD, 4TH, 5TH, REVERSE BAULK RING….2007
1ST AND 2ND BAULK RING….2007
Available Snap Rings….2007
SNAP RING….2007
Available C-rings….2008
4TH INPUT GEAR C-RING….2008
5TH INPUT GEAR REAR C-RING….2008
MAINSHAFT C-RING….2008
Available Adjusting Shims….2009
INPUT SHAFT REAR BEARING ADJUSTING SHIM….2009
MAINSHAFT ADJUSTING SHIM….2010
MAINSHAFT REAR BEARING ADJUSTING SHIM….2010
Available Thrust Washer….2011
MAINSHAFT THRUST WASHER….2011
Available Washers….2011
DIFFERENTIAL SIDE GEAR THRUST WASHER….2011
Available Shims – Differential Side Bearing Preload and Adjusting Shim….2012
BEARING PRELOAD….2012
DIFFERENTIAL SIDE BEARING ADJUSTING SHIMS….2012
rs….2015
Table of Contents….2015
SEAT BELTS….2017
Precautions….2017
SUPPLEMENTAL RESTRAINT SYSTEM (SRS) "AIR BAG" AND "SEAT BELT PRE-TENSIONER"….2017
PRECAUTION FOR SEAT BELT SERVICE….2017
Front Seat Belt….2018
REMOVAL AND INSTALLATION….2018
Rear Seat Belt….2020
REMOVAL AND INSTALLATION….2020
Seat Belt Inspection….2022
AFTER A COLLISION….2022
PRELIMINARY CHECKS….2022
SEAT BELT RETRACTOR ON-VEHICLE CHECK….2023
SEAT BELT RETRACTOR OFF-VEHICLE CHECK….2023
Tether Anchor Plate….2025
REMOVAL AND INSTALLATION….2025
SUPPLEMENTAL RESTRAINT SYSTEM (SRS)….2026
Precautions….2026
SUPPLEMENTAL RESTRAINT SYSTEM (SRS) "AIR BAG" AND "SEAT BELT PRE-TENSIONER"….2026
PRECAUTIONS FOR SRS "AIR BAG" AND "SEAT BELT PRE-TENSIONER" SERVICE….2026
WIRING DIAGRAMS AND TROUBLE DIAGNOSIS….2026
Preparation….2027
SPECIAL SERVICE TOOLS….2027
SRS Configuration….2028
Seat Belt Pre-tensioner with Load Limiter….2029
Side Air Bag….2029
SRS Component Parts Location….2030
Maintenance Items….2030
Diagnosis Sensor Unit….2031
REMOVAL AND INSTALLATION….2031
Seat Belt Pre-tensioner….2032
REMOVAL AND INSTALLATION….2032
Satellite Sensor….2032
REMOVAL AND INSTALLATION….2032
Driver Air Bag Module and Spiral Cable….2033
REMOVAL AND INSTALLATION….2033
REMOVAL….2033
INSTALLATION….2035
Front Passenger Air Bag Module….2036
REMOVAL….2036
INSTALLATION….2037
Side Air Bag Module….2037
REMOVAL….2037
INSTALLATION….2039
Disposal of Air Bag Module and Seat Belt Pre-tensioner….2039
CHECKING DEPLOYMENT TOOL….2040
DEPLOYMENT PROCEDURES FOR AIR BAG MODULE (OUTSIDE OF VEHICLE)….2041
DEPLOYMENT PROCEDURES FOR SEAT BELT PRE-TENSIONER (OUTSIDE OF VEHICLE)….2043
DEPLOYMENT OF AIR BAG MODULE AND SEAT BELT PRE-TENSIONER WHILE MOUNTED IN VEHICLE….2044
DISPOSING OF AIR BAG MODULE AND SEAT BELT PRE-TENSIONER….2044
Trouble Diagnoses Introduction….2046
DIAGNOSIS FUNCTION….2046
DIAGNOSIS MODE FOR CONSULT-II….2046
HOW TO CHANGE SELF-DIAGNOSIS MODE WITH CONSULT-II….2047
HOW TO CHANGE SELF-DIAGNOSIS MODE WITHOUT CONSULT-II….2047
HOW TO ERASE SELF-DIAGNOSIS RESULTS….2047
How to Perform Trouble Diagnoses for Quick and Accurate Repair….2049
INFORMATION FROM CUSTOMER….2049
PRELIMINARY CHECK….2049
WORK FLOW….2050
Wiring Diagram – SRS -….2051
SRS Operation Check….2053
DIAGNOSTIC PROCEDURE 1….2053
Trouble Diagnoses with CONSULT-II….2053
DIAGNOSTIC PROCEDURE 2….2053
DIAGNOSTIC PROCEDURE 3….2057
DIAGNOSTIC PROCEDURE 4 (CONTINUED FROM DIAGNOSTIC PROCEDURE 2)….2058
DIAGNOSTIC PROCEDURE 5….2059
Trouble Diagnoses without CONSULT-II….2063
DIAGNOSTIC PROCEDURE 6….2063
DIAGNOSTIC PROCEDURE 7….2068
DIAGNOSTIC PROCEDURE 8 (CONTINUED FROM DIAGNOSTIC PROCEDURE 6)….2070
Trouble Diagnoses: "AIR BAG" Warning Lamp Does Not Turn Off….2071
DIAGNOSTIC PROCEDURE 9….2071
Trouble Diagnoses: "AIR BAG" Warning Lamp Does Not Turn On….2073
DIAGNOSTIC PROCEDURE 10….2073
Collision Diagnosis….2074
FOR FRONTAL COLLISION….2074
FOR SIDE COLLISION….2076
sc….2079
Table of Contents….2079
PRECAUTIONS….2080
Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….2080
Wiring Diagrams and Trouble Diagnosis….2080
PREPARATION….2081
Special Service Tool….2081
BATTERY….2082
How to Handle Battery….2082
METHODS OF PREVENTING OVER-DISCHARGE….2082
CHECKING ELECTROLYTE LEVEL….2082
SPECIFIC GRAVITY CHECK….2083
CHARGING THE BATTERY….2084
Trouble Diagnoses with Battery/Starting/Charging System Tester….2085
DIAGNOSTIC RESULT ITEM CHART….2087
STARTING SYSTEM….2088
System Description….2088
M/T MODELS….2088
A/T MODELS….2088
Wiring Diagram – START -….2089
M/T MODELS….2089
A/T MODELS….2090
Trouble Diagnoses with Battery/Starting/Charging System Tester….2091
DIAGNOSTIC RESULT ITEM CHART….2092
WORK FLOW….2093
DIAGNOSTIC PROCEDURE 1….2094
DIAGNOSTIC PROCEDURE 2….2096
MINIMUM SPECIFICATION OF CRANKING VOLTAGE REFERENCING COOLANT TEMPERATURE….2097
Construction….2097
Removal and Installation….2097
Pinion/Clutch Check….2098
CHARGING SYSTEM….2099
System Description….2099
Wiring Diagram – CHARGE -….2100
Trouble Diagnoses with Battery/Starting/Charging System Tester….2101
DIAGNOSTIC RESULT ITEM CHART….2103
WORK FLOW….2104
DIAGNOSTIC PROCEDURE 1….2105
DIAGNOSTIC PROCEDURE 2….2106
DIAGNOSTIC PROCEDURE 3….2107
MALFUNCTION INDICATOR….2107
Construction….2108
Removal and Installation….2108
SERVICE DATA AND SPECIFICATIONS (SDS)….2109
Battery….2109
Starter….2109
Alternator….2109
st….2111
Table of Contents….2111
PRECAUTIONS….2112
Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….2112
Precautions for Steering System….2112
PREPARATION….2113
Special Service Tools….2113
Commercial Service Tools….2114
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….2115
NVH Troubleshooting Chart….2115
ON-VEHICLE SERVICE….2116
Checking Steering Wheel Play….2116
Checking Neutral Position on Steering Wheel….2116
PRE-CHECKING….2116
CHECKING….2116
Front Wheel Turning Angle….2116
Checking Gear Housing Movement….2116
Checking and Adjusting Drive Belts….2117
Checking Fluid Level….2117
Checking Fluid Leakage….2117
Bleeding Hydraulic System….2117
Checking Steering Wheel Turning Force….2118
Checking Hydraulic System….2118
STEERING WHEEL AND STEERING COLUMN….2120
Components….2120
Removal and Installation….2120
STEERING WHEEL….2120
STEERING COLUMN….2121
Disassembly and Assembly….2123
Inspection….2124
TILT MECHANISM….2124
POWER STEERING GEAR AND LINKAGE….2125
Components….2125
Removal and Installation….2126
Disassembly….2128
Inspection….2128
BOOT….2128
RACK….2128
PINION ASSEMBLY….2129
GEAR HOUSING CYLINDER….2129
TIE-ROD OUTER AND INNER SOCKETS….2129
Assembly….2129
Adjustment….2134
POWER STEERING OIL PUMP….2136
Components….2136
Pre-disassembly Inspection….2136
Disassembly….2136
Inspection….2137
Assembly….2138
SERVICE DATA AND SPECIFICATIONS (SDS)….2141
General Specifications….2141
Steering Wheel….2141
Steering Column….2141
Steering Gear and Linkage….2142
Power Steering….2143
su….2145
Table of Contents….2145
FRONT SUSPENSION….2146
Precautions….2146
PRECAUTIONS….2146
Preparation….2146
SPECIAL SERVICE TOOLS….2146
COMMERCIAL SERVICE TOOLS….2146
Noise, Vibration and Harshness (NVH) Troubleshooting….2147
NVH TROUBLESHOOTING CHART….2147
Components….2148
On-vehicle Service….2149
FRONT SUSPENSION PARTS….2149
FRONT WHEEL ALIGNMENT….2150
Coil Spring and Shock Absorber….2153
COMPONENTS….2153
REMOVAL….2154
DISASSEMBLY….2154
INSPECTION….2154
ASSEMBLY….2155
Third Link and Upper Link….2155
REMOVAL….2155
INSTALLATION….2155
DISASSEMBLY….2156
ASSEMBLY….2156
Stabilizer Bar….2157
REMOVAL AND INSTALLATION….2157
Transverse Link and Lower Ball Joint….2158
REMOVAL AND INSTALLATION….2158
INSPECTION….2158
Service Data and Specifications (SDS)….2158
GENERAL SPECIFICATIONS (FRONT)….2158
FRONT WHEEL ALIGNMENT (UNLADEN*1)….2159
LOWER BALL JOINT….2159
WHEELARCH HEIGHT (UNLADEN*)….2160
WHEEL RUNOUT….2160
REAR SUSPENSION….2161
Precautions….2161
PRECAUTIONS….2161
Preparation….2161
COMMERCIAL SERVICE TOOLS….2161
Noise, Vibration and Harshness (NVH) Troubleshooting….2161
Components….2162
On-vehicle Service….2163
REAR SUSPENSION PARTS….2163
REAR WHEEL ALIGNMENT….2163
Removal and Installation….2165
REMOVAL….2166
INSTALLATION….2166
Coil Spring and Shock Absorber….2166
REMOVAL….2166
DISASSEMBLY….2167
INSPECTION….2167
ASSEMBLY….2167
Torsion Beam, Lateral Link and Control Rod….2168
DISASSEMBLY….2168
INSPECTION….2168
ASSEMBLY….2168
Service Data and Specifications (SDS)….2169
GENERAL SPECIFICATIONS (REAR)….2169
REAR WHEEL ALIGNMENT (UNLADEN*)….2169

EXCERPT:
Inspection
Check for cracks and excessive wear at roller links. Replace chain if necessary.
Installation
1. Install crankshaft sprocket on crankshaft.
Make sure that mating marks on crankshaft sprocket face front of engine.
2. Position crankshaft so that No. 1 piston is set at TDC and key way is at 12 o’clock. Fit timing chain on crankshaft sprocket, aligning the mating marks.
Mating mark color on timing chain.
1: Yellow
2, 3: Blue
3. Install timing chain and timing chain guides.
…
Infiniti G20 (P11) Workshop Service Repair Manual 1999-2002

---

INSTANT DOWNLOAD

---

---

INSTANT DOWNLOAD

---

Complete workshop repair service manual with electrical wiring diagrams for Infiniti G20 (P10) 1991-1996 (350MB PDF). It’s the same service manual used by dealers that guaranteed to be fully functional and intact without any missing page.

This Infiniti G20 (P10) 1991-1996 service & repair manual (including maintenance, overhaul, disassembling & assembling, adjustment, tune-up, operation, inspecting, diagnostic & troubleshooting…) is divided into different sections. Each section covers a specific component or system with detailed illustrations. A table of contents is placed at the beginning of each section. Pages are easily found by category, and each page is expandable for great detail. The printer-ready PDF documents work like a charm on all kinds of devices.

TABLE OF CONTENTS
  PREPARATION AND PRECAUTIONS….4
    Special Service Tools….4
    Commercial Service Tools….7
    Service Notice….7
    Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….8
  DESCRIPTION….9
    Cross-sectional View – RE4F03A….9
    Cross-sectional View – RE4F03V….10
    Hydraulic Control Circuit….11
    Shift Mechanism….12
    Control System….14
  TROUBLE DIAGNOSES….16
    How to Perform Trouble diagnoses for Quick and Accurate Repair….16
    Remarks….20
    Diagnostic Trouble Code (DTC) Chart….21
    Diagnosis by CONSULT….23
    Preliminary Check….26
    A/T Electrical Parts Location….40
    Circuit Diagram for Quick Pinpoint Check….41
    Wiring Diagram – AT –….42
    Self-diagnosis….49
      DTC P0720 VEHICLE SPEED SENSOR A/T (REVOLUTION SENSOR) CIRCUIT CHECK….55
      VEHICLE SPEED SENSOR MTR CIRCUIT CHECK….57
      DTC P1705 THROTTLE POSITION SENSOR CIRCUIT CHECK….59
      DTC P0750 SHIFT SOLENOID VALVE A CIRCUIT CHECK….61
      DTC P0755 SHIFT SOLENOID VALVE B CIRCUIT CHECK….63
      DTC P1760 OVERRUN CLUTCH SOLENOID VALVE CIRCUIT CHECK….65
      DTC P0740 TORQUE CONVERTER CLUTCH SOLENOID VALVE CIRCUIT CHECK….67
      DTC P0710 FLUID TEMPERATURE SENSOR CIRCUIT AND A/T CONTROL UNIT POWER SOURCE CIRCUIT CHECKS….69
      DTC P0725 ENGINE SPEED SIGNAL CIRCUIT CHECK….72
      DTC P0745 LINE PRESSURE SOLENOID VALVE CIRCUIT CHECK….74
      DTC P0705 INHIBITOR, OVERDRIVE AND THROTTLE POSITION SWITCH CIRCUIT CHECK….76
      DTC P0731 IMPROPER SHIFTING TO 1ST GEAR POSITION….80
      DTC P0732 IMPROPER SHIFTING TO 2ND GEAR POSITION….82
      DTC P0733 IMPROPER SHIFTING TO 3RD GEAR POSITION….84
      DTC P0734 IMPROPER SHIFTING TO 4TH GEAR POSITION….86
    Diagnostic Procedures for Symptoms….90
      Diagnostic Procedure 1….90
      Diagnostic Procedure 2….91
      Diagnostic Procedure 3….91
      Diagnostic Procedure 4….91
      Diagnostic Procedure 5….92
      Diagnostic Procedure 6….92
      Diagnostic Procedure 7….93
      Diagnostic Procedure 8….94
      Diagnostic Procedure 9….95
      Diagnostic Procedure 10….96
       Diagnostic Procedure 11….97
      Diagnostic Procedure 12….98
      Diagnostic Procedure 13….99
      Diagnostic Procedure 14….100
      Diagnostic Procedure 15….101
      Diagnostic Procedure 16….102
      Diagnostic Procedure 17….102
      Diagnostic Procedure 18….103
      Diagnostic Procedure 19….104
      Diagnostic Procedure 20….104
      Diagnostic Procedure 21….105
      Diagnostic Procedure 22….105
      Diagnostic Procedure 23….105
    Electrical Components Inspection….106
    Final Check….113
    Symptom Chart….118
  TROUBLE DIAGNOSES – A/T Shift Lock System….121
    Description….121
    Shift Lock System Electrical Parts Location….122
    Wiring Diagram – SHIFT –….123
    Diagnostic Procedure….124
    Key Interlock Cable….128
    Shift Lock Control Unit Inspection….130
    Shift Lock Control Unit Inspection Table….130
    Component Check….131
  ON-VEHICLE SERVICE….132
    Control Valve Assembly and Accumulator….132
    Control Cable Adjustment….133
    Inhibitor Switch Adjustment….133
    Differential Side Oil Seal Replacement….134
    Revolution Sensor Replacement….134
  REMOVAL AND INSTALLATION….135
    Removal….135
    Installation….136
  MAJOR OVERHAUL….138
    REF03A and RE4V03V….138
    Oil Channel….141
    Locations of Adjusting Shims, Needle Bearings, Thrust Washers and Snap Rings….142
  DISASSEMBLY….143
  REPAIR FOR COMPONENT PARTS….156
    Manual Shaft….156
    Oil Pump….159
    Control Valve Assembly….163
    Control Valve Upper Body….172
    Control Valve Lower Body….176
    Reverse Clutch….178
    High Clutch….182
    Forward Clutch and Overrun Clutch….187
    Low & Reverse Brake….193
    Rear Internal Gear, Forward Clutch Hub and Overrun Clutch Hub….197
    Output Shaft, Idler Gear, Reduction Pinion Gear and Bearing Retainer….201
    Band Servo Piston Assembly….206
    Final Drive….211
  ASSEMBLY….217
    Assembly 1….217
    Adjustment 1….218
    Assembly 2….223
    Adjustment 2….227
    Assembly 3….231
  SERVICE DATA AND SPECIFICATIONS (SDS)….238
    General Specifications….238
    Specifications and Adjustments….238
BR….246
  TABLE OF CONTENTS….246
  PRECAUTIONS AND PREPARATION….247
    Precautions….247
    Commercial Service Tools….247
  BRAKE HUDRAULIC LINE/CONTROL VALVE….248
    Brake Hydraulic Line….248
    Dual Proportioning Valve….249
  CHECK AND ADJUSTMENT….250
    Checking Brake Fluid Level….250
    Checking Brake Line….250
    Changing Brake Fluid….250
    Bleeding Brake System….251
  BRAKE PEDAL AND BRACKET….252
    Removal and Installation….252
    Inspection….252
    Adjustment….252
  MASTER CYLINDER….253
    Removal….253
    Disassembly….253
    Inspection….254
    Assembly….254
    Installation….254
  BRAKE BOOSTER/VACUUM HOSE….255
    Brake Booster….255
    Vacuum Hose….256
  FRONT DISC BRAKE….257
    Pad Replacement….257
    Removal….258
    Disassembly….259
    Inspection – Caliper….259
    Inspection – Rotor….259
    Assembly….260
    Installation….260
  REAR DISC BRAKE….261
    Pad Replacement….261
    Removal….263
    Disassembly….263
    Inspection – Caliper….264
    Inspection – Rotor….265
    Assembly….265
    Installation….267
  PARK BRAKE CONTROL….268
    Removal and Installation….268
    Inspection….269
    Adjustment….269
  ANTI-LOCK BRAKE SYSTEM….270
    Purpose….270
    Operation….270
    ABS Hydraulic Circuit….270
    System Components….271
    System Description….271
    Removal and Installation….272
    Wiring Diagram – ABS –….274
  TROUBLE DIAGNOSES….278
    Contents….278
    Component Parts and Harness Connector Location….282
  SERVICE DATA AND SPECIFICATIONS (SDS)….305
    General Specifications….305
    Inspection and Adjustment….305
BT….306
  TABLE OF CONTENTS….306
  PRECAUTIONS….307
    Service Notice….307
    Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….307
  GENERAL SERVICING….308
    Clip and Fastener….308
  BODY END….310
    Body Front End….310
    Body Rear End and Opener….311
  DOOR….313
    Front Door….313
    Rear Door….314
  INSTRUMENT PANEL….315
  INTERIOR TRIM….317
    Side and Floor Trim….317
    Door Trim….319
    Roof Trim….320
    Trunk Room Trim….321
  EXTERIOR….322
  SEAT….328
    Front Seat….328
    Rear Seat….330
  SUN ROOF….331
  WINDSHIELD AND WINDOWS….333
    Windshield and Rear Window….333
  MIRROR….334
    Door Mirror….334
  REAR AIR SPOILER….335
  BODY ALIGNMENT….336
    Engine Compartment….336
    Underbody….338
CL….340
  TABLE OF CONTENTS….340
  PRECAUTION AND PREPARATION….341
    Precaution….341
    Special Service Tools….341
  CLUTCH SYSTEM….342
  INSPECTION AND ADJUSTMENT….343
    Adjusting Clutch Pedal….343
  CLUTCH RELEASE MECHANISM….344
  CLUTCH DISC AND CLUTCH COVER….345
    Clutch Disc….345
    Clutch Cover and Flywheel….346
  SERVICE DATA AND SPECIFICATIONS….347
    General Specifications….347
    Inspection and Adjustment….347
EC….348
  TABLE OF CONTENTS….348
  PRECAUTIONS AND PREPARATION….350
    Special Service Tools….350
    Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….350
    Precautions for On-Board Diagnostic (OBD) System of Engine and A/T….351
    Engine Fuel & Emission Control System….352
    Precautions….353
  ENGINE AND EMISSION CONTROL OVERALL SYSTEM….355
    Circuit Diagram….355
    System Diagram….356
    ECCS Component Parts Location….357
    Vacuum Hose Drawing….361
    System Chart….362
  ENGINE AND EMISSION BASIC CONTROL SYSTEM DESCRIPTION….363
    Multiport Fuel Injection (MFI) System….363
    Distributor Ignition (DI) System….365
    Air Conditioning Cut Control….366
    Fuel Cut Control (at no load & high engine speed)….367
  EVAPORATIVE EMISSION SYSTEM….368
    Description….368
    Inspection….368
  POSITIVE CRANKCASE VENTILATION….370
    Description….370
    Inspection….370
  BASIC SERVICE PROCEDURE….371
    Fuel Pressure Release….371
    Fuel Pressure Check….371
    Fuel Pressure Regulator Check….372
    Injector Removal and Installation….372
    Idle Speed/Ignition Timing/Idle Mixture Ratio Adjustment….373
  ON-BOARD DIAGNOSTIC SYSTEM DESCRIPTION….380
    Introduction….380
    Two Trip Detection Logic….380
    Diagnostic Trouble Code (DTC)….380
    Freeze Frame Data….381
    Malfunction Indicator lamp (MIL)….382
    OBD System Operation Chart….385
    CONSULT….390
    Generic Scan Tool (GST)….402
  TROUBLE DIAGNOSIS – Indroduction….404
    Introduction….404
    Diagnostic Worksheet….405
  TROUBLE DIAGNOSIS – Work Flow….406
    Work Flow….406
    Description for Work Flow….407
  TROUBLE DIAGNOSIS – Basic Inspection….408
    Basic Inspection….408
  TROUBLE DIAGNOSIS – General Description….411
    Diagnostic Troubel Code (DTC) Chart….411
    Fail-Safe Chart….422
    Symptom Martix Chart….423
    CONSULT Reference Value In Data Monitor Mode….426
    Major Sensor Reference Graph in Data Monitor Mode….428
    ECM Terminals and Reference Value….430
  TROUBLE DIAGNOSIS FOR POWER SUPPLY….436
    Main Power Supply and Ground Circuit….436
  DTC P0100, Mass Air flow Sensor (MAFS) (DTC: 0102)….439
  DTC P0110, Intake air temperature Sensor (DTC: 0401)….444
  DTC P0115, Engine Coolant Temperature Sensor (ECTS) (DTC: 0103)….449
  DTC P0120, Throttle Position Sensor (DTC: 0403)….453
  DTC P0125, Engine Coolant Temperature (ECT) Sensor (DTC: 0908)….458
  DTC P0130, Front Heated Oxygen Sensor (Front H02S) (DTC: 0303)….463
  DTC P0130, Closed Loop Control (DTC: 0307)….468
  DTC P0135, Front Heated Oxygen Sensor Heater (DTC: 0901)….469
  DTC P0136, Rear Heated Oxygen Sensor (Rear HO2S) (DTC: 0707)….473
  DTC P0170, Fuel injection system Function (DTC: 0706)….478
  DTC P0300 – P0304, No. 4 – 1 Cylinder Milsfire, Multiple Cylinder Misfire (DTC: 0701 – 0605)….483
  DTC P0325, Knock Sensor (KS) (DTC: 0304)….487
  DTC P0335, Crankshaft Position Sensor (CKPS) (OBD) (DTC: 0802)….490
  DTC P0340, Camshaft Position Sensor (CMPS) (DTC: 0101)….494
  DTC P0400, EGR Function (DTC: 0302)….498
  DTC P0402, EGRC-BPT Valve Function (DTC: 0306)….507
  DTC P0420, Three Way Catalyst Function (DTC: 0702)….509
  DTC P0500, Vehicle Speed Sensor (VSS) (DTC: 0104)….512
  DTC P0505, Idle Air Control Valve (IACV) – Auxiliary Air control (AAC) Valve (DTC: 0205)….516
  DTC P0600, A/T Control (DTC: 0600)….520
  DTC P0605, Engine control Module (ECM)-ECCS Control Module (DTC: 0301)….523
  DTC P0705, Park/Neutral Position SWitch (DTC: 1003)….525
  DTC P1320, Ignition Signal (DTC: 0201)….529
  DTC P1336, Crankshaft Position Sensor (CKPS) (OBD) (COG) (DTC: 0905)….534
  DTC P1400, EGR Valve & EVAP Canister Purge Control Solenoid Valve (DTC: 1005)….538
  DTC P1401, EGR Temperature Sensor (DTC: 0305)….542
  DTC P1605, A/T Diagnosis Communication line (DTC: 0804)….547
  DTC P1900, Cooling Fan (Overheat) (DTC 0208)….550
  TROUBLE DIAGNOSIS FOR NON-DETECTABLE ITEMS….569
    Injector….569
    Start Signal….572
    Fuel Pump….574
    Power Steering Oil Pressure Switch….578
    IACV-Air Regulator….581
    IACV-FICD Solenoid Valve….584
    MIL & Data Link Connectors….588
  TROUBLE DIAGNOSIS – Index….589
    Alphabetical & P No. Index for DTC….589
  SERVICE DATA AND SPECIFICATIONS (SDS)….590
    General Specification….590
    Inspection and Adjustment….590
EL….592
  TABLE OF CONTENTS….592
  PRECAUTION….595
    Supplemental Restraint System "AIR BAG" and "SEAT BELT PRE-TENSIONER"….595
  HARNESS CONNECTOR….596
    Description….596
  STANDARDIZED RELAY….597
    Description….597
  POWER SUPPLY ROUTING….601
    Schematic….601
    Wiring Diagram – POWER –….603
    Fuse….608
    Fusible Link….608
    Circuit Breaker Inspection….608
  GROUND DISTRIBUTION….609
  BATTERY….613
    How to Handle Battery….613
    Service Data and Specifications (SDS)….616
  STARTING SYSTEM….617
    System Description….617
    Wiring Diagram – START –….618
    Construction….620
    Removal and Installation….621
    Pinion/Clutch Check….621
    Service Data and Specifications (SDS)….621
  CHARGING SYSTEM….622
    System Description….622
    Construction….622
    Wiring Diagram – CHARGE –….623
    Trouble Diagnoses….624
    Service Data and Specifications (SDS)….625
  COMBINATION SWITCH….626
    Combination Switch/Check….626
    Replacement….627
  HEADLAMP….628
    System Description (For U.S.A.)….628
    Wiring Diagram (For U.S.A.) – H/LAMP –….629
    Trouble Diagnoses (For U.S.A.)….630
    System Description (For Canada)….631
    Operation….632
    Schematic….632
    Wiring Diagram (For Canada) – DTRL –….633
    Trouble Diagnoses (For Canada)….636
    Bulb Replacement….637
    Aiming Adjustment….638
  EXTERIOR LAMP….640
    Clearance, License, Tail and Stop Lamps/Schematic….640
    Clearance, License, Tail and Stop Lamps/Wiring Diagram – TAIL/L –….641
    Back-up Lamp/Wiring Diagram – BACK/L –….644
    Front Fog Lamp/System Description….645
    Front Fog Lamp/Wiring Diagram – F/FOG –….646
    Turn Signal and Hazard Warning Lamps/System Description….647
    Turn Signal and Hazard Warning Lamps/Schematic….649
    Turn Signal and Hazard Warning Lamps/Wiring Diagram – TURN –….650
    Turn Signal and Hazard Warning Lamps/Trouble Diagnoses….653
    Combination Flasher Unit Check….653
    Bulb Specifications….654
  INTERIOR LAMP….655
    Illumination/System Description….655
    Illumination/Schematic….656
    Illumination/Wiring Diagram – ILL –….657
    Interior, Spot and Trunk Room Lamps/System Dessciption….660
    Interior, Spot and Trunk Room Lamps/Wiring Diagram – INT/L –….662
  METER AND GAUGES….663
    System Description….663
    Combination Meter….664
    Speedometer, Tachometer, Temp., Oil and Fuel Gauges/Wiring Diagram – METER –….665
    Inspection/Fuel Gauge, Water Temperature Gauge and Oil Pressure Gauge….667
    Fuel Tank Gauge Unit Check….668
    Fuel Warning Lamp Sensor Check….668
    Thermal Transmitter Check….668
    Oil Pressure Switch Check….669
    Vehicle Speed Sensor Signal Check….669
  WARNING LAMPS AND CHIME….670
    Warning Lamps/Schematic….670
    Warning Lamps/Wiring Diagram – WARN –….671
    Warning Chime/System Description….673
    Warning Chime/Wiring Diagram – CHIME –….674
    Diode Check….675
    Warning Chime Check….675
  POWER WINDOW….676
    System Description….676
    Schematic….679
    Wiring Diagram – WINDOW –….680
    Trouble Diagnoses….685
  POWER DOOR LOCK….686
    System Description….686
    Schematic….688
    Wiring Diagram – D/LOCK –….689
    Door Lock Timer Inspection….694
    Electrical Components Inspection….696
  MULTI-REMOTE CONTROL SYSTEM….698
    System Description….698
    Schematic….701
    Wiring Diagram – MULTI –….702
    Trouble Diagnoses Preliminary Inspection….707
    Trouble Diagnoses….708
    Replacing Remote Controller or Control Unit….714
  TIME CONTROL SYSTEM….715
    System Description….715
    Schematic….716
    Wiring Diagram – TIME –….717
    Trouble Diagnoses….722
  WIPER AND WASHER….732
    Front Wiper and Washer/System Description….732
    Front Wiper and Washer/Wiring Diagram – WIPER –….734
    Installation….735
    Washer Nozzle Adjustment….736
    Check Valve….736
    Washer Tube Layout….736
  HORN, CIGARETTE LIGHTER AND CLOCK….737
    Wiring Diagram – HORN –….737
  REAR WINDOW DEFOGGER….738
    System Description….738
    Wiring Diagram – DEF –….739
    Filament Check….740
    Filament Repair….741
  AUDIO AND POWER ANTENNA….742
    Audio/System Description….742
    Audio/Wiring Diagram – AUDIO –….743
    Power Antenna/System Description….745
    Power Antenna/Wiring Diagram – P/ANT –….746
    Trouble Diagnoses….747
    Location of Antenna….748
    Antenna Rod Replacement….749
    Window Antenna Repair….750
  ELECTRIC SUNROOF….751
    Wiring Diagram – SROOF –….751
  SEAT….752
    Wiring Diagram – SEAT –….752
  POWER DOOR MIRROR….754
    Schematic….754
    Wiring Diagram – MIRROR –….755
  DOOR MIRROR WITH HEATED MIRROR….757
    Wiring Diagram – H/MIRR –….757
  TRUNK LID AND FUEL FILLER LID OPENER….761
    Trunk Lid and Fuel Filler Lid Opener/Wiring Diagram – TLID –….761
  AUTOMATIC SPEED CONTROL DEVICE (ASCD)….762
    System Description….762
    Component Parts and Harness Connector Location….764
    Schematic….765
    Wiring Diagram – ASCD –….766
    Trouble Diagnoses….771
  THEFT WARNING SYSTEM….784
    Component Parts and Harness Connector Location….784
    Schematic….785
    Wiring Diagram – THEFT –….787
    Trouble Diagnoses….794
  LOCATION OF ELECTRICAL UNITS….811
    Engine Compartment….811
    Passenger Compartment….812
    Luggage Compartment….813
  HARNESS LAYOUT….814
    Outline….814
    Engine Room Harness….815
    Room Lamp Harness….818
    Main Harness….819
    Main Harness, Tail Harness and Tail Harness No.2….822
    Engine Control Harness and Alternator Harness….823
    Engine Harness….824
    Door Harness (LH side)….825
    Door Harness (RH side)….826
    Air Bag Harness….827
EM….828
  TABLE OF CONTENTS….828
  PRECAUTIONS….829
    Parts Requiring Angular Tightening….829
    Liquid Gasket Application Procedure….829
  PREPARATION….830
    Special Service Tools….830
    Commercial Service Tools….833
  OUTER COMPONENT PARTS….834
  COMPRESSION PRESSURE….837
    Measurenment of Compression Pressure….837
  OIL PAN….838
    Removal….838
    Installation….841
  TIMING CHAIN….843
    Removal….844
    Inspection….848
    Installation….848
  OIL SEAL REPLACEMENT….857
  CYLINDER HEAD….859
    Removal….860
    Disassembly….860
    Inspection….862
    Assembly….867
    Installation….871
  ENGINE REMOVAL….872
    Removal….873
    Installation….874
  CYLINDER BLOCK….875
    Disassembly….876
    Inspection….876
  SERVICE DATA DAND SPECIFICATIONS (SDS)….887
    General Specifications….887
    Inspection and Adjustment….887
FA….895
  TABLE OF CONTENTS….895
  PRECAUTIONS AND PREPARATION….896
    Precautions….896
    Special Service Tools….896
    Commercial Service Tools….896
  FRONT AXLE AND FRONT SUSPENSION….897
  ON-VEHICLE SERVICE….898
    Front Axle and Front Suspension Parts….898
    Front Wheel Bearing….899
    Front Wheel Alignment….900
    Drive Shaft….901
  FRONT AXLE….902
    Wheel Hub and Knuckle….902
    Drive Shaft….906
  FRONT SUSPENSION….916
    Coil Spring and Shock Absorber….917
    Third Link and Upper Link….918
    Stabilizer Bar….920
    Transverse Link and Lower Ball Joint….921
  SERVICE DATA AND SPECIFICATIONS (SDS)….922
    General Specifications….922
    Inspection and Adjustment….923
FE….924
  TABLE OF CONTENTS….924
  PREPARATION/ACCELERATOR CONTROL SYSTEM….925
    Special Service Tool….925
    Accelerator Control System….925
    Adjusting Accelerator Wire….925
  FUEL SYSTEM….926
    Fuel Tank….926
    Fuel Pump and Gauge….928
  EXHAUST SYSTEM….929
FWD….930
  QUICK REFERENCE INDEX….930
  FOREWORD….931
  Inch to Metric Conversion….932
  Quick Reference Chart….933
Foldout….934
  SUPER MULTIPLE JUNCTION (SMJ)….934
    INSTALLATION….934
    Terminal Arrangement….935
  JOINT CONNECTOR….936
    Terminal Arrangement….936
GI….937
  TABLE OF CONTENTS….937
  PRECAUTIONS….938
    Supplemental Restraint System "AIR BAG" and "SEAT BELT PRE-TENSIONER"….938
    General Precautions….938
    Precautions for Multiport Fuel Injection System or ECCS Engine….940
    Precautions for Three Way Catalyst….940
    Engine Oils….940
    Precautions for Fuel….941
    Precautions for Air Conditioning….941
  HOW TO USE THIS MANUAL….942
  HOW TO READ WIRING DIAGRAMS….944
    Sample/Wiring Diagram – EXAMPL –….944
    Description….946
    Wiring diagram Codes (Cell Codes)….952
  HOW TO PERFORM EFFICIENT DIAGNOSIS FOR AN ELECTRICAL INCIDENT….953
    Work Flow….953
    Incident Simulation Tests….954
    Circuit Inspection….958
  HOW TO FOLLOW FLOW CHART IN TROUBLE DIAGNOSES….964
  CONSULT CHECKING SYSTEM….967
    Function and system Application….967
    Lithium Battery Replacement….967
    Checking Equipment….967
  IDENTIFICATION INFORMATION….968
    Model Variation….968
    Identification Number….969
    Dimensions….971
    Wheels and Tires….971
  LIFTING POINTS AND TOW TRUCK TOWING….972
    Preparation….972
    Board-on Lift….972
    Garage Jack and Safety Stand….973
    2-pole Lift….973
    Tow Truck Towing….974
  TIGHTENING TORQUE OF STANDARD BOLTS….975
  SAE J1930 TERMINOLOGY LIST….976
    SAE J1930 Terminology List….976
HA….980
  TABLE OF CONTENTS….980
  PRECAUTIONS AND PREPRARTION….981
    Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….981
    Introduction….982
    Identification….982
    Precautions for Working with HFC-134a (R-134a)….983
    General Refrigerant Precautions….983
    Precautions for Refrigerant Connection….984
    Precautions for Servicing Compressor….985
    Special Service Tools….985
    HFC-134a (R-134a) Service Tools and Equipment….986
    Precautions for Service Equipment….988
  DESCRIPTION….990
    Refrigeration Cycle….990
    Component Layout….991
    Discharge Air Flow….992
    Control Operation….994
  TROUBLE DIAGNOSES….995
    Contents….995
    Wiring Diagram – A/C –….1016
  SYSTEM DESCRIPTION….1044
    Push Control System….1044
  SERVICE PROCEDURES….1047
    HFC-134a (R-134a) Service Procedure….1047
    Maintenance of Lubricant Quantity in Compressor….1049
    Refrigerant Lines….1051
    Checking Refrigerant Leaks….1052
    Compressor Mounting….1054
    Thermo Control Amp…1054
    Belt Tension….1054
    Fast Idle Control Device (FICD)….1054
    Compressor….1055
    Compressor Clutch….1055
    Thermal Protector….1057
    Push Control System….1058
  SERVICE DATA AND SPECIFICATIONS (SDS)….1061
    General Specifications….1061
    Inspection and Adjustment….1061
IDX….1062
LC….1070
  TABLE OF CONTENTS….1070
  PRECAUTION….1071
    Liquid Gasket Application Procedure….1071
  PREPARATION….1072
    Special Service Tools….1072
  ENGINE LUBRICATIONS SYSTEM….1073
    Lubrication Circuit….1073
    Oil Pressure Check….1073
    Oil Pump….1074
  ENGINE COOLING SYSTEM….1077
    Cooling Circuit….1077
    System Check….1077
    Cooling System Inspection….1077
    Water Pump….1078
    Thermostat….1079
    Water Outlet….1080
    Radiator….1081
    Cooling Fan control System….1084
    Refilling Engine Coolant….1084
    Overheating Cause Analysis….1085
  SERVICE DATA AND SPECIFICATIONS (SDS)….1086
    Engine Lubrication system….1086
    Engine Cooling system….1086
MA….1087
  TABLE OF CONTENTS….1087
  PRECAUTIONS AND PREPARATION….1088
    Supplemental Restraint System "AIR BAG" and "SEAT BELT PRE-TENSIONER"….1088
    Special Service Tool….1088
  GENERAL MAINTENANCE….1089
  PERIODIC MAINTENANCE….1091
    Schedule 1….1092
    Schedule 2….1093
  RECOMMENDED FLUIDS AND LUBRICANTS….1094
    Fluids and Lubricants….1094
    SAE Viscosity Number….1094
    Anti-freeze Coolant Mixture Ratio….1095
  ENGINE MAINTENANCE….1096
    Checking Drive Belts….1096
    Changing Engine Coolant….1097
    Checking Fuel Lines….1098
    Changing Fuel Filter….1099
    Changing Air Cleaner Filter….1099
    Changing Engine Oil….1100
    Changing Oil Filter….1100
    Changing Spark Plugs (Platinum-tipped type)….1101
    Changing Spark Plugs (Conventional type)….1102
    Checking EVAP Vapor Purge Lines….1102
  CHASSIS AND BODY MAINTENANCE….1103
    Checking Exhaust System….1103
    Checking Clutch System….1103
    Checking M/T Oil….1103
    Changing M/T Oil….1103
    Checking A/T Fluid….1103
    Changing A/T Fluid….1104
    Balancing Wheels….1104
    Tire Rotation….1105
    Checking Brake Fluid Level and Leaks….1105
    Checking Brake Lines and Cables….1105
    Checking Disc Brake….1105
    Checking Steering Gear and Linkage….1106
    Checking Power Steering Fluid and Lines….1106
    Lubricating Hood Latches, Locks and Hingers….1107
    Checking Seat Belts, Buckles, Retractors, Anchors and Adjusters….1107
  SERVICE DATA AND SPECIFICATIONS (SDS)….1108
    Engine Maintenance….1108
    Chassis and Body Maintenance….1108
MT….1109
  TABLE OF CONTENTS….1109
  PREPARATION….1110
    Special Service Tools….1110
    Commercial Service Tools….1112
  ON-VEHICLE SERVICE….1113
    Replacing Oil Seal….1113
    Position Switch Check….1114
  REMOVAL AND INSTALLATION….1115
    Removal….1115
    Installation….1116
  TRANSAXLE GEAR CONTROL….1117
  MAJOR OVERHAUL….1118
    Case Components….1118
    Gear Components….1119
    Shift Control Components….1120
  DISASSEMBLY….1121
  REPAIR FOR COMPONENTS PARTS….1124
    Input Shaft and Gears….1124
    Mainshaft and Gears….1126
    Final Drive….1132
    Shift Control Components….1136
    Case Components….1138
  ADJUSTMENT….1141
    Differential Side Bearing Preload….1141
  ASSEMBLY….1143
  SERVICE DATA AND SPECIFICATIONS (SDS)….1147
    General Specifications….1147
    Inspection and Adjustment….1147
QR….1151
  ENGINE – SR20DE….1151
  A/T….1154
  M/T….1156
  HEATER & A/C….1159
  SUSPENSION….1162
  BRAKE SYSTEM….1165
  ELECTRICAL….1168
RA….1171
  TABLE OF CONTENTS….1171
  PRECAUTIONS AND PREPARATION….1172
    Precautions….1172
    Special Service Tools….1172
    Commercial Service Tools….1172
  REAR AXLE AND REAR SUSPENSION….1173
  ON-VEHICLE SERVICE….1174
    Rear Axle and Rear Suspension Parts….1174
    Rear Wheel Bearing….1174
    Rear Wheel Alignment….1174
  REAR AXLE….1176
    Wheel Hub….1176
  REAR SUSPENSION….1177
    Removal and Installation….1178
    Coil Spring and Strut Assembly….1178
    Stabilizer Bar….1179
  SERVICE DATA AND SPECIFICATIONS (SDS)….1180
    General Specifications….1180
    Inspection and Adjustment….1180
RS….1181
  TABLE OF CONTENTS….1181
  PRECAUTION….1182
    Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….1182
  SEAT BELTS….1183
    Front Seat Belt….1183
    Rear Seat Belt….1184
  SUPPLEMENTAL RESTRAINT SYSTEM (SRS)….1185
    Precautions for SRS "Air Bag" and "Seat Belt Pre-tensioner" Service….1185
    Special Service Tools….1185
    Description….1186
    SRS Component Parts Location….1187
    Maintenance Items….1188
    Removal and Installation – Diagnosis Unit, Sensors and Seat Belt Pre-tensioner….1189
    Removal – Air Bag Module and Spiral Cable….1190
    Removal – Front Passenger Air Bag Module….1191
    Installation – Air Bag Module and Spiral Cable….1192
    Installation – Front Passenger Air Bag Module….1193
    Disposal of Air Bag Module and Seat Belt Pre-tensioner….1194
  TROUBLE DIAGNOSES – Supplemental Restraint System (SRS)….1199
    Schematic….1199
    Wiring Diagram – SRS –….1200
    Self-diagnosis….1204
    Diagnostic Procedure 1….1210
    Diagnostic Procedure 2….1210
    Diagnostic Procedure 3….1211
    Collision Diagnosis….1211
ST….1213
  TABLE OF CONTENTS….1213
  PRECAUTIONS AND PREPARATION….1214
    Precautions….1214
    Special Service Tools….1214
    Commercial Service Tool….1215
  ON-VEHICLE SERVICE….1216
    Checking Steering Wheel Play….1216
    Checking Neutral Position on Steering Wheel….1216
    Front Wheel Turning Angle….1216
    Checking Gear Housing Movement….1217
    Checking and Adjusting Drive Belts (For power steering)….1217
    Checking Fluid Level….1217
    Checking Fluid Leakage….1217
    Bleeding Hydraulic System….1218
    Checking Steering Wheel Turning Force (For power steering)….1218
    Checking Hydraulic System….1219
  STEERING WHEEL AND STEERING COLUMN….1220
    Removal and Installation….1220
    Disassembly and Assembly….1222
    Inspection….1223
  POWER STEERING GEAR AND LINKAGE….1224
    Removal and Installation….1224
    Disassembly….1226
    Inspection….1227
    Assembly….1228
    Adjustment….1232
  POWER STEERING OIL PUMP….1234
    Pre-disassembly Inspection….1234
    Disassembly….1235
    Inspection….1235
    Assembly….1236
  SERVICE DATA AND SPECIFICATIONS (SDS)….1237
    General Specifications….1237
    Inspection and Adjustment….1237

EXCERPT:
Removal
1. Release fuel pressure. Refer to EC section (“”Fuel Pressure Release'”, “‘BASIC SERVICE PROCEDURE”‘).
2. Remove engine under covers.
3. Remove front RH wheel and engine side cover.
4. Drain coolant by removing cylinder block drain plug and radiator drain cock. Refer to MA section (“‘Changing Engine Coolant”, “‘ENGINE MAINTENANCE”).
5. Remove radiator.
6. Remove air duct to intake manifold.
7. Remove drive belts and water pump pulley.
8. Remove alternator and power steering pump.
9. Disconnect the following parts:
• Vacuum hoses
• Fuel hoses
• Wires
• Harness
• Connectors
10. Remove all spark plugs.
11. Remove rocker cover and oil separator.
12. Remove intake manifold supports.
…
Infiniti G20 (P10) Service & Shop Manual 1991-1996

---

INSTANT DOWNLOAD

---

---

INSTANT DOWNLOAD

---

Complete workshop manual contains service, maintenance, and troubleshooting information for the 2009-2016 Infiniti FX/FX35/FX37/FX37 Limited Edition/FX50/QX70 (S51). Diagnostic and repair procedures are covered in great detail to repair, maintain, rebuild, refurbish or restore your vehicle like a professional mechanic in local service/repair workshop. This cost-effective quality manual is 100% complete and intact as should be without any missing pages. It is the same factory shop manual used by dealers that guaranteed to be fully functional to save your precious time.

This manual for 2009-2016 Infiniti FX/FX35/FX37/FX37 Limited Edition/FX50/QX70 (S51) is divided into different sections. Each section covers a specific component or system and, in addition to the standard service procedures, includes disassembling, inspecting, and assembling instructions. A table of contents is placed at the beginning of each section. Pages are easily found by category, and each page is expandable for great detail. It is in the cross-platform PDF document format so that it works like a charm on all kinds of devices. You do not need to be skilled with a computer to use the manual.

  Table of Contents
    PRECAUTION….4
      PRECAUTIONS….4
        PRECAUTIONS….4
        Precautions for Removing Battery Terminal….4
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….4
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….4
    REMOVAL AND INSTALLATION….5
      ACCELERATOR CONTROL SYSTEM….5
        ACCELERATOR CONTROL SYSTEM….5
        MODELS WITHOUT DISTANCE CONTROL ASSIST SYSTEM….5
          MODELS WITHOUT DISTANCE CONTROL ASSIST SYSTEM : Exploded View….5
          MODELS WITHOUT DISTANCE CONTROL ASSIST SYSTEM : Removal and Installation….5
            REMOVAL….5
            INSTALLATION….5
          MODELS WITHOUT DISTANCE CONTROL ASSIST SYSTEM : Inspection….5
            INSPECTION AFTER INSTALLATION….5
        MODELS WITH DISTANCE CONTROL ASSIST SYSTEM….6
          MODELS WITH DISTANCE CONTROL ASSIST SYSTEM : Exploded View….6
          MODELS WITH DISTANCE CONTROL ASSIST SYSTEM : Removal and Installation….7
            REMOVAL….7
            INSTALLATION….7
          MODELS WITH DISTANCE CONTROL ASSIST SYSTEM : Inspection….7
            INSPECTION AFTER INSTALLATION….7
adp….8
  Table of Contents….8
    BASIC INSPECTION….12
      DIAGNOSIS AND REPAIR WORKFLOW….12
        DIAGNOSIS AND REPAIR WORKFLOW….12
        Work Flow….12
          OVERALL SEQUENCE….12
          DETAILED FLOW….12
      INSPECTION AND ADJUSTMENT….15
        INSPECTION AND ADJUSTMENT….15
        ADDITIONAL SERVICE WHEN REMOVING BATTERY NEGATIVE TERMINAL….15
          ADDITIONAL SERVICE WHEN REMOVING BATTERY NEGATIVE TERMINAL : Description….15
          ADDITIONAL SERVICE WHEN REMOVING BATTERY NEGATIVE TERMINAL : Special Repair Requirement….15
        ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT….15
          ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT : Description….15
          ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT : Special Repair Requirement….16
        SYSTEM INITIALIZATION….16
          SYSTEM INITIALIZATION : Description….16
          SYSTEM INITIALIZATION : Special Repair Requirement….16
            INITIALIZATION PROCEDURE….16
        MEMORY STORING….16
          MEMORY STORING : Description….17
          MEMORY STORING : Special Repair Requirement….17
            Memory Storage Procedure….17
        SYSTEM SETTING….18
          SYSTEM SETTING : Description….18
            Setting Change….18
          SYSTEM SETTING : Special Repair Requirement….18
    SYSTEM DESCRIPTION….20
      AUTOMATIC DRIVE POSITIONER SYSTEM….20
        AUTOMATIC DRIVE POSITIONER SYSTEM….20
        AUTOMATIC DRIVE POSITIONER SYSTEM….20
          AUTOMATIC DRIVE POSITIONER SYSTEM : System Diagram….20
          AUTOMATIC DRIVE POSITIONER SYSTEM : System Description….21
            OUTLINE….21
          AUTOMATIC DRIVE POSITIONER SYSTEM : Component Parts Location….22
          AUTOMATIC DRIVE POSITIONER SYSTEM : Component Description….23
            CONTROL UNITS….23
            INPUT PARTS….23
              Switches….23
              Sensors….24
            OUTPUT PARTS….24
        MANUAL FUNCTION….24
          MANUAL FUNCTION : System Diagram….25
          MANUAL FUNCTION : System Description….25
            OUTLINE….25
            OPERATION PROCEDURE….25
            DETAIL FLOW….25
              Seat….25
              Tilt & Telescopic….25
              Door Mirror….26
          MANUAL FUNCTION : Component Parts Location….27
          MANUAL FUNCTION : Component Description….28
            CONTROL UNITS….28
            INPUT PARTS….28
              Switches….28
              Sensors….29
            OUTPUT PARTS….29
        SEAT SYNCHRONIZATION FUNCTION….29
          SEAT SYNCHRONIZATION FUNCTION : System Diagram….29
          SEAT SYNCHRONIZATION FUNCTION : System Description….29
            OUTLINE….29
            OPERATION PROCEDURE….30
            OPERATION CONDITION….30
            DETAIL FLOW….30
          SEAT SYNCHRONIZATION FUNCTION : Component Parts Location….31
          SEAT SYNCHRONIZATION FUNCTION : Component Description….32
            CONTROL UNITS….32
            INPUT PARTS….32
              Switches….32
              Sensors….32
            OUTPUT PARTS….33
        MEMORY FUNCTION….33
          MEMORY FUNCTION : System Diagram….33
          MEMORY FUNCTION : System Description….33
            OPERATION CONDITION….33
            DETAIL FLOW….34
          MEMORY FUNCTION : Component Parts Location….35
          MEMORY FUNCTION : Component Description….36
            CONTROL UNITS….36
            INPUT PARTS….36
              Switches….36
              Sensors….36
            OUTPUT PARTS….37
        EXIT ASSIST FUNCTION….37
          EXIT ASSIST FUNCTION : System Diagram….37
          EXIT ASSIST FUNCTION : System Description….37
            OUTLINE….37
            OPERATION PROCEDURE….37
            OPERATION CONDITION….37
…
          BCM : CONSULT Function (BCM – BCM)….638
            WORK SUPPORT….638
        IMMU….638
          IMMU : CONSULT Function (BCM – IMMU)….638
            DATA MONITOR….638
            ACTIVE TEST….638
        BATTERY SAVER….639
          BATTERY SAVER : CONSULT Function (BCM – BATTERY SAVER)….639
            WORK SUPPORT….639
            DATA MONITOR….639
            ACTIVE TEST….640
        TRUNK….640
          TRUNK : CONSULT Function (BCM – TRUNK)….640
            BCM CONSULT FUNCTION….640
            DATA MONITOR….640
            ACTIVE TEST….640
        THEFT ALM….640
          THEFT ALM : CONSULT Function (BCM – THEFT ALM)….641
            DATA MONITOR….641
            WORK SUPPORT….641
            ACTIVE TEST….641
        RETAIND PWR….642
          RETAIND PWR : CONSULT Function (BCM – RETAINED PWR)….642
            Data monitor….642
        SIGNAL BUFFER….642
          SIGNAL BUFFER : CONSULT Function (BCM – SIGNAL BUFFER)….642
            DATA MONITOR….642
            ACTIVE TEST….642
    DTC/CIRCUIT DIAGNOSIS….643
      U1000 CAN COMM….643
        U1000 CAN COMM….643
        Description….643
        DTC Logic….643
          DTC DETECTION LOGIC….643
        Diagnosis Procedure….643
      U1010 CONTROL UNIT (CAN)….644
        U1010 CONTROL UNIT (CAN)….644
        DTC Logic….644
          DTC DETECTION LOGIC….644
        Diagnosis Procedure….644
      U0415 VEHICLE SPEED SIG….645
        U0415 VEHICLE SPEED SIG….645
        Description….645
        DTC Logic….645
          DTC DETECTION LOGIC….645
          DTC CONFIRMATION PROCEDURE….645
        Diagnosis Procedure….645
      B2562 LOW VOLTAGE….646
        B2562 LOW VOLTAGE….646
        DTC Logic….646
          DTC DETECTION LOGIC….646
          DTC CONFIRMATION PROCEDURE….646
        Diagnosis Procedure….646
      B26E7 TPMS CAN COMM….647
        B26E7 TPMS CAN COMM….647
        DTC Logic….647
          DTC DETECTION LOGIC….647
          DTC CONFIRMATION PROCEDURE….647
        Diagnosis Procedure….647
      POWER SUPPLY AND GROUND CIRCUIT….648
        POWER SUPPLY AND GROUND CIRCUIT….648
        Diagnosis Procedure….648
      COMBINATION SWITCH INPUT CIRCUIT….649
        COMBINATION SWITCH INPUT CIRCUIT….649
        Diagnosis Procedure….649
      COMBINATION SWITCH OUTPUT CIRCUIT….651
        COMBINATION SWITCH OUTPUT CIRCUIT….651
        Diagnosis Procedure….651
    ECU DIAGNOSIS INFORMATION….653
      BCM (BODY CONTROL MODULE)….653
        BCM (BODY CONTROL MODULE)….653
        Reference Value….653
          VALUES ON THE DIAGNOSIS TOOL….653
          TERMINAL LAYOUT….658
          PHYSICAL VALUES….658
        Wiring Diagram – BCM -….675
        Fail-safe….690
          FAIL-SAFE CONTROL BY DTC….690
          FAIL-SAFE CONTROL BY RAIN SENSOR MALFUNCTION….691
          REAR WIPER MOTOR PROTECTION….691
        DTC Inspection Priority Chart….691
        DTC Index….692
    SYMPTOM DIAGNOSIS….694
      COMBINATION SWITCH SYSTEM SYMPTOMS….694
        COMBINATION SWITCH SYSTEM SYMPTOMS….694
        Symptom Table….694
      NORMAL OPERATING CONDITION….695
        NORMAL OPERATING CONDITION….695
        Description….695
          TRANSIT MODE….695
    PRECAUTION….696
      PRECAUTIONS….696
        PRECAUTIONS….696
        Precautions for Removing Battery Terminal….696
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….696
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….696
    REMOVAL AND INSTALLATION….697
      BCM (BODY CONTROL MODULE)….697
        BCM (BODY CONTROL MODULE)….697
        Exploded View….697
        Removal and Installation….697
          REMOVAL….697
          INSTALLATION….697
      COMBINATION SWITCH….698
        COMBINATION SWITCH….698
        Exploded View….698
        Removal and Installation….698
          REMOVAL….698
          INSTALLATION….698
br….699
  Table of Contents….699
    PRECAUTION….701
      PRECAUTIONS….701
        PRECAUTIONS….701
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….701
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….701
        Precaution for Procedure without Cowl Top Cover….701
        Precaution for Brake System….701
        Precautions for Removing Battery Terminal….702
    PREPARATION….703
      PREPARATION….703
        PREPARATION….703
        Commercial Service Tool….703
    BASIC INSPECTION….704
      FRONT DISC BRAKE….704
        FRONT DISC BRAKE….704
        DISC ROTOR….704
          DISC ROTOR : Inspection….704
            INSPECTION….704
              Uneven wear….704
      REAR DISC BRAKE….705
        REAR DISC BRAKE….705
        DISC ROTOR….705
          DISC ROTOR : Inspection….705
            INSPECTION….705
              Uneven wear….705
    SYMPTOM DIAGNOSIS….706
      NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….706
        NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….706
        NVH Troubleshooting Chart….706
    PERIODIC MAINTENANCE….707
      BRAKE PEDAL….707
        BRAKE PEDAL….707
        Inspection and Adjustment….707
          INSPECTION….707
            Brake Pedal Height….707
            Stop Lamp Switch and ASCD Brake Switch….707
            Brake Pedal Play….707
            Depressed Brake Pedal Height….707
          ADJUSTMENT….708
            Brake Pedal Height….708
            Stop Lamp Switch and ASCD Brake Switch….708
            Brake Pedal Play….708
      BRAKE FLUID….710
        BRAKE FLUID….710
        Inspection….710
          BRAKE FLUID LEVEL….710
          BRAKE LINE….710
        Draining….710
        Refilling….710
        Bleeding Brake System….711
      BRAKE MASTER CYLINDER….712
        BRAKE MASTER CYLINDER….712
        Inspection….712
          FLUID LEAK….712
      BRAKE BOOSTER….713
        BRAKE BOOSTER….713
        Inspection….713
          OPERATION….713
          AIR TIGHT….713
      FRONT DISC BRAKE….714
        FRONT DISC BRAKE….714
        BRAKE PAD….714
          BRAKE PAD : Inspection and Adjustment….714
            INSPECTION….714
              2 Piston Type….714
              4 Piston Type….714
            ADJUSTMENT….714
        DISC ROTOR….714
          DISC ROTOR : Inspection and Adjustment….714
            INSPECTION….714
              Appearance….714
              Runout….714
              Thickness….715
            ADJUSTMENT….715
      REAR DISC BRAKE….716
        REAR DISC BRAKE….716
        BRAKE PAD….716
          BRAKE PAD : Inspection and Adjustment….716
            INSPECTION….716
              1 Piston Type….716
              2 Piston Type….716
            ADJUSTMENT….716
        DISC ROTOR….716
          DISC ROTOR : Inspection and Adjustment….716
            INSPECTION….716
              Appearance….716
              Runout….716
              Thickness….717
            ADJUSTMENT….717
    REMOVAL AND INSTALLATION….718
      BRAKE PEDAL….718
        BRAKE PEDAL….718
        Exploded View….718
        Removal and Installation….718
          REMOVAL….718
          INSTALLATION….719
        Inspection and Adjustment….719
          INSPECTION AFTER REMOVAL….719
          ADJUSTMENT AFTER INSTALLATION….719
      BRAKE PIPING….720
        BRAKE PIPING….720
        FRONT….720
          FRONT : Exploded View….720
            2 PISTON TYPE….720
            4 PISTON TYPE….720
          FRONT : Hydraulic Piping….721
            2 PISTON TYPE….721
            4 PISTON TYPE….722
          FRONT : Removal and Installation….722
            REMOVAL….722
              2 Piston Type….722
              4 Piston Type….723
            INSTALLATION….723
              2 Piston Type….723
              4 Piston Type….724
          FRONT : Inspection….724
            INSPECTION AFTER INSTALLATION….724
        REAR….724
          REAR : Exploded View….724
            1 PISTON TYPE….724
            2 PISTON TYPE….725
          REAR : Hydraulic Piping….726
            1 PISTON TYPE….726
            2 PISTON TYPE….726
          REAR : Removal and Installation….727
            REMOVAL….727
              1 Piston Type….727
              2 Piston Type….727
            INSTALLATION….727
              1 Piston Type….727
              2 Piston Type….728
          REAR : Inspection….728
            INSPECTION AFTER INSTALLATION….728
      BRAKE MASTER CYLINDER….729
        BRAKE MASTER CYLINDER….729
        Exploded View….729
          WITHOUT ICC….729
          WITH ICC….729
        Removal and Installation….730
          REMOVAL ….730
          INSTALLATION….731
        Disassembly and Assembly….731
          DISASSEMBLY….731
          ASSEMBLY….731
        Inspection….732
          INSPECTION AFTER INSTALLATION….732
            Fluid Leak….732
      BRAKE BOOSTER….733
        BRAKE BOOSTER….733
        Exploded View….733
          WITHOUT ICC….733
          WITH ICC….733
        Removal and installation….733
          REMOVAL….733
          INSTALLATION….734
        Inspection and Adjustment….734
          INSPECTION BEFORE REMOVAL….734
            Air Tight….734
          INSPECTION AFTER REMOVAL….735
            Input Rod Length Inspection….735
          INSPECTION AFTER INSTALLATION….735
            Operation….735
            Air Tight….735
          ADJUSTMENT AFTER INSTALLATION….736
      VACUUM LINES….737
        VACUUM LINES….737
        Exploded View….737
          VQ37VHR….737
          VK50VE….737
        Removal and Installation….738
          REMOVAL….738
          INSTALLATION….738
        Inspection….738
          INSPECTION AFTER REMOVAL….738
            Appearance….738
            Check Valve Airtightness….738
      FRONT DISC BRAKE….739
        FRONT DISC BRAKE….739
        BRAKE PAD (2 PISTON TYPE)….739
          BRAKE PAD (2 PISTON TYPE) : Exploded View….739
            FOR MEXICO….739
            EXPECT FOR MEXICO….739
          BRAKE PAD (2 PISTON TYPE) : Removal and Installation….740
            REMOVAL….740
            INSTALLATION….740
          BRAKE PAD (2 PISTON TYPE) : Inspection….741
            INSPECTION AFTER REMOVAL….741
            INSPECTION AFTER INSTALLATION….741
        BRAKE PAD (4 PISTON TYPE)….741
          BRAKE PAD (4 PISTON TYPE) : Exploded View….741
          BRAKE PAD (4 PISTON TYPE) : Removal and Installation….742
            REMOVAL….742
            INSTALLATION….742
          BRAKE PAD (4 PISTON TYPE) : Inspection….743
            INSPECTION AFTER REMOVAL….743
            INSPECTION AFTER INSTALLATION….743
        BRAKE CALIPER ASSEMBLY (2 PISTON TYPE)….743
          BRAKE CALIPER ASSEMBLY (2 PISTON TYPE) : Exploded View….743
            REMOVAL….743
            DISASSEMBLY….744
          BRAKE CALIPER ASSEMBLY (2 PISTON TYPE) : Removal and Installation….744
            REMOVAL….744
            INSTALLATION….745
          BRAKE CALIPER ASSEMBLY (2 PISTON TYPE) : Disassembly and Assembly….745
            DISASSEMBLY….745
            ASSEMBLY….746
          BRAKE CALIPER ASSEMBLY (2 PISTON TYPE) : Inspection….747
            INSPECTION AFTER DISASSEMBLY….747
              Cylinder Body….747
              Torque Member….747
              Pistons….747
              Sliding Pin and Sliding Pin Boot….747
            INSPECTION AFTER INSTALLATION….747
        BRAKE CALIPER ASSEMBLY (4 PISTON TYPE)….747
          BRAKE CALIPER ASSEMBLY (4 PISTON TYPE) : Exploded View….747
            REMOVAL….747
            DISASSEMBLY….748
          BRAKE CALIPER ASSEMBLY (4 PISTON TYPE) : Removal and Installation….748
            REMOVAL….748
            INSTALLATION….749
          BRAKE CALIPER ASSEMBLY (4 PISTON TYPE) : Disassembly and Assembly….749
            DISASSEMBLY….749
            ASSEMBLY….750
          BRAKE CALIPER ASSEMBLY (4 PISTON TYPE) : Inspection….751
            INSPECTION AFTER DISASSEMBLY….751
              Caliper….751
              Pistons….751
            INSPECTION AFTER INSTALLATION….751
      REAR DISC BRAKE….752
        REAR DISC BRAKE….752
        BRAKE PAD (1 PISTON TYPE)….752
          BRAKE PAD (1 PISTON TYPE) : Exploded View….752
          BRAKE PAD (1 PISTON TYPE) : Removal and Installation….752
            REMOVAL….752
            INSTALLATION….752
          BRAKE PAD (1 PISTON TYPE) : Inspection….753
            INSPECTION AFTER REMOVAL….753
            INSPECTION AFTER INSTALLATION….753
        BRAKE PAD (2 PISTON TYPE)….753
          BRAKE PAD (2 PISTON TYPE) : Exploded View….754
          BRAKE PAD (2 PISTON TYPE) : Removal and Installation….754
            REMOVAL….754
            INSTALLATION….755
          BRAKE PAD (2 PISTON TYPE) : Inspection….756
            INSPECTION AFTER REMOVAL….756
            INSPECTION AFTER INSTALLATION….756
        BRAKE CALIPER ASSEMBLY (1 PISTON TYPE)….756
          BRAKE CALIPER ASSEMBLY (1 PISTON TYPE) : Exploded View….756
            REMOVAL….756
            DISASSEMBLY….757
          BRAKE CALIPER ASSEMBLY (1 PISTON TYPE) : Removal and Installation….757
            REMOVAL….757
            INSTALLATION….758
          BRAKE CALIPER ASSEMBLY (1 PISTON TYPE) : Disassembly and Assembly….758
            DISASSEMBLY….758
            ASSEMBLY….759
          BRAKE CALIPER ASSEMBLY (1 PISTON TYPE) : Inspection….760
            INSPECTION AFTER DISASSEMBLY….760
              Cylinder Body….760
              Torque Member….760
              Piston….760
              Sliding Pin Bolt and Sliding Pin Boot….760
            INSPECTION AFTER INSTALLATION….760
        BRAKE CALIPER ASSEMBLY (2 PISTON TYPE)….761
          BRAKE CALIPER ASSEMBLY (2 PISTON TYPE) : Exploded View….761
            REMOVAL….761
            DISASSEMBLY….761
          BRAKE CALIPER ASSEMBLY (2 PISTON TYPE) : Removal and Installation….762
            REMOVAL….762
            INSTALLATION….762
          BRAKE CALIPER ASSEMBLY (2 PISTON TYPE) : Disassembly and Assembly….763
            DISASSEMBLY….763
            ASSEMBLY….763
          BRAKE CALIPER ASSEMBLY (2 PISTON TYPE) : Inspection….764
            INSPECTION AFTER DISASSEMBLY….764
              Caliper….764
              Pistons….764
            INSPECTION AFTER INSTALLATION….764
    SERVICE DATA AND SPECIFICATIONS (SDS)….765
      SERVICE DATA AND SPECIFICATIONS (SDS)….765
        SERVICE DATA AND SPECIFICATIONS (SDS)….765
        General Specifications….765
          FRONT 2 PISTON AND REAR 1 PISTON TYPE….765
            FOR MEXICO….765
            EXPECT FOR MEXICO….765
          FRONT 4 PISTON AND REAR 2 PISTON TYPE….765
        Brake Pedal….766
        Brake Booster….766
        Front Disc Brake….766
          2 PISTON TYPE….766
            FOR MEXICO….766
            EXPECT FOR MEXICO….766
          4 PISTON TYPE….766
        Rear Disc Brake….767
          1 PISTON TYPE….767
          2 PISTON TYPE….767
brc….768
  Table of Contents….768
    VDC/TCS/ABS….772
      VDC/TCS/ABS….772
      BASIC INSPECTION….772
        DIAGNOSIS AND REPAIR WORK FLOW….772
          DIAGNOSIS AND REPAIR WORK FLOW….772
          Work Flow….772
            PRECAUTIONS FOR DIAGNOSIS….772
            OVERALL SEQUENCE….773
            DETAILED FLOW….773
          Diagnostic Work Sheet….775
        INSPECTION AND ADJUSTMENT….776
          INSPECTION AND ADJUSTMENT….776
          ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT….776
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT : Description….776
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT : Special Repair Requirement….776
          ADJUSTMENT OF STEERING ANGLE SENSOR NEUTRAL POSITION….776
            ADJUSTMENT OF STEERING ANGLE SENSOR NEUTRAL POSITION : Description….776
            ADJUSTMENT OF STEERING ANGLE SENSOR NEUTRAL POSITION : Special Repair Requirement….776
              ADJUSTMENT OF STEERING ANGLE SENSOR NEUTRAL POSITION….776
      SYSTEM DESCRIPTION….778
        VDC….778
          VDC….778
          System Diagram….778
          System Description….779
          Component Parts Location….780
          Component Description….782
        TCS….783
          TCS….783
          System Diagram….783
          System Description….784
          Component Parts Location….785
          Component Description….787
        ABS….788
          ABS….788
          System Diagram….788
          System Description….789
          Component Parts Location….790
          Component Description….792
        EBD….793
          EBD….793
          System Diagram….793
          System Description….794
          Component Parts Location….795
          Component Description….797
        DIAGNOSIS SYSTEM [ABS ACTUATOR AND ELECTRIC UNIT (CONTROL UNIT)]….798
          DIAGNOSIS SYSTEM [ABS ACTUATOR AND ELECTRIC UNIT (CONTROL UNIT)]….798
          CONSULT Function….798
            FUNCTION….798
            WORK SUPPORT….798
            SELF DIAGNOSTIC RESULT….798
              Operation Procedure….798
              Display Item List….798
              How to Erase Self-diagnosis Results….798
            DATA MONITOR….798
              Display Item List….798
            ACTIVE TEST….801
              Test Item….801
            ECU IDENTIFICATION….802
            SPECIFIC DATA MONITOR….802
      DTC/CIRCUIT DIAGNOSIS….804
        C1101, C1102, C1103, C1104 WHEEL SENSOR….804
          C1101, C1102, C1103, C1104 WHEEL SENSOR….804
          Description….804
          DTC Logic….804
            DTC DETECTION LOGIC….804
            DTC CONFIRMATION PROCEDURE….804
          Diagnosis Procedure….804
          Special Repair Requirement….806
        C1105, C1106, C1107, C1108 WHEEL SENSOR….807
          C1105, C1106, C1107, C1108 WHEEL SENSOR….807
          Description….807
          DTC Logic….807
            DTC DETECTION LOGIC….807
            DTC CONFIRMATION PROCEDURE….807
          Diagnosis Procedure….807
          Special Repair Requirement….811
        C1109 POWER AND GROUND SYSTEM….812
          C1109 POWER AND GROUND SYSTEM….812
          Description….812
          DTC Logic….812
            DTC DETECTION LOGIC….812
            DTC CONFIRMATION PROCEDURE….812
          Diagnosis Procedure….812
          Special Repair Requirement….813
        C1110, C1153, C1170 ABS ACTUATOR AND ELECTRIC UNIT (CONTROL UNIT)….814
          C1110, C1153, C1170 ABS ACTUATOR AND ELECTRIC UNIT (CONTROL UNIT)….814
          DTC Logic….814
            DTC DETECTION LOGIC….814
            DTC CONFIRMATION PROCEDURE….814
          Diagnosis Procedure….814
          Special Repair Requirement….814
        C1111 ABS MOTOR, MOTOR RELAY SYSTEM….815
          C1111 ABS MOTOR, MOTOR RELAY SYSTEM….815
          Description….815
            PUMP….815
            MOTOR….815
            MOTOR RELAY….815
          DTC Logic….815
            DTC DETECTION LOGIC….815
            DTC CONFIRMATION PROCEDURE….815
          Diagnosis Procedure….815
          Special Repair Requirement….816
        C1115 WHEEL SENSOR….817
          C1115 WHEEL SENSOR….817
          Description….817
          DTC Logic….817
            DTC DETECTION LOGIC….817
            DTC CONFIRMATION PROCEDURE….817
          Diagnosis Procedure….817
          Special Repair Requirement….821
        C1116 STOP LAMP SWITCH….822
          C1116 STOP LAMP SWITCH….822
          Description….822
          DTC Logic….822
            DTC DETECTION LOGIC….822
            DTC CONFIRMATION PROCEDURE….822
          Diagnosis Procedure….822
          Component Inspection….825
          Special Repair Requirement….825
        C1120, C1122, C1124, C1126 IN ABS SOL….827
          C1120, C1122, C1124, C1126 IN ABS SOL….827
          Description….827
          DTC Logic….827
            DTC DETECTION LOGIC….827
            DTC CONFIRMATION PROCEDURE….827
          Diagnosis Procedure….827
          Special Repair Requirement….828
        C1121, C1123, C1125, C1127 OUT ABS SOL….829
          C1121, C1123, C1125, C1127 OUT ABS SOL….829
          Description….829
          DTC Logic….829
            DTC DETECTION LOGIC….829
            DTC CONFIRMATION PROCEDURE….829
          Diagnosis Procedure….829
          Special Repair Requirement….830
        C1130 ENGINE SIGNAL….831
          C1130 ENGINE SIGNAL….831
          Description….831
          DTC Logic….831
            DTC DETECTION LOGIC….831
            DTC CONFIRMATION PROCEDURE….831
          Diagnosis Procedure….831
          Special Repair Requirement….831
        C1140 ACTUATOR RELAY SYSTEM….833
          C1140 ACTUATOR RELAY SYSTEM….833
          Description….833
          DTC Logic….833
            DTC DETECTION LOGIC….833
            DTC CONFIRMATION PROCEDURE….833
          Diagnosis Procedure….833
          Special Repair Requirement….834
        C1142 PRESS SENSOR….835
          C1142 PRESS SENSOR….835
          Description….835
          DTC Logic….835
            DTC DETECTION LOGIC….835
            DTC CONFIRMATION PROCEDURE….835
          Diagnosis Procedure….835
          Special Repair Requirement….836
        C1143 STEERING ANGLE SENSOR….837
          C1143 STEERING ANGLE SENSOR….837
          Description….837
          DTC Logic….837
            DTC DETECTION LOGIC….837
            DTC CONFIRMATION PROCEDURE….837
          Diagnosis Procedure….837
          Special Repair Requirement….838
        C1144 STEERING ANGLE SENSOR….839
          C1144 STEERING ANGLE SENSOR….839
          DTC Logic….839
            DTC DETECTION LOGIC….839
            DTC CONFIRMATION PROCEDURE….839
          Diagnosis Procedure….839
          Special Repair Requirement….839
        C1145, C1146 YAW RATE/SIDE G SENSOR….840
          C1145, C1146 YAW RATE/SIDE G SENSOR….840
          Description….840
          DTC Logic….840
            DTC DETECTION LOGIC….840
            DTC CONFIRMATION PROCEDURE….840
          Diagnosis Procedure….840
          Special Repair Requirement….842
        C1147, C1148, C1149, C1150 USV/HSV LINE….843
          C1147, C1148, C1149, C1150 USV/HSV LINE….843
          Description….843
            USV1, USV2 (CUT VALVE)….843
            HSV1, HSV2 (SUCTION VALVE)….843
          DTC Logic….843
            DTC DETECTION LOGIC….843
            DTC CONFIRMATION PROCEDURE….843
          Diagnosis Procedure….843
          Special Repair Requirement….844
        C1154 TRANSMISSION RANGE SWITCH….845
          C1154 TRANSMISSION RANGE SWITCH….845
          Description….845
          DTC Logic….845
            DTC DETECTION LOGIC….845
            DTC CONFIRMATION PROCEDURE….845
          Diagnosis Procedure….845
          Special Repair Requirement….845
        C1155 BRAKE FLUID LEVEL SWITCH….847
          C1155 BRAKE FLUID LEVEL SWITCH….847
          Description….847
          DTC Logic….847
            DTC DETECTION LOGIC….847
            DTC CONFIRMATION PROCEDURE….847
          Diagnosis Procedure….847
          Component Inspection….849
          Special Repair Requirement….849
        C1156 STEERING ANGLE SENSOR (CAN)….850
          C1156 STEERING ANGLE SENSOR (CAN)….850
          Description….850
          DTC Logic….850
            DTC DETECTION LOGIC….850
            DTC CONFIRMATION PROCEDURE….850
          Diagnosis Procedure….850
          Special Repair Requirement….850
        C1185 ICC UNIT….851
          C1185 ICC UNIT….851
          Description….851
          DTC Logic….851
            DTC DETECTION LOGIC….851
            DTC CONFIRMATION PROCEDURE….851
          Diagnosis Procedure….851
          Special Repair Requirement….851
        C1197 VACUUM SENSOR….852
          C1197 VACUUM SENSOR….852
          Description….852
          DTC Logic….852
            DTC DETECTION LOGIC….852
            DTC CONFIRMATION PROCEDURE….852
          Diagnosis Procedure….852
          Special Repair Requirement….853
        C1198 VACUUM SENSOR….854
          C1198 VACUUM SENSOR….854
          Description….854
          DTC Logic….854
            DTC DETECTION LOGIC….854
            DTC CONFIRMATION PROCEDURE….854
          Diagnosis Procedure….854
          Special Repair Requirement….855
        C1199 VACUUM SENSOR….856
          C1199 VACUUM SENSOR….856
          Description….856
          DTC Logic….856
            DTC DETECTION LOGIC….856
            DTC CONFIRMATION PROCEDURE….856
          Diagnosis Procedure….856
          Special Repair Requirement….857
        C119A VACUUM SENSOR….858
          C119A VACUUM SENSOR….858
          Description….858
          DTC Logic….858
            DTC DETECTION LOGIC….858
            DTC CONFIRMATION PROCEDURE….858
          Diagnosis Procedure….858
          Special Repair Requirement….859
        U1000 CAN COMM CIRCUIT….860
          U1000 CAN COMM CIRCUIT….860
          Description….860
          DTC Logic….860
            DTC DETECTION LOGIC….860
            DTC CONFIRMATION PROCEDURE….860
          Diagnosis Procedure….860
          Special Repair Requirement….860
        U1002 SYSTEM COMM (CAN)….861
          U1002 SYSTEM COMM (CAN)….861
          Description….861
          DTC Logic….861
            DTC DETECTION LOGIC….861
            DTC CONFIRMATION PROCEDURE….861
          Diagnosis Procedure….861
          Special Repair Requirement….862
        U1100 CAN COMM CIRCUIT (ICC UNIT)….863
          U1100 CAN COMM CIRCUIT (ICC UNIT)….863
          Description….863
          DTC Logic….863
            DTC DETECTION LOGIC….863
            DTC CONFIRMATION PROCEDURE….863
          Diagnosis Procedure….863
          Special Repair Requirement….863
        POWER SUPPLY AND GROUND CIRCUIT….864
          POWER SUPPLY AND GROUND CIRCUIT….864
          Description….864
          Diagnosis Procedure….864
          Special Repair Requirement….865
        PARKING BRAKE SWITCH….866
          PARKING BRAKE SWITCH….866
          Description….866
          Diagnosis Procedure….866
          Component Inspection….866
          Special Repair Requirement….867
        VDC OFF SWITCH….868
          VDC OFF SWITCH….868
          Description….868
          Diagnosis Procedure….868
          Component Inspection….869
          Special Repair Requirement….869
        ABS WARNING LAMP….870
          ABS WARNING LAMP….870
          Description….870
          Component Function Check….870
          Diagnosis Procedure….870
          Special Repair Requirement….870
        BRAKE WARNING LAMP….871
          BRAKE WARNING LAMP….871
          Description….871
          Component Function Check….871
          Diagnosis Procedure….871
          Special Repair Requirement….872
        VDC WARNING LAMP….873
          VDC WARNING LAMP….873
          Description….873
          Component Function Check….873
          Diagnosis Procedure….873
          Special Repair Requirement….873
        VDC OFF INDICATOR LAMP….874
          VDC OFF INDICATOR LAMP….874
          Description….874
          Component Function Check….874
          Diagnosis Procedure….874
          Special Repair Requirement….875
      ECU DIAGNOSIS INFORMATION….876
        ABS ACTUATOR AND ELECTRIC UNIT (CONTROL UNIT)….876
          ABS ACTUATOR AND ELECTRIC UNIT (CONTROL UNIT)….876
          Reference Value….876
            VALUES ON THE DIAGNOSIS TOOL….876
          Wiring Diagram – BRAKE CONTROL SYSTEM -….881
          Fail-Safe….886
            ABS/EBD SYSTEM….886
            VDC/TCS SYSTEM ….887
            LDW/LDP SYSTEM….887
          DTC Index….887
      SYMPTOM DIAGNOSIS….889
        EXCESSIVE ABS FUNCTION OPERATION FREQUENCY….889
          EXCESSIVE ABS FUNCTION OPERATION FREQUENCY….889
          Diagnosis Procedure….889
        UNEXPECTED PEDAL REACTION….890
          UNEXPECTED PEDAL REACTION….890
          Diagnosis Procedure….890
        THE BRAKING DISTANCE IS LONG….891
          THE BRAKING DISTANCE IS LONG….891
          Diagnosis Procedure….891
        ABS FUNCTION DOES NOT OPERATE….892
          ABS FUNCTION DOES NOT OPERATE….892
          Diagnosis Procedure….892
        PEDAL VIBRATION OR ABS OPERATION SOUND OCCURS….893
          PEDAL VIBRATION OR ABS OPERATION SOUND OCCURS….893
          Diagnosis Procedure….893
        VEHICLE JERKS DURING VDC/TCS/ABS CONTROL….894
          VEHICLE JERKS DURING VDC/TCS/ABS CONTROL….894
          Diagnosis Procedure….894
        NORMAL OPERATING CONDITION….895
          NORMAL OPERATING CONDITION….895
          Description….895
      PRECAUTION….896
        PRECAUTIONS….896
          PRECAUTIONS….896
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….896
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….896
          Precaution for Procedure without Cowl Top Cover….896
          Precautions for Removing Battery Terminal….897
          Precaution for Brake System….897
          Precaution for Brake Control….897
          Precautions for Harness Repair….898
            COMMUNICATION LINE….898
      PREPARATION….899
        PREPARATION….899
          PREPARATION….899
          Special Service Tool….899
          Commercial Service Tool….899
      REMOVAL AND INSTALLATION….900
        WHEEL SENSOR….900
          WHEEL SENSOR….900
          FRONT WHEEL SENSOR….900
            FRONT WHEEL SENSOR : Exploded View….900
            FRONT WHEEL SENSOR : Removal and Installation….900
              REMOVAL….900
              INSTALLATION….900
          REAR WHEEL SENSOR….901
            REAR WHEEL SENSOR : Exploded View….901
            REAR WHEEL SENSOR : Removal and Installation….901
              REMOVAL….901
              INSTALLATION….901
        SENSOR ROTOR….902
          SENSOR ROTOR….902
          FRONT SENSOR ROTOR….902
            FRONT SENSOR ROTOR : Exploded View….902
            FRONT SENSOR ROTOR : Removal and Installation….902
              REMOVAL….902
              INSTALLATION….902
          REAR SENSOR ROTOR….902
            REAR SENSOR ROTOR : Exploded View….902
            REAR SENSOR ROTOR : Removal and Installation….902
              REMOVAL….902
              INSTALLATION….902
        ABS ACTUATOR AND ELECTRIC UNIT (CONTROL UNIT)….903
          ABS ACTUATOR AND ELECTRIC UNIT (CONTROL UNIT)….903
          Exploded View….903
          Removal and Installation….903
            REMOVAL….903
            INSTALLATION….904
        YAW RATE/SIDE G SENSOR….905
          YAW RATE/SIDE G SENSOR….905
          Exploded View….905
          Removal and Installation….905
            REMOVAL….905
            INSTALLATION….905
        STEERING ANGLE SENSOR….906
          STEERING ANGLE SENSOR….906
          Exploded View….906
          Removal and Installation….906
            REMOVAL….906
            INSTALLATION….906
        VDC OFF SWITCH….907
          VDC OFF SWITCH….907
          Removal and Installation….907
            REMOVAL….907
            INSTALLATION….907
    BRAKE ASSIST (WITH PREVIEW FUNCTION)….908
      BRAKE ASSIST (WITH PREVIEW FUNCTION)….908
      SYSTEM DESCRIPTION….908
        PREVIEW FUNCTION….908
          PREVIEW FUNCTION….908
          System Description….908
            FUNCTION DESCRIPTION….908
            OPERATION DESCRIPTION….908
              Operation….908
              End of Operation….908
          Component Parts Location….909
          Component Description….910
      DTC/CIRCUIT DIAGNOSIS….911
        PREVIEW FUNCTION….911
          PREVIEW FUNCTION….911
          Diagnosis Procedure….911
      SYMPTOM DIAGNOSIS….912
        NORMAL OPERATING CONDITION….912
          NORMAL OPERATING CONDITION….912
          Description….912
            PRECAUTIONS FOR PREVIEW FUNCTION….912
      PRECAUTION….913
        PRECAUTIONS….913
          PRECAUTIONS….913
          Precautions for Preview Function Service….913
          Precautions for Removing Battery Terminal….913
    INTELLIGENT BRAKE ASSIST….914
      INTELLIGENT BRAKE ASSIST….914
      SYSTEM DESCRIPTION….914
        INTELLIGENT BRAKE ASSIST….914
          INTELLIGENT BRAKE ASSIST….914
          System Description….914
            FUNCTION DESCRIPTION….914
            OPERATION DESCRIPTION….914
              Switch and Indicators….914
              Fail-safe Indication….914
          Component Parts Location….915
          Component Description….916
      DTC/CIRCUIT DIAGNOSIS….917
        INTELLIGENT BRAKE ASSIST….917
          INTELLIGENT BRAKE ASSIST….917
          Diagnosis Procedure….917
      SYMPTOM DIAGNOSIS….918
        SWITCH DOES NOT TURN ON / SWITCH DOES NOT TURN OFF….918
          SWITCH DOES NOT TURN ON / SWITCH DOES NOT TURN OFF….918
          Symptom Table….918
          Description….918
          Diagnosis Procedure….918
        NORMAL OPERATING CONDITION….920
          NORMAL OPERATING CONDITION….920
          Description….920
            PRECAUTIONS FOR INTELLIGENT BRAKE ASSIST….920
      PRECAUTION….921
        PRECAUTIONS….921
          PRECAUTIONS….921
          Precautions for Removing Battery Terminal….921
          Precautions for IBA System Service….921
      REMOVAL AND INSTALLATION….922
        IBA OFF SWITCH….922
          IBA OFF SWITCH….922
          Removal and Installation….922
            REMOVAL….922
            INSTALLATION….922
brm….923
  Table of Contents….923
    FOR USA AND CANADA….924
      FOR USA AND CANADA….924
      VEHICLE INFORMATION….924
        BODY EXTERIOR PAINT COLOR….924
          BODY EXTERIOR PAINT COLOR….924
          Body Exterior Paint Color….924
            PAINTING BACK DOOR (SERVICE PART)….925
      PRECAUTION….926
        REPAIRING HIGH STRENGTH STEEL….926
          REPAIRING HIGH STRENGTH STEEL….926
          High Strength Steel (HSS)….926
          Handling of Ultra High Strength Steel Plate Parts….928
            PROHIBITION OF CUT AND CONNECTION….928
      PREPARATION….929
        REPAIRING MATERIAL….929
          REPAIRING MATERIAL….929
          Foam Repair….929
            URETHANE FOAM APPLICATIONS….929
              Example of foaming agent filling operation procedure….929
        BODY COMPONENT PARTS….931
          BODY COMPONENT PARTS….931
          Underbody Component Parts….931
          Body Component Parts….933
      REMOVAL AND INSTALLATION….935
        CORROSION PROTECTION….935
          CORROSION PROTECTION….935
          Description….935
            ANTI-CORROSIVE PRECOATED STEEL (GALVANNEALED STEEL)….935
            PHOSPHATE COATING TREATMENT AND CATIONIC ELECTRODEPOSITION PRIMER….935
          Undercoating….935
            PRECAUTIONS IN UNDERCOATING….935
          Body Sealing….936
        BODY CONSTRUCTION….940
          BODY CONSTRUCTION….940
          Body Construction….940
        REPLACEMENT OPERATIONS….942
          REPLACEMENT OPERATIONS….942
          Description….942
            REAR FENDER HEMMING PROCESS….943
              Procedure of the hemming process….943
            FOAM REPAIR….944
              Urethane foam applications….944
          Radiator Core Support….946
          Hoodledge….946
          Front Side Member….949
          Front Side Member (Partial Replacement)….952
          Front Pillar….953
          Center Pillar….957
          Outer Sill….958
          Rear Fender….962
          Rear Panel….965
          Rear End Crossmember….966
          Rear Floor Rear….967
          Rear Side Member Extension….968
      SERVICE DATA AND SPECIFICATIONS (SDS)….970
        BODY ALIGNMENT….970
          BODY ALIGNMENT….970
          Body Center Marks….970
          Description….971
          Engine Compartment….971
            MEASUREMENT….971
            MEASUREMENT POINTS….972
          Underbody….973
            MEASUREMENT ….973
            MEASUREMENT POINTS….974
          Passenger Compartment….976
            MEASUREMENT….976
            MEASUREMENT POINTS….977
          Rear Body….979
            MEASUREMENT….979
            MEASUREMENT POINTS….979
        LOCATION OF PLASTIC PARTS….981
          LOCATION OF PLASTIC PARTS….981
          Precautions for Plastics….981
          Location of Plastic Parts….982
    FOR MEXICO….984
      FOR MEXICO….984
      SERVICE DATA AND SPECIFICATIONS (SDS)….984
        BODY ALIGNMENT….984
          BODY ALIGNMENT….984
          Description….984
          Engine Compartment….984
            MEASUREMENT….984
            MEASUREMENT POINTS….985
          Underbody….986
            MEASUREMENT ….986
            MEASUREMENT POINTS….987
          Passenger Compartment….989
            MEASUREMENT….989
            MEASUREMENT POINTS….990
          Rear Body….992
            MEASUREMENT….992
            MEASUREMENT POINTS….992
ccs….994
  Table of Contents….994
    ICC (FULL SPEED RANGE)….998
      ICC (FULL SPEED RANGE)….998
      BASIC INSPECTION….998
        DIAGNOSIS AND REPAIR WORK FLOW….998
          DIAGNOSIS AND REPAIR WORK FLOW….998
          Work Flow….998
            OVERALL SEQUENCE….998
            DETAILED FLOW….998
        INSPECTION AND ADJUSTMENT….1000
          INSPECTION AND ADJUSTMENT….1000
          ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (ICC SENSOR INTEGRATED UNIT)….1000
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (ICC SENSOR INTEGRATED UNIT) : Description….1000
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (ICC SENSOR INTEGRATED UNIT) : Special Repair Requirement….1000
          LASER BEAM AIMING ADJUSTMENT….1000
            LASER BEAM AIMING ADJUSTMENT : Description….1000
              OUTLINE OF LASER BEAM AIMING ADJUSTMENT….1000
              CAUTIONARY POINT FOR LASER BEAM AIMING ADJUSTMENT….1000
            LASER BEAM AIMING ADJUSTMENT : Special Repair Requirement (Preparation)….1001
            LASER BEAM AIMING ADJUSTMENT : Special Repair Requirement (Setting The ICC Target Board)….1001
              DESCRIPTION….1001
            LASER BEAM AIMING ADJUSTMENT : Special Repair Requirement (Laser Beam Aiming Adjustment)….1004
              DESCRIPTION….1004
          ACTION TEST….1005
            ACTION TEST : Description….1005
            ACTION TEST : Special Repair Requirement (Vehicle-To-Vehicle Distance Control Mode)….1005
            ACTION TEST : Special Repair Requirement [Conventional (Fixed Speed) Cruise Control Mode]….1008
      SYSTEM DESCRIPTION….1011
        ICC (FULL SPEED RANGE)….1011
          ICC (FULL SPEED RANGE)….1011
          System Diagram….1011
          System Description….1011
            DESCRIPTION….1011
              Vehicle-to-vehicle Distance Control Mode….1012
              Conventional (Fixed Speed) Cruise Control Mode….1012
              Forward Collision Warning (FCW)….1012
              Brake Assist (With Preview Function)….1012
              Intelligent Brake Assist (IBA) System….1012
            ICC SENSOR INTEGRATED UNIT INPUT/OUTPUT SIGNAL ITEM….1012
              Input Signal Item….1012
              Output Signal Item….1013
          Component Parts Location….1014
          Component Description….1015
        VEHICLE-TO-VEHICLE DISTANCE CONTROL MODE FUNCTION….1016
          VEHICLE-TO-VEHICLE DISTANCE CONTROL MODE FUNCTION….1016
          System Diagram….1016
          System Description….1016
            FUNCTION DESCRIPTION….1016
            OPERATION DESCRIPTION….1017
              Set Condition….1017
              Cancel Conditions….1018
            OPERATION AND DISPLAY….1018
              ICC Steering Switch….1018
              ICC System Display (On The Information Display)….1019
              System Control Condition Display….1020
              Approach Warning Display….1021
              Warning Lamp and Automatic Cancellation Display….1022
          Component Parts Location….1023
          Component Description….1024
        CONVENTIONAL (FIXED SPEED) CRUISE CONTROL MODE FUNCTION….1025
          CONVENTIONAL (FIXED SPEED) CRUISE CONTROL MODE FUNCTION….1025
          System Diagram….1025
          System Description….1025
            FUNCTION DESCRIPTION….1025
            OPERATION DESCRIPTION….1026
              Set Condition….1026
            OPERATION AND DISPLAY….1026
              ICC Steering Switch….1026
              ICC System Display (On The Information Display)….1027
              System Control Condition Display….1027
              Warning and Automatic Cancellation Display….1028
          Component Parts Location….1029
          Component Description….1030
        DIAGNOSIS SYSTEM (ICC SENSOR INTEGRATED UNIT)….1031
          DIAGNOSIS SYSTEM (ICC SENSOR INTEGRATED UNIT)….1031
          Diagnosis Description….1031
            ON BOARD SELF-DIAGNOSIS SYSTEM DIAGRAM….1031
            ON BOARD SELF-DIAGNOSIS OPERATION PROCEDURE….1031
            WHEN THE ON BOARD SELF-DIAGNOSIS DOES NOT START….1032
            HOW TO ERASE ON BOARD SELF-DIAGNOSIS….1032
          CONSULT Function (ICC/ADAS)….1032
            DESCRIPTION….1032
            WORK SUPPORT….1033
              Display Items For The Cause Of Automatic Cancellation….1033
              Laser Beam Adjust….1034
            SELF DIAGNOSTIC RESULT….1034
            DATA MONITOR….1034
            ACTIVE TEST….1036
              METER LAMP….1036
              DCA INDICATOR….1037
              STOP LAMP….1037
              BOOSTER SOL/V….1037
              ICC BUZZER….1038
              ACCELERATOR PEDAL ACTUATOR….1038
      DTC/CIRCUIT DIAGNOSIS….1040
        C1A00 CONTROL UNIT….1040
          C1A00 CONTROL UNIT….1040
          Description….1040
          DTC Logic….1040
            DTC DETECTION LOGIC….1040
            DTC CONFIRMATION PROCEDURE….1040
          Diagnosis Procedure….1040
          Special Repair Requirement….1040
            DESCRIPTION….1040
            SPECIAL REPAIR REQUIREMENT….1040
        C1A01 POWER SUPPLY CIRCUIT 1, C1A02 POWER SUPPLY CIRCUIT 2….1042
          C1A01 POWER SUPPLY CIRCUIT 1, C1A02 POWER SUPPLY CIRCUIT 2….1042
          Description….1042
          DTC Logic….1042
            DTC DETECTION LOGIC….1042
            DTC CONFIRMATION PROCEDURE….1042
          Diagnosis Procedure….1042
          Special Repair Requirement….1042
            DESCRIPTION….1042
            SPECIAL REPAIR REQUIREMENT….1042
        C1A03 VEHICLE SPEED SENSOR….1044
          C1A03 VEHICLE SPEED SENSOR….1044
          Description….1044
          DTC Logic….1044
            DTC DETECTION LOGIC….1044
            DTC CONFIRMATION PROCEDURE….1044
          Diagnosis Procedure….1044
          Special Repair Requirement….1045
            DESCRIPTION….1045
            SPECIAL REPAIR REQUIREMENT….1045
        C1A04 ABS/TCS/VDC SYSTEM….1046
          C1A04 ABS/TCS/VDC SYSTEM….1046
          Description….1046
          DTC Logic….1046
            DTC DETECTION LOGIC….1046
          Diagnosis Procedure….1046
          Special Repair Requirement….1046
            DESCRIPTION….1046
            SPECIAL REPAIR REQUIREMENT….1046
        C1A05 BRAKE SW/STOP LAMP SW….1048
          C1A05 BRAKE SW/STOP LAMP SW….1048
          Description….1048
          DTC Logic….1048
            DTC DETECTION LOGIC….1048
          Diagnosis Procedure….1048
          Component Inspection (ICC Brake Switch)….1051
          Component Inspection (Stop Lamp Switch)….1051
          Special Repair Requirement….1051
            DESCRIPTION….1051
            SPECIAL REPAIR REQUIREMENT….1051
        C1A06 OPERATION SW….1053
          C1A06 OPERATION SW….1053
          Description….1053
          DTC Logic….1053
            DTC DETECTION LOGIC….1053
            DTC CONFIRMATION PROCEDURE….1053
          Diagnosis Procedure….1053
          Component Inspection….1054
          Special Repair Requirement….1055
            DESCRIPTION….1055
            SPECIAL REPAIR REQUIREMENT….1055
        C1A08 PRESSURE SENSOR….1056
          C1A08 PRESSURE SENSOR….1056
          Description….1056
          DTC Logic….1056
            DTC DETECTION LOGIC….1056
            DTC CONFIRMATION PROCEDURE….1056
          Diagnosis Procedure….1056
          Special Repair Requirement….1057
            DESCRIPTION….1057
            SPECIAL REPAIR REQUIREMENT….1057
        C1A09 BOOSTER SOLENOID….1058
          C1A09 BOOSTER SOLENOID….1058
          Description….1058
          DTC Logic….1058
            DTC DETECTION LOGIC….1058
            DTC CONFIRMATION PROCEDURE….1058
          Diagnosis Procedure….1058
          Component Inspection….1059
          Special Repair Requirement….1059
            DESCRIPTION….1059
            SPECIAL REPAIR REQUIREMENT….1059
        C1A10 RELEASE SWITCH….1061
          C1A10 RELEASE SWITCH….1061
          Description….1061
          DTC Logic….1061
            DTC DETECTION LOGIC….1061
            DTC CONFIRMATION PROCEDURE….1061
          Diagnosis Procedure….1061
          Component Inspection….1062
          Special Repair Requirement….1063
            DESCRIPTION….1063
            SPECIAL REPAIR REQUIREMENT….1063
        C1A11 PRESSURE CONTROL….1064
          C1A11 PRESSURE CONTROL….1064
          Description….1064
          DTC Logic….1064
            DTC DETECTION LOGIC….1064
            DTC CONFIRMATION PROCEDURE….1064
          Diagnosis Procedure….1064
          Component Inspection….1065
          Special Repair Requirement….1065
            DESCRIPTION….1065
            SPECIAL REPAIR REQUIREMENT….1065
        C1A12 LASER BEAM OFF CENTER….1067
          C1A12 LASER BEAM OFF CENTER….1067
          Description….1067
          DTC Logic….1067
            DTC DETECTION LOGIC….1067
          Diagnosis Procedure….1067
          Special Repair Requirement….1067
            DESCRIPTION….1067
            SPECIAL REPAIR REQUIREMENT….1067
        C1A13 STOP LAMP RELAY….1068
          C1A13 STOP LAMP RELAY….1068
          Description….1068
          DTC Logic….1068
            DTC DETECTION LOGIC….1068
            DTC CONFIRMATION PROCEDURE….1068
          Diagnosis Procedure….1068
          Component Inspection….1073
          Special Repair Requirement….1073
            DESCRIPTION….1073
            SPECIAL REPAIR REQUIREMENT….1074
        C1A14 ECM….1075
          C1A14 ECM….1075
          Description….1075
          DTC Logic….1075
            DTC DETECTION LOGIC….1075
          Diagnosis Procedure….1075
          Special Repair Requirement….1075
            DESCRIPTION….1075
            SPECIAL REPAIR REQUIREMENT….1076
        C1A15 GEAR POSITION….1077
          C1A15 GEAR POSITION….1077
          Description….1077
          DTC Logic….1077
            DTC DETECTION LOGIC….1077
            DTC CONFIRMATION PROCEDURE….1077
          Diagnosis Procedure….1077
          Special Repair Requirement….1078
            DESCRIPTION….1078
            SPECIAL REPAIR REQUIREMENT….1078
        C1A16 RADAR STAIN….1080
          C1A16 RADAR STAIN….1080
          Description….1080
          DTC Logic….1080
            DTC DETECTION LOGIC….1080
          Diagnosis Procedure….1080
          Special Repair Requirement….1080
            DESCRIPTION….1080
            SPECIAL REPAIR REQUIREMENT….1081
        C1A18 LASER AIMING INCMP….1082
          C1A18 LASER AIMING INCMP….1082
          Description….1082
          DTC Logic….1082
            DTC DETECTION LOGIC….1082
            DTC CONFIRMATION PROCEDURE….1082
          Diagnosis Procedure….1082
          Special Repair Requirement….1082
            DESCRIPTION….1082
            SPECIAL REPAIR REQUIREMENT….1082
        C1A21 UNIT HIGH TEMP….1084
          C1A21 UNIT HIGH TEMP….1084
          Description….1084
          DTC Logic….1084
            DTC DETECTION LOGIC….1084
            DTC CONFIRMATION PROCEDURE….1084
          Diagnosis Procedure….1084
          Special Repair Requirement….1084
            DESCRIPTION….1084
            SPECIAL REPAIR REQUIREMENT….1084
        C1A22 BCU CIRCUIT….1086
          C1A22 BCU CIRCUIT….1086
          Description….1086
          DTC Logic….1086
            DTC DETECTION LOGIC….1086
            DTC CONFIRMATION PROCEDURE….1086
          Diagnosis Procedure….1086
          Special Repair Requirement….1088
            DESCRIPTION….1088
            SPECIAL REPAIR REQUIREMENT….1088
        C1A24 NP RANGE….1090
          C1A24 NP RANGE….1090
          Description….1090
          DTC Logic….1090
            DTC DETECTION LOGIC….1090
            DTC CONFIRMATION PROCEDURE….1090
          Diagnosis Procedure….1090
          Special Repair Requirement….1091
            DESCRIPTION….1091
            SPECIAL REPAIR REQUIREMENT….1091
        C1A28 BCU POWER SUPPLY CIRCUIT, C1A29 BCU POWER SUPPLY CIRCUIT2….1092
          C1A28 BCU POWER SUPPLY CIRCUIT, C1A29 BCU POWER SUPPLY CIRCUIT2….1092
          Description….1092
          DTC Logic….1092
            DTC DETECTION LOGIC….1092
            DTC CONFIRMATION PROCEDURE….1092
          Diagnosis Procedure….1092
          Special Repair Requirement….1092
            DESCRIPTION….1092
            SPECIAL REPAIR REQUIREMENT….1093
        C1A30 BCU CAN COMM CIRC ….1094
          C1A30 BCU CAN COMM CIRC ….1094
          Description….1094
          DTC Logic….1094
            DTC DETECTION LOGIC….1094
          Diagnosis Procedure….1094
          Special Repair Requirement….1094
            DESCRIPTION….1094
            SPECIAL REPAIR REQUIREMENT….1094
        C1A31 BCU INTERNAL MALF….1095
          C1A31 BCU INTERNAL MALF….1095
          Description….1095
          DTC Logic….1095
            DTC DETECTION LOGIC….1095
            DTC CONFIRMATION PROCEDURE….1095
          Diagnosis Procedure….1095
          Special Repair Requirement….1095
            DESCRIPTION….1095
            SPECIAL REPAIR REQUIREMENT….1095
        C1A32 IBA FLAG STUCK….1097
          C1A32 IBA FLAG STUCK….1097
          Description….1097
          DTC Logic….1097
            DTC DETECTION LOGIC….1097
            DTC CONFIRMATION PROCEDURE….1097
          Diagnosis Procedure….1097
          Special Repair Requirement….1097
            DESCRIPTION….1097
            SPECIAL REPAIR REQUIREMENT….1097
        C1A33 CAN TRANSMISSION ERROR….1099
          C1A33 CAN TRANSMISSION ERROR….1099
          Description….1099
          DTC Logic….1099
            DTC DETECTION LOGIC….1099
            DTC CONFIRMATION PROCEDURE….1099
          Diagnosis Procedure….1099
          Special Repair Requirement….1099
            DESCRIPTION….1099
            SPECIAL REPAIR REQUIREMENT….1099
        C1A34 COMMAND ERROR….1101
          C1A34 COMMAND ERROR….1101
          Description….1101
          DTC Logic….1101
            DTC DETECTION LOGIC….1101
            DTC CONFIRMATION PROCEDURE….1101
          Diagnosis Procedure….1101
          Special Repair Requirement….1101
            DESCRIPTION….1101
            SPECIAL REPAIR REQUIREMENT….1101
        C1A39 STEERING ANGLE SENSOR….1103
          C1A39 STEERING ANGLE SENSOR….1103
          Description….1103
          DTC Logic….1103
            DTC DETECTION LOGIC….1103
            DTC CONFIRMATION PROCEDURE….1103
          Diagnosis Procedure….1103
          Special Repair Requirement….1103
            DESCRIPTION….1103
            SPECIAL REPAIR REQUIREMENT….1103
        C1A40 SYSTEM SWITCH CIRCUIT….1105
          C1A40 SYSTEM SWITCH CIRCUIT….1105
          Description….1105
            IBA OFF SWITCH….1105
          DTC Logic….1105
            DTC DETECTION LOGIC….1105
            DTC CONFIRMATION PROCEDURE….1105
          Diagnosis Procedure….1105
          Component Inspection (IBA OFF Switch)….1106
          Special Repair Requirement….1107
            DESCRIPTION….1107
            SPECIAL REPAIR REQUIREMENT….1107
        U0121 VDC CAN 2….1108
          U0121 VDC CAN 2….1108
          Description….1108
          DTC Logic….1108
            DTC DETECTION LOGIC….1108
            DTC CONFIRMATION PROCEDURE….1108
          Diagnosis Procedure….1108
          Special Repair Requirement….1108
            DESCRIPTION….1108
            SPECIAL REPAIR REQUIREMENT….1108
        U0126 STRG SEN CAN 1….1110
          U0126 STRG SEN CAN 1….1110
          Description….1110
          DTC Logic….1110
            DTC DETECTION LOGIC….1110
            DTC CONFIRMATION PROCEDURE….1110
          Diagnosis Procedure….1110
          Special Repair Requirement….1110
            DESCRIPTION….1110
            SPECIAL REPAIR REQUIREMENT….1110
        U0129 BCU CAN 2….1112
          U0129 BCU CAN 2….1112
          Description….1112
          DTC Logic….1112
            DTC DETECTION LOGIC….1112
            DTC CONFIRMATION PROCEDURE….1112
          Diagnosis Procedure….1112
          Special Repair Requirement….1112
            DESCRIPTION….1112
            SPECIAL REPAIR REQUIREMENT….1113
        U0401 ECM CAN 1….1114
          U0401 ECM CAN 1….1114
          Description….1114
          DTC Logic….1114
            DTC DETECTION LOGIC….1114
            DTC CONFIRMATION PROCEDURE….1114
          Diagnosis Procedure….1114
          Special Repair Requirement….1114
            DESCRIPTION….1114
            SPECIAL REPAIR REQUIREMENT….1114
        U0402 TCM CAN 1….1116
          U0402 TCM CAN 1….1116
          Description….1116
          DTC Logic….1116
            DTC DETECTION LOGIC….1116
            DTC CONFIRMATION PROCEDURE….1116
          Diagnosis Procedure….1116
          Special Repair Requirement….1116
            DESCRIPTION….1116
            SPECIAL REPAIR REQUIREMENT….1116
        U0415 VDC CAN 1….1118
          U0415 VDC CAN 1….1118
          Description….1118
          DTC Logic….1118
            DTC DETECTION LOGIC….1118
            DTC CONFIRMATION PROCEDURE….1118
          Diagnosis Procedure….1118
          Special Repair Requirement….1118
            DESCRIPTION….1118
            SPECIAL REPAIR REQUIREMENT….1118
        U0418 BCU CAN 1….1120
          U0418 BCU CAN 1….1120
          Description….1120
          DTC Logic….1120
            DTC DETECTION LOGIC….1120
            DTC CONFIRMATION PROCEDURE….1120
          Diagnosis Procedure….1120
          Special Repair Requirement….1120
            DESCRIPTION….1120
            SPECIAL REPAIR REQUIREMENT….1121
        U0428 STRG SEN CAN 2….1122
          U0428 STRG SEN CAN 2….1122
          Description….1122
          DTC Logic….1122
            DTC DETECTION LOGIC….1122
            DTC CONFIRMATION PROCEDURE….1122
          Diagnosis Procedure….1122
          Special Repair Requirement….1122
            DESCRIPTION….1122
            SPECIAL REPAIR REQUIREMENT….1122
        U1000 CAN COMM CIRCUIT….1124
          U1000 CAN COMM CIRCUIT….1124
          Description….1124
            CAN COMMUNICATION….1124
            ITS COMMUNICATION….1124
          DTC Logic….1124
            DTC DETECTION LOGIC….1124
          Diagnosis Procedure….1124
          Special Repair Requirement….1124
            DESCRIPTION….1124
            SPECIAL REPAIR REQUIREMENT….1124
        U1010 CONTROL UNIT (CAN)….1126
          U1010 CONTROL UNIT (CAN)….1126
          Description….1126
          DTC Logic….1126
            DTC DETECTION LOGIC….1126
          Diagnosis Procedure….1126
          Special Repair Requirement….1126
            DESCRIPTION….1126
            SPECIAL REPAIR REQUIREMENT….1126
        POWER SUPPLY AND GROUND CIRCUIT….1127
          POWER SUPPLY AND GROUND CIRCUIT….1127
          ICC SENSOR INTEGRATED UNIT….1127
            ICC SENSOR INTEGRATED UNIT : Diagnosis Procedure….1127
          BRAKE BOOSTER CONTROL UNIT….1127
            BRAKE BOOSTER CONTROL UNIT : Diagnosis Procedure….1127
        ICC WARNING CHIME CIRCUIT….1129
          ICC WARNING CHIME CIRCUIT….1129
          Description….1129
          Component Function Check….1129
          Diagnosis Procedure….1129
          Component Inspection….1130
      ECU DIAGNOSIS INFORMATION….1131
        ICC SENSOR INTEGRATED UNIT….1131
          ICC SENSOR INTEGRATED UNIT….1131
          Reference Value….1131
            VALUES ON THE DIAGNOSIS TOOL….1131
            TERMINAL LAYOUT….1134
            PHYSICAL VALUES….1134
          Wiring Diagram – INTELLIGENT CRUISE CONTROL (FULL SPEED RANGE) -….1135
          Fail-Safe….1145
          DTC Inspection Priority Chart….1146
          DTC Index….1146
        BRAKE BOOSTER CONTROL UNIT….1149
          BRAKE BOOSTER CONTROL UNIT….1149
          Reference Value….1149
            TERMINAL LAYOUT….1149
            PHYSICAL VALUES….1149
      SYMPTOM DIAGNOSIS….1151
        INTELLIGENT CRUISE CONTROL (FULL SPEED RANGE) SYSTEM SYMPTOMS….1151
          INTELLIGENT CRUISE CONTROL (FULL SPEED RANGE) SYSTEM SYMPTOMS….1151
          Symptom Table….1151
        MAIN SWITCH DOES NOT TURN ON, MAIN SWITCH DOES NOT TURN OFF….1152
          MAIN SWITCH DOES NOT TURN ON, MAIN SWITCH DOES NOT TURN OFF….1152
          Description….1152
          Diagnosis Procedure….1152
        ICC SYSTEM CANNOT BE SET (MAIN SWITCH TURNS ON/OFF)….1153
          ICC SYSTEM CANNOT BE SET (MAIN SWITCH TURNS ON/OFF)….1153
          Description….1153
          Diagnosis Procedure….1153
        ICC STEERING SWITCH (OTHER THAN MAIN SWITCH) DOES NOT FUNCTION….1155
          ICC STEERING SWITCH (OTHER THAN MAIN SWITCH) DOES NOT FUNCTION….1155
          Description….1155
          Diagnosis Procedure….1155
        ICC SYSTEM DOES NOT CANCEL WHEN A/T SELECTOR LEVER SETS ON "N"….1156
          ICC SYSTEM DOES NOT CANCEL WHEN A/T SELECTOR LEVER SETS ON "N"….1156
          Description….1156
          Diagnosis Procedure….1156
        CHIME DOES NOT SOUND….1157
          CHIME DOES NOT SOUND….1157
          Description….1157
          Diagnosis Procedure….1157
        DRIVING FORCE IS HUNTING….1159
          DRIVING FORCE IS HUNTING….1159
          Description….1159
          Diagnosis Procedure….1159
        FREQUENTLY CANNOT DETECT THE VEHICLE AHEAD / DETECTION ZONE IS SHORT….1160
          FREQUENTLY CANNOT DETECT THE VEHICLE AHEAD / DETECTION ZONE IS SHORT….1160
          Description….1160
          Diagnosis Procedure….1160
        THE SYSTEM DOES NOT DETECT THE VEHICLE AHEAD AT ALL….1161
          THE SYSTEM DOES NOT DETECT THE VEHICLE AHEAD AT ALL….1161
          Description….1161
          Diagnosis Procedure….1161
        NORMAL OPERATING CONDITION….1162
          NORMAL OPERATING CONDITION….1162
          Description….1162
            PRECAUTIONS FOR VEHICLE-TO-VEHICLE DISTANCE CONTROL MODE….1162
            PRECAUTIONS FOR CONVENTIONAL (FIXED SPEED) CRUISE CONTROL MODE….1164
      PRECAUTION….1165
        PRECAUTIONS….1165
          PRECAUTIONS….1165
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….1165
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….1165
          Precautions for Removing Battery Terminal….1165
          Precautions For Harness Repair….1165
          ICC System Service….1166
      PREPARATION….1167
        PREPARATION….1167
          PREPARATION….1167
          Special Service Tools….1167
      REMOVAL AND INSTALLATION….1168
        ICC SENSOR INTEGRATED UNIT….1168
          ICC SENSOR INTEGRATED UNIT….1168
          Exploded View….1168
          Removal and Installation….1168
            REMOVAL….1168
            INSTALLATION….1168
        BRAKE BOOSTER CONTROL UNIT….1169
          BRAKE BOOSTER CONTROL UNIT….1169
          Exploded View….1169
          Removal and Installation….1169
            REMOVAL….1169
            INSTALLATION….1169
        ICC WARNING CHIME….1170
          ICC WARNING CHIME….1170
          Exploded View….1170
          Removal and Installation….1170
            REMOVAL….1170
            INSTALLATION….1170
        ICC STEERING SWITCH….1171
          ICC STEERING SWITCH….1171
          Exploded View….1171
    ASCD….1172
      ASCD….1172
      SYSTEM DESCRIPTION….1172
        AUTOMATIC SPEED CONTROL DEVICE (ASCD)….1172
          AUTOMATIC SPEED CONTROL DEVICE (ASCD)….1172
          Information….1172
chg….1173
  Table of Contents….1173
    BASIC INSPECTION….1175
      DIAGNOSIS AND REPAIR WORK FLOW….1175
        DIAGNOSIS AND REPAIR WORK FLOW….1175
        Work Flow(With EXP-800 NI or GR8-1200 NI)….1175
          CHARGING SYSTEM DIAGNOSIS WITH EXP-800 NI OR GR8-1200 NI….1175
          OVERALL SEQUENCE….1176
          DETAILED FLOW….1176
        Work Flow(Without EXP-800 NI or GR8-1200 NI)….1179
          OVERALL SEQUENCE….1179
          DETAILED FLOW….1179
    SYSTEM DESCRIPTION….1182
      CHARGING SYSTEM….1182
        CHARGING SYSTEM….1182
        System Diagram….1182
        System Description….1182
        VQ37VHR….1182
          VQ37VHR : Component Parts Location….1182
        VK50VE….1183
          VK50VE : Component Parts Location….1183
        Component Description….1183
      POWER GENERATION VOLTAGE VARIABLE CONTROL SYSTEM….1184
        POWER GENERATION VOLTAGE VARIABLE CONTROL SYSTEM….1184
        System Diagram….1184
        System Description….1184
        VQ37VHR….1184
          VQ37VHR : Component Parts Location….1184
        VK50VE….1184
          VK50VE : Component Parts Location….1185
        Component Description….1185
    DTC/CIRCUIT DIAGNOSIS….1186
      B TERMINAL CIRCUIT….1186
        B TERMINAL CIRCUIT….1186
        Description….1186
        Diagnosis Procedure….1186
      L TERMINAL CIRCUIT (OPEN)….1187
        L TERMINAL CIRCUIT (OPEN)….1187
        Description….1187
        Diagnosis Procedure….1187
      L TERMINAL CIRCUIT (SHORT)….1189
        L TERMINAL CIRCUIT (SHORT)….1189
        Description….1189
        Diagnosis Procedure….1189
      S TERMINAL CIRCUIT….1190
        S TERMINAL CIRCUIT….1190
        Description….1190
        Diagnosis Procedure….1190
      CHARGING SYSTEM….1191
        CHARGING SYSTEM….1191
        Wiring Diagram – CHARGING SYSTEM -….1191
    SYMPTOM DIAGNOSIS….1196
      CHARGING SYSTEM….1196
        CHARGING SYSTEM….1196
        Symptom Table….1196
    PRECAUTION….1197
      PRECAUTIONS….1197
        PRECAUTIONS….1197
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….1197
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….1197
        Precaution for Procedure without Cowl Top Cover….1197
        Precautions For Xenon Headlamp Service….1197
        Precaution for Power Generation Voltage Variable Control System….1198
        Precautions for Removing Battery Terminal….1198
    PREPARATION….1199
      PREPARATION….1199
        PREPARATION….1199
        Special Service Tools….1199
        Commercial Service Tools….1199
    PERIODIC MAINTENANCE….1200
      CHARGING SYSTEM PRELIMINARY INSPECTION….1200
        CHARGING SYSTEM PRELIMINARY INSPECTION….1200
        Inspection Procedure….1200
      POWER GENERATION VOLTAGE VARIABLE CONTROL SYSTEM OPERATION INSPECTION….1201
        POWER GENERATION VOLTAGE VARIABLE CONTROL SYSTEM OPERATION INSPECTION….1201
        Inspection Procedure….1201
    REMOVAL AND INSTALLATION….1203
      ALTERNATOR….1203
        ALTERNATOR….1203
        VQ37VHR….1203
          VQ37VHR : Exploded View….1203
            REMOVAL….1203
            DISASSEMBLY….1203
          VQ37VHR : Removal and Installation (2WD)….1204
            REMOVAL….1204
            INSTALLATION….1205
          VQ37VHR : Removal and Installation (AWD)….1205
            REMOVAL….1205
            INSTALLATION….1206
          VQ37VHR : Inspection….1206
            ALTERNATOR PULLEY INSPECTION….1206
        VK50VE….1206
          VK50VE : Exploded View….1206
            REMOVAL….1206
            DISASSEMBLY….1207
          VK50VE : Removal and Installation….1208
            REMOVAL….1208
            INSTALLATION….1208
          VK50VE : Inspection….1209
            ALTERNATOR PULLEY INSPECTION….1209
    SERVICE DATA AND SPECIFICATIONS (SDS)….1210
      SERVICE DATA AND SPECIFICATIONS (SDS)….1210
        SERVICE DATA AND SPECIFICATIONS (SDS)….1210
        Alternator….1210
co….1211
  Table of Contents….1211
    VQ37VHR….1213
      VQ37VHR….1213
      SYSTEM DESCRIPTION….1213
        DESCRIPTION….1213
          DESCRIPTION….1213
          Engine Cooling System….1213
          Engine Cooling System Schematic….1214
      SYMPTOM DIAGNOSIS….1216
        OVERHEATING CAUSE ANALYSIS….1216
          OVERHEATING CAUSE ANALYSIS….1216
          Troubleshooting Chart….1216
      PRECAUTION….1218
        PRECAUTIONS….1218
          PRECAUTIONS….1218
          Precautions for Removing Battery Terminal….1218
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….1218
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….1218
      PREPARATION….1219
        PREPARATION….1219
          PREPARATION….1219
          Commercial Service Tools….1219
      PERIODIC MAINTENANCE….1220
        ENGINE COOLANT….1220
          ENGINE COOLANT….1220
          Inspection….1220
            LEVEL ….1220
            LEAKAGE….1220
          Draining….1220
          Refilling….1221
          Flushing….1223
        RADIATOR….1224
          RADIATOR….1224
          RADIATOR CAP….1224
            RADIATOR CAP : Inspection….1224
          RADIATOR….1224
            RADIATOR : Inspection….1224
      REMOVAL AND INSTALLATION….1226
        RADIATOR….1226
          RADIATOR….1226
          Exploded View….1226
          Removal and Installation….1226
            REMOVAL….1226
            INSTALLATION….1228
          Inspection….1229
            INSPECTION AFTER INSTALLATION….1229
        COOLING FAN….1230
          COOLING FAN….1230
          Exploded View….1230
          Removal and Installation….1230
            REMOVAL….1230
            INSTALLATION….1230
          Disassembly and Assembly….1230
            DISASSEMBLY….1230
            ASSEMBLY….1231
          Inspection….1231
            INSPECTION AFTER REMOVAL….1231
            INSPECTION AFTER DISASSEMBLY….1231
              Cooling Fan….1231
        WATER PUMP….1232
          WATER PUMP….1232
          Exploded View….1232
          Removal and Installation….1232
            REMOVAL….1232
            INSTALLATION….1233
          Inspection….1234
            INSPECTION AFTER REMOVAL….1234
            INSPECTION AFTER INSTALLATION….1234
        WATER INLET AND THERMOSTAT ASSEMBLY….1235
          WATER INLET AND THERMOSTAT ASSEMBLY….1235
          Exploded View….1235
          Removal and Installation….1235
            REMOVAL….1235
            INSTALLATION….1235
          Inspection….1236
            INSPECTION AFTER REMOVAL….1236
            INSPECTION AFTER INSTALLATION….1236
        WATER OUTLET AND WATER PIPING….1237
          WATER OUTLET AND WATER PIPING….1237
          Exploded View….1237
          Removal and Installation….1238
            REMOVAL….1238
            INSTALLATION….1239
          Inspection….1239
            INSPECTION AFTER INSTALLATION….1239
      SERVICE DATA AND SPECIFICATIONS (SDS)….1240
        SERVICE DATA AND SPECIFICATIONS (SDS)….1240
          SERVICE DATA AND SPECIFICATIONS (SDS)….1240
          Periodical Maintenance Specification….1240
            ENGINE COOLANT CAPACITY (APPROXIMATELY)….1240
          Radiator….1240
          Thermostat….1240
    VK50VE….1241
      VK50VE….1241
      SYSTEM DESCRIPTION….1241
        DESCRIPTION….1241
          DESCRIPTION….1241
          Engine Cooling System….1241
          Engine Cooling System Schematic….1242
      SYMPTOM DIAGNOSIS….1243
        OVERHEATING CAUSE ANALYSIS….1243
          OVERHEATING CAUSE ANALYSIS….1243
          Troubleshooting Chart….1243
      PRECAUTION….1245
        PRECAUTIONS….1245
          PRECAUTIONS….1245
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….1245
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….1245
          Precautions for Removing Battery Terminal….1245
      PREPARATION….1246
        PREPARATION….1246
          PREPARATION….1246
          Commercial Service Tools….1246
      PERIODIC MAINTENANCE….1247
        ENGINE COOLANT….1247
          ENGINE COOLANT….1247
          Inspection….1247
            LEVEL ….1247
            LEAKAGE….1247
          Draining….1247
          Refilling….1248
          Flushing….1250
        RADIATOR….1251
          RADIATOR….1251
          RADIATOR CAP….1251
            RADIATOR CAP : Inspection….1251
          RADIATOR….1251
            RADIATOR : Inspection….1251
      REMOVAL AND INSTALLATION….1253
        RADIATOR….1253
          RADIATOR….1253
          Exploded View….1253
          Removal and Installation….1253
            REMOVAL….1253
            INSTALLATION….1255
          Inspection….1256
            INSPECTION AFTER INSTALLATION….1256
        COOLING FAN….1257
          COOLING FAN….1257
          Exploded View….1257
          Removal and Installation….1257
            REMOVAL….1257
            INSTALLATION….1257
          Disassembly and Assembly….1257
            DISASSEMBLY….1257
            ASSEMBLY….1258
          Inspection….1258
            INSPECTION AFTER REMOVAL….1258
            INSPECTION AFTER DISASSEMBLY….1258
              Cooling Fan….1258
        WATER PUMP….1259
          WATER PUMP….1259
          Exploded View….1259
          Removal and Installation….1259
            REMOVAL….1259
            INSTALLATION….1260
          Inspection….1260
            INSPECTION AFTER REMOVAL….1260
            INSPECTION AFTER INSTALLATION….1260
        WATER INLET AND THERMOSTAT ASSEMBLY….1261
          WATER INLET AND THERMOSTAT ASSEMBLY….1261
          Exploded View….1261
          Removal and Installation….1261
            REMOVAL….1261
            INSTALLATION….1262
              Thermostat….1262
              Water Connector and Heater Pipe ….1262
          Inspection….1262
            INSPECTION AFTER REMOVAL….1262
            INSPECTION AFTER INSTALLATION….1263
      SERVICE DATA AND SPECIFICATIONS (SDS)….1264
        SERVICE DATA AND SPECIFICATIONS (SDS)….1264
          SERVICE DATA AND SPECIFICATIONS (SDS)….1264
          Periodical Maintenance Specification….1264
            ENGINE COOLANT CAPACITY (APPROXIMATELY)….1264
          Radiator….1264
          Thermostat….1264
das….1265
  Table of Contents….1265
    DCA….1272
      DCA….1272
      BASIC INSPECTION….1272
        DIAGNOSIS AND REPAIR WORK FLOW….1272
          DIAGNOSIS AND REPAIR WORK FLOW….1272
          Work Flow….1272
            OVERALL SEQUENCE….1272
            DETAILED FLOW….1272
        INSPECTION AND ADJUSTMENT….1274
          INSPECTION AND ADJUSTMENT….1274
          ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (ICC SENSOR INTEGRATED UNIT)….1274
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (ICC SENSOR INTEGRATED UNIT) : Description….1274
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (ICC SENSOR INTEGRATED UNIT) : Special Repair Requirement….1274
          ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (ACCELERATOR PEDAL ASSEMBLY)….1274
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (ACCELERATOR PEDAL ASSEMBLY) : Description….1274
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (ACCELERATOR PEDAL ASSEMBLY) : Special Repair Requirement….1274
          ACTION TEST….1274
            ACTION TEST : Description….1275
            ACTION TEST : Special Repair Requirement (Distance Control Assist)….1275
      SYSTEM DESCRIPTION….1276
        DISTANCE CONTROL ASSIST SYSTEM….1276
          DISTANCE CONTROL ASSIST SYSTEM….1276
          System Diagram….1276
          System Description….1276
            FUNCTION DESCRIPTION….1276
            OPERATION DESCRIPTION….1277
              Operation Condition….1278
              No Operation Condition….1278
              Operation Cancellation Condition….1278
              Operation At The Driver Operation….1278
            OPERATION AND DISPLAY….1278
              Switch and Display….1278
              System Control Condition Display….1279
              Approach Warning Display….1279
              Warning Lamp Display….1279
            ICC SENSOR INTEGRATED UNIT INPUT/OUTPUT SIGNAL ITEM….1280
              Input Signal Item….1280
              Output Signal Item….1281
          Component Parts Location….1282
          Component Description….1282
        DIAGNOSIS SYSTEM (ICC SENSOR INTEGRATED UNIT)….1284
          DIAGNOSIS SYSTEM (ICC SENSOR INTEGRATED UNIT)….1284
          Diagnosis Description….1284
            ON BOARD SELF-DIAGNOSIS SYSTEM DIAGRAM….1284
            ON BOARD SELF-DIAGNOSIS OPERATION PROCEDURE….1284
            WHEN THE ON BOARD SELF-DIAGNOSIS DOES NOT START….1285
            HOW TO ERASE ON BOARD SELF-DIAGNOSIS….1285
          CONSULT Function (ICC/ADAS)….1285
            DESCRIPTION….1285
            WORK SUPPORT….1286
              Display Items For The Cause Of Automatic Cancellation….1286
              Laser Beam Adjust….1287
            SELF DIAGNOSTIC RESULT….1287
            DATA MONITOR….1287
            ACTIVE TEST….1289
              METER LAMP….1289
              DCA INDICATOR….1290
              STOP LAMP….1290
              BOOSTER SOL/V….1290
              ICC BUZZER….1291
              ACCELERATOR PEDAL ACTUATOR….1291
        DIAGNOSIS SYSTEM (ACCELERATOR PEDAL ACTUATOR)….1293
          DIAGNOSIS SYSTEM (ACCELERATOR PEDAL ACTUATOR)….1293
          CONSULT Function (ACCELE PEDAL ACT)….1293
            DESCRIPTION….1293
            SELF DIAGNOSTIC RESULT….1293
              Self Diagnostic Result….1293
              FFD (Freeze Frame Data)….1293
            DATA MONITOR….1293
            ACTIVE TEST….1294
              Item list….1294
              ACCELERATOR PEDAL ACTUATOR TEST 1….1294
              ACCELERATOR PEDAL ACTUATOR TEST 2….1294
            ECU IDENTIFICATION….1294
      DTC/CIRCUIT DIAGNOSIS….1295
        C1A00 CONTROL UNIT….1295
          C1A00 CONTROL UNIT….1295
          Description….1295
          DTC Logic….1295
            DTC DETECTION LOGIC….1295
            DTC CONFIRMATION PROCEDURE….1295
          Diagnosis Procedure….1295
          Special Repair Requirement….1295
            DESCRIPTION….1295
            SPECIAL REPAIR REQUIREMENT….1295
        C1A01 POWER SUPPLY CIRCUIT 1, C1A02 POWER SUPPLY CIRCUIT 2….1297
          C1A01 POWER SUPPLY CIRCUIT 1, C1A02 POWER SUPPLY CIRCUIT 2….1297
          Description….1297
          DTC Logic….1297
            DTC DETECTION LOGIC….1297
            DTC CONFIRMATION PROCEDURE….1297
          Diagnosis Procedure….1297
          Special Repair Requirement….1297
            DESCRIPTION….1297
            SPECIAL REPAIR REQUIREMENT….1297
        C1A03 VEHICLE SPEED SENSOR….1299
          C1A03 VEHICLE SPEED SENSOR….1299
          Description….1299
          DTC Logic….1299
            DTC DETECTION LOGIC….1299
            DTC CONFIRMATION PROCEDURE….1299
          Diagnosis Procedure….1299
          Special Repair Requirement….1300
            DESCRIPTION….1300
            SPECIAL REPAIR REQUIREMENT….1300
        C1A04 ABS/TCS/VDC SYSTEM….1301
          C1A04 ABS/TCS/VDC SYSTEM….1301
          Description….1301
          DTC Logic….1301
            DTC DETECTION LOGIC….1301
          Diagnosis Procedure….1301
          Special Repair Requirement….1301
            DESCRIPTION….1301
            SPECIAL REPAIR REQUIREMENT….1301
        C1A05 BRAKE SW/STOP LAMP SW….1303
          C1A05 BRAKE SW/STOP LAMP SW….1303
          Description….1303
          DTC Logic….1303
            DTC DETECTION LOGIC….1303
          Diagnosis Procedure….1303
          Component Inspection (ICC Brake Switch)….1306
          Component Inspection (Stop Lamp Switch)….1306
          Special Repair Requirement….1306
            DESCRIPTION….1306
            SPECIAL REPAIR REQUIREMENT….1306
        C1A06 OPERATION SW….1308
          C1A06 OPERATION SW….1308
          Description….1308
          DTC Logic….1308
            DTC DETECTION LOGIC….1308
            DTC CONFIRMATION PROCEDURE….1308
          Diagnosis Procedure….1308
          Component Inspection….1309
          Special Repair Requirement….1310
            DESCRIPTION….1310
            SPECIAL REPAIR REQUIREMENT….1310
        C1A08 PRESSURE SENSOR….1311
          C1A08 PRESSURE SENSOR….1311
          Description….1311
          DTC Logic….1311
            DTC DETECTION LOGIC….1311
            DTC CONFIRMATION PROCEDURE….1311
          Diagnosis Procedure….1311
          Special Repair Requirement….1312
            DESCRIPTION….1312
            SPECIAL REPAIR REQUIREMENT….1312
        C1A09 BOOSTER SOLENOID….1313
          C1A09 BOOSTER SOLENOID….1313
          Description….1313
          DTC Logic….1313
            DTC DETECTION LOGIC….1313
            DTC CONFIRMATION PROCEDURE….1313
          Diagnosis Procedure….1313
          Component Inspection….1314
          Special Repair Requirement….1314
            DESCRIPTION….1314
            SPECIAL REPAIR REQUIREMENT….1314
        C1A10 RELEASE SWITCH….1316
          C1A10 RELEASE SWITCH….1316
          Description….1316
          DTC logic….1316
            DTC DETECTION LOGIC….1316
            DTC CONFIRMATION PROCEDURE….1316
          Diagnosis Procedure….1316
          Component Inspection….1317
          Special Repair Requirement….1318
            DESCRIPTION….1318
            SPECIAL REPAIR REQUIREMENT….1318
        C1A11 PRESSURE CONTROL….1319
          C1A11 PRESSURE CONTROL….1319
          Description….1319
          DTC Logic….1319
            DTC DETECTION LOGIC….1319
            DTC CONFIRMATION PROCEDURE….1319
          Diagnosis Procedure….1319
          Component Inspection….1320
          Special Repair Requirement….1320
            DESCRIPTION….1320
            SPECIAL REPAIR REQUIREMENT….1320
        C1A12 LASER BEAM OFF CENTER….1322
          C1A12 LASER BEAM OFF CENTER….1322
          Description….1322
          DTC Logic….1322
            DTC DETECTION LOGIC….1322
          Diagnosis Procedure….1322
          Special Repair Requirement….1322
            DESCRIPTION….1322
            SPECIAL REPAIR REQUIREMENT….1322
        C1A13 STOP LAMP RELAY….1323
          C1A13 STOP LAMP RELAY….1323
          Description….1323
          DTC Logic….1323
            DTC DETECTION LOGIC….1323
            DTC CONFIRMATION PROCEDURE….1323
          Diagnosis Procedure….1323
          Component Inspection….1328
          Special Repair Requirement….1328
            DESCRIPTION….1328
            SPECIAL REPAIR REQUIREMENT….1329
        C1A14 ECM….1330
          C1A14 ECM….1330
          Description….1330
          DTC Logic….1330
            DTC DETECTION LOGIC….1330
          Diagnosis Procedure….1330
          Special Repair Requirement….1330
            DESCRIPTION….1330
            SPECIAL REPAIR REQUIREMENT….1330
        C1A15 GEAR POSITION….1332
          C1A15 GEAR POSITION….1332
          Description….1332
          DTC Logic….1332
            DTC DETECTION LOGIC….1332
            DTC CONFIRMATION PROCEDURE….1332
          Diagnosis Procedure….1332
          Special Repair Requirement….1333
            DESCRIPTION….1333
            SPECIAL REPAIR REQUIREMENT….1333
        C1A16 RADAR STAIN….1335
          C1A16 RADAR STAIN….1335
          Description….1335
          DTC Logic….1335
            DTC DETECTION LOGIC….1335
          Diagnosis Procedure….1335
          Special Repair Requirement….1335
            DESCRIPTION….1335
            SPECIAL REPAIR REQUIREMENT….1336
        C1A18 LASER AIMING INCMP….1337
          C1A18 LASER AIMING INCMP….1337
          Description….1337
          DTC Logic….1337
            DTC DETECTION LOGIC….1337
            DTC CONFIRMATION PROCEDURE….1337
          Diagnosis Procedure….1337
          Special Repair Requirement….1337
            DESCRIPTION….1337
            SPECIAL REPAIR REQUIREMENT….1337
        C1A21 UNIT HIGH TEMP….1339
          C1A21 UNIT HIGH TEMP….1339
          Description….1339
          DTC Logic….1339
            DTC DETECTION LOGIC….1339
            DTC CONFIRMATION PROCEDURE….1339
          Diagnosis Procedure….1339
          Special Repair Requirement….1339
            DESCRIPTION….1339
            SPECIAL REPAIR REQUIREMENT….1339
        C1A22 BCU CIRCUIT….1341
          C1A22 BCU CIRCUIT….1341
          Description….1341
          DTC Logic….1341
…
            TOUCH SENSOR : Exploded View….2031
            TOUCH SENSOR : Removal and Installation….2031
              REMOVAL….2031
              INSTALLATION….2032
          EMERGENCY LEVER….2032
            EMERGENCY LEVER : Exploded View….2033
            EMERGENCY LEVER : Unlock procedures….2033
              UNLOCK PROCEDURES….2033
        FUEL FILLER LID OPENER….2034
          FUEL FILLER LID OPENER….2034
          Exploded View….2034
          Removal and Installation….2034
            REMOVAL ….2034
            INSTALLATION ….2035
        DOOR SWITCH….2036
          DOOR SWITCH….2036
          Exploded View….2036
          Removal and Installation….2036
            REMOVAL….2036
            INSTALLATION….2036
        INSIDE KEY ANTENNA….2037
          INSIDE KEY ANTENNA….2037
          INSTRUMENT CENTER….2037
            INSTRUMENT CENTER : Exploded View….2037
            INSTRUMENT CENTER : Removal and Installation….2037
              REMOVAL….2037
              INSTALLATION….2037
          LUGGAGE ROOM….2037
            LUGGAGE ROOM : Exploded View….2037
            LUGGAGE ROOM : Removal and Installation….2037
              REMOVAL….2037
              INSTALLATION….2038
        OUTSIDE KEY ANTENNA….2039
          OUTSIDE KEY ANTENNA….2039
          DRIVER SIDE….2039
            DRIVER SIDE : Exploded View….2039
            DRIVER SIDE : Removal and Installation….2039
              REMOVAL….2039
              INSTALLATION….2039
          PASSENGER SIDE….2039
            PASSENGER SIDE : Exploded View….2039
            PASSENGER SIDE : Removal and Installation….2039
              REMOVAL….2039
              INSTALLATION….2039
          BACK DOOR….2039
            BACK DOOR : Exploded View….2039
            BACK DOOR : Removal and Installation….2039
              REMOVAL….2039
              INSTALLATION….2039
        INTELLIGENT KEY WARNING BUZZER….2040
          INTELLIGENT KEY WARNING BUZZER….2040
          Exploded View….2040
          Removal and Installation….2040
            REMOVAL….2040
            INSTALLATION….2040
        KEY SLOT….2041
          KEY SLOT….2041
          Exploded View….2041
          Removal and Installation….2041
            REMOVAL….2041
            INSTALLATION….2041
        REMOTE KEYLESS ENTRY RECEIVER….2042
          REMOTE KEYLESS ENTRY RECEIVER….2042
          Exploded View….2042
          Removal and Installation….2042
            REMOVAL….2042
            INSTALLATION….2042
        INTELLIGENT KEY BATTERY….2043
          INTELLIGENT KEY BATTERY….2043
          Removal and Installation….2043
        AUTOMATIC BACK DOOR CONTROL UNIT….2044
          AUTOMATIC BACK DOOR CONTROL UNIT….2044
          Removal and Installation….2044
            REMOVAL….2044
            INSTALLATION….2044
        AUTOMATIC BACK DOOR WARNING BUZZER….2045
          AUTOMATIC BACK DOOR WARNING BUZZER….2045
          Removal and Installation….2045
            REMOVAL….2045
            INSTALLATION….2045
        AUTOMATIC BACK DOOR MAIN SWITCH….2046
          AUTOMATIC BACK DOOR MAIN SWITCH….2046
          Removal and Installation….2046
            REMOVAL….2046
            INSTALLATION….2046
        AUTOMATIC BACK DOOR CLOSE SWITCH….2047
          AUTOMATIC BACK DOOR CLOSE SWITCH….2047
          Removal and Installation….2047
            REMOVAL….2047
            INSTALLATION….2047
        AUTOMATIC BACK DOOR SWITCH….2048
          AUTOMATIC BACK DOOR SWITCH….2048
          Removal and Installation….2048
            REMOVAL….2048
            INSTALLATION….2048
dln….2049
  Table of Contents….2049
    TRANSFER: ETX13C….2055
      TRANSFER: ETX13C….2055
      BASIC INSPECTION….2055
        DIAGNOSIS AND REPAIR WORK FLOW….2055
          DIAGNOSIS AND REPAIR WORK FLOW….2055
          Work Flow….2055
            DETAILED FLOW….2055
      SYSTEM DESCRIPTION….2056
        AWD SYSTEM….2056
          AWD SYSTEM….2056
          System Diagram….2056
            CONTROL DIAGRAM….2056
            CROSS-SECTIONAL VIEW….2056
          System Description….2058
            DESCRIPTION….2058
            OPERATION PRINCIPLE….2058
          Component Parts Location….2059
          Component Description….2059
        DIAGNOSIS SYSTEM (AWD CONTROL UNIT)….2060
          DIAGNOSIS SYSTEM (AWD CONTROL UNIT)….2060
          CONSULT Function….2060
            FUNCTION….2060
            ECU IDENTIFICATION….2060
            SELF DIAGNOSTIC RESULT….2060
              Display Item List….2060
              How to Erase Self-Diagnostic Results….2060
            DATA MONITOR….2060
            ACTIVE TEST….2060
              Description….2061
              Test Item….2061
      DTC/CIRCUIT DIAGNOSIS….2062
        C1201 AWD CONTROL UNIT….2062
          C1201 AWD CONTROL UNIT….2062
          Description….2062
          DTC Logic….2062
            DTC DETECTION LOGIC….2062
            DTC CONFIRMATION PROCEDURE….2062
          Diagnosis Procedure….2062
        C1203 ABS ACTUATOR AND ELECTRIC UNIT (CONTROL UNIT)….2063
          C1203 ABS ACTUATOR AND ELECTRIC UNIT (CONTROL UNIT)….2063
          Description….2063
          DTC Logic….2063
            DTC DETECTION LOGIC….2063
            DTC CONFIRMATION PROCEDURE….2063
          Diagnosis Procedure….2063
        C1204 AWD SOLENOID….2064
          C1204 AWD SOLENOID….2064
          Description….2064
          DTC Logic….2064
            DTC DETECTION LOGIC….2064
            DTC CONFIRMATION PROCEDURE….2064
          Diagnosis Procedure….2064
          Component Inspection….2065
        C1205 AWD ACTUATOR RELAY….2066
          C1205 AWD ACTUATOR RELAY….2066
          Description….2066
          DTC Logic….2066
            DTC DETECTION LOGIC….2066
            DTC CONFIRMATION PROCEDURE….2066
          Diagnosis Procedure….2066
        C1210 ECM….2068
          C1210 ECM….2068
          Description….2068
          DTC Logic….2068
            DTC DETECTION LOGIC….2068
            DTC CONFIRMATION PROCEDURE….2068
          Diagnosis Procedure….2068
        P1804 TRANSFER CONTROL UNIT….2069
          P1804 TRANSFER CONTROL UNIT….2069
          Description….2069
          DTC Logic….2069
            DTC DETECTION LOGIC….2069
            DTC CONFIRMATION PROCEDURE….2069
          Diagnosis Procedure….2069
        P1809 TRANSFER CONTROL UNIT….2070
          P1809 TRANSFER CONTROL UNIT….2070
          Description….2070
          DTC Logic….2070
            DTC DETECTION LOGIC….2070
            DTC CONFIRMATION PROCEDURE….2070
          Diagnosis Procedure….2070
        P1826 TRANSFER FLUID TEMPERATURE….2071
          P1826 TRANSFER FLUID TEMPERATURE….2071
          Description….2071
          DTC Logic….2071
            DTC DETECTION LOGIC….2071
            DTC CONFIRMATION PROCEDURE….2071
          Diagnosis Procedure….2071
          Component Inspection….2073
        U1000 CAN COMM CIRCUIT….2074
          U1000 CAN COMM CIRCUIT….2074
          Description….2074
          DTC Logic….2074
            DTC DETECTION LOGIC….2074
            DTC CONFIRMATION PROCEDURE….2074
          Diagnosis Procedure….2074
        U1010 CONTROL UNIT (CAN)….2075
          U1010 CONTROL UNIT (CAN)….2075
          Description….2075
          DTC Logic….2075
            DTC DETECTION LOGIC….2075
            DTC CONFIRMATION PROCEDURE….2075
          Diagnosis Procedure….2075
        POWER SUPPLY AND GROUND CIRCUIT….2076
          POWER SUPPLY AND GROUND CIRCUIT….2076
          Description….2076
          Diagnosis Procedure….2076
        AWD WARNING LAMP….2079
          AWD WARNING LAMP….2079
          Description….2079
            AWD WARNING LAMP INDICATION….2079
          Component Function Check….2079
          Diagnosis Procedure….2079
      ECU DIAGNOSIS INFORMATION….2081
        AWD CONTROL UNIT….2081
          AWD CONTROL UNIT….2081
          Reference Value….2081
            VALUES ON THE DIAGNOSIS TOOL….2081
            TERMINAL LAYOUT….2082
            PHYSICAL VALUES….2082
          Wiring Diagram – AWD SYSTEM -….2083
          Fail-Safe….2087
            AWD system….2087
          DTC Inspection Priority Chart….2088
          DTC Index….2088
      SYMPTOM DIAGNOSIS….2090
        AWD WARNING LAMP DOES NOT TURN ON….2090
          AWD WARNING LAMP DOES NOT TURN ON….2090
          Description….2090
          Diagnosis Procedure….2090
        AWD WARNING LAMP DOES NOT TURN OFF….2091
          AWD WARNING LAMP DOES NOT TURN OFF….2091
          Description….2091
          Diagnosis Procedure….2091
        HEAVY TIGHT-CORNER BRAKING SYMPTOM OCCURS….2092
          HEAVY TIGHT-CORNER BRAKING SYMPTOM OCCURS….2092
          Description….2092
          Diagnosis Procedure….2092
        VEHICLE DOES NOT ENTER AWD MODE….2093
          VEHICLE DOES NOT ENTER AWD MODE….2093
          Description….2093
          Diagnosis Procedure….2093
        AWD WARNING LAMP BLINKS QUICKLY….2094
          AWD WARNING LAMP BLINKS QUICKLY….2094
          Description….2094
        AWD WARNING LAMP BLINKS SLOWLY….2095
          AWD WARNING LAMP BLINKS SLOWLY….2095
          Description….2095
          Diagnosis Procedure….2095
        NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….2096
          NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….2096
          NVH Troubleshooting Chart….2096
      PRECAUTION….2097
        PRECAUTIONS….2097
          PRECAUTIONS….2097
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….2097
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….2097
          Precautions for Removing Battery Terminal….2097
          Service Notice or Precautions for Transfer….2097
      PREPARATION….2099
        PREPARATION….2099
          PREPARATION….2099
          VQ37VHR….2099
            VQ37VHR : Special Service Tools….2099
            VQ37VHR : Commercial Service Tools….2100
          VK50VE….2101
            VK50VE : Special Service Tools….2101
            VK50VE : Commercial Service Tools….2102
      PERIODIC MAINTENANCE….2104
        TRANSFER FLUID….2104
          TRANSFER FLUID….2104
          VQ37VHR….2104
            VQ37VHR : Inspection….2104
              FLUID LEAKAGE….2104
              FLUID LEVEL….2104
            VQ37VHR : Draining….2104
            VQ37VHR : Refilling….2104
          VK50VE….2104
            VK50VE : Inspection….2104
              FLUID LEAKAGE….2104
              FLUID LEVEL….2105
            VK50VE : Draining….2105
            VK50VE : Refilling….2105
      REMOVAL AND INSTALLATION….2106
        AWD CONTROL UNIT….2106
          AWD CONTROL UNIT….2106
          Exploded View….2106
          Removal and Installation….2106
            REMOVAL….2106
            INSTALLATION….2106
        FRONT OIL SEAL….2107
          FRONT OIL SEAL….2107
          Exploded View….2107
          Removal and Installation….2107
            REMOVAL….2107
            INSTALLATION….2107
        REAR OIL SEAL….2108
          REAR OIL SEAL….2108
          VQ37VHR….2108
            VQ37VHR : Exploded View….2108
            VQ37VHR : Removal and Installation….2108
              REMOVAL….2108
              INSTALLATION….2109
          VK50VE….2110
            VK50VE : Exploded View….2110
            VK50VE : Removal and Installation….2110
              REMOVAL….2110
              INSTALLATION….2111
      UNIT REMOVAL AND INSTALLATION….2113
        TRANSFER ASSEMBLY….2113
          TRANSFER ASSEMBLY….2113
          VQ37VHR….2113
            VQ37VHR : Exploded View….2113
            VQ37VHR : Removal and Installation….2113
              REMOVAL….2113
              INSTALLATION….2113
          VK50VE….2114
            VK50VE : Exploded View….2114
            VK50VE : Removal and Installation….2114
              REMOVAL….2114
              INSTALLATION….2115
      UNIT DISASSEMBLY AND ASSEMBLY….2116
        FRONT CASE AND REAR CASE….2116
          FRONT CASE AND REAR CASE….2116
          VQ37VHR….2116
            VQ37VHR : Exploded View….2116
            VQ37VHR : Disassembly….2117
            VQ37VHR : Assembly….2120
            VQ37VHR : Inspection….2124
              CASES….2124
              BEARING….2124
              SHAFT….2125
              GEARS AND CHAIN….2125
          VK50VE….2125
            VK50VE : Exploded View….2126
            VK50VE : Disassembly….2127
            VK50VE : Assembly….2130
            VK50VE : Inspection….2134
              CASES….2134
              BEARING….2134
              SHAFT….2135
              GEARS AND CHAIN….2135
        MAIN SHAFT….2136
          MAIN SHAFT….2136
          VQ37VHR….2136
            VQ37VHR : Exploded View….2136
            VQ37VHR : Disassembly….2137
            VQ37VHR : Assembly….2138
            VQ37VHR : Inspection….2139
              CASES….2139
              BEARING….2139
              SHAFT….2139
              GEARS AND CHAIN….2139
          VK50VE….2140
            VK50VE : Exploded View….2140
            VK50VE : Disassembly….2141
            VK50VE : Assembly….2142
            VK50VE : Inspection….2143
              CASES….2143
              BEARING….2143
              SHAFT….2143
              GEARS AND CHAIN….2144
        FRONT DRIVE SHAFT AND DRIVE CHAIN….2145
          FRONT DRIVE SHAFT AND DRIVE CHAIN….2145
          VQ37VHR….2145
            VQ37VHR : Exploded View….2145
            VQ37VHR : Disassembly….2146
            VQ37VHR : Assembly….2146
            VQ37VHR : Inspection….2147
              CASES….2147
              BEARING….2147
              SHAFT….2147
              GEARS AND CHAIN….2148
          VK50VE….2148
            VK50VE : Exploded View….2149
            VK50VE : Disassembly….2150
            VK50VE : Assembly….2150
            VK50VE : Inspection….2151
              CASES….2151
              BEARING….2151
              SHAFT….2151
              GEARS AND CHAIN….2152
      SERVICE DATA AND SPECIFICATIONS (SDS)….2153
        SERVICE DATA AND SPECIFICATIONS (SDS)….2153
          SERVICE DATA AND SPECIFICATIONS (SDS)….2153
          General Specifications….2153
    FRONT PROPELLER SHAFT: 2S56A….2154
      FRONT PROPELLER SHAFT: 2S56A….2154
      SYMPTOM DIAGNOSIS….2154
        NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….2154
          NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….2154
          NVH Troubleshooting Chart….2154
      PRECAUTION….2155
        PRECAUTIONS….2155
          PRECAUTIONS….2155
          Precautions for Removing Battery Terminal….2155
      PREPARATION….2156
        PREPARATION….2156
          PREPARATION….2156
          Commercial Service Tools….2156
      PERIODIC MAINTENANCE….2157
        FRONT PROPELLER SHAFT….2157
          FRONT PROPELLER SHAFT….2157
…
            2WD : Inspection After Disassembly….2299
              DRIVE GEAR AND DRIVE PINION….2299
              BEARING….2299
              SIDE GEAR AND PINION MATE GEAR….2300
              SIDE GEAR THRUST WASHER AND PINION MATE THRUST WASHER….2300
              OIL SEAL….2300
              DIFFERENTIAL CASE….2300
              COMPANION FLANGE….2300
          AWD….2300
            AWD : Exploded View….2300
            AWD : Disassembly….2301
            AWD : Assembly….2303
            AWD : Adjustment….2306
              PINION GEAR HEIGHT….2306
              COMPANION FLANGE RUNOUT….2307
            AWD : Inspection After Disassembly….2307
              DRIVE GEAR AND DRIVE PINION….2307
              BEARING….2307
              SIDE GEAR AND PINION MATE GEAR….2307
              SIDE GEAR THRUST WASHER AND PINION MATE THRUST WASHER….2307
              OIL SEAL….2307
              DIFFERENTIAL CASE….2307
              COMPANION FLANGE….2307
      SERVICE DATA AND SPECIFICATIONS (SDS)….2309
        SERVICE DATA AND SPECIFICATIONS (SDS)….2309
          SERVICE DATA AND SPECIFICATIONS (SDS)….2309
          General Specification….2309
          Drive Gear Runout….2309
          Differential Side Gear Clearance….2309
          Preload Torque….2309
          Backlash….2309
          Drive Pinion Runout (2WD)….2309
          Companion Flange Runout (AWD)….2309
    REAR FINAL DRIVE: R230….2311
      REAR FINAL DRIVE: R230….2311
      SYSTEM DESCRIPTION….2311
        REAR FINAL DRIVE ASSEMBLY….2311
          REAR FINAL DRIVE ASSEMBLY….2311
          System Diagram….2311
            CROSS-SECTIONAL VIEW….2311
      SYMPTOM DIAGNOSIS….2312
        NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….2312
          NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….2312
          NVH Troubleshooting Chart….2312
      PRECAUTION….2313
        PRECAUTIONS….2313
          PRECAUTIONS….2313
          Service Notice or Precautions for Rear Final Drive….2313
          Precautions for Removing Battery Terminal….2313
      PREPARATION….2314
        PREPARATION….2314
          PREPARATION….2314
…
          Diagnosis Procedure….2617
        P0172, P0175 FUEL INJECTION SYSTEM FUNCTION….2620
          P0172, P0175 FUEL INJECTION SYSTEM FUNCTION….2620
          DTC Logic….2620
            DTC DETECTION LOGIC….2620
            DTC CONFIRMATION PROCEDURE….2620
          Diagnosis Procedure….2621
        P0181 FTT SENSOR….2624
          P0181 FTT SENSOR….2624
          Description….2624
          DTC Logic….2624
            DTC DETECTION LOGIC….2624
            DTC CONFIRMATION PROCEDURE….2624
          Component Function Check….2626
          Diagnosis Procedure….2626
          Component Inspection….2627
        P0182, P0183 FTT SENSOR….2628
          P0182, P0183 FTT SENSOR….2628
          Description….2628
          DTC Logic….2628
            DTC DETECTION LOGIC….2628
            DTC CONFIRMATION PROCEDURE….2628
          Diagnosis Procedure….2628
          Component Inspection….2630
        P0196 EOT SENSOR….2631
          P0196 EOT SENSOR….2631
          Description….2631
          DTC Logic….2631
            DTC DETECTION LOGIC….2631
            DTC CONFIRMATION PROCEDURE….2631
          Component Function Check….2633
          Diagnosis Procedure….2634
          Component Inspection….2634
        P0197, P0198 EOT SENSOR….2635
          P0197, P0198 EOT SENSOR….2635
          Description….2635
          DTC Logic….2635
            DTC DETECTION LOGIC….2635
            DTC CONFIRMATION PROCEDURE….2635
          Diagnosis Procedure….2636
          Component Inspection….2636
        P0222, P0223, P2132, P2133 TP SENSOR….2638
          P0222, P0223, P2132, P2133 TP SENSOR….2638
          Description….2638
          DTC Logic….2638
            DTC DETECTION LOGIC….2638
            DTC CONFIRMATION PROCEDURE….2638
          Diagnosis Procedure….2638
          Component Inspection….2640
          Special Repair Requirement….2640
        P0300, P0301, P0302, P0303, P0304, P0305, P0306 MISFIRE….2641
          P0300, P0301, P0302, P0303, P0304, P0305, P0306 MISFIRE….2641
          DTC Logic….2641
            DTC DETECTION LOGIC….2641
            DTC CONFIRMATION PROCEDURE….2641
          Diagnosis Procedure….2642
        P0327, P0328, P0332, P0333 KS….2647
          P0327, P0328, P0332, P0333 KS….2647
          Description….2647
          DTC Logic….2647
            DTC DETECTION LOGIC….2647
            DTC CONFIRMATION PROCEDURE….2647
          Diagnosis Procedure….2647
          Component Inspection….2648
        P0335 CKP SENSOR (POS)….2650
          P0335 CKP SENSOR (POS)….2650
          Description….2650
          DTC Logic….2650
            DTC DETECTION LOGIC….2650
            DTC CONFIRMATION PROCEDURE….2650
          Diagnosis Procedure….2651
          Component Inspection….2653
        P0340, P0345 CMP SENSOR (PHASE)….2654
          P0340, P0345 CMP SENSOR (PHASE)….2654
          Description….2654
          DTC Logic….2654
            DTC DETECTION LOGIC….2654
            DTC CONFIRMATION PROCEDURE….2654
          Diagnosis Procedure….2655
          Component Inspection….2657
        P0420, P0430 THREE WAY CATALYST FUNCTION….2658
          P0420, P0430 THREE WAY CATALYST FUNCTION….2658
          DTC Logic….2658
            DTC DETECTION LOGIC….2658
            DTC CONFIRMATION PROCEDURE….2658
          Component Function Check….2659
          Diagnosis Procedure….2660
        P0441 EVAP CONTROL SYSTEM….2663
          P0441 EVAP CONTROL SYSTEM….2663
          DTC Logic….2663
            DTC DETECTION LOGIC….2663
            DTC CONFIRMATION PROCEDURE….2663
          Component Function Check….2664
          Diagnosis Procedure….2665
        P0443 EVAP CANISTER PURGE VOLUME CONTROL SOLENOID VALVE….2668
          P0443 EVAP CANISTER PURGE VOLUME CONTROL SOLENOID VALVE….2668
          Description….2668
          DTC Logic….2668
            DTC DETECTION LOGIC….2668
            DTC CONFIRMATION PROCEDURE….2668
          Diagnosis Procedure….2669
          Component Inspection….2671
        P0444, P0445 EVAP CANISTER PURGE VOLUME CONTROL SOLENOID VALVE….2673
          P0444, P0445 EVAP CANISTER PURGE VOLUME CONTROL SOLENOID VALVE….2673
          Description….2673
          DTC Logic….2673
            DTC DETECTION LOGIC….2673
            DTC CONFIRMATION PROCEDURE….2673
          Diagnosis Procedure….2673
          Component Inspection….2675
        P0447 EVAP CANISTER VENT CONTROL VALVE….2676
          P0447 EVAP CANISTER VENT CONTROL VALVE….2676
          Description….2676
          DTC Logic….2676
            DTC DETECTION LOGIC….2676
            DTC CONFIRMATION PROCEDURE….2676
          Diagnosis Procedure….2676
          Component Inspection….2678
        P0448 EVAP CANISTER VENT CONTROL VALVE….2680
          P0448 EVAP CANISTER VENT CONTROL VALVE….2680
          Description….2680
          DTC Logic….2680
            DTC DETECTION LOGIC….2680
            DTC CONFIRMATION PROCEDURE….2680
          Diagnosis Procedure….2681
          Component Inspection….2682
        P0451 EVAP CONTROL SYSTEM PRESSURE SENSOR….2684
          P0451 EVAP CONTROL SYSTEM PRESSURE SENSOR….2684
          Description….2684
          DTC Logic….2684
            DTC DETECTION LOGIC….2684
            DTC CONFIRMATION PROCEDURE….2684
          Diagnosis Procedure….2684
          Component Inspection….2686
        P0452 EVAP CONTROL SYSTEM PRESSURE SENSOR….2687
          P0452 EVAP CONTROL SYSTEM PRESSURE SENSOR….2687
          Description….2687
          DTC Logic….2687
            DTC DETECTION LOGIC….2687
            DTC CONFIRMATION PROCEDURE….2687
          Diagnosis Procedure….2688
          Component Inspection….2691
        P0453 EVAP CONTROL SYSTEM PRESSURE SENSOR….2692
          P0453 EVAP CONTROL SYSTEM PRESSURE SENSOR….2692
          Description….2692
          DTC Logic….2692
            DTC DETECTION LOGIC….2692
            DTC CONFIRMATION PROCEDURE….2692
          Diagnosis Procedure….2693
          Component Inspection….2696
        P0456 EVAP CONTROL SYSTEM….2698
          P0456 EVAP CONTROL SYSTEM….2698
          DTC Logic….2698
            DTC DETECTION LOGIC….2698
            DTC CONFIRMATION PROCEDURE….2698
          Diagnosis Procedure….2699
          Component Inspection….2702
        P0460 FUEL LEVEL SENSOR….2704
          P0460 FUEL LEVEL SENSOR….2704
          Description….2704
          DTC Logic….2704
            DTC DETECTION LOGIC….2704
            DTC CONFIRMATION PROCEDURE….2704
          Diagnosis Procedure….2704
        P0461 FUEL LEVEL SENSOR….2706
          P0461 FUEL LEVEL SENSOR….2706
          Description….2706
          DTC Logic….2706
            DTC DETECTION LOGIC….2706
            DTC CONFIRMATION PROCEDURE….2706
          Component Function Check….2706
          Diagnosis Procedure….2707
        P0462, P0463 FUEL LEVEL SENSOR….2708
          P0462, P0463 FUEL LEVEL SENSOR….2708
          Description….2708
          DTC Logic….2708
            DTC DETECTION LOGIC….2708
            DTC CONFIRMATION PROCEDURE….2708
          Diagnosis Procedure….2708
        P0500 VSS….2710
          P0500 VSS….2710
          Description….2710
          DTC Logic….2710
            DTC DETECTION LOGIC….2710
            DTC CONFIRMATION PROCEDURE….2710
          Diagnosis Procedure….2710
        P0506 ISC SYSTEM….2712
          P0506 ISC SYSTEM….2712
          Description….2712
          DTC Logic….2712
            DTC DETECTION LOGIC….2712
            DTC CONFIRMATION PROCEDURE….2712
          Diagnosis Procedure….2712
        P0507 ISC SYSTEM….2714
          P0507 ISC SYSTEM….2714
          Description….2714
          DTC Logic….2714
            DTC DETECTION LOGIC….2714
            DTC CONFIRMATION PROCEDURE….2714
          Diagnosis Procedure….2714
        P050A, P050E COLD START CONTROL….2716
          P050A, P050E COLD START CONTROL….2716
          Description….2716
          DTC Logic….2716
            DTC DETECTION LOGIC….2716
            DTC CONFIRMATION PROCEDURE….2716
          Diagnosis Procedure….2717
        P0524 ENGINE OIL PRESSURE….2718
          P0524 ENGINE OIL PRESSURE….2718
          DTC Logic….2718
            DTC DETECTION LOGIC….2718
            DTC CONFIRMATION PROCEDURE….2718
          Diagnosis Procedure….2719
          Component Inspection….2720
        P0550 PSP SENSOR….2721
          P0550 PSP SENSOR….2721
          Description….2721
          DTC Logic….2721
            DTC DETECTION LOGIC….2721
            DTC CONFIRMATION PROCEDURE….2721
          Diagnosis Procedure….2721
          Component Inspection….2722
        P0603 ECM POWER SUPPLY….2724
          P0603 ECM POWER SUPPLY….2724
          Description….2724
          DTC Logic….2724
            DTC DETECTION LOGIC….2724
            DTC CONFIRMATION PROCEDURE….2724
          Diagnosis Procedure….2724
        P0605 ECM….2726
          P0605 ECM….2726
          Description….2726
          DTC Logic….2726
            DTC DETECTION LOGIC….2726
            DTC CONFIRMATION PROCEDURE….2726
          Diagnosis Procedure….2727
        P0607 ECM….2728
          P0607 ECM….2728
          Description….2728
          DTC Logic….2728
            DTC DETECTION LOGIC….2728
            DTC CONFIRMATION PROCEDURE….2728
          Diagnosis Procedure….2728
        P0643 SENSOR POWER SUPPLY….2729
          P0643 SENSOR POWER SUPPLY….2729
          DTC Logic….2729
            DTC DETECTION LOGIC….2729
            DTC CONFIRMATION PROCEDURE….2729
          Diagnosis Procedure….2729
        P0850 PNP SWITCH….2732
          P0850 PNP SWITCH….2732
          Description….2732
          DTC Logic….2732
            DTC DETECTION LOGIC….2732
            DTC CONFIRMATION PROCEDURE….2732
          Component Function Check….2733
          Diagnosis Procedure….2733
        P100A, P100B VVEL SYSTEM….2735
          P100A, P100B VVEL SYSTEM….2735
          DTC Logic….2735
            DTC DETECTION LOGIC….2735
            DTC CONFIRMATION PROCEDURE….2735
          Diagnosis Procedure….2735
          Component Inspection (VVEL ACTUATOR MOTOR)….2737
          Component Inspection (VVEL ACTUATOR SUB ASSEMBLY)….2737
          Special Repair Requirement….2738
        P1087, P1088 VVEL SYSTEM….2739
          P1087, P1088 VVEL SYSTEM….2739
          DTC Logic….2739
            DTC DETECTION LOGIC….2739
        P1089, P1092 VVEL CONTROL SHAFT POSITION SENSOR….2740
          P1089, P1092 VVEL CONTROL SHAFT POSITION SENSOR….2740
          Description….2740
          DTC Logic….2740
            DTC DETECTION LOGIC….2740
            DTC CONFIRMATION PROCEDURE….2740
          Diagnosis Procedure….2740
          Special Repair Requirement….2742
        P1090, P1093 VVEL ACTUATOR MOTOR….2744
          P1090, P1093 VVEL ACTUATOR MOTOR….2744
          Description….2744
          DTC Logic….2744
            DTC DETECTION LOGIC….2744
            DTC CONFIRMATION PROCEDURE….2744
          Diagnosis Procedure….2744
          Component Inspection (VVEL ACTUATOR MOTOR)….2746
          Component Inspection (VVEL ACTUATOR SUB ASSEMBLY)….2746
          Special Repair Requirement….2747
        P1091 VVEL ACTUATOR MOTOR RELAY….2748
          P1091 VVEL ACTUATOR MOTOR RELAY….2748
          Description….2748
          DTC Logic….2748
            DTC DETECTION LOGIC….2748
            DTC CONFIRMATION PROCEDURE….2748
          Diagnosis Procedure….2748
          Component Inspection….2750
        P1148, P1168 CLOSED LOOP CONTROL….2751
          P1148, P1168 CLOSED LOOP CONTROL….2751
          DTC Logic….2751
            DTC DETECTION LOGIC….2751
        P1211 TCS CONTROL UNIT….2752
          P1211 TCS CONTROL UNIT….2752
          Description….2752
          DTC Logic….2752
            DTC DETECTION LOGIC….2752
            DTC CONFIRMATION PROCEDURE….2752
          Diagnosis Procedure….2752
        P1212 TCS COMMUNICATION LINE….2753
          P1212 TCS COMMUNICATION LINE….2753
          Description….2753
          DTC Logic….2753
            DTC DETECTION LOGIC….2753
            DTC CONFIRMATION PROCEDURE….2753
          Diagnosis Procedure….2753
        P1217 ENGINE OVER TEMPERATURE….2754
          P1217 ENGINE OVER TEMPERATURE….2754
          DTC Logic….2754
            DTC DETECTION LOGIC….2754
            DTC CONFIRMATION PROCEDURE….2754
          Component Function Check….2754
          Diagnosis Procedure….2755
        P1225, P1234 TP SENSOR….2758
          P1225, P1234 TP SENSOR….2758
          Description….2758
          DTC Logic….2758
            DTC DETECTION LOGIC….2758
            DTC CONFIRMATION PROCEDURE….2758
          Diagnosis Procedure….2758
          Special Repair Requirement….2759
        P1226, P1235 TP SENSOR….2760
          P1226, P1235 TP SENSOR….2760
          Description….2760
          DTC Logic….2760
            DTC DETECTION LOGIC….2760
            DTC CONFIRMATION PROCEDURE….2760
          Diagnosis Procedure….2760
          Special Repair Requirement….2761
        P1233, P2101 ELECTRIC THROTTLE CONTROL FUNCTION….2762
          P1233, P2101 ELECTRIC THROTTLE CONTROL FUNCTION….2762
          Description….2762
          DTC Logic….2762
            DTC DETECTION LOGIC….2762
            DTC CONFIRMATION PROCEDURE….2762
          Diagnosis Procedure….2762
          Component Inspection….2765
          Special Repair Requirement….2765
        P1236, P2118 THROTTLE CONTROL MOTOR….2766
          P1236, P2118 THROTTLE CONTROL MOTOR….2766
          Description….2766
          DTC Logic….2766
            DTC DETECTION LOGIC….2766
            DTC CONFIRMATION PROCEDURE….2766
          Diagnosis Procedure….2766
          Component Inspection….2767
          Special Repair Requirement….2768
        P1238, P2119 ELECTRIC THROTTLE CONTROL ACTUATOR….2769
          P1238, P2119 ELECTRIC THROTTLE CONTROL ACTUATOR….2769
          Description….2769
          DTC Logic….2769
            DTC DETECTION LOGIC….2769
            DTC CONFIRMATION PROCEDURE….2769
          Diagnosis Procedure….2770
          Special Repair Requirement….2770
        P1239, P2135 TP SENSOR….2771
          P1239, P2135 TP SENSOR….2771
          Description….2771
          DTC Logic….2771
            DTC DETECTION LOGIC….2771
            DTC CONFIRMATION PROCEDURE….2771
          Diagnosis Procedure….2771
          Component Inspection….2773
          Special Repair Requirement….2773
        P1290, P2100, P2103 THROTTLE CONTROL MOTOR RELAY….2774
          P1290, P2100, P2103 THROTTLE CONTROL MOTOR RELAY….2774
          Description….2774
          DTC Logic….2774
            DTC DETECTION LOGIC….2774
            DTC CONFIRMATION PROCEDURE….2774
          Diagnosis Procedure….2774
        P1550 BATTERY CURRENT SENSOR….2776
          P1550 BATTERY CURRENT SENSOR….2776
          Description….2776
          DTC Logic….2776
            DTC DETECTION LOGIC….2776
            DTC CONFIRMATION PROCEDURE….2776
          Diagnosis Procedure….2776
          Component Inspection….2778
        P1551, P1552 BATTERY CURRENT SENSOR….2779
          P1551, P1552 BATTERY CURRENT SENSOR….2779
          Description….2779
          DTC Logic….2779
            DTC DETECTION LOGIC….2779
            DTC CONFIRMATION PROCEDURE….2779
          Diagnosis Procedure….2779
          Component Inspection….2781
        P1553 BATTERY CURRENT SENSOR….2782
          P1553 BATTERY CURRENT SENSOR….2782
          Description….2782
          DTC Logic….2782
            DTC DETECTION LOGIC….2782
            DTC CONFIRMATION PROCEDURE….2782
          Diagnosis Procedure….2782
          Component Inspection….2784
        P1554 BATTERY CURRENT SENSOR….2785
          P1554 BATTERY CURRENT SENSOR….2785
          Description….2785
          DTC Logic….2785
            DTC DETECTION LOGIC….2785
            DTC CONFIRMATION PROCEDURE….2785
          Component Function Check….2785
          Diagnosis Procedure….2786
          Component Inspection….2787
        P1564 ASCD STEERING SWITCH….2789
          P1564 ASCD STEERING SWITCH….2789
          Description….2789
          DTC Logic….2789
            DTC DETECTION LOGIC….2789
            DTC CONFIRMATION PROCEDURE….2789
          Diagnosis Procedure….2789
          Component Inspection….2791
        P1564 ICC STEERING SWITCH….2792
          P1564 ICC STEERING SWITCH….2792
          Description….2792
          DTC Logic….2792
            DTC DETECTION LOGIC….2792
            DTC CONFIRMATION PROCEDURE….2792
          Diagnosis Procedure….2792
          Component Inspection….2794
        P1568 ICC FUNCTION….2795
          P1568 ICC FUNCTION….2795
          DTC Logic….2795
            DTC DETECTION LOGIC….2795
            DTC CONFIRMATION PROCEDURE….2795
          Diagnosis Procedure….2795
        P1572 ASCD BRAKE SWITCH….2796
          P1572 ASCD BRAKE SWITCH….2796
          Description….2796
          DTC Logic….2796
            DTC DETECTION LOGIC….2796
            DTC CONFIRMATION PROCEDURE….2796
          Diagnosis Procedure….2797
          Component Inspection (ASCD Brake Switch)….2800
          Component Inspection (Stop Lamp Switch)….2800
        P1572 ICC BRAKE SWITCH….2801
          P1572 ICC BRAKE SWITCH….2801
          Description….2801
          DTC Logic….2801
            DTC DETECTION LOGIC….2801
            DTC CONFIRMATION PROCEDURE….2801
          Diagnosis Procedure….2802
          Component Inspection (ICC Brake Switch)….2805
          Component Inspection (Stop Lamp Switch)….2805
          Component Inspection (ICC Brake Hold Relay)….2806
        P1574 ASCD VEHICLE SPEED SENSOR….2807
          P1574 ASCD VEHICLE SPEED SENSOR….2807
          Description….2807
          DTC Logic….2807
            DTC DETECTION LOGIC….2807
            DTC CONFIRMATION PROCEDURE….2807
          Diagnosis Procedure….2807
        P1574 ICC VEHICLE SPEED SENSOR….2809
          P1574 ICC VEHICLE SPEED SENSOR….2809
          Description….2809
          DTC Logic….2809
            DTC DETECTION LOGIC….2809
            DTC CONFIRMATION PROCEDURE….2809
          Diagnosis Procedure….2809
        P1606 VVEL CONTROL MODULE….2811
          P1606 VVEL CONTROL MODULE….2811
          Description….2811
          DTC Logic….2811
            DTC DETECTION LOGIC….2811
            DTC CONFIRMATION PROCEDURE….2811
          Diagnosis Procedure….2811
        P1607 VVEL CONTROL MODULE….2813
          P1607 VVEL CONTROL MODULE….2813
          Description….2813
          DTC Logic….2813
            DTC DETECTION LOGIC….2813
            DTC CONFIRMATION PROCEDURE….2813
          Diagnosis Procedure….2813
        P1608 VVEL SENSOR POWER SUPPLY….2815
          P1608 VVEL SENSOR POWER SUPPLY….2815
          DTC Logic….2815
            DTC DETECTION LOGIC….2815
            DTC CONFIRMATION PROCEDURE….2815
          Diagnosis Procedure….2815
          Special Repair Requirement….2816
        P1805 BRAKE SWITCH….2818
          P1805 BRAKE SWITCH….2818
          Description….2818
          DTC Logic….2818
            DTC DETECTION LOGIC….2818
            DTC CONFIRMATION PROCEDURE….2818
          Diagnosis Procedure….2818
          Component Inspection (Stop Lamp Switch)….2819
        P2096, P2097, P2098, P2099 A/F SENSOR 1….2821
          P2096, P2097, P2098, P2099 A/F SENSOR 1….2821
          Description….2821
          DTC Logic….2821
            DTC DETECTION LOGIC….2821
            DTC CONFIRMATION PROCEDURE….2821
          Diagnosis Procedure….2822
        P2122, P2123 APP SENSOR….2826
          P2122, P2123 APP SENSOR….2826
          Description….2826
          DTC Logic….2826
            DTC DETECTION LOGIC….2826
            DTC CONFIRMATION PROCEDURE….2826
          Diagnosis Procedure….2826
          Component Inspection….2828
          Special Repair Requirement….2829
        P2127, P2128 APP SENSOR….2830
          P2127, P2128 APP SENSOR….2830
          Description….2830
          DTC Logic….2830
            DTC DETECTION LOGIC….2830
            DTC CONFIRMATION PROCEDURE….2830
          Diagnosis Procedure….2830
          Component Inspection….2833
          Special Repair Requirement….2833
        P2138 APP SENSOR….2835
          P2138 APP SENSOR….2835
          Description….2835
          DTC Logic….2835
            DTC DETECTION LOGIC….2835
            DTC CONFIRMATION PROCEDURE….2835
          Diagnosis Procedure….2836
          Component Inspection….2839
          Special Repair Requirement….2839
        ASCD BRAKE SWITCH….2840
          ASCD BRAKE SWITCH….2840
          Description….2840
          Component Function Check….2840
          Diagnosis Procedure….2840
          Component Inspection (ASCD Brake Switch)….2841
        ASCD INDICATOR….2843
          ASCD INDICATOR….2843
          Description….2843
          Component Function Check….2843
          Diagnosis Procedure….2843
        COOLING FAN….2844
          COOLING FAN….2844
          Description….2844
            COOLING FAN CONTROL MODULE….2844
            COOLING FAN MOTOR….2844
          Component Function Check….2844
          Diagnosis Procedure….2844
          Component Inspection (Cooling Fan Motor)….2847
          Component Inspection (Cooling Fan Relay-1)….2847
        ELECTRICAL LOAD SIGNAL….2848
          ELECTRICAL LOAD SIGNAL….2848
          Description….2848
          Component Function Check….2848
          Diagnosis Procedure….2848
        FUEL INJECTOR….2850
          FUEL INJECTOR….2850
          Description….2850
          Component Function Check….2850
          Diagnosis Procedure….2850
          Component Inspection….2852
        FUEL PUMP….2853
          FUEL PUMP….2853
          Description….2853
          Component Function Check….2853
          Diagnosis Procedure….2853
          Component Inspection….2855
        ICC BRAKE SWITCH….2856
          ICC BRAKE SWITCH….2856
          Description….2856
          Component Function Check….2856
          Diagnosis Procedure….2856
          Component Inspection (ICC Brake Switch)….2857
        IGNITION SIGNAL….2859
          IGNITION SIGNAL….2859
          Description….2859
          Component Function Check….2859
          Diagnosis Procedure….2859
          Component Inspection (Ignition Coil with Power Transistor)….2862
          Component Inspection (Condenser)….2863
        MALFUNCTION INDICATOR LAMP….2864
          MALFUNCTION INDICATOR LAMP….2864
          Description….2864
          Component Function Check….2864
          Diagnosis Procedure….2864
        ON BOARD REFUELING VAPOR RECOVERY (ORVR)….2865
          ON BOARD REFUELING VAPOR RECOVERY (ORVR)….2865
          Description….2865
          Component Function Check….2865
          Diagnosis Procedure….2865
          Component Inspection….2868
        POSITIVE CRANKCASE VENTILATION….2870
          POSITIVE CRANKCASE VENTILATION….2870
          Description….2870
          Component Inspection….2870
        REFRIGERANT PRESSURE SENSOR….2872
          REFRIGERANT PRESSURE SENSOR….2872
          Description….2872
          Component Function Check….2872
          Diagnosis Procedure….2872
        SNOW MODE SWITCH….2874
          SNOW MODE SWITCH….2874
          Description….2874
          Component Function Check….2874
          Diagnosis Procedure….2874
          Component Inspection….2876
      ECU DIAGNOSIS INFORMATION….2877
        ECM….2877
          ECM….2877
          Reference Value….2877
            VALUES ON THE DIAGNOSIS TOOL….2877
            TERMINAL LAYOUT….2882
            PHYSICAL VALUES….2882
          Wiring Diagram – ENGINE CONTROL SYSTEM -….2894
          Fail safe….2916
            NON DTC RELATED ITEM….2916
            DTC RELATED ITEM….2917
          DTC Inspection Priority Chart….2918
          DTC Index….2920
          Test Value and Test Limit….2925
        VVEL CONTROL MODULE….2934
          VVEL CONTROL MODULE….2934
          Reference Value….2934
            TERMINAL LAYOUT….2934
            PHYSICAL VALUES….2934
          Wiring Diagram – ENGINE CONTROL SYSTEM -….2938
      SYMPTOM DIAGNOSIS….2961
        ENGINE CONTROL SYSTEM SYMPTOMS….2961
          ENGINE CONTROL SYSTEM SYMPTOMS….2961
          Symptom Table….2961
            SYSTEM – BASIC ENGINE CONTROL SYSTEM….2961
            SYSTEM – ENGINE MECHANICAL & OTHER….2962
        NORMAL OPERATING CONDITION….2965
          NORMAL OPERATING CONDITION….2965
          Description….2965
            FUEL CUT CONTROL (AT NO LOAD AND HIGH ENGINE SPEED)….2965
            TORQUE CUT CONTROL (AT HIGH ENGINE OIL TEMPERATURE)….2965
      PRECAUTION….2966
        PRECAUTIONS….2966
          PRECAUTIONS….2966
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….2966
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….2966
          Precaution for Procedure without Cowl Top Cover….2966
          Precautions For Xenon Headlamp Service….2966
          Precautions for Removing Battery Terminal….2967
          On Board Diagnostic (OBD) System of Engine and A/T….2967
          General Precautions….2968
      PREPARATION….2971
        PREPARATION….2971
          PREPARATION….2971
          Special Service Tools….2971
          Commercial Service Tools….2971
      PERIODIC MAINTENANCE….2973
        FUEL PRESSURE….2973
          FUEL PRESSURE….2973
          Inspection….2973
            FUEL PRESSURE RELEASE….2973
              <GRAPHIC> With CONSULT….2973
              <GRAPHIC> Without CONSULT….2973
            FUEL PRESSURE CHECK….2973
        EVAP LEAK CHECK….2974
          EVAP LEAK CHECK….2974
          Inspection….2974
            <GRAPHIC> WITH CONSULT….2974
            <GRAPHIC> WITHOUT CONSULT….2974
      SERVICE DATA AND SPECIFICATIONS (SDS)….2976
        SERVICE DATA AND SPECIFICATIONS (SDS)….2976
          SERVICE DATA AND SPECIFICATIONS (SDS)….2976
          Idle Speed….2976
          Ignition Timing….2976
          Calculated Load Value….2976
          Mass Air Flow Sensor….2976
    VQ37VHR FOR MEXICO….2977
      VQ37VHR FOR MEXICO….2977
      BASIC INSPECTION….2977
        DIAGNOSIS AND REPAIR WORKFLOW….2977
          DIAGNOSIS AND REPAIR WORKFLOW….2977
          Work Flow….2977
            OVERALL SEQUENCE….2977
            DETAILED FLOW….2978
          Diagnostic Work Sheet….2980
            DESCRIPTION….2980
            WORKSHEET SAMPLE….2981
        INSPECTION AND ADJUSTMENT….2982
          INSPECTION AND ADJUSTMENT….2982
          BASIC INSPECTION….2982
            BASIC INSPECTION : Special Repair Requirement….2982
          ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (ECM)….2985
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (ECM) : Description….2985
              PROGRAMMING OPERATION….2985
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (ECM) : Special Repair Requirement….2985
          ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (VVEL CONTROL MODULE)….2987
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (VVEL CONTROL MODULE) : Description….2987
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (VVEL CONTROL MODULE) : Special Repair Requirement….2987
          IDLE SPEED….2987
            IDLE SPEED : Description….2987
            IDLE SPEED : Special Repair Requirement….2987
          IGNITION TIMING….2987
            IGNITION TIMING : Description….2987
            IGNITION TIMING : Special Repair Requirement….2987
          VIN REGISTRATION….2988
            VIN REGISTRATION : Description….2988
            VIN REGISTRATION : Special Repair Requirement….2988
          ACCELERATOR PEDAL RELEASED POSITION LEARNING….2988
            ACCELERATOR PEDAL RELEASED POSITION LEARNING : Description….2988
            ACCELERATOR PEDAL RELEASED POSITION LEARNING : Special Repair Requirement….2988
          THROTTLE VALVE CLOSED POSITION LEARNING….2989
            THROTTLE VALVE CLOSED POSITION LEARNING : Description….2989
            THROTTLE VALVE CLOSED POSITION LEARNING : Special Repair Requirement….2989
          IDLE AIR VOLUME LEARNING….2989
            IDLE AIR VOLUME LEARNING : Description….2989
            IDLE AIR VOLUME LEARNING : Special Repair Requirement….2989
          VVEL CONTROL SHAFT POSITION SENSOR ADJUSTMENT….2991
            VVEL CONTROL SHAFT POSITION SENSOR ADJUSTMENT : Description….2991
            VVEL CONTROL SHAFT POSITION SENSOR ADJUSTMENT : Special Repair Requirement….2991
          MIXTURE RATIO SELF-LEARNING VALUE CLEAR….2993
            MIXTURE RATIO SELF-LEARNING VALUE CLEAR : Description….2993
            MIXTURE RATIO SELF-LEARNING VALUE CLEAR : Special Repair Requirement….2993
        HOW TO SET SRT CODE….2994
          HOW TO SET SRT CODE….2994
          Description….2994
            OUTLINE….2994
            SRT ITEM….2994
            SRT SERVICE PROCEDURE….2994
          SRT Set Driving Pattern….2996
          Work Procedure….2997
      SYSTEM DESCRIPTION….2999
        ENGINE CONTROL SYSTEM….2999
          ENGINE CONTROL SYSTEM….2999
          System Diagram….2999
          System Description….3000
          Component Parts Location….3000
          Component Description….3007
        MULTIPORT FUEL INJECTION SYSTEM….3008
          MULTIPORT FUEL INJECTION SYSTEM….3008
          System Diagram….3008
          System Description….3008
            INPUT/OUTPUT SIGNAL CHART….3008
            SYSTEM DESCRIPTION….3009
            VARIOUS FUEL INJECTION INCREASE/DECREASE COMPENSATION….3009
            MIXTURE RATIO FEEDBACK CONTROL (CLOSED LOOP CONTROL)….3009
            MIXTURE RATIO SELF-LEARNING CONTROL….3009
            FUEL INJECTION TIMING….3010
            FUEL SHUT-OFF….3010
          Component Parts Location….3011
          Component Description….3018
        ELECTRIC IGNITION SYSTEM….3019
          ELECTRIC IGNITION SYSTEM….3019
          System Diagram….3019
          System Description….3019
            INPUT/OUTPUT SIGNAL CHART….3019
            SYSTEM DESCRIPTION….3019
          Component Parts Location….3020
          Component Description….3027
        AIR CONDITIONING CUT CONTROL….3028
          AIR CONDITIONING CUT CONTROL….3028
          System Diagram….3028
          System Description….3028
            INPUT/OUTPUT SIGNAL CHART….3028
            SYSTEM DESCRIPTION….3028
          Component Parts Location….3029
          Component Description….3036
        AUTOMATIC SPEED CONTROL DEVICE (ASCD)….3037
          AUTOMATIC SPEED CONTROL DEVICE (ASCD)….3037
          System Diagram….3037
          System Description….3037
            INPUT/OUTPUT SIGNAL CHART….3037
            BASIC ASCD SYSTEM….3037
            SET OPERATION….3037
            ACCELERATE OPERATION….3037
            CANCEL OPERATION….3037
            COAST OPERATION….3038
            RESUME OPERATION….3038
          Component Parts Location….3039
          Component Description….3046
        CAN COMMUNICATION….3047
          CAN COMMUNICATION….3047
          System Description….3047
        COOLING FAN CONTROL….3048
          COOLING FAN CONTROL….3048
          System Diagram….3048
          System Description….3048
            INPUT/OUTPUT SIGNAL CHART….3048
            SYSTEM DESCRIPTION….3048
          Component Parts Location….3049
          Component Description….3056
        EVAPORATIVE EMISSION SYSTEM….3057
          EVAPORATIVE EMISSION SYSTEM….3057
          System Diagram….3057
          System Description….3057
            INPUT/OUTPUT SIGNAL CHART….3057
            SYSTEM DESCRIPTION….3058
          Component Parts Location….3059
          Component Description….3066
        INTAKE VALVE TIMING CONTROL….3067
          INTAKE VALVE TIMING CONTROL….3067
          System Diagram….3067
          System Description….3067
            INPUT/OUTPUT SIGNAL CHART….3067
            SYSTEM DESCRIPTION….3067
          Component Parts Location….3068
          Component Description….3075
        VVEL SYSTEM….3076
          VVEL SYSTEM….3076
          System Diagram….3076
          System Description….3076
            INPUT/OUTPUT SIGNAL CHART….3076
            SYSTEM DESCRIPTION….3076
          Component Parts Location….3077
          Component Description….3084
        ON BOARD DIAGNOSTIC (OBD) SYSTEM….3085
          ON BOARD DIAGNOSTIC (OBD) SYSTEM….3085
          Diagnosis Description….3085
          GST (Generic Scan Tool)….3085
        DIAGNOSIS SYSTEM (ECM)….3086
          DIAGNOSIS SYSTEM (ECM)….3086
          DIAGNOSIS DESCRIPTION….3086
            DIAGNOSIS DESCRIPTION : 1st Trip Detection Logic and Two Trip Detection Logic….3086
            DIAGNOSIS DESCRIPTION : DTC and Freeze Frame Data….3086
              DTC AND 1ST TRIP DTC….3086
              FREEZE FRAME DATA AND 1ST TRIP FREEZE FRAME DATA….3086
            DIAGNOSIS DESCRIPTION : Counter System….3087
              RELATIONSHIP BETWEEN MIL, 1ST TRIP DTC, DTC, AND DETECTABLE ITEMS….3087
              COUNTER SYSTEM CHART….3087
              Relationship Between MIL, DTC, 1st Trip DTC and Driving Patterns for “Misfire <Exhaust Quality Deterioration>”, “Fuel Injection System”….3087
              Explanation for Driving Patterns for “Misfire <Exhaust Quality Deterioration>”, “Fuel Injection System”….3088
                Driving Pattern B….3088
                Driving Pattern C….3089
              Relationship Between MIL, DTC, 1st Trip DTC and Driving Patterns Except For “Misfire <Exhaust Quality Deterioration>”, “Fuel Injection System”….3089
              Explanation for Driving Patterns Except for “Misfire <Exhaust Quality Deterioration>”, “Fuel Injection System”….3090
                Driving Pattern A….3090
                Driving Pattern B….3090
            DIAGNOSIS DESCRIPTION : Driving Pattern….3090
              DRIVING PATTERN A….3090
              DRIVING PATTERN B….3090
              DRIVING PATTERN C….3090
            DIAGNOSIS DESCRIPTION : System Readiness Test (SRT) Code….3091
              SRT SET TIMING….3091
            DIAGNOSIS DESCRIPTION : Malfunction Indicator Lamp (MIL)….3092
          On Board Diagnosis Function….3092
            ON BOARD DIAGNOSIS ITEM….3092
            BULB CHECK MODE….3093
              Description….3093
              Operation Procedure….3093
            SRT STATUS MODE….3093
              Description….3093
              Operation Procedure….3093
            MALFUNCTION WARNING MODE….3093
              Description….3093
              Operation Procedure….3093
            SELF-DIAGNOSTIC RESULTS MODE….3094
              Description….3094
              How to Set Self-diagnostic Results Mode….3094
              How to Read Self-diagnostic Results….3094
              How to Erase Self-diagnostic Results….3095
          CONSULT Function….3096
            FUNCTION….3096
            SELF DIAGNOSTIC RESULT MODE….3096
              Self Diagnostic Item….3096
              How to Read DTC and 1st Trip DTC….3096
              How to Erase DTC and 1st Trip DTC….3096
              Freeze Frame Data and 1st Trip Freeze Frame Data….3096
            DATA MONITOR MODE….3097
              Monitored Item….3097
            WORK SUPPORT MODE….3101
              Work Item….3101
            ACTIVE TEST MODE….3102
              Test Item….3102
            DTC WORK SUPPORT MODE….3103
              Test Item….3103
            SRT & P-DTC MODE….3103
              SRT STATUS Mode….3103
              SRT WORK SUPPORT Mode….3103
      DTC/CIRCUIT DIAGNOSIS….3104
        TROUBLE DIAGNOSIS – SPECIFICATION VALUE….3104
          TROUBLE DIAGNOSIS – SPECIFICATION VALUE….3104
          Description….3104
          Component Function Check….3104
          Diagnosis Procedure….3105
            OVERALL SEQUENCE….3105
            DETAILED PROCEDURE….3106
        POWER SUPPLY AND GROUND CIRCUIT….3112
          POWER SUPPLY AND GROUND CIRCUIT….3112
          Diagnosis Procedure….3112
        POWER SUPPLY AND GROUND CIRCUIT (VVEL CONTROL MODULE)….3115
          POWER SUPPLY AND GROUND CIRCUIT (VVEL CONTROL MODULE)….3115
          Diagnosis Procedure….3115
        U0101 CAN COMM CIRCUIT….3117
          U0101 CAN COMM CIRCUIT….3117
          Description….3117
          DTC Logic….3117
            DTC DETECTION LOGIC….3117
            DTC CONFIRMATION PROCEDURE….3117
          Diagnosis Procedure….3117
        U0164 CAN COMM CIRCUIT….3118
          U0164 CAN COMM CIRCUIT….3118
          Description….3118
          DTC Logic….3118
            DTC DETECTION LOGIC….3118
            DTC CONFIRMATION PROCEDURE….3118
          Diagnosis Procedure….3118
        U1001 CAN COMM CIRCUIT….3119
          U1001 CAN COMM CIRCUIT….3119
          Description….3119
          DTC Logic….3119
            DTC DETECTION LOGIC….3119
            DTC CONFIRMATION PROCEDURE….3119
          Diagnosis Procedure….3119
        U1003 CAN COMM CIRCUIT….3120
          U1003 CAN COMM CIRCUIT….3120
          Description….3120
          DTC Logic….3120
            DTC DETECTION LOGIC….3120
            DTC CONFIRMATION PROCEDURE….3120
          Diagnosis Procedure….3120
        U1024 CAN COMM CIRCUIT….3122
          U1024 CAN COMM CIRCUIT….3122
          Description….3122
          DTC Logic….3122
            DTC DETECTION LOGIC….3122
            DTC CONFIRMATION PROCEDURE….3122
          Diagnosis Procedure….3122
        P0011, P0021 IVT CONTROL….3124
          P0011, P0021 IVT CONTROL….3124
          DTC Logic….3124
            DTC DETECTION LOGIC….3124
            DTC CONFIRMATION PROCEDURE….3124
          Diagnosis Procedure….3125
          Component Inspection….3126
        P0031, P0032, P0051, P0052 A/F SENSOR 1 HEATER….3128
          P0031, P0032, P0051, P0052 A/F SENSOR 1 HEATER….3128
          Description….3128
            SYSTEM DESCRIPTION….3128
          DTC Logic….3128
            DTC DETECTION LOGIC….3128
            DTC CONFIRMATION PROCEDURE….3128
          Diagnosis Procedure….3129
          Component Inspection….3130
        P0037, P0038, P0057, P0058 HO2S2 HEATER….3131
          P0037, P0038, P0057, P0058 HO2S2 HEATER….3131
          Description….3131
            SYSTEM DESCRIPTION….3131
            OPERATION….3131
          DTC Logic….3131
            DTC DETECTION LOGIC….3131
            DTC CONFIRMATION PROCEDURE….3131
          Diagnosis Procedure….3132
          Component Inspection….3133
        P0075, P0081 IVT CONTROL SOLENOID VALVE….3134
          P0075, P0081 IVT CONTROL SOLENOID VALVE….3134
          Description….3134
          DTC Logic….3134
            DTC DETECTION LOGIC….3134
            DTC CONFIRMATION PROCEDURE….3134
          Diagnosis Procedure….3134
          Component Inspection….3135
        P0102, P0103, P010C, P010D MAF SENSOR….3137
          P0102, P0103, P010C, P010D MAF SENSOR….3137
          Description….3137
          DTC Logic….3137
            DTC DETECTION LOGIC….3137
            DTC CONFIRMATION PROCEDURE….3137
          Diagnosis Procedure….3138
          Component Inspection….3139
        P010A MANIFOLD ABSOLUTE PRESSURE SENSOR….3142
          P010A MANIFOLD ABSOLUTE PRESSURE SENSOR….3142
          Description….3142
          DTC Logic….3142
            DTC DETECTION LOGIC….3142
            DTC CONFIRMATION PROCEDURE….3142
          Diagnosis Procedure….3142
          Component Inspection….3143
        P0112, P0113 IAT SENSOR….3146
          P0112, P0113 IAT SENSOR….3146
          Description….3146
          DTC Logic….3146
            DTC DETECTION LOGIC….3146
            DTC CONFIRMATION PROCEDURE….3146
          Diagnosis Procedure….3147
          Component Inspection….3147
        P0117, P0118 ECT SENSOR….3149
          P0117, P0118 ECT SENSOR….3149
          Description….3149
          DTC Logic….3149
            DTC DETECTION LOGIC….3149
            DTC CONFIRMATION PROCEDURE….3149
          Diagnosis Procedure….3150
          Component Inspection….3151
        P0122, P0123, P0227, P0228 TP SENSOR….3152
          P0122, P0123, P0227, P0228 TP SENSOR….3152
          Description….3152
          DTC Logic….3152
            DTC DETECTION LOGIC….3152
            DTC CONFIRMATION PROCEDURE….3152
          Diagnosis Procedure….3153
          Component Inspection….3154
          Special Repair Requirement….3154
        P0130, P0150 A/F SENSOR 1….3156
          P0130, P0150 A/F SENSOR 1….3156
          Description….3156
          DTC Logic….3156
            DTC DETECTION LOGIC….3156
            DTC CONFIRMATION PROCEDURE….3156
          Component Function Check….3158
          Diagnosis Procedure….3158
        P0131, P0151 A/F SENSOR 1….3160
          P0131, P0151 A/F SENSOR 1….3160
          Description….3160
          DTC Logic….3160
            DTC DETECTION LOGIC….3160
            DTC CONFIRMATION PROCEDURE….3160
          Diagnosis Procedure….3161
        P0132, P0152 A/F SENSOR 1….3163
          P0132, P0152 A/F SENSOR 1….3163
          Description….3163
          DTC Logic….3163
            DTC DETECTION LOGIC….3163
            DTC CONFIRMATION PROCEDURE….3163
          Diagnosis Procedure….3164
        P0133, P0153 A/F SENSOR 1….3166
          P0133, P0153 A/F SENSOR 1….3166
          Description….3166
          DTC Logic….3166
            DTC DETECTION LOGIC….3166
            DTC CONFIRMATION PROCEDURE….3166
          Diagnosis Procedure….3168
        P0137, P0157 HO2S2….3171
          P0137, P0157 HO2S2….3171
          Description….3171
          DTC Logic….3171
            DTC DETECTION LOGIC….3171
            DTC CONFIRMATION PROCEDURE….3171
          Component Function Check….3172
          Diagnosis Procedure….3173
          Component Inspection….3175
        P0138, P0158 HO2S2….3177
          P0138, P0158 HO2S2….3177
          Description….3177
          DTC Logic….3177
            DTC DETECTION LOGIC….3177
            DTC CONFIRMATION PROCEDURE….3178
          Component Function Check….3179
          Diagnosis Procedure….3180
          Component Inspection….3183
        P0139, P0159 HO2S2….3186
          P0139, P0159 HO2S2….3186
          Description….3186
          DTC Logic….3186
            DTC DETECTION LOGIC….3186
            DTC CONFIRMATION PROCEDURE….3186
          Component Function Check….3188
          Diagnosis Procedure….3189
          Component Inspection….3190
        P0171, P0174 FUEL INJECTION SYSTEM FUNCTION….3193
          P0171, P0174 FUEL INJECTION SYSTEM FUNCTION….3193
          DTC Logic….3193
            DTC DETECTION LOGIC….3193
            DTC CONFIRMATION PROCEDURE….3193
          Diagnosis Procedure….3194
        P0172, P0175 FUEL INJECTION SYSTEM FUNCTION….3197
          P0172, P0175 FUEL INJECTION SYSTEM FUNCTION….3197
          DTC Logic….3197
            DTC DETECTION LOGIC….3197
            DTC CONFIRMATION PROCEDURE….3197
          Diagnosis Procedure….3198
        P0182, P0183 FTT SENSOR….3201
          P0182, P0183 FTT SENSOR….3201
          Description….3201
          DTC Logic….3201
            DTC DETECTION LOGIC….3201
            DTC CONFIRMATION PROCEDURE….3201
          Diagnosis Procedure….3201
          Component Inspection….3203
        P0196 EOT SENSOR….3204
          P0196 EOT SENSOR….3204
          Description….3204
          DTC Logic….3204
            DTC DETECTION LOGIC….3204
            DTC CONFIRMATION PROCEDURE….3204
          Component Function Check….3206
          Diagnosis Procedure….3207
          Component Inspection….3207
        P0197, P0198 EOT SENSOR….3208
          P0197, P0198 EOT SENSOR….3208
          Description….3208
          DTC Logic….3208
            DTC DETECTION LOGIC….3208
            DTC CONFIRMATION PROCEDURE….3208
          Diagnosis Procedure….3209
          Component Inspection….3209
        P0222, P0223, P2132, P2133 TP SENSOR….3211
          P0222, P0223, P2132, P2133 TP SENSOR….3211
          Description….3211
          DTC Logic….3211
            DTC DETECTION LOGIC….3211
            DTC CONFIRMATION PROCEDURE….3211
          Diagnosis Procedure….3211
          Component Inspection….3213
          Special Repair Requirement….3213
        P0300, P0301, P0302, P0303, P0304, P0305, P0306 MISFIRE….3214
          P0300, P0301, P0302, P0303, P0304, P0305, P0306 MISFIRE….3214
          DTC Logic….3214
            DTC DETECTION LOGIC….3214
            DTC CONFIRMATION PROCEDURE….3214
          Diagnosis Procedure….3215
        P0327, P0328, P0332, P0333 KS….3220
          P0327, P0328, P0332, P0333 KS….3220
          Description….3220
          DTC Logic….3220
            DTC DETECTION LOGIC….3220
            DTC CONFIRMATION PROCEDURE….3220
          Diagnosis Procedure….3220
          Component Inspection….3221
        P0335 CKP SENSOR (POS)….3223
          P0335 CKP SENSOR (POS)….3223
          Description….3223
          DTC Logic….3223
            DTC DETECTION LOGIC….3223
            DTC CONFIRMATION PROCEDURE….3223
          Diagnosis Procedure….3224
          Component Inspection….3226
        P0340, P0345 CMP SENSOR (PHASE)….3227
          P0340, P0345 CMP SENSOR (PHASE)….3227
          Description….3227
          DTC Logic….3227
            DTC DETECTION LOGIC….3227
            DTC CONFIRMATION PROCEDURE….3227
          Diagnosis Procedure….3228
          Component Inspection….3230
        P0420, P0430 THREE WAY CATALYST FUNCTION….3231
          P0420, P0430 THREE WAY CATALYST FUNCTION….3231
          DTC Logic….3231
            DTC DETECTION LOGIC….3231
            DTC CONFIRMATION PROCEDURE….3231
          Component Function Check….3232
          Diagnosis Procedure….3233
        P0444, P0445 EVAP CANISTER PURGE VOLUME CONTROL SOLENOID VALVE….3236
          P0444, P0445 EVAP CANISTER PURGE VOLUME CONTROL SOLENOID VALVE….3236
          Description….3236
          DTC Logic….3236
            DTC DETECTION LOGIC….3236
            DTC CONFIRMATION PROCEDURE….3236
          Diagnosis Procedure….3236
          Component Inspection….3238
        P0500 VSS….3239
          P0500 VSS….3239
          Description….3239
          DTC Logic….3239
            DTC DETECTION LOGIC….3239
            DTC CONFIRMATION PROCEDURE….3239
          Diagnosis Procedure….3239
        P0524 ENGINE OIL PRESSURE….3241
          P0524 ENGINE OIL PRESSURE….3241
          DTC Logic….3241
            DTC DETECTION LOGIC….3241
            DTC CONFIRMATION PROCEDURE….3241
          Diagnosis Procedure….3242
          Component Inspection….3243
        P0550 PSP SENSOR….3244
          P0550 PSP SENSOR….3244
          Description….3244
          DTC Logic….3244
            DTC DETECTION LOGIC….3244
            DTC CONFIRMATION PROCEDURE….3244
          Diagnosis Procedure….3244
          Component Inspection….3245
        P0603 ECM POWER SUPPLY….3247
          P0603 ECM POWER SUPPLY….3247
          Description….3247
          DTC Logic….3247
            DTC DETECTION LOGIC….3247
            DTC CONFIRMATION PROCEDURE….3247
          Diagnosis Procedure….3247
        P0605 ECM….3249
          P0605 ECM….3249
          Description….3249
          DTC Logic….3249
            DTC DETECTION LOGIC….3249
            DTC CONFIRMATION PROCEDURE….3249
          Diagnosis Procedure….3250
        P0607 ECM….3251
          P0607 ECM….3251
          Description….3251
          DTC Logic….3251
            DTC DETECTION LOGIC….3251
            DTC CONFIRMATION PROCEDURE….3251
          Diagnosis Procedure….3251
        P0643 SENSOR POWER SUPPLY….3252
          P0643 SENSOR POWER SUPPLY….3252
          DTC Logic….3252
            DTC DETECTION LOGIC….3252
            DTC CONFIRMATION PROCEDURE….3252
          Diagnosis Procedure….3252
        P0850 PNP SWITCH….3255
          P0850 PNP SWITCH….3255
          Description….3255
          DTC Logic….3255
            DTC DETECTION LOGIC….3255
            DTC CONFIRMATION PROCEDURE….3255
          Component Function Check….3256
          Diagnosis Procedure….3256
        P100A, P100B VVEL SYSTEM….3258
          P100A, P100B VVEL SYSTEM….3258
          DTC Logic….3258
            DTC DETECTION LOGIC….3258
            DTC CONFIRMATION PROCEDURE….3258
          Diagnosis Procedure….3258
          Component Inspection (VVEL ACTUATOR MOTOR)….3260
          Component Inspection (VVEL ACTUATOR SUB ASSEMBLY)….3260
          Special Repair Requirement….3261
        P1087, P1088 VVEL SYSTEM….3262
          P1087, P1088 VVEL SYSTEM….3262
          DTC Logic….3262
            DTC DETECTION LOGIC….3262
        P1089, P1092 VVEL CONTROL SHAFT POSITION SENSOR….3263
          P1089, P1092 VVEL CONTROL SHAFT POSITION SENSOR….3263
          Description….3263
          DTC Logic….3263
            DTC DETECTION LOGIC….3263
            DTC CONFIRMATION PROCEDURE….3263
          Diagnosis Procedure….3263
          Special Repair Requirement….3265
        P1090, P1093 VVEL ACTUATOR MOTOR….3267
          P1090, P1093 VVEL ACTUATOR MOTOR….3267
          Description….3267
          DTC Logic….3267
            DTC DETECTION LOGIC….3267
            DTC CONFIRMATION PROCEDURE….3267
          Diagnosis Procedure….3267
          Component Inspection (VVEL ACTUATOR MOTOR)….3269
          Component Inspection (VVEL ACTUATOR SUB ASSEMBLY)….3269
          Special Repair Requirement….3270
        P1091 VVEL ACTUATOR MOTOR RELAY….3271
          P1091 VVEL ACTUATOR MOTOR RELAY….3271
          Description….3271
          DTC Logic….3271
            DTC DETECTION LOGIC….3271
            DTC CONFIRMATION PROCEDURE….3271
          Diagnosis Procedure….3271
          Component Inspection….3273
        P1211 TCS CONTROL UNIT….3274
          P1211 TCS CONTROL UNIT….3274
          Description….3274
          DTC Logic….3274
            DTC DETECTION LOGIC….3274
            DTC CONFIRMATION PROCEDURE….3274
          Diagnosis Procedure….3274
        P1212 TCS COMMUNICATION LINE….3275
          P1212 TCS COMMUNICATION LINE….3275
          Description….3275
          DTC Logic….3275
            DTC DETECTION LOGIC….3275
            DTC CONFIRMATION PROCEDURE….3275
          Diagnosis Procedure….3275
        P1217 ENGINE OVER TEMPERATURE….3276
          P1217 ENGINE OVER TEMPERATURE….3276
          DTC Logic….3276
            DTC DETECTION LOGIC….3276
            DTC CONFIRMATION PROCEDURE….3276
          Component Function Check….3276
          Diagnosis Procedure….3277
        P1225, P1234 TP SENSOR….3280
          P1225, P1234 TP SENSOR….3280
          Description….3280
          DTC Logic….3280
            DTC DETECTION LOGIC….3280
            DTC CONFIRMATION PROCEDURE….3280
          Diagnosis Procedure….3280
          Special Repair Requirement….3281
        P1226, P1235 TP SENSOR….3282
          P1226, P1235 TP SENSOR….3282
          Description….3282
          DTC Logic….3282
            DTC DETECTION LOGIC….3282
            DTC CONFIRMATION PROCEDURE….3282
          Diagnosis Procedure….3282
          Special Repair Requirement….3283
        P1233, P2101 ELECTRIC THROTTLE CONTROL FUNCTION….3284
          P1233, P2101 ELECTRIC THROTTLE CONTROL FUNCTION….3284
          Description….3284
          DTC Logic….3284
            DTC DETECTION LOGIC….3284
            DTC CONFIRMATION PROCEDURE….3284
          Diagnosis Procedure….3284
          Component Inspection….3287
          Special Repair Requirement….3287
        P1236, P2118 THROTTLE CONTROL MOTOR….3288
          P1236, P2118 THROTTLE CONTROL MOTOR….3288
          Description….3288
          DTC Logic….3288
            DTC DETECTION LOGIC….3288
            DTC CONFIRMATION PROCEDURE….3288
          Diagnosis Procedure….3288
          Component Inspection….3289
          Special Repair Requirement….3290
        P1238, P2119 ELECTRIC THROTTLE CONTROL ACTUATOR….3291
          P1238, P2119 ELECTRIC THROTTLE CONTROL ACTUATOR….3291
          Description….3291
          DTC Logic….3291
            DTC DETECTION LOGIC….3291
            DTC CONFIRMATION PROCEDURE….3291
          Diagnosis Procedure….3292
          Special Repair Requirement….3292
        P1239, P2135 TP SENSOR….3293
          P1239, P2135 TP SENSOR….3293
          Description….3293
          DTC Logic….3293
            DTC DETECTION LOGIC….3293
            DTC CONFIRMATION PROCEDURE….3293
          Diagnosis Procedure….3293
          Component Inspection….3295
          Special Repair Requirement….3295
        P1290, P2100, P2103 THROTTLE CONTROL MOTOR RELAY….3296
          P1290, P2100, P2103 THROTTLE CONTROL MOTOR RELAY….3296
          Description….3296
          DTC Logic….3296
            DTC DETECTION LOGIC….3296
            DTC CONFIRMATION PROCEDURE….3296
          Diagnosis Procedure….3296
        P1550 BATTERY CURRENT SENSOR….3298
          P1550 BATTERY CURRENT SENSOR….3298
          Description….3298
          DTC Logic….3298
            DTC DETECTION LOGIC….3298
            DTC CONFIRMATION PROCEDURE….3298
          Diagnosis Procedure….3298
          Component Inspection….3300
        P1551, P1552 BATTERY CURRENT SENSOR….3301
          P1551, P1552 BATTERY CURRENT SENSOR….3301
          Description….3301
          DTC Logic….3301
            DTC DETECTION LOGIC….3301
            DTC CONFIRMATION PROCEDURE….3301
          Diagnosis Procedure….3301
          Component Inspection….3303
        P1553 BATTERY CURRENT SENSOR….3304
          P1553 BATTERY CURRENT SENSOR….3304
          Description….3304
          DTC Logic….3304
            DTC DETECTION LOGIC….3304
            DTC CONFIRMATION PROCEDURE….3304
          Diagnosis Procedure….3304
          Component Inspection….3306
        P1554 BATTERY CURRENT SENSOR….3307
          P1554 BATTERY CURRENT SENSOR….3307
          Description….3307
          DTC Logic….3307
            DTC DETECTION LOGIC….3307
            DTC CONFIRMATION PROCEDURE….3307
          Component Function Check….3307
          Diagnosis Procedure….3308
          Component Inspection….3309
        P1564 ASCD STEERING SWITCH….3311
          P1564 ASCD STEERING SWITCH….3311
          Description….3311
          DTC Logic….3311
            DTC DETECTION LOGIC….3311
            DTC CONFIRMATION PROCEDURE….3311
          Diagnosis Procedure….3311
          Component Inspection….3313
        P1572 ASCD BRAKE SWITCH….3314
          P1572 ASCD BRAKE SWITCH….3314
          Description….3314
          DTC Logic….3314
            DTC DETECTION LOGIC….3314
            DTC CONFIRMATION PROCEDURE….3314
          Diagnosis Procedure….3315
          Component Inspection (ASCD Brake Switch)….3318
          Component Inspection (Stop Lamp Switch)….3318
        P1574 ASCD VEHICLE SPEED SENSOR….3319
          P1574 ASCD VEHICLE SPEED SENSOR….3319
          Description….3319
          DTC Logic….3319
            DTC DETECTION LOGIC….3319
            DTC CONFIRMATION PROCEDURE….3319
          Diagnosis Procedure….3319
        P1606 VVEL CONTROL MODULE….3321
          P1606 VVEL CONTROL MODULE….3321
          Description….3321
          DTC Logic….3321
            DTC DETECTION LOGIC….3321
            DTC CONFIRMATION PROCEDURE….3321
          Diagnosis Procedure….3321
        P1607 VVEL CONTROL MODULE….3323
          P1607 VVEL CONTROL MODULE….3323
          Description….3323
          DTC Logic….3323
            DTC DETECTION LOGIC….3323
            DTC CONFIRMATION PROCEDURE….3323
          Diagnosis Procedure….3323
        P1608 VVEL SENSOR POWER SUPPLY….3325
          P1608 VVEL SENSOR POWER SUPPLY….3325
          DTC Logic….3325
            DTC DETECTION LOGIC….3325
            DTC CONFIRMATION PROCEDURE….3325
          Diagnosis Procedure….3325
          Special Repair Requirement….3326
        P1805 BRAKE SWITCH….3328
          P1805 BRAKE SWITCH….3328
          Description….3328
          DTC Logic….3328
            DTC DETECTION LOGIC….3328
            DTC CONFIRMATION PROCEDURE….3328
          Diagnosis Procedure….3328
          Component Inspection (Stop Lamp Switch)….3329
        P2122, P2123 APP SENSOR….3331
          P2122, P2123 APP SENSOR….3331
          Description….3331
          DTC Logic….3331
            DTC DETECTION LOGIC….3331
            DTC CONFIRMATION PROCEDURE….3331
          Diagnosis Procedure….3331
          Component Inspection….3333
          Special Repair Requirement….3333
        P2127, P2128 APP SENSOR….3335
          P2127, P2128 APP SENSOR….3335
          Description….3335
          DTC Logic….3335
            DTC DETECTION LOGIC….3335
            DTC CONFIRMATION PROCEDURE….3335
          Diagnosis Procedure….3335
          Component Inspection….3338
          Special Repair Requirement….3338
        P2138 APP SENSOR….3339
          P2138 APP SENSOR….3339
          Description….3339
          DTC Logic….3339
            DTC DETECTION LOGIC….3339
            DTC CONFIRMATION PROCEDURE….3339
          Diagnosis Procedure….3339
          Component Inspection….3342
          Special Repair Requirement….3342
        P2A00, P2A03 A/F SENSOR 1….3344
          P2A00, P2A03 A/F SENSOR 1….3344
          Description….3344
          DTC Logic….3344
            DTC DETECTION LOGIC….3344
            DTC CONFIRMATION PROCEDURE….3344
          Diagnosis Procedure….3345
        ASCD BRAKE SWITCH….3348
          ASCD BRAKE SWITCH….3348
          Description….3348
          Component Function Check….3348
          Diagnosis Procedure….3348
          Component Inspection (ASCD Brake Switch)….3349
        ASCD INDICATOR….3351
          ASCD INDICATOR….3351
          Description….3351
          Component Function Check….3351
          Diagnosis Procedure….3351
        COOLING FAN….3352
          COOLING FAN….3352
          Description….3352
            COOLING FAN CONTROL MODULE….3352
            COOLING FAN MOTOR….3352
          Component Function Check….3352
          Diagnosis Procedure….3352
          Component Inspection (Cooling Fan Motor)….3354
          Component Inspection (Cooling Fan Relay-1)….3355
        ELECTRICAL LOAD SIGNAL….3356
          ELECTRICAL LOAD SIGNAL….3356
          Description….3356
          Component Function Check….3356
          Diagnosis Procedure….3356
        FUEL INJECTOR….3358
          FUEL INJECTOR….3358
          Description….3358
          Component Function Check….3358
          Diagnosis Procedure….3358
          Component Inspection….3360
        FUEL PUMP….3361
          FUEL PUMP….3361
          Description….3361
          Component Function Check….3361
          Diagnosis Procedure….3361
          Component Inspection….3363
        IGNITION SIGNAL….3364
          IGNITION SIGNAL….3364
          Description….3364
          Component Function Check….3364
          Diagnosis Procedure….3364
          Component Inspection (Ignition Coil with Power Transistor)….3367
          Component Inspection (Condenser)….3368
        MALFUNCTION INDICATOR LAMP….3369
          MALFUNCTION INDICATOR LAMP….3369
          Description….3369
          Component Function Check….3369
          Diagnosis Procedure….3369
        POSITIVE CRANKCASE VENTILATION….3370
          POSITIVE CRANKCASE VENTILATION….3370
          Description….3370
          Component Inspection….3370
        REFRIGERANT PRESSURE SENSOR….3372
          REFRIGERANT PRESSURE SENSOR….3372
          Description….3372
          Component Function Check….3372
          Diagnosis Procedure….3372
        SNOW MODE SWITCH….3374
          SNOW MODE SWITCH….3374
          Description….3374
          Component Function Check….3374
          Diagnosis Procedure….3374
          Component Inspection….3376
      ECU DIAGNOSIS INFORMATION….3377
        ECM….3377
          ECM….3377
          Reference Value….3377
            VALUES ON THE DIAGNOSIS TOOL….3377
            TERMINAL LAYOUT….3382
            PHYSICAL VALUES….3382
          Wiring Diagram – ENGINE CONTROL SYSTEM -….3393
          Fail safe….3415
            NON DTC RELATED ITEM….3415
            DTC RELATED ITEM….3416
          DTC Inspection Priority Chart….3417
          DTC Index….3419
          Test Value and Test Limit….3423
        VVEL CONTROL MODULE….3431
          VVEL CONTROL MODULE….3431
          Reference Value….3431
            TERMINAL LAYOUT….3431
            PHYSICAL VALUES….3431
          Wiring Diagram – ENGINE CONTROL SYSTEM -….3435
      SYMPTOM DIAGNOSIS….3458
        ENGINE CONTROL SYSTEM SYMPTOMS….3458
          ENGINE CONTROL SYSTEM SYMPTOMS….3458
          Symptom Table….3458
            SYSTEM – BASIC ENGINE CONTROL SYSTEM….3458
            SYSTEM – ENGINE MECHANICAL & OTHER….3459
        NORMAL OPERATING CONDITION….3462
          NORMAL OPERATING CONDITION….3462
          Description….3462
            FUEL CUT CONTROL (AT NO LOAD AND HIGH ENGINE SPEED)….3462
            TORQUE CUT CONTROL (AT HIGH ENGINE OIL TEMPERATURE)….3462
      PRECAUTION….3463
        PRECAUTIONS….3463
          PRECAUTIONS….3463
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….3463
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….3463
          Precaution for Procedure without Cowl Top Cover….3463
          Precautions For Xenon Headlamp Service….3463
          Precautions for Removing Battery Terminal….3464
          On Board Diagnostic (OBD) System of Engine and A/T….3464
          General Precautions….3465
      PREPARATION….3468
        PREPARATION….3468
          PREPARATION….3468
          Special Service Tools….3468
          Commercial Service Tools….3468
      PERIODIC MAINTENANCE….3470
        FUEL PRESSURE….3470
          FUEL PRESSURE….3470
          Inspection….3470
            FUEL PRESSURE RELEASE….3470
              <GRAPHIC> With CONSULT….3470
              <GRAPHIC> Without CONSULT….3470
            FUEL PRESSURE CHECK….3470
        EVAP LEAK CHECK….3471
          EVAP LEAK CHECK….3471
          Inspection….3471
      SERVICE DATA AND SPECIFICATIONS (SDS)….3472
        SERVICE DATA AND SPECIFICATIONS (SDS)….3472
          SERVICE DATA AND SPECIFICATIONS (SDS)….3472
          Idle Speed….3472
          Ignition Timing….3472
          Calculated Load Value….3472
          Mass Air Flow Sensor….3472
    VK50VE….3473
      VK50VE….3473
      BASIC INSPECTION….3473
        DIAGNOSIS AND REPAIR WORKFLOW….3473
          DIAGNOSIS AND REPAIR WORKFLOW….3473
          Work Flow….3473
            OVERALL SEQUENCE….3473
            DETAILED FLOW….3473
          Diagnostic Work Sheet….3476
            DESCRIPTION….3476
            WORKSHEET SAMPLE….3476
        INSPECTION AND ADJUSTMENT….3477
          INSPECTION AND ADJUSTMENT….3477
          BASIC INSPECTION….3477
            BASIC INSPECTION : Special Repair Requirement….3477
          ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (ECM)….3480
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (ECM) : Description….3480
              PROGRAMMING OPERATION….3480
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (ECM) : Special Repair Requirement….3480
          ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (VVEL CONTROL MODULE)….3481
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (VVEL CONTROL MODULE) : Description….3481
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (VVEL CONTROL MODULE) : Special Repair Requirement….3481
          IDLE SPEED….3481
            IDLE SPEED : Description….3481
            IDLE SPEED : Special Repair Requirement….3481
          IGNITION TIMING….3482
            IGNITION TIMING : Description….3482
            IGNITION TIMING : Special Repair Requirement….3482
          VIN REGISTRATION….3482
            VIN REGISTRATION : Description….3482
            VIN REGISTRATION : Special Repair Requirement….3482
          ACCELERATOR PEDAL RELEASED POSITION LEARNING….3482
            ACCELERATOR PEDAL RELEASED POSITION LEARNING : Description….3483
            ACCELERATOR PEDAL RELEASED POSITION LEARNING : Special Repair Requirement….3483
          THROTTLE VALVE CLOSED POSITION LEARNING….3483
            THROTTLE VALVE CLOSED POSITION LEARNING : Description….3483
            THROTTLE VALVE CLOSED POSITION LEARNING : Special Repair Requirement….3483
          IDLE AIR VOLUME LEARNING….3483
            IDLE AIR VOLUME LEARNING : Description….3483
            IDLE AIR VOLUME LEARNING : Special Repair Requirement….3484
          VVEL CONTROL SHAFT POSITION SENSOR ADJUSTMENT….3485
            VVEL CONTROL SHAFT POSITION SENSOR ADJUSTMENT : Description….3485
            VVEL CONTROL SHAFT POSITION SENSOR ADJUSTMENT : Special Repair Requirement….3485
          MIXTURE RATIO SELF-LEARNING VALUE CLEAR….3487
            MIXTURE RATIO SELF-LEARNING VALUE CLEAR : Description….3487
            MIXTURE RATIO SELF-LEARNING VALUE CLEAR : Special Repair Requirement….3487
        HOW TO SET SRT CODE….3489
          HOW TO SET SRT CODE….3489
          Description….3489
            OUTLINE….3489
            SRT ITEM….3489
            SRT SERVICE PROCEDURE….3489
          SRT Set Driving Pattern….3490
          Work Procedure….3492
      SYSTEM DESCRIPTION….3494
        ENGINE CONTROL SYSTEM….3494
          ENGINE CONTROL SYSTEM….3494
          System Diagram….3494
          System Description….3495
          Component Parts Location….3496
          Component Description….3503
        MULTIPORT FUEL INJECTION SYSTEM….3505
          MULTIPORT FUEL INJECTION SYSTEM….3505
          System Diagram….3505
          System Description….3505
            INPUT/OUTPUT SIGNAL CHART….3505
            SYSTEM DESCRIPTION….3506
            VARIOUS FUEL INJECTION INCREASE/DECREASE COMPENSATION….3506
            MIXTURE RATIO FEEDBACK CONTROL (CLOSED LOOP CONTROL)….3506
            MIXTURE RATIO SELF-LEARNING CONTROL….3506
            FUEL INJECTION TIMING….3507
            FUEL SHUT-OFF….3507
          Component Parts Location….3508
          Component Description….3515
        ELECTRIC IGNITION SYSTEM….3516
          ELECTRIC IGNITION SYSTEM….3516
          System Diagram….3516
          System Description….3516
            INPUT/OUTPUT SIGNAL CHART….3516
            SYSTEM DESCRIPTION….3516
          Component Parts Location….3517
          Component Description….3524
        AIR CONDITIONING CUT CONTROL….3525
          AIR CONDITIONING CUT CONTROL….3525
          System Diagram….3525
          System Description….3525
            INPUT/OUTPUT SIGNAL CHART….3525
            SYSTEM DESCRIPTION….3525
          Component Parts Location….3526
          Component Description….3533
        AUTOMATIC SPEED CONTROL DEVICE (ASCD)….3534
          AUTOMATIC SPEED CONTROL DEVICE (ASCD)….3534
          System Diagram….3534
          System Description….3534
            INPUT/OUTPUT SIGNAL CHART….3534
            BASIC ASCD SYSTEM….3534
            SET OPERATION….3534
            ACCELERATE OPERATION….3534
            CANCEL OPERATION….3534
            COAST OPERATION….3535
            RESUME OPERATION….3535
          Component Parts Location….3536
          Component Description….3543
        CAN COMMUNICATION….3544
          CAN COMMUNICATION….3544
          System Description….3544
        COOLING FAN CONTROL….3545
          COOLING FAN CONTROL….3545
          System Diagram….3545
          System Description….3545
            INPUT/OUTPUT SIGNAL CHART….3545
            SYSTEM DESCRIPTION….3545
          Component Parts Location….3546
          Component Description….3553
        EVAPORATIVE EMISSION SYSTEM….3554
          EVAPORATIVE EMISSION SYSTEM….3554
          System Diagram….3554
          System Description….3554
            INPUT/OUTPUT SIGNAL CHART….3554
            SYSTEM DESCRIPTION….3555
          Component Parts Location….3556
          Component Description….3563
        EXHAUST VALVE TIMING CONTROL….3564
          EXHAUST VALVE TIMING CONTROL….3564
          System Diagram….3564
          System Description….3564
            INPUT/OUTPUT SIGNAL CHART….3564
            SYSTEM DESCRIPTION….3564
          Component Parts Location….3565
          Component Description….3572
        FUEL PUMP CONTROL MODULE….3573
          FUEL PUMP CONTROL MODULE….3573
          System Diagram….3573
          System Description….3573
            INPUT/OUTPUT SIGNAL CHART….3573
            SYSTEM DESCRIPTION….3573
          Component Parts Location….3574
          Component Description….3581
        INTAKE VALVE TIMING CONTROL….3582
          INTAKE VALVE TIMING CONTROL….3582
          System Diagram….3582
          System Description….3582
            INPUT/OUTPUT SIGNAL CHART….3582
            SYSTEM DESCRIPTION….3582
          Component Parts Location….3583
          Component Description….3590
        VVEL SYSTEM….3591
          VVEL SYSTEM….3591
          System Diagram….3591
          System Description….3591
            INPUT/OUTPUT SIGNAL CHART….3591
            SYSTEM DESCRIPTION….3591
          Component Parts Location….3592
          Component Description….3599
        ON BOARD DIAGNOSTIC (OBD) SYSTEM….3600
          ON BOARD DIAGNOSTIC (OBD) SYSTEM….3600
          Diagnosis Description….3600
          GST (Generic Scan Tool)….3600
        DIAGNOSIS SYSTEM (ECM)….3601
          DIAGNOSIS SYSTEM (ECM)….3601
          DIAGNOSIS DESCRIPTION….3601
            DIAGNOSIS DESCRIPTION : 1st Trip Detection Logic and Two Trip Detection Logic….3601
            DIAGNOSIS DESCRIPTION : DTC and Freeze Frame Data….3601
              DTC AND 1ST TRIP DTC….3601
              FREEZE FRAME DATA AND 1ST TRIP FREEZE FRAME DATA….3601
            DIAGNOSIS DESCRIPTION : Counter System….3602
              RELATIONSHIP BETWEEN MIL, 1ST TRIP DTC, DTC, AND DETECTABLE ITEMS….3602
              COUNTER SYSTEM CHART….3602
              Relationship Between MIL, DTC, 1st Trip DTC and Driving Patterns for “Misfire <Exhaust Quality Deterioration>”, “Fuel Injection System”….3602
              Explanation for Driving Patterns for “Misfire <Exhaust Quality Deterioration>”, “Fuel Injection System”….3603
                Driving Pattern B….3603
                Driving Pattern C….3604
              Relationship Between MIL, DTC, 1st Trip DTC and Driving Patterns Except For “Misfire <Exhaust Quality Deterioration>”, “Fuel Injection System”….3604
              Explanation for Driving Patterns Except for “Misfire <Exhaust Quality Deterioration>”, “Fuel Injection System”….3605
                Driving Pattern A….3605
                Driving Pattern B….3605
            DIAGNOSIS DESCRIPTION : Driving Pattern….3605
              DRIVING PATTERN A….3605
              DRIVING PATTERN B….3605
              DRIVING PATTERN C….3605
              DRIVING PATTERN D….3606
            DIAGNOSIS DESCRIPTION : System Readiness Test (SRT) Code….3606
              SRT SET TIMING….3606
            DIAGNOSIS DESCRIPTION : Malfunction Indicator Lamp (MIL)….3607
          On Board Diagnosis Function….3608
            ON BOARD DIAGNOSIS ITEM….3608
            BULB CHECK MODE….3608
              Description….3608
              Operation Procedure….3608
            SRT STATUS MODE….3608
              Description….3608
              Operation Procedure….3608
            MALFUNCTION WARNING MODE….3609
              Description….3609
              Operation Procedure….3609
            SELF-DIAGNOSTIC RESULTS MODE….3609
              Description….3609
              How to Set Self-diagnostic Results Mode….3609
              How to Read Self-diagnostic Results….3610
              How to Erase Self-diagnostic Results….3611
          CONSULT Function….3611
            FUNCTION….3611
            SELF DIAGNOSTIC RESULT MODE….3611
              Self Diagnostic Item….3611
              How to Read DTC and 1st Trip DTC….3611
              How to Erase DTC and 1st Trip DTC….3611
              Freeze Frame Data and 1st Trip Freeze Frame Data….3612
            DATA MONITOR MODE….3612
              Monitored Item….3612
            WORK SUPPORT MODE….3618
              Work Item….3618
            ACTIVE TEST MODE….3618
              Test Item….3618
            DTC WORK SUPPORT MODE….3619
              Test Item….3619
            SRT & P-DTC MODE….3619
              SRT STATUS Mode….3619
              SRT WORK SUPPORT Mode….3619
      DTC/CIRCUIT DIAGNOSIS….3621
        TROUBLE DIAGNOSIS – SPECIFICATION VALUE….3621
          TROUBLE DIAGNOSIS – SPECIFICATION VALUE….3621
          Description….3621
          Component Function Check….3621
          Diagnosis Procedure….3622
            OVERALL SEQUENCE….3622
            DETAILED PROCEDURE….3623
        POWER SUPPLY AND GROUND CIRCUIT….3629
          POWER SUPPLY AND GROUND CIRCUIT….3629
          Diagnosis Procedure….3629
        U0101 CAN COMM CIRCUIT….3632
          U0101 CAN COMM CIRCUIT….3632
          Description….3632
          DTC Logic….3632
            DTC DETECTION LOGIC….3632
            DTC CONFIRMATION PROCEDURE….3632
          Diagnosis Procedure….3632
        U0113, U1003 CAN COMM CIRCUIT….3633
          U0113, U1003 CAN COMM CIRCUIT….3633
          Description….3633
          DTC Logic….3633
            DTC DETECTION LOGIC….3633
            DTC CONFIRMATION PROCEDURE….3633
          Diagnosis Procedure….3633
        U1001 CAN COMM CIRCUIT….3635
          U1001 CAN COMM CIRCUIT….3635
          Description….3635
          DTC Logic….3635
            DTC DETECTION LOGIC….3635
            DTC CONFIRMATION PROCEDURE….3635
          Diagnosis Procedure….3635
        U1024 CAN COMM CIRCUIT….3636
          U1024 CAN COMM CIRCUIT….3636
          Description….3636
          DTC Logic….3636
            DTC DETECTION LOGIC….3636
            DTC CONFIRMATION PROCEDURE….3636
          Diagnosis Procedure….3636
        P0011, P0021 IVT CONTROL….3638
          P0011, P0021 IVT CONTROL….3638
          DTC Logic….3638
            DTC DETECTION LOGIC….3638
            DTC CONFIRMATION PROCEDURE….3638
          Diagnosis Procedure….3639
          Component Inspection….3640
        P0014, P0024 EVT CONTROL….3642
          P0014, P0024 EVT CONTROL….3642
          DTC Logic….3642
            DTC DETECTION LOGIC….3642
            DTC CONFIRMATION PROCEDURE….3642
          Diagnosis Procedure….3643
          Component Inspection….3644
        P0031, P0032, P0051, P0052 A/F SENSOR 1 HEATER….3646
          P0031, P0032, P0051, P0052 A/F SENSOR 1 HEATER….3646
          Description….3646
            SYSTEM DESCRIPTION….3646
          DTC Logic….3646
            DTC DETECTION LOGIC….3646
            DTC CONFIRMATION PROCEDURE….3646
          Diagnosis Procedure….3646
          Component Inspection….3648
        P0037, P0038, P0057, P0058 HO2S2 HEATER….3649
          P0037, P0038, P0057, P0058 HO2S2 HEATER….3649
          Description….3649
            SYSTEM DESCRIPTION….3649
            OPERATION….3649
          DTC Logic….3649
            DTC DETECTION LOGIC….3649
            DTC CONFIRMATION PROCEDURE….3649
          Diagnosis Procedure….3650
          Component Inspection….3651
        P0075, P0081 IVT CONTROL SOLENOID VALVE….3652
          P0075, P0081 IVT CONTROL SOLENOID VALVE….3652
          Description….3652
          DTC Logic….3652
            DTC DETECTION LOGIC….3652
            DTC CONFIRMATION PROCEDURE….3652
          Diagnosis Procedure….3652
          Component Inspection….3653
        P0078, P0084 EVT CONTROL SOLENOID VALVE….3655
          P0078, P0084 EVT CONTROL SOLENOID VALVE….3655
          Description….3655
          DTC Logic….3655
            DTC DETECTION LOGIC….3655
            DTC CONFIRMATION PROCEDURE….3655
          Diagnosis Procedure….3655
          Component Inspection….3656
        P0102, P0103, P010C, P010D MAF SENSOR….3658
          P0102, P0103, P010C, P010D MAF SENSOR….3658
          Description….3658
          DTC Logic….3658
            DTC DETECTION LOGIC….3658
            DTC CONFIRMATION PROCEDURE….3658
          Diagnosis Procedure….3659
          Component Inspection….3660
        P010A MANIFOLD ABSOLUTE PRESSURE SENSOR….3664
          P010A MANIFOLD ABSOLUTE PRESSURE SENSOR….3664
          Description….3664
          DTC Logic….3664
            DTC DETECTION LOGIC….3664
            DTC CONFIRMATION PROCEDURE….3664
          Diagnosis Procedure….3665
          Component Inspection….3667
        P0112, P0113 IAT SENSOR….3669
          P0112, P0113 IAT SENSOR….3669
          Description….3669
          DTC Logic….3669
            DTC DETECTION LOGIC….3669
            DTC CONFIRMATION PROCEDURE….3669
          Diagnosis Procedure….3670
          Component Inspection….3670
        P0117, P0118 ECT SENSOR….3672
          P0117, P0118 ECT SENSOR….3672
          Description….3672
          DTC Logic….3672
            DTC DETECTION LOGIC….3672
            DTC CONFIRMATION PROCEDURE….3672
          Diagnosis Procedure….3673
          Component Inspection….3673
        P0122, P0123, P0227, P0228 TP SENSOR….3675
          P0122, P0123, P0227, P0228 TP SENSOR….3675
          Description….3675
          DTC Logic….3675
            DTC DETECTION LOGIC….3675
            DTC CONFIRMATION PROCEDURE….3675
          Diagnosis Procedure….3675
          Component Inspection….3677
          Special Repair Requirement….3677
        P0130, P0150 A/F SENSOR 1….3678
          P0130, P0150 A/F SENSOR 1….3678
          Description….3678
          DTC Logic….3678
            DTC DETECTION LOGIC….3678
            DTC CONFIRMATION PROCEDURE….3678
          Component Function Check….3680
          Diagnosis Procedure….3680
        P0131, P0151 A/F SENSOR 1….3682
          P0131, P0151 A/F SENSOR 1….3682
          Description….3682
          DTC Logic….3682
            DTC DETECTION LOGIC….3682
            DTC CONFIRMATION PROCEDURE….3682
          Diagnosis Procedure….3683
        P0132, P0152 A/F SENSOR 1….3685
          P0132, P0152 A/F SENSOR 1….3685
          Description….3685
          DTC Logic….3685
            DTC DETECTION LOGIC….3685
            DTC CONFIRMATION PROCEDURE….3685
          Diagnosis Procedure….3686
        P0133, P0153 A/F SENSOR 1….3688
          P0133, P0153 A/F SENSOR 1….3688
          Description….3688
          DTC Logic….3688
            DTC DETECTION LOGIC….3688
            DTC CONFIRMATION PROCEDURE….3688
          Diagnosis Procedure….3690
        P0137, P0157 HO2S2….3693
          P0137, P0157 HO2S2….3693
          Description….3693
          DTC Logic….3693
            DTC DETECTION LOGIC….3693
            DTC CONFIRMATION PROCEDURE….3693
          Component Function Check….3694
          Diagnosis Procedure….3695
          Component Inspection….3696
        P0138, P0158 HO2S2….3699
          P0138, P0158 HO2S2….3699
          Description….3699
          DTC Logic….3699
            DTC DETECTION LOGIC….3699
            DTC CONFIRMATION PROCEDURE….3700
          Component Function Check….3701
          Diagnosis Procedure….3702
          Component Inspection….3705
        P0139, P0159 HO2S2….3707
          P0139, P0159 HO2S2….3707
          Description….3707
          DTC Logic….3707
            DTC DETECTION LOGIC….3707
            DTC CONFIRMATION PROCEDURE….3707
          Component Function Check….3708
          Diagnosis Procedure….3709
          Component Inspection….3710
        P0171, P0174 FUEL INJECTION SYSTEM FUNCTION….3713
          P0171, P0174 FUEL INJECTION SYSTEM FUNCTION….3713
          DTC Logic….3713
            DTC DETECTION LOGIC….3713
            DTC CONFIRMATION PROCEDURE….3713
          Diagnosis Procedure….3714
        P0172, P0175 FUEL INJECTION SYSTEM FUNCTION….3717
          P0172, P0175 FUEL INJECTION SYSTEM FUNCTION….3717
          DTC Logic….3717
            DTC DETECTION LOGIC….3717
            DTC CONFIRMATION PROCEDURE….3717
          Diagnosis Procedure….3718
        P0197, P0198 EOT SENSOR….3721
          P0197, P0198 EOT SENSOR….3721
          Description….3721
          DTC Logic….3721
            DTC DETECTION LOGIC….3721
            DTC CONFIRMATION PROCEDURE….3721
          Diagnosis Procedure….3722
          Component Inspection….3722
        P0222, P0223, P2132, P2133 TP SENSOR….3724
          P0222, P0223, P2132, P2133 TP SENSOR….3724
          Description….3724
          DTC Logic….3724
            DTC DETECTION LOGIC….3724
            DTC CONFIRMATION PROCEDURE….3724
          Diagnosis Procedure….3724
          Component Inspection….3726
          Special Repair Requirement….3726
        P0225 TP SENSOR….3727
          P0225 TP SENSOR….3727
          DTC Logic….3727
            DTC DETECTION LOGIC….3727
        P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 MISFIRE….3728
          P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 MISFIRE….3728
          DTC Logic….3728
            DTC DETECTION LOGIC….3728
            DTC CONFIRMATION PROCEDURE….3728
          Diagnosis Procedure….3729
        P0327, P0328, P0332, P0333 KS….3734
          P0327, P0328, P0332, P0333 KS….3734
          Description….3734
          DTC Logic….3734
            DTC DETECTION LOGIC….3734
            DTC CONFIRMATION PROCEDURE….3734
          Diagnosis Procedure….3734
          Component Inspection….3735
        P0335 CKP SENSOR….3737
          P0335 CKP SENSOR….3737
          Description….3737
          DTC Logic….3737
            DTC DETECTION LOGIC….3737
            DTC CONFIRMATION PROCEDURE….3737
          Diagnosis Procedure….3738
          Component Inspection….3740
        P0340, P0345 CMP SENSOR….3741
          P0340, P0345 CMP SENSOR….3741
          Description….3741
          DTC Logic….3741
            DTC DETECTION LOGIC….3741
            DTC CONFIRMATION PROCEDURE….3742
          Diagnosis Procedure….3743
          Component Inspection….3745
        P0420, P0430 THREE WAY CATALYST FUNCTION….3747
          P0420, P0430 THREE WAY CATALYST FUNCTION….3747
          DTC Logic….3747
            DTC DETECTION LOGIC….3747
            DTC CONFIRMATION PROCEDURE….3747
          Component Function Check….3748
          Diagnosis Procedure….3749
        P0444 EVAP CANISTER PURGE VOLUME CONTROL SOLENOID VALVE….3752
          P0444 EVAP CANISTER PURGE VOLUME CONTROL SOLENOID VALVE….3752
          Description….3752
          DTC Logic….3752
            DTC DETECTION LOGIC….3752
            DTC CONFIRMATION PROCEDURE….3752
          Diagnosis Procedure….3752
          Component Inspection….3754
        P0500 VSS….3755
          P0500 VSS….3755
          Description….3755
          DTC Logic….3755
            DTC DETECTION LOGIC….3755
            DTC CONFIRMATION PROCEDURE….3755
          Diagnosis Procedure….3755
        P0506 ISC SYSTEM….3757
          P0506 ISC SYSTEM….3757
          Description….3757
          DTC Logic….3757
            DTC DETECTION LOGIC….3757
            DTC CONFIRMATION PROCEDURE….3757
          Diagnosis Procedure….3757
        P0507 ISC SYSTEM….3759
          P0507 ISC SYSTEM….3759
          Description….3759
          DTC Logic….3759
            DTC DETECTION LOGIC….3759
            DTC CONFIRMATION PROCEDURE….3759
          Diagnosis Procedure….3759
        P0524 ENGINE OIL PRESSURE….3761
          P0524 ENGINE OIL PRESSURE….3761
          DTC Logic….3761
            DTC DETECTION LOGIC….3761
            DTC CONFIRMATION PROCEDURE….3761
          Diagnosis Procedure….3762
        P0550 PSP SENSOR….3764
          P0550 PSP SENSOR….3764
          Description….3764
          DTC Logic….3764
            DTC DETECTION LOGIC….3764
            DTC CONFIRMATION PROCEDURE….3764
          Diagnosis Procedure….3764
          Component Inspection….3765
        P0603 ECM POWER SUPPLY….3767
          P0603 ECM POWER SUPPLY….3767
          Description….3767
          DTC Logic….3767
            DTC DETECTION LOGIC….3767
            DTC CONFIRMATION PROCEDURE….3767
          Diagnosis Procedure….3767
        P0604 ECM….3769
          P0604 ECM….3769
          DTC Logic….3769
            DTC DETECTION LOGIC….3769
            DTC CONFIRMATION PROCEDURE….3769
          Diagnosis Procedure….3769
        P0605 ECM….3770
          P0605 ECM….3770
          Description….3770
          DTC Logic….3770
            DTC DETECTION LOGIC….3770
            DTC CONFIRMATION PROCEDURE….3770
          Diagnosis Procedure….3770
        P0606 ECM….3772
          P0606 ECM….3772
          DTC Logic….3772
            DTC DETECTION LOGIC….3772
            DTC CONFIRMATION PROCEDURE….3772
          Diagnosis Procedure….3772
        P0607 ECM….3773
          P0607 ECM….3773
          Description….3773
          DTC Logic….3773
            DTC DETECTION LOGIC….3773
            DTC CONFIRMATION PROCEDURE….3773
          Diagnosis Procedure….3773
        P060A ECM….3774
          P060A ECM….3774
          DTC Logic….3774
            DTC DETECTION LOGIC….3774
            DTC CONFIRMATION PROCEDURE….3774
          Diagnosis Procedure….3774
        P060B ECM….3775
          P060B ECM….3775
          DTC Logic….3775
            DTC DETECTION LOGIC….3775
            DTC CONFIRMATION PROCEDURE….3775
          Diagnosis Procedure….3775
        P0643 SENSOR POWER SUPPLY….3776
          P0643 SENSOR POWER SUPPLY….3776
          DTC Logic….3776
            DTC DETECTION LOGIC….3776
            DTC CONFIRMATION PROCEDURE….3776
          Diagnosis Procedure….3776
        P0850 PNP SWITCH….3779
          P0850 PNP SWITCH….3779
          Description….3779
          DTC Logic….3779
            DTC DETECTION LOGIC….3779
            DTC CONFIRMATION PROCEDURE….3779
          Component Function Check….3780
          Diagnosis Procedure….3780
        P100A, P100B VVEL SYSTEM….3782
          P100A, P100B VVEL SYSTEM….3782
          DTC Logic….3782
            DTC DETECTION LOGIC….3782
            DTC CONFIRMATION PROCEDURE….3782
          Diagnosis Procedure….3782
          Component Inspection (VVEL ACTUATOR MOTOR)….3784
          Component Inspection (VVEL ACTUATOR SUB ASSEMBLY)….3784
          Special Repair Requirement….3785
        P1078, P1084 EVT CONTROL POSITION SENSOR….3786
          P1078, P1084 EVT CONTROL POSITION SENSOR….3786
          Description….3786
          DTC Logic….3786
            DTC DETECTION LOGIC….3786
            DTC CONFIRMATION PROCEDURE….3786
          Diagnosis Procedure….3787
          Component Inspection….3789
        P1087, P1088 VVEL SYSTEM….3791
          P1087, P1088 VVEL SYSTEM….3791
          DTC Logic….3791
            DTC DETECTION LOGIC….3791
        P1089, P1092 VVEL CONTROL SHAFT POSITION SENSOR….3792
          P1089, P1092 VVEL CONTROL SHAFT POSITION SENSOR….3792
          Description….3792
          DTC Logic….3792
            DTC DETECTION LOGIC….3792
            DTC CONFIRMATION PROCEDURE….3792
          Diagnosis Procedure….3792
          Special Repair Requirement….3794
        P1090, P1093 VVEL ACTUATOR MOTOR….3796
          P1090, P1093 VVEL ACTUATOR MOTOR….3796
          Description….3796
          DTC Logic….3796
            DTC DETECTION LOGIC….3796
            DTC CONFIRMATION PROCEDURE….3796
          Diagnosis Procedure….3796
          Component Inspection (VVEL ACTUATOR MOTOR)….3798
          Component Inspection (VVEL ACTUATOR SUB ASSEMBLY)….3798
          Special Repair Requirement….3799
        P1091 VVEL ACTUATOR MOTOR RELAY….3800
          P1091 VVEL ACTUATOR MOTOR RELAY….3800
          Description….3800
          DTC Logic….3800
            DTC DETECTION LOGIC….3800
            DTC CONFIRMATION PROCEDURE….3800
          Diagnosis Procedure….3800
          Component Inspection….3802
        P1211 TCS CONTROL UNIT….3803
          P1211 TCS CONTROL UNIT….3803
          Description….3803
          DTC Logic….3803
            DTC DETECTION LOGIC….3803
            DTC CONFIRMATION PROCEDURE….3803
          Diagnosis Procedure….3803
        P1212 TCS COMMUNICATION LINE….3804
          P1212 TCS COMMUNICATION LINE….3804
          Description….3804
          DTC Logic….3804
            DTC DETECTION LOGIC….3804
            DTC CONFIRMATION PROCEDURE….3804
          Diagnosis Procedure….3804
        P1217 ENGINE OVER TEMPERATURE….3805
          P1217 ENGINE OVER TEMPERATURE….3805
          DTC Logic….3805
            DTC DETECTION LOGIC….3805
            DTC CONFIRMATION PROCEDURE….3805
          Component Function Check….3805
          Diagnosis Procedure….3806
        P1220 FUEL PUMP CONTROL MODULE (FPCM)….3809
          P1220 FUEL PUMP CONTROL MODULE (FPCM)….3809
          Description….3809
          DTC Logic….3809
            DTC DETECTION LOGIC….3809
            DTC CONFIRMATION PROCEDURE….3809
          Diagnosis Procedure….3809
          Component Inspection….3811
        P1225, P1234 TP SENSOR….3812
          P1225, P1234 TP SENSOR….3812
          Description….3812
          DTC Logic….3812
            DTC DETECTION LOGIC….3812
            DTC CONFIRMATION PROCEDURE….3812
          Diagnosis Procedure….3812
          Special Repair Requirement….3813
        P1226, P1235 TP SENSOR….3814
          P1226, P1235 TP SENSOR….3814
          Description….3814
          DTC Logic….3814
            DTC DETECTION LOGIC….3814
            DTC CONFIRMATION PROCEDURE….3814
          Diagnosis Procedure….3814
          Special Repair Requirement….3815
        P1233, P2101 ELECTRIC THROTTLE CONTROL FUNCTION….3816
          P1233, P2101 ELECTRIC THROTTLE CONTROL FUNCTION….3816
          Description….3816
          DTC Logic….3816
            DTC DETECTION LOGIC….3816
            DTC CONFIRMATION PROCEDURE….3816
          Diagnosis Procedure….3816
          Component Inspection….3819
          Special Repair Requirement….3819
        P1236, P2118 THROTTLE CONTROL MOTOR….3820
          P1236, P2118 THROTTLE CONTROL MOTOR….3820
          Description….3820
          DTC Logic….3820
            DTC DETECTION LOGIC….3820
            DTC CONFIRMATION PROCEDURE….3820
          Diagnosis Procedure….3820
          Component Inspection….3821
          Special Repair Requirement….3822
        P1238, P2119 ELECTRIC THROTTLE CONTROL ACTUATOR….3823
          P1238, P2119 ELECTRIC THROTTLE CONTROL ACTUATOR….3823
          Description….3823
          DTC Logic….3823
            DTC DETECTION LOGIC….3823
            DTC CONFIRMATION PROCEDURE….3823
          Diagnosis Procedure….3824
          Special Repair Requirement….3824
        P1239, P2135 TP SENSOR….3825
          P1239, P2135 TP SENSOR….3825
          Description….3825
          DTC Logic….3825
            DTC DETECTION LOGIC….3825
            DTC CONFIRMATION PROCEDURE….3825
          Diagnosis Procedure….3825
          Component Inspection….3827
          Special Repair Requirement….3827
        P1290, P2100, P2103 THROTTLE CONTROL MOTOR RELAY….3828
          P1290, P2100, P2103 THROTTLE CONTROL MOTOR RELAY….3828
          Description….3828
          DTC Logic….3828
            DTC DETECTION LOGIC….3828
            DTC CONFIRMATION PROCEDURE….3828
          Diagnosis Procedure….3828
        P1550 BATTERY CURRENT SENSOR….3830
          P1550 BATTERY CURRENT SENSOR….3830
          Description….3830
          DTC Logic….3830
            DTC DETECTION LOGIC….3830
            DTC CONFIRMATION PROCEDURE….3830
          Diagnosis Procedure….3830
          Component Inspection….3833
        P1551, P1552 BATTERY CURRENT SENSOR….3834
          P1551, P1552 BATTERY CURRENT SENSOR….3834
          Description….3834
          DTC Logic….3834
            DTC DETECTION LOGIC….3834
            DTC CONFIRMATION PROCEDURE….3834
          Diagnosis Procedure….3835
          Component Inspection….3837
        P1553 BATTERY CURRENT SENSOR….3838
          P1553 BATTERY CURRENT SENSOR….3838
          Description….3838
          DTC Logic….3838
            DTC DETECTION LOGIC….3838
            DTC CONFIRMATION PROCEDURE….3838
          Diagnosis Procedure….3839
          Component Inspection….3841
        P1554 BATTERY CURRENT SENSOR….3842
          P1554 BATTERY CURRENT SENSOR….3842
          Description….3842
          DTC Logic….3842
            DTC DETECTION LOGIC….3842
            DTC CONFIRMATION PROCEDURE….3842
          Component Function Check….3842
          Diagnosis Procedure….3843
          Component Inspection….3845
        P1564 ASCD STEERING SWITCH….3847
          P1564 ASCD STEERING SWITCH….3847
          Description….3847
          DTC Logic….3847
            DTC DETECTION LOGIC….3847
            DTC CONFIRMATION PROCEDURE….3847
          Diagnosis Procedure….3847
          Component Inspection….3849
        P1572 ASCD BRAKE SWITCH….3850
          P1572 ASCD BRAKE SWITCH….3850
          Description….3850
          DTC Logic….3850
            DTC DETECTION LOGIC….3850
            DTC CONFIRMATION PROCEDURE….3850
          Diagnosis Procedure….3851
          Component Inspection (ASCD Brake Switch)….3854
          Component Inspection (Stop Lamp Switch)….3854
        P1574 ASCD VEHICLE SPEED SENSOR….3855
          P1574 ASCD VEHICLE SPEED SENSOR….3855
          Description….3855
          DTC Logic….3855
            DTC DETECTION LOGIC….3855
            DTC CONFIRMATION PROCEDURE….3855
          Diagnosis Procedure….3855
        P1606 VVEL CONTROL MODULE….3857
          P1606 VVEL CONTROL MODULE….3857
          Description….3857
          DTC Logic….3857
            DTC DETECTION LOGIC….3857
            DTC CONFIRMATION PROCEDURE….3857
          Diagnosis Procedure….3857
        P1607 VVEL CONTROL MODULE….3859
          P1607 VVEL CONTROL MODULE….3859
          Description….3859
          DTC Logic….3859
            DTC DETECTION LOGIC….3859
            DTC CONFIRMATION PROCEDURE….3859
          Diagnosis Procedure….3859
        P1608 VVEL SENSOR POWER SUPPLY….3861
          P1608 VVEL SENSOR POWER SUPPLY….3861
          DTC Logic….3861
            DTC DETECTION LOGIC….3861
            DTC CONFIRMATION PROCEDURE….3861
          Diagnosis Procedure….3861
          Special Repair Requirement….3862
        P1715 INPUT SPEED SENSOR….3864
          P1715 INPUT SPEED SENSOR….3864
          Description….3864
          DTC Logic….3864
            DTC DETECTION LOGIC….3864
          Diagnosis Procedure….3864
        P1805 BRAKE SWITCH….3865
          P1805 BRAKE SWITCH….3865
          Description….3865
          DTC Logic….3865
            DTC DETECTION LOGIC….3865
            DTC CONFIRMATION PROCEDURE….3865
          Diagnosis Procedure….3865
          Component Inspection (Stop Lamp Switch)….3866
        P2122, P2123 APP SENSOR….3868
          P2122, P2123 APP SENSOR….3868
          Description….3868
          DTC Logic….3868
            DTC DETECTION LOGIC….3868
            DTC CONFIRMATION PROCEDURE….3868
          Diagnosis Procedure….3868
          Component Inspection….3870
          Special Repair Requirement….3870
        P2127, P2128 APP SENSOR….3872
          P2127, P2128 APP SENSOR….3872
          Description….3872
          DTC Logic….3872
            DTC DETECTION LOGIC….3872
            DTC CONFIRMATION PROCEDURE….3872
          Diagnosis Procedure….3873
          Component Inspection….3875
          Special Repair Requirement….3875
        P2138 APP SENSOR….3876
          P2138 APP SENSOR….3876
          Description….3876
          DTC Logic….3876
            DTC DETECTION LOGIC….3876
            DTC CONFIRMATION PROCEDURE….3876
          Diagnosis Procedure….3877
          Component Inspection….3879
          Special Repair Requirement….3880
        ASCD BRAKE SWITCH….3881
          ASCD BRAKE SWITCH….3881
          Description….3881
          Component Function Check….3881
          Diagnosis Procedure….3881
          Component Inspection (ASCD Brake Switch)….3882
        ASCD INDICATOR….3884
          ASCD INDICATOR….3884
          Description….3884
          Component Function Check….3884
          Diagnosis Procedure….3884
        COOLING FAN….3885
          COOLING FAN….3885
          Description….3885
            COOLING FAN CONTROL MODULE….3885
            COOLING FAN MOTOR….3885
          Component Function Check….3885
          Diagnosis Procedure….3885
          Component Inspection (Cooling Fan Motor)….3888
          Component Inspection (Cooling Fan Relay)….3889
        ELECTRICAL LOAD SIGNAL….3890
          ELECTRICAL LOAD SIGNAL….3890
          Description….3890
          Component Function Check….3890
          Diagnosis Procedure….3890
        FUEL INJECTOR….3892
          FUEL INJECTOR….3892
          Description….3892
          Component Function Check….3892
          Diagnosis Procedure….3892
          Component Inspection….3894
        FUEL PUMP….3895
          FUEL PUMP….3895
          Description….3895
          Component Function Check….3895
          Diagnosis Procedure….3895
          Component Inspection….3897
        IGNITION SIGNAL….3898
          IGNITION SIGNAL….3898
          Description….3898
          Component Function Check….3898
          Diagnosis Procedure….3898
          Component Inspection (Ignition Coil with Power Transistor)….3901
          Component Inspection (Condenser)….3902
        INFORMATION DISPLAY (ASCD)….3903
          INFORMATION DISPLAY (ASCD)….3903
          Description….3903
          Component Function Check….3903
          Diagnosis Procedure….3903
        MALFUNCTION INDICATOR LAMP….3904
          MALFUNCTION INDICATOR LAMP….3904
          Description….3904
          Component Function Check….3904
          Diagnosis Procedure….3904
        POSITIVE CRANKCASE VENTILATION….3905
          POSITIVE CRANKCASE VENTILATION….3905
          Description….3905
          Component Inspection….3905
        REFRIGERANT PRESSURE SENSOR….3907
          REFRIGERANT PRESSURE SENSOR….3907
          Description….3907
          Component Function Check….3907
          Diagnosis Procedure….3907
        SNOW MODE SWITCH….3909
          SNOW MODE SWITCH….3909
          Description….3909
          Component Function Check….3909
          Diagnosis Procedure….3909
          Component Inspection….3911
      ECU DIAGNOSIS INFORMATION….3912
        ECM….3912
          ECM….3912
          Reference Value….3912
            VALUES ON THE DIAGNOSIS TOOL….3912
            TERMINAL LAYOUT….3917
            PHYSICAL VALUES….3917
          Wiring Diagram – ENGINE CONTROL SYSTEM -….3930
          Fail-safe….3953
            NON DTC RELATED ITEM….3953
            DTC RELATED ITEM….3954
          DTC Inspection Priority Chart….3955
          DTC Index….3957
          Test Value and Test Limit….3961
        VVEL CONTROL MODULE….3970
          VVEL CONTROL MODULE….3970
          Reference Value….3970
            TERMINAL LAYOUT….3970
            PHYSICAL VALUES….3970
          Wiring Diagram – ENGINE CONTROL SYSTEM -….3974
      SYMPTOM DIAGNOSIS….3998
        ENGINE CONTROL SYSTEM SYMPTOMS….3998
          ENGINE CONTROL SYSTEM SYMPTOMS….3998
          Symptom Table….3998
            SYSTEM – BASIC ENGINE CONTROL SYSTEM….3998
            SYSTEM – ENGINE MECHANICAL & OTHER….3999
        NORMAL OPERATING CONDITION….4002
          NORMAL OPERATING CONDITION….4002
          Description….4002
            FUEL CUT CONTROL (AT NO LOAD AND HIGH ENGINE SPEED)….4002
      PRECAUTION….4003
        PRECAUTIONS….4003
          PRECAUTIONS….4003
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….4003
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….4003
          Precaution for Procedure without Cowl Top Cover….4003
          Precautions for Removing Battery Terminal….4004
          Precautions For Xenon Headlamp Service….4004
          On Board Diagnostic (OBD) System of Engine and A/T….4004
          General Precautions….4005
      PREPARATION….4008
        PREPARATION….4008
          PREPARATION….4008
          Special Service Tools….4008
          Commercial Service Tools….4008
      PERIODIC MAINTENANCE….4010
        FUEL PRESSURE….4010
          FUEL PRESSURE….4010
          Inspection….4010
            FUEL PRESSURE RELEASE….4010
              <GRAPHIC> With CONSULT….4010
              <GRAPHIC> Without CONSULT….4010
            FUEL PRESSURE CHECK….4010
        EVAP LEAK CHECK….4011
          EVAP LEAK CHECK….4011
          Inspection….4011
      SERVICE DATA AND SPECIFICATIONS (SDS)….4012
        SERVICE DATA AND SPECIFICATIONS (SDS)….4012
          SERVICE DATA AND SPECIFICATIONS (SDS)….4012
          Idle Speed….4012
          Ignition Timing….4012
          Calculated Load Value….4012
          Mass Air Flow Sensor….4012
em….4014
  Table of Contents….4014
    VQ37VHR….4018
      VQ37VHR….4018
      SYMPTOM DIAGNOSIS….4018
        NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….4018
          NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….4018
          NVH Troubleshooting – Engine Noise….4018
          Use the Chart Below to Help You Find the Cause of the Symptom….4018
      PRECAUTION….4020
        PRECAUTIONS….4020
          PRECAUTIONS….4020
          Precautions for Removing Battery Terminal….4020
          Precaution for Procedure without Cowl Top Cover….4020
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….4020
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….4020
          Precautions Necessary for Steering Wheel Rotation After Battery Disconnection….4021
            OPERATION PROCEDURE….4021
          Precautions For Engine Service….4021
            DISCONNECTING FUEL PIPING….4021
            DRAINING ENGINE COOLANT….4021
            INSPECTION, REPAIR AND REPLACEMENT….4021
            REMOVAL AND DISASSEMBLY….4021
            ASSEMBLY AND INSTALLATION….4022
          Parts Requiring Angle Tightening….4022
          Liquid Gasket….4022
            REMOVAL OF LIQUID GASKET SEALING….4022
            LIQUID GASKET APPLICATION PROCEDURE….4022
          Definitions of Bank Names….4023
      PREPARATION….4024
        PREPARATION….4024
          PREPARATION….4024
          Special Service Tools….4024
          Commercial Service Tools….4025
      PERIODIC MAINTENANCE….4028
        DRIVE BELT ….4028
          DRIVE BELT ….4028
          Exploded View….4028
          Checking….4028
          Tension Adjustment….4028
          Removal and Installation….4028
            REMOVAL….4028
            INSTALLATION….4029
          Inspection….4029
            INSPECTION AFTER INSTALLATION….4029
        AIR CLEANER FILTER….4030
          AIR CLEANER FILTER….4030
          Removal and Installation….4030
            REMOVAL….4030
            INSTALLATION….4030
          Inspection (Viscous Paper Type)….4030
            INSPECTION AFTER REMOVAL….4030
            MAINTENANCE INTERVAL….4030
        SPARK PLUG….4031
          SPARK PLUG….4031
          Exploded View….4031
          Removal and Installation….4031
            REMOVAL….4031
            INSTALLATION….4032
          Inspection….4032
            INSPECTION AFTER REMOVAL….4032
        CAMSHAFT VALVE CLEARANCE….4033
          CAMSHAFT VALVE CLEARANCE….4033
          Inspection and Adjustment….4033
            INSPECTION….4033
              Check valve clearance if applicable to the following cases:….4033
            CAMSHAFT (EXH) VALVE CLEARANCE ADJUSTMENT….4036
        COMPRESSION PRESSURE….4038
          COMPRESSION PRESSURE….4038
          Inspection….4038
      REMOVAL AND INSTALLATION….4040
        ENGINE COVER….4040
          ENGINE COVER….4040
          Exploded View….4040
          Removal and Installation….4040
            REMOVAL….4040
            INSTALLATION….4040
        DRIVE BELT AUTO TENSIONER AND IDLER PULLEY….4041
          DRIVE BELT AUTO TENSIONER AND IDLER PULLEY….4041
          Exploded View….4041
          Removal and Installation….4041
            Removal….4041
            Installation….4041
        AIR CLEANER AND AIR DUCT….4042
          AIR CLEANER AND AIR DUCT….4042
          Exploded View….4042
          Removal and Installation….4042
            REMOVAL….4042
            INSTALLATION….4042
          Inspection….4043
            INSPECTION AFTER REMOVAL….4043
        INTAKE MANIFOLD COLLECTOR….4044
          INTAKE MANIFOLD COLLECTOR….4044
          Exploded View….4044
          Removal and Installation….4044
            REMOVAL….4044
            INSTALLATION….4045
        INTAKE MANIFOLD….4047
          INTAKE MANIFOLD….4047
          Exploded View….4047
          Removal and Installation….4047
            REMOVAL….4047
            INSTALLATION….4047
          Inspection….4048
            INSPECTION AFTER REMOVAL….4048
              Surface Distortion….4048
        EXHAUST MANIFOLD….4049
          EXHAUST MANIFOLD….4049
          Exploded View….4049
          Removal and Installation….4049
            REMOVAL….4049
            INSTALLATION….4051
              Air Fuel Ratio Sensor 1 and Heated Oxygen Sensor 2….4051
          Inspection….4051
            INSPECTION AFTER REMOVAL….4051
              Surface Distortion….4052
        FUEL INJECTOR AND FUEL TUBE….4053
          FUEL INJECTOR AND FUEL TUBE….4053
          Exploded View….4053
          Removal and Installation….4053
            REMOVAL….4053
            INSTALLATION….4055
          Inspection….4058
            INSPECTION AFTER INSTALLATION….4058
              Check for Fuel Leakage….4059
        OIL PAN (LOWER)….4060
          OIL PAN (LOWER)….4060
          Exploded View….4060
          Removal and Installation….4061
            REMOVAL….4061
            INSTALLATION….4062
          Inspection….4063
            INSPECTION AFTER REMOVAL….4063
            INSPECTION AFTER INSTALLATION….4063
        IGNITION COIL, SPARK PLUG AND ROCKER COVER….4064
          IGNITION COIL, SPARK PLUG AND ROCKER COVER….4064
          Exploded View….4064
          Removal and Installation….4064
            REMOVAL….4064
            INSTALLATION….4065
        TIMING CHAIN….4067
          TIMING CHAIN….4067
          Exploded View….4067
          Removal and Installation….4068
            REMOVAL….4068
            INSTALLATION….4073
          Inspection….4082
            INSPECTION AFTER REMOVAL….4082
              Timing Chain….4082
            INSPECTION AFTER INSTALLATION….4082
              Inspection for Leakage….4082
        OIL SEAL….4084
          OIL SEAL….4084
          FRONT OIL SEAL….4084
            FRONT OIL SEAL : Removal and Installation….4084
              REMOVAL….4084
              INSTALLATION….4084
          REAR OIL SEAL….4084
            REAR OIL SEAL : Removal and Installation….4084
              REMOVAL….4084
              INSTALLATION….4085
      UNIT REMOVAL AND INSTALLATION….4086
        ENGINE ASSEMBLY….4086
          ENGINE ASSEMBLY….4086
          2WD….4086
            2WD : Exploded View….4086
            2WD : Removal and Installation….4086
              REMOVAL….4087
                Outline….4087
                Preparation….4087
                Engine Room LH….4087
                Engine Room RH….4087
                Vehicle Inside….4087
                Vehicle Underbody….4087
                Removal Work….4088
                Separation Work….4088
              INSTALLATION….4089
            2WD : Inspection….4089
              INSPECTION AFTER INSTALLATION….4089
                Inspection for Leakage….4089
          AWD….4090
            AWD : Exploded View….4090
            AWD : Removal and Installation….4091
              REMOVAL….4091
                Outline….4091
                Preparation….4091
                Engine Room LH….4091
                Engine Room RH….4092
                Vehicle Inside….4092
                Vehicle Underbody….4092
                Removal Work….4092
                Separation Work….4093
              INSTALLATION….4094
            AWD : Inspection….4094
              INSPECTION AFTER INSTALLATION….4094
                Inspection for Leakage….4094
      UNIT DISASSEMBLY AND ASSEMBLY….4096
        ENGINE STAND SETTING….4096
          ENGINE STAND SETTING….4096
          Setting….4096
        ENGINE UNIT….4098
          ENGINE UNIT….4098
          Disassembly….4098
          Assembly….4098
        OIL PAN (UPPER) AND OIL STRAINER….4099
          OIL PAN (UPPER) AND OIL STRAINER….4099
          2WD….4099
            2WD : Exploded View….4099
            2WD : Disassembly and Assembly….4099
              REMOVAL….4099
              INSTALLATION….4100
            2WD : Inspection….4101
              INSPECTION AFTER REMOVAL….4101
              INSPECTION AFTER INSTALLATION….4101
          AWD….4101
            AWD : Exploded View….4102
            AWD : Disassembly and Assembly….4102
              REMOVAL….4102
              INSTALLATION….4103
            AWD : Inspection….4105
              INSPECTION AFTER REMOVAL….4105
              INSPECTION AFTER INSTALLATION….4105
        REAR TIMING CHAIN CASE….4106
          REAR TIMING CHAIN CASE….4106
          Exploded View….4106
          Disassembly and Assembly….4107
            DISASSEMBLY….4107
            ASSEMBLY….4108
        CAMSHAFT….4111
          CAMSHAFT….4111
          Exploded View….4111
          Disassembly and Assembly….4112
            DISASSEMBLY….4112
            ASSEMBLY….4114
          Inspection….4121
            INSPECTION AFTER REMOVAL (EXHAUST SIDE)….4121
              Camshaft (EXH) Runout….4121
              Camshaft (EXH) Cam Height….4121
              Camshaft (EXH) Journal Oil Clearance….4121
              Camshaft (EXH) End Play….4122
              Camshaft Sprocket (EXH) Runout….4122
              Valve Lifter (EXH)….4123
              Valve Lifter Clearance (EXH)….4123
            INSPECTION AFTER REMOVAL (INTAKE SIDE)….4124
              Drive Shaft End Play….4124
              Camshaft Sprocket (INT) Runout….4124
              Valve Lifter (INT)….4124
              Valve Lifter Clearance (INT)….4124
              VVEL Ladder Assembly….4125
            INSPECTION AFTER INSTALLATION….4126
              Inspection of Camshaft Sprocket (INT) Oil Groove….4126
              Inspection for Leakage….4127
        CYLINDER HEAD….4128
          CYLINDER HEAD….4128
          Exploded View….4128
          Disassembly and Assembly….4129
            DISASSEMBLY….4129
            ASSEMBLY….4130
          Inspection….4134
            INSPECTION AFTER DISASSEMBLY….4134
              Cylinder Head Bolts Outer Diameter….4134
              Cylinder Head Distortion….4135
              Valve Dimensions….4135
              Valve Guide Clearance….4135
              Valve Seat Contact….4136
              Valve Spring Squareness….4136
              Valve Spring Dimensions and Valve Spring Pressure Load….4136
            INSPECTION AFTER INSTALLATION….4136
              Inspection for Leakage….4136
        CYLINDER BLOCK….4138
          CYLINDER BLOCK….4138
          Exploded View….4138
          Disassembly and Assembly….4139
            DISASSEMBLY….4139
            ASSEMBLY….4141
          Inspection….4147
            CRANKSHAFT END PLAY….4147
            CONNECTING ROD SIDE CLEARANCE….4147
            PISTON TO PISTON PIN OIL CLEARANCE….4148
              Piston Pin Hole Diameter….4148
              Piston Pin Outer Diameter….4148
              Piston to Piston Pin Oil Clearance….4148
            PISTON RING SIDE CLEARANCE….4148
            PISTON RING END GAP….4149
            CONNECTING ROD BEND AND TORSION….4149
            CONNECTING ROD BIG END DIAMETER….4149
            CONNECTING ROD BUSHING OIL CLEARANCE….4150
              Connecting Rod Bushing Inner Diameter….4150
              Piston Pin Outer Diameter….4150
              Connecting Rod Bushing Oil Clearance….4150
            CYLINDER BLOCK DISTORTION….4151
            MAIN BEARING HOUSING INNER DIAMETER….4151
            PISTON TO CYLINDER BORE CLEARANCE….4152
              Cylinder Bore inner Diameter ….4152
              Piston Skirt Diameter….4152
              Piston-to-Cylinder Bore Clearance….4152
              Reboring Cylinder Bore….4152
            CRANKSHAFT MAIN JOURNAL DIAMETER….4153
            CRANKSHAFT PIN JOURNAL DIAMETER….4153
            CRANKSHAFT OUT-OF-ROUND AND TAPER….4153
            CRANKSHAFT RUNOUT ….4153
            CONNECTING ROD BEARING OIL CLEARANCE….4154
              Method by Calculation….4154
              Method of Using Plastigage….4154
            MAIN BEARING OIL CLEARANCE….4154
              Method by Calculation….4154
              Method of Using Plastigage….4155
            MAIN BEARING CRUSH HEIGHT….4155
            CONNECTING ROD BEARING CRUSH HEIGHT….4155
            LOWER CYLINDER BLOCK BOLT OUTER DIAMETER….4156
            CONNECTING ROD BOLT OUTER DIAMETER….4156
            DRIVE PLATE….4156
            OIL JET….4156
            OIL JET RELIEF VALVE….4156
        HOW TO SELECT PISTON AND BEARING….4157
          HOW TO SELECT PISTON AND BEARING….4157
          Description….4157
          Piston….4157
            WHEN NEW CYLINDER BLOCK IS USED….4157
            WHEN CYLINDER BLOCK IS REUSED….4157
            PISTON SELECTION TABLE….4158
          Connecting Rod Bearing….4158
            WHEN NEW CONNECTING ROD AND CRANKSHAFT ARE USED….4158
            WHEN CONNECTING ROD AND CRANKSHAFT ARE REUSED….4159
            CONNECTING ROD BEARING SELECTION TABLE….4159
            CONNECTING ROD BEARING GRADE TABLE….4160
            UNDERSIZE BEARING USAGE GUIDE….4160
          Main Bearing….4161
            WHEN NEW CYLINDER BLOCK AND CRANKSHAFT ARE USED….4161
            WHEN CYLINDER BLOCK AND CRANKSHAFT ARE REUSED….4161
            MAIN BEARING SELECTION TABLE….4162
            MAIN BEARING GRADE TABLE (ALL JOURNALS)….4162
            UNDERSIZE BEARING USAGE GUIDE….4162
      SERVICE DATA AND SPECIFICATIONS (SDS)….4164
        SERVICE DATA AND SPECIFICATIONS (SDS)….4164
          SERVICE DATA AND SPECIFICATIONS (SDS)….4164
          General Specification….4164
            GENERAL SPECIFICATIONS….4164
          Drive Belt….4164
            DRIVE BELT….4164
          Spark Plug….4164
            SPARK PLUG….4164
          Intake Manifold ….4165
            INTAKE MANIFOLD….4165
          Exhaust Manifold….4165
            EXHAUST MANIFOLD….4165
          Camshaft….4165
            CAMSHAFT (EXH)….4165
            CAMSHAFT (INT)….4165
            VALVE LIFTER….4166
            VALVE CLEARANCE….4166
            AVAILABLE VALVE LIFTER….4166
          Cylinder Head….4167
            CYLINDER HEAD….4167
            VALVE DIMENSIONS….4167
            VALVE GUIDE….4168
            VALVE SEAT….4168
            VALVE SPRING….4169
          Cylinder Block….4169
            CYLINDER BLOCK….4169
            AVAILABLE PISTON….4170
            PISTON RING….4171
            PISTON PIN….4171
            CONNECTING ROD….4171
            CRANKSHAFT….4172
          Main Bearing….4173
            MAIN BEARING….4173
            UNDERSIZE….4174
            MAIN BEARING OIL CLEARANCE….4174
          Connecting Rod Bearing….4174
            CONNECTING ROD BEARING….4174
              UNDERSIZE….4174
              CONNECTING ROD BEARING OIL CLEARANCE….4175
    VK50VE….4176
      VK50VE….4176
      SYMPTOM DIAGNOSIS….4176
        NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….4176
          NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….4176
          NVH Troubleshooting – Engine Noise….4176
          Use the Chart Below to Help You Find the Cause of the Symptom….4176
      PRECAUTION….4178
        PRECAUTIONS….4178
          PRECAUTIONS….4178
          Precautions for Removing Battery Terminal….4178
          Precaution for Procedure without Cowl Top Cover….4178
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….4178
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….4178
          Precautions For Engine Service….4179
            DISCONNECTING FUEL PIPING….4179
            DRAINING ENGINE COOLANT….4179
            INSPECTION, REPAIR AND REPLACEMENT….4179
            REMOVAL AND DISASSEMBLY….4179
            ASSEMBLY AND INSTALLATION….4179
          Parts Requiring Angle Tightening….4179
          Precaution for Liquid Gasket….4180
            REMOVAL OF LIQUID GASKET SEALING….4180
            LIQUID GASKET APPLICATION PROCEDURE….4180
          Definitions of Bank Names….4181
      PREPARATION….4182
        PREPARATION….4182
          PREPARATION….4182
          Special Service Tool….4182
          Commercial Service Tool….4183
      PERIODIC MAINTENANCE….4186
        DRIVE BELTS….4186
          DRIVE BELTS….4186
          Exploded View….4186
          Checking….4186
          Tension Adjustment….4187
          Removal and Installation….4187
            REMOVAL….4187
              Alternator, Water Pump and A/C Compressor Belt….4187
              Power Steering Oil Pump Belt….4187
            INSTALLATION….4187
…
          INSTALLATION….4592
      FENDER PROTECTOR….4594
        FENDER PROTECTOR….4594
        FENDER PROTECTOR….4594
          FENDER PROTECTOR : Exploded View….4594
          FENDER PROTECTOR : Removal and Installation….4594
            REMOVAL….4594
            INSTALLATION….4595
        REAR WHEEL HOUSE PROTECTOR….4595
          REAR WHEEL HOUSE PROTECTOR : Exploded View….4596
          REAR WHEEL HOUSE PROTECTOR : Removal and Installation….4596
            REMOVAL….4596
            INSTALLATION….4597
      CENTER MUD GUARD….4598
        CENTER MUD GUARD….4598
        Exploded View….4598
        Removal and Installation….4598
          REMOVAL….4598
          INSTALLATION….4599
      FLOOR SIDE FAIRING….4600
        FLOOR SIDE FAIRING….4600
        Exploded View….4600
        Removal and Installation….4600
          REMOVAL….4600
          INSTALLATION….4600
      FILLET MOLDING….4601
        FILLET MOLDING….4601
        Exploded View….4601
        Removal and Installation….4601
          REMOVAL….4601
            FRONT FILLET MOLDING….4601
            REAR FILLET MOLDING….4602
          INSTALLATION….4602
      ROOF RAIL….4604
        ROOF RAIL….4604
        Exploded View….4604
        Removal and Installation….4604
          REMOVAL….4604
          INSTALLATION….4606
      ROOF SIDE MOLDING….4607
        ROOF SIDE MOLDING….4607
        Exploded View….4607
        Removal and Installation….4607
          REMOVAL….4607
          INSTALLATION….4607
          REMOVAL AND INSTALLATION OF ROOF SIDE MOLDING CLIP….4608
            Removal….4608
            Installation….4608
      DOOR SASH MOLDING….4609
        DOOR SASH MOLDING….4609
        Exploded View….4609
        Removal and Installation….4609
          REMOVAL….4609
            FRONT DOOR SASH MOLDING….4609
            REAR DOOR SASH MOLDING….4610
            FRONT DOOR SASH OUTER COVER….4611
            REAR DOOR SASH OUTER COVER FRONT….4611
            REAR DOOR SASH OUTER COVER REAR….4611
          INSTALLATION….4612
      DOOR OUTSIDE MOLDING….4613
        DOOR OUTSIDE MOLDING….4613
        Exploded View….4613
        Removal and Installation….4613
          REMOVAL….4613
            FRONT DOOR OUTSIDE MOLDING….4613
            REAR DOOR OUTSIDE MOLDING….4614
          INSTALLATION….4614
      DOOR OUTSIDE LOWER MOLDING….4615
        DOOR OUTSIDE LOWER MOLDING….4615
        Exploded View….4615
        Removal and Installation….4615
          REMOVAL….4615
            FRONT DOOR OUTSIDE LOWER MOLDING….4615
            REAR DOOR OUTSIDE LOWER MOLDING….4616
          INSTALLATION….4616
      DOOR PARTING SEAL….4617
        DOOR PARTING SEAL….4617
        Exploded View….4617
        Removal and Installation….4617
          REMOVAL….4617
            FRONT DOOR PARTING SEAL….4617
            REAR DOOR PARTING SEAL (LOWER)….4618
            REAR DOOR PARTING SEAL (FRONT)….4618
          INSTALLATION….4618
      BACK DOOR FINISHER….4619
        BACK DOOR FINISHER….4619
        Exploded View….4619
        Removal and Installation….4619
          REMOVAL….4619
            BACK DOOR FINISHER UPPER….4619
            BACK DOOR FINISHER LOWER….4620
          INSTALLATION….4620
      BACK PILLAR FINISHER….4621
        BACK PILLAR FINISHER….4621
        Exploded View….4621
        Removal and Installation….4621
          REMOVAL….4621
            WITHOUT AUTOMATIIC BACK DOOR….4621
            WITH AUTOMATIIC BACK DOOR….4622
          INSTALLATION….4623
fax….4624
  Table of Contents….4624
    2WD….4626
      2WD….4626
      SYMPTOM DIAGNOSIS….4626
        NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….4626
          NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….4626
          NVH Troubleshooting Chart….4626
      PRECAUTION….4627
        PRECAUTIONS….4627
          PRECAUTIONS….4627
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….4627
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….4627
          Precautions for Removing Battery Terminal….4627
      PREPARATION….4628
        PREPARATION….4628
          PREPARATION….4628
          Commercial Service Tool….4628
      PERIODIC MAINTENANCE….4629
        FRONT WHEEL HUB AND KNUCKLE….4629
          FRONT WHEEL HUB AND KNUCKLE….4629
          Inspection….4629
            MOUNTING INSPECTION….4629
            WHEEL BEARING INSPECTION….4629
      REMOVAL AND INSTALLATION….4630
        FRONT WHEEL HUB AND KNUCKLE….4630
          FRONT WHEEL HUB AND KNUCKLE….4630
          Exploded View….4630
          Removal and Installation….4630
            REMOVAL….4630
            INSTALLATION….4630
          Inspection….4631
            INSPECTION AFTER REMOVAL….4631
              Ball Joint Inspection….4631
            INSPECTION AFTER INSTALLATION….4631
      SERVICE DATA AND SPECIFICATIONS (SDS)….4632
        SERVICE DATA AND SPECIFICATIONS (SDS)….4632
          SERVICE DATA AND SPECIFICATIONS (SDS)….4632
          Wheel Bearing….4632
    AWD….4633
      AWD….4633
      SYMPTOM DIAGNOSIS….4633
        NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….4633
          NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….4633
          NVH Troubleshooting Chart….4633
      PRECAUTION….4634
        PRECAUTIONS….4634
          PRECAUTIONS….4634
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….4634
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….4634
          Precautions for Drive Shaft….4634
          Precautions for Removing Battery Terminal….4635
      PREPARATION….4636
        PREPARATION….4636
          PREPARATION….4636
          Special Service Tool….4636
          Commercial Service Tool….4637
      PERIODIC MAINTENANCE….4638
        FRONT WHEEL HUB AND KNUCKLE….4638
          FRONT WHEEL HUB AND KNUCKLE….4638
          Inspection….4638
            MOUNTING INSPECTION….4638
            WHEEL BEARING INSPECTION….4638
        FRONT DRIVE SHAFT….4639
          FRONT DRIVE SHAFT….4639
          Inspection….4639
      REMOVAL AND INSTALLATION….4640
        FRONT WHEEL HUB AND KNUCKLE….4640
          FRONT WHEEL HUB AND KNUCKLE….4640
          Exploded View….4640
          Removal and Installation….4640
            REMOVAL….4640
            INSTALLATION….4641
          Inspection….4641
            INSPECTION AFTER REMOVAL….4641
              Ball Joint Inspection….4641
            INSPECTION AFTER INSTALLATION….4641
        FRONT DRIVE SHAFT BOOT….4642
          FRONT DRIVE SHAFT BOOT….4642
          Exploded View….4642
            LEFT SIDE….4642
            RIGHT SIDE….4643
          WHEEL SIDE….4643
            WHEEL SIDE : Removal and Installation….4643
              REMOVAL….4643
                Left Side….4643
                Right Side….4644
              INSTALLATION….4645
                Left Side….4645
                Right Side….4647
          FINAL DRIVE SIDE….4648
            FINAL DRIVE SIDE : Removal and Installation….4648
          Inspection….4649
            INSPECTION AFTER REMOVAL….4649
        FRONT DRIVE SHAFT….4650
          FRONT DRIVE SHAFT….4650
          Exploded View….4650
            LEFT SIDE….4650
            RIGHT SIDE….4651
          LEFT SIDE….4651
            LEFT SIDE : Removal and Installation….4651
              REMOVAL….4651
              INSTALLATION….4652
          RIGHT SIDE….4652
            RIGHT SIDE : Removal and Installation….4652
              REMOVAL….4652
              INSTALLATION….4653
          WHEEL SIDE….4653
            WHEEL SIDE : Disassembly and Assembly….4653
              DISASSEMBLY….4653
              ASSEMBLY….4653
          FINAL DRIVE SIDE….4655
            FINAL DRIVE SIDE : Disassembly and Assembly….4655
              DISASSEMBLY….4655
              ASSEMBLY….4656
          Inspection….4658
            INSPECTION AFTER REMOVAL….4658
            INSPECTION AFTER DISASSEMBLY….4658
              Shaft….4658
              Joint Sub-Assembly (Wheel Side)….4658
              Housing and Spider assembly (Final Drive side)….4659
      SERVICE DATA AND SPECIFICATIONS (SDS)….4660
        SERVICE DATA AND SPECIFICATIONS (SDS)….4660
          SERVICE DATA AND SPECIFICATIONS (SDS)….4660
          Wheel Bearing….4660
          Drive Shaft….4660
            VQ37VHR….4660
            VK50VE….4660
fl….4661
  Table of Contents….4661
    PRECAUTION….4662
      PRECAUTIONS….4662
        PRECAUTIONS….4662
        General Precautions….4662
        Precautions for Removing Battery Terminal….4662
    PREPARATION….4663
      PREPARATION….4663
        PREPARATION….4663
        Commercial Service Tools….4663
    PERIODIC MAINTENANCE….4664
      FUEL SYSTEM….4664
        FUEL SYSTEM….4664
        Inspection….4664
        Quick Connector….4664
    REMOVAL AND INSTALLATION….4665
      FUEL LEVEL SENSOR UNIT, FUEL FILTER AND FUEL PUMP ASSEMBLY….4665
        FUEL LEVEL SENSOR UNIT, FUEL FILTER AND FUEL PUMP ASSEMBLY….4665
        Exploded View….4665
          REMOVAL….4665
          DISASSEMBLY….4665
        Removal and Installation….4666
          REMOVAL….4666
          INSTALLATION….4668
        Disassembly and Assembly….4669
          DISASSEMBLY….4669
          ASSEMBLY….4669
        Inspection….4670
          INSPECTION AFTER INSTALLATION….4670
      FUEL TANK….4671
        FUEL TANK….4671
        Exploded View….4671
        Removal and Installation….4672
          REMOVAL….4672
          INSTALLATION….4673
        Inspection….4673
          INSPECTION AFTER INSTALLATION….4673
      EVAP CANISTER….4675
        EVAP CANISTER….4675
        VQ37VHR….4675
          VQ37VHR : Hydraulic Layout….4675
            FOR USA AND CANADA….4675
            FOR MEXICO….4676
          VQ37VHR : Exploded View….4678
            DISASSEMBLY (FOR USA AND CANADA)….4678
          VQ37VHR : Removal and Installation….4679
            REMOVAL….4679
            INSTALLATION….4679
            DISASSEMBLY….4679
            ASSEMBLY….4679
          VQ37VHR : Inspection….4679
        VK50VE….4679
          VK50VE : Hydraulic Layout….4680
    SERVICE DATA AND SPECIFICATIONS (SDS)….4682
      SERVICE DATA AND SPECIFICATIONS (SDS)….4682
        SERVICE DATA AND SPECIFICATIONS (SDS)….4682
        Fuel Tank….4682
          Standard and Limit….4682
fsu….4683
  Table of Contents….4683
    2WD….4685
      2WD….4685
      SYMPTOM DIAGNOSIS….4685
        NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….4685
          NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….4685
          NVH Troubleshooting Chart….4685
      PRECAUTION….4686
        PRECAUTIONS….4686
          PRECAUTIONS….4686
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….4686
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….4686
          Precaution for Procedure without Cowl Top Cover….4686
          Precautions for Suspension….4686
          Precautions for Removing Battery Terminal….4687
      PREPARATION….4688
        PREPARATION….4688
          PREPARATION….4688
          Special Service Tool….4688
          Commercial Service Tool….4688
      PERIODIC MAINTENANCE….4689
        FRONT SUSPENSION ASSEMBLY….4689
          FRONT SUSPENSION ASSEMBLY….4689
          Inspection….4689
            COMPONENT PART….4689
              Ball Joint Axial End Play….4689
            SHOCK ABSORBER….4689
        WHEEL ALIGNMENT….4690
          WHEEL ALIGNMENT….4690
          Inspection….4690
            DESCRIPTION….4690
            PRELIMINARY CHECK….4690
            GENERAL INFORMATION AND RECOMMENDATIONS….4690
            ALIGNMENT PROCESS….4690
          Adjustment….4690
            TOE-IN….4690
      REMOVAL AND INSTALLATION….4692
        FRONT COIL SPRING AND SHOCK ABSORBER….4692
          FRONT COIL SPRING AND SHOCK ABSORBER….4692
          Exploded View….4692
          Removal and Installation….4692
            REMOVAL….4692
            INSTALLATION….4692
          Disassembly and Assembly….4692
            DISASSEMBLY….4692
            ASSEMBLY….4693
          Inspection….4695
            INSPECTION AFTER INSTALLATION….4695
            INSPECTION AFTER DISASSEMBLY….4695
              Shock Absorber….4695
              Shock Absorber Mounting Bracket and Rubber Parts Inspection….4695
              Coil Spring….4695
          Disposal….4695
        TRANSVERSE LINK….4696
          TRANSVERSE LINK….4696
          Exploded View….4696
          Removal and Installation….4696
            REMOVAL….4696
            INSTALLATION….4696
          Inspection….4696
            INSPECTION AFTER REMOVAL….4696
              Appearance….4696
              Ball Joint Inspection….4697
              Swing Torque Inspection….4697
              Rotating Torque Inspection….4697
              Axial End Play Inspection….4697
            INSPECTION AFTER INSTALLATION….4697
        UPPER LINK….4698
          UPPER LINK….4698
          Exploded View….4698
          Removal and Installation….4698
            REMOVAL….4698
            INSTALLATION….4698
          Inspection….4698
            INSPECTION AFTER REMOVAL….4698
              Appearance….4698
              Ball Joint Inspection….4698
              Swing Torque Inspection….4698
              Axial End Play Inspection….4699
            INSPECTION AFTER INSTALLATION….4699
        FRONT STABILIZER….4700
          FRONT STABILIZER….4700
          Exploded View….4700
          Removal and Installation….4700
            REMOVAL….4700
            INSTALLATION….4700
          Inspection….4700
            INSPECTION AFTER REMOVAL….4700
      UNIT REMOVAL AND INSTALLATION….4701
        FRONT SUSPENSION MEMBER….4701
          FRONT SUSPENSION MEMBER….4701
          Exploded View….4701
          Removal and Installation….4701
            REMOVAL….4701
            INSTALLATION….4701
          Inspection….4701
            INSPECTION AFTER REMOVAL….4701
            INSPECTION AFTER INSTALLATION….4701
      SERVICE DATA AND SPECIFICATIONS (SDS)….4703
        SERVICE DATA AND SPECIFICATIONS (SDS)….4703
          SERVICE DATA AND SPECIFICATIONS (SDS)….4703
          Wheel Alignment….4703
          Ball Joint….4703
          Wheel Height….4704
    AWD….4705
      AWD….4705
      SYMPTOM DIAGNOSIS….4705
        NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….4705
          NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….4705
          NVH Troubleshooting Chart….4705
      PRECAUTION….4706
        PRECAUTIONS….4706
          PRECAUTIONS….4706
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….4706
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….4706
          Precaution for Procedure without Cowl Top Cover….4706
          Precautions for Suspension….4706
          Precautions for Removing Battery Terminal….4707
      PREPARATION….4708
        PREPARATION….4708
          PREPARATION….4708
          Special Service Tool….4708
          Commercial Service Tool….4708
      PERIODIC MAINTENANCE….4709
        FRONT SUSPENSION ASSEMBLY….4709
          FRONT SUSPENSION ASSEMBLY….4709
          Inspection….4709
            COMPONENT PART….4709
              Ball Joint Axial End Play….4709
            SHOCK ABSORBER….4709
        WHEEL ALIGNMENT….4710
          WHEEL ALIGNMENT….4710
          Inspection….4710
            DESCRIPTION….4710
            PRELIMINARY CHECK….4710
            GENERAL INFORMATION AND RECOMMENDATIONS….4710
            ALIGNMENT PROCESS….4710
          Adjustment….4710
            TOE-IN….4710
      REMOVAL AND INSTALLATION….4712
        FRONT COIL SPRING AND SHOCK ABSORBER….4712
          FRONT COIL SPRING AND SHOCK ABSORBER….4712
          Exploded View….4712
          Removal and Installation….4712
            REMOVAL….4712
            INSTALLATION….4712
          Disassembly and Assembly….4713
            DISASSEMBLY….4713
            ASSEMBLY….4713
          Inspection….4715
            INSPECTION AFTER INSTALLATION….4715
            INSPECTION AFTER DISASSEMBLY….4715
              Shock Absorber….4715
              Shock Absorber Mounting Bracket and Rubber Parts Inspection….4715
              Coil Spring….4715
          Disposal….4715
        TRANSVERSE LINK….4716
          TRANSVERSE LINK….4716
          Exploded View….4716
          Removal and Installation….4716
            REMOVAL….4716
            INSTALLATION….4716
          Inspection….4716
            INSPECTION AFTER REMOVAL….4716
              Appearance….4716
              Ball Joint Inspection….4716
              Swing Torque Inspection….4717
              Rotating Torque Inspection….4717
              Axial End Play Inspection….4717
            INSPECTION AFTER INSTALLATION….4717
        UPPER LINK….4718
          UPPER LINK….4718
          Exploded View….4718
          Removal and Installation….4718
            REMOVAL….4718
            INSTALLATION….4718
          Inspection….4718
            INSPECTION AFTER REMOVAL….4718
              Appearance….4718
              Ball Joint Inspection….4718
              Swing Torque Inspection….4718
              Axial End Play Inspection….4719
            INSPECTION AFTER INSTALLATION….4719
        FRONT STABILIZER….4720
          FRONT STABILIZER….4720
          Exploded View….4720
          Removal and Installation….4720
            REMOVAL….4720
            INSTALLATION….4720
          Inspection….4720
            INSPECTION AFTER REMOVAL….4720
      UNIT REMOVAL AND INSTALLATION….4721
        FRONT SUSPENSION MEMBER….4721
          FRONT SUSPENSION MEMBER….4721
          Exploded View….4721
          Removal and Installation….4721
            REMOVAL….4721
            INSTALLATION….4721
          Inspection….4721
            INSPECTION AFTER REMOVAL….4721
            INSPECTION AFTER INSTALLATION….4721
      SERVICE DATA AND SPECIFICATIONS (SDS)….4723
        SERVICE DATA AND SPECIFICATIONS (SDS)….4723
          SERVICE DATA AND SPECIFICATIONS (SDS)….4723
          Wheel Alignment….4723
          Ball Joint….4723
          Wheel Height….4724
gi….4725
  Table of Contents….4725
    HOW TO USE THIS MANUAL….4727
      HOW TO USE THIS MANUAL….4727
        HOW TO USE THIS MANUAL….4727
        Description….4727
        Terms….4727
        Units….4727
        Contents….4727
        Relation between Illustrations and Descriptions….4728
        Components….4728
          SYMBOLS….4729
      HOW TO FOLLOW TROUBLE DIAGNOSES….4730
        HOW TO FOLLOW TROUBLE DIAGNOSES….4730
        Description….4730
        How to Follow Test Groups in Trouble Diagnosis….4730
        Key to Symbols Signifying Measurements or Procedures….4731
      HOW TO READ WIRING DIAGRAMS….4733
        HOW TO READ WIRING DIAGRAMS….4733
        Connector Symbols….4733
        Sample/Wiring Diagram -Example-….4734
          SWITCH POSITIONS ….4735
          MULTIPLE SWITCH….4735
        Connector Information….4736
          HOW TO USE CONNECTOR INFORMATION….4736
        How to Repair Aluminum Wires….4737
          PRECAUTIONS FOR THE HANDLING OF ALUMINUM WIRES….4737
          HOW TO DISTINGUISH ALUMINUM WIRES….4737
          HOW TO REPAIR BROKEN WIRES….4737
          HOW TO EXTEND WIRES….4739
      ABBREVIATIONS….4740
        ABBREVIATIONS….4740
        Abbreviation List….4740
      TIGHTENING TORQUE OF STANDARD BOLTS….4745
        TIGHTENING TORQUE OF STANDARD BOLTS….4745
        Description….4745
        Tightening Torque Table (New Standard Included)….4745
          PREVIOUS STANDARD….4745
          NEW STANDARD BASED ON ISO….4746
          DISCRIMINATION OF BOLTS AND NUTS….4747
      RECOMMENDED CHEMICAL PRODUCTS AND SEALANTS….4748
        RECOMMENDED CHEMICAL PRODUCTS AND SEALANTS….4748
        Recommended Chemical Products and Sealants….4748
    VEHICLE INFORMATION….4749
      IDENTIFICATION INFORMATION….4749
        IDENTIFICATION INFORMATION….4749
        Model Variation….4749
          FOR USA AND CANADA….4749
          FOR MEXICO….4749
        Information About Identification or Model Code….4750
          IDENTIFICATION NUMBER….4750
          VEHICLE IDENTIFICATION NUMBER ARRANGEMENT….4750
            For USA and Canada….4750
            For Mexico….4751
          CERTIFICATION LABEL….4751
            For USA and Mexico….4751
            For Canada….4751
          ENGINE SERIAL NUMBER ….4752
            VK50VE….4752
            VQ37VHR….4752
          AUTOMATIC TRANSMISSION NUMBER ….4752
        Dimensions….4753
          FOR USA AND CANADA….4753
          FOR MEXICO….4753
        Wheels & Tires….4753
    PRECAUTION….4755
      PRECAUTIONS….4755
        PRECAUTIONS….4755
        Description….4755
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….4755
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….4755
        Precautions For Xenon Headlamp Service….4755
        Precaution for Procedure without Cowl Top Cover….4756
        Precautions for Removing Battery Terminal….4756
        General Precautions….4756
        Three Way Catalyst….4758
        Multiport Fuel Injection System or Engine Control System….4758
        Hoses….4758
          HOSE REMOVAL AND INSTALLATION….4758
          HOSE CLAMPING….4758
        Engine Oils….4759
          HEALTH PROTECTION PRECAUTIONS ….4759
          ENVIRONMENTAL PROTECTION PRECAUTIONS ….4759
        Air Conditioning….4759
        Fuel….4760
          FOR USA AND CANADA….4760
          FOR MEXICO….4760
            VK50VE engine models….4760
            VQ37VHR engine models….4760
      LIFTING POINT….4761
        LIFTING POINT….4761
        Commercial Service Tools….4761
        Garage Jack and Safety Stand and 2-Pole Lift….4761
        Board-On Lift….4762
      TOW TRUCK TOWING….4763
        TOW TRUCK TOWING….4763
        Tow Truck Towing….4763
          2WD MODELS….4763
          AWD MODELS….4764
        Vehicle Recovery (Freeing a Stuck Vehicle)….4764
          FRONT….4764
          REAR….4764
          AUTOMATIC TRANSMISSION….4765
    PREPARATION….4766
      PREPARATION….4766
        PREPARATION….4766
        Special Service Tools….4766
        Commercial Service Tools….4766
        Repair Parts….4766
    BASIC INSPECTION….4767
      SERVICE INFORMATION FOR ELECTRICAL INCIDENT….4767
        SERVICE INFORMATION FOR ELECTRICAL INCIDENT….4767
        Work Flow….4767
          WORK FLOW….4767
        Control Units and Electrical Parts….4767
          PRECAUTIONS….4767
        How to Check Terminal….4768
          CONNECTOR AND TERMINAL PIN KIT….4768
          HOW TO PROBE CONNECTORS….4769
            Probing from Harness Side ….4769
            Probing from Terminal Side ….4769
            How to Check Enlarged Contact Spring of Terminal….4770
            Waterproof Connector Inspection ….4771
            Terminal Lock Inspection ….4771
        Intermittent Incident….4771
          DESCRIPTION….4771
          VEHICLE VIBRATION….4772
            Connector & Harness….4772
            Hint….4772
            Sensor & Relay….4772
            Engine Compartment….4772
            Behind the Instrument Panel….4772
            Under Seating Areas….4772
          HEAT SENSITIVE….4773
          FREEZING ….4773
          WATER INTRUSION….4773
          ELECTRICAL LOAD ….4773
          COLD OR HOT START UP ….4773
        Circuit Inspection….4774
          DESCRIPTION ….4774
          TESTING FOR “OPENS” IN THE CIRCUIT….4774
            Continuity Check Method….4774
            Voltage Check Method….4774
          TESTING FOR “SHORTS” IN THE CIRCUIT….4775
            Resistance Check Method….4775
            Voltage Check Method….4775
          GROUND INSPECTION ….4775
          VOLTAGE DROP TESTS ….4776
            Measuring Voltage Drop – Accumulated Method….4776
            Measuring Voltage Drop – Step-by-Step….4777
          CONTROL UNIT CIRCUIT TEST ….4777
            CASE 1….4777
            CASE 2….4778
      CONSULT/GST CHECKING SYSTEM….4779
        CONSULT/GST CHECKING SYSTEM….4779
        Description….4779
        CONSULT Function and System Application*1….4779
          FUNCTION….4779
          SYSTEM APPLICATION*1….4779
        CONSULT/GST Data Link Connector (DLC) Circuit….4780
          INSPECTION PROCEDURE….4780
        Wiring Diagram – CONSULT/GST CHECKING SYSTEM -….4781
          WITH ICC….4781
          WITHOUT ICC….4789
      INSPECTION AND ADJUSTMENT….4796
        INSPECTION AND ADJUSTMENT….4796
        ADDITIONAL SERVICE WHEN REMOVING BATTERY NEGATIVE TERMINAL….4796
          ADDITIONAL SERVICE WHEN REMOVING BATTERY NEGATIVE TERMINAL : Required Procedure After Battery Disconnection….4796
gw….4797
  Table of Contents….4797
    SYMPTOM DIAGNOSIS….4798
      SQUEAK AND RATTLE TROUBLE DIAGNOSES….4798
        SQUEAK AND RATTLE TROUBLE DIAGNOSES….4798
        Work Flow….4798
          CUSTOMER INTERVIEW….4798
          DUPLICATE THE NOISE AND TEST DRIVE….4798
          CHECK RELATED SERVICE BULLETINS….4799
          LOCATE THE NOISE AND IDENTIFY THE ROOT CAUSE….4799
          REPAIR THE CAUSE….4799
          CONFIRM THE REPAIR….4800
        Inspection Procedure….4800
          INSTRUMENT PANEL….4800
          CENTER CONSOLE….4800
          DOORS….4800
          TRUNK….4800
          SUNROOF/HEADLINING….4801
          SEATS….4801
          UNDERHOOD….4801
        Diagnostic Worksheet….4802
    PRECAUTION….4804
      PRECAUTIONS….4804
        PRECAUTIONS….4804
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….4804
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….4804
        Precaution for Procedure without Cowl Top Cover….4804
        Precautions for Removing Battery Terminal….4805
        Handling for Adhesive and Primer….4805
    PREPARATION….4806
      PREPARATION….4806
        PREPARATION….4806
        Special Service Tools….4806
        Commercial Service Tools….4806
    REMOVAL AND INSTALLATION….4807
      WINDSHIELD GLASS….4807
        WINDSHIELD GLASS….4807
        Exploded View….4807
        Removal and Installation….4808
          REMOVAL….4808
          INSTALLATION….4808
        Inspection….4809
          REPAIRING WATER LEAKAGE FOR WINDSHIELD….4809
      SIDE WINDOW GLASS….4810
        SIDE WINDOW GLASS….4810
        Exploded View….4810
        Removal and Installation….4810
          REMOVAL….4810
          INSTALLATION….4811
        Inspection….4811
          REPAIRING WATER LEAKAGE FOR SIDE WINDOW GLASS….4811
      BACK DOOR WINDOW GLASS….4812
        BACK DOOR WINDOW GLASS….4812
        Exploded View….4812
        Removal and Installation….4812
          REMOVAL….4812
          INSTALLATION….4813
        Inspection….4813
          REPAIRING WATER LEAKAGE FOR BACK DOOR WINDOW GLASS….4813
      FRONT DOOR GLASS….4815
        FRONT DOOR GLASS….4815
        Exploded View….4815
        Removal and Installation….4815
          REMOVAL….4815
          INSTALLATION….4816
        Inspection and Adjustment….4816
          SYSTEM INITIALIZATION….4816
            Initialization….4816
          INSPECT THE FUNCTION OF THE ANTI-PINCH SYSTEM….4816
          FITTING INSPECTION….4817
      FRONT REGULATOR….4818
        FRONT REGULATOR….4818
        Exploded View….4818
        Removal and Installation….4818
          REMOVAL….4818
          INSTALLATION….4819
        Disassembly and Assembly….4819
          DISASSEMBLY….4819
          ASSEMBLY….4819
        Inspection and Adjustment….4819
          Inspection after Removal….4819
          SYSTEM INITIALIZATION….4819
            Initialization….4819
          INSPECT THE FUNCTION OF THE ANTI-PINCH SYSTEM….4820
          FITTING INSPECTION….4820
      REAR DOOR GLASS….4821
        REAR DOOR GLASS….4821
        Exploded View….4821
        Removal and Installation….4821
          REMOVAL….4821
          INSTALLATION….4823
        Inspection and Adjustment….4823
          FITTING INSPECTION….4823
      REAR REGULATOR….4824
        REAR REGULATOR….4824
        Exploded View….4824
        Removal and Installation….4824
          REMOVAL….4824
          INSTALLATION….4824
        Disassembly and Assembly….4825
          DISASSEMBLY….4825
          ASSEMBLY….4825
        Inspection and Adjustment….4825
          Inspection after Removal….4825
          FITTING INSPECTION….4825
ha….4826
  Table of Contents….4826
    VQ37VHR….4829
      VQ37VHR….4829
      BASIC INSPECTION….4829
        DIAGNOSIS AND REPAIR WORKFLOW….4829
          DIAGNOSIS AND REPAIR WORKFLOW….4829
          Work Flow….4829
            DETAILED FLOW….4829
      SYSTEM DESCRIPTION….4830
        REFRIGERATION SYSTEM….4830
          REFRIGERATION SYSTEM….4830
          System Diagram….4830
          System Description….4830
            REFRIGERANT CYCLE….4830
              Refrigerant Flow….4830
              Freeze Protection….4830
            REFRIGERANT SYSTEM PROTECTION….4830
              Refrigerant Pressure Sensor….4830
              Pressure Relief Valve….4830
          Component Parts Location….4831
          Component Description….4832
      SYMPTOM DIAGNOSIS….4833
        REFRIGERATION SYSTEM SYMPTOMS….4833
          REFRIGERATION SYSTEM SYMPTOMS….4833
          Trouble Diagnosis For Unusual Pressure….4833
          Symptom Table….4833
      PRECAUTION….4836
        PRECAUTIONS….4836
          PRECAUTIONS….4836
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….4836
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….4836
          Precaution for Procedure without Cowl Top Cover….4836
          Precautions for Removing Battery Terminal….4837
          Working with HFC-134a (R-134a)….4837
            CONTAMINATED REFRIGERANT….4837
          General Refrigerant Precaution….4837
          Refrigerant Connection….4838
            ABOUT ONE-TOUCH JOINT….4838
              Description….4838
            O-RING AND REFRIGERANT CONNECTION….4840
              O-Ring Part Numbers and Specifications….4840
          Service Equipment….4842
            RECOVERY/RECYCLING RECHARGING EQUIPMENT….4842
            ELECTRICAL LEAK DETECTOR….4842
            VACUUM PUMP….4842
            MANIFOLD GAUGE SET….4842
            SERVICE HOSES….4842
            SERVICE COUPLERS….4842
            REFRIGERANT WEIGHT SCALE….4843
            CHARGING CYLINDER….4843
        COMPRESSOR….4844
          COMPRESSOR….4844
          General Precautions….4844
        LEAK DETECTION DYE….4845
          LEAK DETECTION DYE….4845
          General Precautions….4845
            IDENTIFICATION….4845
            IDENTIFICATION LABEL FOR VEHICLE….4845
      PREPARATION….4846
        PREPARATION….4846
          PREPARATION….4846
          Special Service Tool….4846
          Commercial Service Tool….4849
          Sealant or/and Lubricant….4849
      PERIODIC MAINTENANCE….4850
        REFRIGERANT….4850
          REFRIGERANT….4850
          Collection and Charge….4850
            SETTING OF SERVICE TOOLS AND EQUIPMENT….4850
              Discharging Refrigerant….4850
              Evacuating System and Charging Refrigerant….4850
            Procedure….4850
        LUBRICANT….4854
          LUBRICANT….4854
          Maintenance of Lubricant Quantity….4854
            LUBRICANT….4854
            LUBRICANT RETURN OPERATION….4854
          Lubricant Adjusting Procedure for Components Replacement Except Compressor….4854
          Lubricant Adjusting Procedure for Compressor Replacement….4855
        REFRIGERATION SYSTEM….4857
          REFRIGERATION SYSTEM….4857
          Inspection….4857
          Performance Chart….4857
            TEST CONDITION….4857
            TEST READING….4857
          Refrigerant Leakages….4858
        FLUORESCENT LEAK DETECTOR….4859
          FLUORESCENT LEAK DETECTOR….4859
          Inspection….4859
            CHECKING SYSTEM FOR LEAKAGES USING THE FLUORESCENT LEAK DETECTOR….4859
            DYE INJECTION….4859
        ELECTRICAL LEAK DETECTOR….4860
          ELECTRICAL LEAK DETECTOR….4860
          Inspection….4860
            PRECAUTIONS FOR HANDLING LEAK DETECTOR….4860
            CHECKING PROCEDURE….4860
      REMOVAL AND INSTALLATION….4863
        COMPRESSOR….4863
          COMPRESSOR….4863
          Exploded View….4863
            REMOVAL….4863
            DISASSEMBLY….4863
          COMPRESSOR….4864
            COMPRESSOR : Removal and Installation….4864
              REMOVAL….4864
              INSTALLATION….4864
          MAGNET CLUTCH….4865
            MAGNET CLUTCH : Removal and Installation of Compressor Clutch….4865
              REMOVAL….4865
                Overhaul….4865
              INSTALLATION….4865
                Break-in Operation….4865
          Inspection….4865
            CHECK DISC TO PULLEY CLEARANCE….4865
        COOLER PIPE AND HOSE….4867
          COOLER PIPE AND HOSE….4867
          Exploded View….4867
          LOW-PRESSURE FLEXIBLE HOSE….4867
            LOW-PRESSURE FLEXIBLE HOSE : Removal and Installation….4867
              REMOVAL….4867
              INSTALLATION….4868
          HIGH-PRESSURE FLEXIBLE HOSE….4868
            HIGH-PRESSURE FLEXIBLE HOSE : Removal and Installation….4868
              REMOVAL….4868
              INSTALLATION….4869
          HIGH-PRESSURE PIPE 1….4869
            HIGH-PRESSURE PIPE 1 : Removal and Installation….4869
              REMOVAL….4869
              INSTALLATION….4870
          LOW-PRESSURE PIPE 2….4870
            LOW-PRESSURE PIPE 2 : Removal and Installation….4870
              REMOVAL….4870
              INSTALLATION….4871
          LOW-PRESSURE PIPE 1 AND HIGH-PRESSURE PIPE 2….4871
            LOW-PRESSURE PIPE 1 AND HIGH-PRESSURE PIPE 2 : Removal and Installation….4871
              REMOVAL….4871
              INSTALLATION….4873
        CONDENSER….4874
          CONDENSER….4874
          Exploded View….4874
          CONDENSER….4874
            CONDENSER : Removal and Installation….4874
              REMOVAL….4874
              INSTALLATION….4875
          CONDENSER PIPE ASSEMBLY….4875
            CONDENSER PIPE ASSEMBLY : Removal and Installation….4875
              REMOVAL….4875
              INSTALLATION….4876
          LIQUID TANK….4876
            LIQUID TANK : Removal and Installation….4876
              REMOVAL….4876
              INSTALLATION….4877
          REFRIGERANT PRESSURE SENSOR….4877
            REFRIGERANT PRESSURE SENSOR : Removal and Installation….4877
              REMOVAL….4877
              INSTALLATION….4877
        HEATER & COOLING UNIT ASSEMBLY….4878
          HEATER & COOLING UNIT ASSEMBLY….4878
          Exploded View….4878
            DISASSEMBLY….4878
          HEATER & COOLING UNIT ASSEMBLY….4880
            HEATER & COOLING UNIT ASSEMBLY : ….4880
              REMOVAL….4880
              INSTALLATION….4882
          HEATER CORE….4882
            HEATER CORE : Removal and Installation….4882
              REMOVAL….4882
              INSTALLATION….4882
          EVAPORATOR….4882
            EVAPORATOR : Removal and Installation….4882
              REMOVAL….4882
              INSTALLATION….4883
          EXPANSION VALVE….4883
            EXPANSION VALVE : Removal and Installation….4883
              REMOVAL….4883
              INSTALLATION….4883
        BLOWER UNIT….4884
          BLOWER UNIT….4884
          Exploded View….4884
          BLOWER UNIT….4884
            BLOWER UNIT : Removal and Installation….4884
              REMOVAL….4884
              INSTALLATION….4885
          BLOWER MOTOR….4885
            BLOWER MOTOR : Removal and Installation….4885
              REMOVAL….4885
              INSTALLATION….4885
      SERVICE DATA AND SPECIFICATIONS (SDS)….4886
        SERVICE DATA AND SPECIFICATIONS (SDS)….4886
          SERVICE DATA AND SPECIFICATIONS (SDS)….4886
          Compressor….4886
          Lubricant….4886
          Refrigerant….4886
          Engine Idling Speed….4886
          Belt Tension….4886
    VK50VE….4887
      VK50VE….4887
      BASIC INSPECTION….4887
        DIAGNOSIS AND REPAIR WORKFLOW….4887
          DIAGNOSIS AND REPAIR WORKFLOW….4887
          Work Flow….4887
            DETAILED FLOW….4887
      SYSTEM DESCRIPTION….4888
        REFRIGERATION SYSTEM….4888
          REFRIGERATION SYSTEM….4888
          System Diagram….4888
          System Description….4888
            REFRIGERANT CYCLE….4888
              Refrigerant Flow….4888
              Freeze Protection….4888
            REFRIGERANT SYSTEM PROTECTION….4888
              Refrigerant Pressure Sensor….4888
              Pressure Relief Valve….4888
          Component Parts Location….4889
          Component Description….4890
      SYMPTOM DIAGNOSIS….4891
        REFRIGERATION SYSTEM SYMPTOMS….4891
          REFRIGERATION SYSTEM SYMPTOMS….4891
          Trouble Diagnosis For Unusual Pressure….4891
          Symptom Table….4891
      PRECAUTION….4894
        PRECAUTIONS….4894
          PRECAUTIONS….4894
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….4894
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….4894
          Precaution for Procedure without Cowl Top Cover….4894
          Precautions for Removing Battery Terminal….4895
          Working with HFC-134a (R-134a)….4895
            CONTAMINATED REFRIGERANT….4895
          General Refrigerant Precaution….4895
          Refrigerant Connection….4896
            ABOUT ONE-TOUCH JOINT….4896
              Description….4896
            O-RING AND REFRIGERANT CONNECTION….4898
              O-Ring Part Numbers and Specifications….4898
          Service Equipment….4899
            RECOVERY/RECYCLING RECHARGING EQUIPMENT….4899
            ELECTRICAL LEAK DETECTOR….4900
            VACUUM PUMP….4900
            MANIFOLD GAUGE SET….4900
            SERVICE HOSES….4900
            SERVICE COUPLERS….4900
            REFRIGERANT WEIGHT SCALE….4901
            CHARGING CYLINDER….4901
        COMPRESSOR….4902
          COMPRESSOR….4902
          General Precautions….4902
        LEAK DETECTION DYE….4903
          LEAK DETECTION DYE….4903
          General Precautions….4903
            IDENTIFICATION….4903
            IDENTIFICATION LABEL FOR VEHICLE….4903
      PREPARATION….4904
        PREPARATION….4904
          PREPARATION….4904
          Special Service Tool….4904
          Commercial Service Tool….4907
          Sealant or/and Lubricant….4907
      PERIODIC MAINTENANCE….4908
        REFRIGERANT….4908
          REFRIGERANT….4908
          Collection and Charge….4908
            SETTING OF SERVICE TOOLS AND EQUIPMENT….4908
              Discharging Refrigerant….4908
              Evacuating System and Charging Refrigerant….4908
            Procedure….4908
        LUBRICANT….4912
          LUBRICANT….4912
          Maintenance of Lubricant Quantity….4912
            LUBRICANT….4912
            LUBRICANT RETURN OPERATION….4912
          Lubricant Adjusting Procedure for Components Replacement Except Compressor….4912
          Lubricant Adjusting Procedure for Compressor Replacement….4913
        REFRIGERATION SYSTEM….4915
          REFRIGERATION SYSTEM….4915
          Inspection….4915
          Performance Chart….4915
            TEST CONDITION….4915
            TEST READING….4915
          Refrigerant Leakages….4916
        FLUORESCENT LEAK DETECTOR….4917
          FLUORESCENT LEAK DETECTOR….4917
          Inspection….4917
            CHECKING SYSTEM FOR LEAKAGES USING THE FLUORESCENT LEAK DETECTOR….4917
            DYE INJECTION….4917
        ELECTRICAL LEAK DETECTOR….4918
          ELECTRICAL LEAK DETECTOR….4918
          Inspection….4918
            PRECAUTIONS FOR HANDLING LEAK DETECTOR….4918
            CHECKING PROCEDURE….4918
      REMOVAL AND INSTALLATION….4921
        COMPRESSOR….4921
          COMPRESSOR….4921
          Exploded View….4921
          Removal and Installation….4921
            REMOVAL….4921
            INSTALLATION….4922
          Inspection….4922
            CHECK DISC TO PULLEY CLEARANCE….4922
        COOLER PIPE AND HOSE….4923
          COOLER PIPE AND HOSE….4923
          Exploded View….4923
          LOW-PRESSURE FLEXIBLE HOSE….4923
            LOW-PRESSURE FLEXIBLE HOSE : Removal and Installation….4923
              REMOVAL….4923
              INSTALLATION….4924
          HIGH-PRESSURE FLEXIBLE HOSE….4924
            HIGH-PRESSURE FLEXIBLE HOSE : Removal and Installation….4924
              REMOVAL….4924
              INSTALLATION….4925
          HIGH-PRESSURE PIPE 1….4925
            HIGH-PRESSURE PIPE 1 : Removal and Installation….4925
              REMOVAL….4925
              INSTALLATION….4926
          LOW-PRESSURE PIPE 2….4926
            LOW-PRESSURE PIPE 2 : Removal and Installation….4926
              REMOVAL….4926
              INSTALLATION….4927
          LOW-PRESSURE PIPE 3….4927
            LOW-PRESSURE PIPE 3 : Removal and Installation….4927
              REMOVAL….4927
              INSTALLATION….4928
          LOW-PRESSURE PIPE 1 AND HIGH-PRESSURE PIPE 2….4928
            LOW-PRESSURE PIPE 1 AND HIGH-PRESSURE PIPE 2 : Removal and Installation….4928
              REMOVAL….4928
              INSTALLATION….4930
        CONDENSER….4931
          CONDENSER….4931
          Exploded View….4931
          CONDENSER….4931
            CONDENSER : Removal and Installation….4931
              REMOVAL….4931
              INSTALLATION….4932
          CONDENSER PIPE ASSEMBLY….4932
            CONDENSER PIPE ASSEMBLY : Removal and Installation….4932
              REMOVAL….4932
              INSTALLATION….4933
          LIQUID TANK….4933
            LIQUID TANK : Removal and Installation….4933
              REMOVAL….4933
              INSTALLATION….4933
          REFRIGERANT PRESSURE SENSOR….4934
            REFRIGERANT PRESSURE SENSOR : Removal and Installation….4934
              REMOVAL….4934
              INSTALLATION….4934
        HEATER & COOLING UNIT ASSEMBLY….4935
          HEATER & COOLING UNIT ASSEMBLY….4935
          Exploded View….4935
            DISASSEMBLY….4935
          HEATER & COOLING UNIT ASSEMBLY….4937
            HEATER & COOLING UNIT ASSEMBLY : ….4937
              REMOVAL….4937
              INSTALLATION….4939
          HEATER CORE….4939
            HEATER CORE : Removal and Installation….4939
              REMOVAL….4939
              INSTALLATION….4939
          EVAPORATOR….4939
            EVAPORATOR : Removal and Installation….4939
              REMOVAL….4939
              INSTALLATION….4940
          EXPANSION VALVE….4940
            EXPANSION VALVE : Removal and Installation….4940
              REMOVAL….4940
              INSTALLATION….4940
        BLOWER UNIT….4941
          BLOWER UNIT….4941
          Exploded View….4941
          BLOWER UNIT….4941
            BLOWER UNIT : Removal and Installation….4941
              REMOVAL….4941
              INSTALLATION….4942
          BLOWER MOTOR….4942
            BLOWER MOTOR : Removal and Installation….4942
              REMOVAL….4942
              INSTALLATION….4942
      SERVICE DATA AND SPECIFICATIONS (SDS)….4943
        SERVICE DATA AND SPECIFICATIONS (SDS)….4943
          SERVICE DATA AND SPECIFICATIONS (SDS)….4943
          Compressor….4943
          Lubricant….4943
          Refrigerant….4943
          Engine Idling Speed….4943
          Belt Tension….4943
hac….4944
  Table of Contents….4944
    AUTOMATIC AIR CONDITIONER….4947
      AUTOMATIC AIR CONDITIONER….4947
      BASIC INSPECTION….4947
        DIAGNOSIS AND REPAIR WORKFLOW….4947
          DIAGNOSIS AND REPAIR WORKFLOW….4947
          Work Flow….4947
            OVERALL SEQUENCE….4947
            DETAILED FLOW….4947
        INSPECTION AND ADJUSTMENT….4950
          INSPECTION AND ADJUSTMENT….4950
          WITHOUT ACCS….4950
            WITHOUT ACCS : Description & Inspection….4950
              DESCRIPTION….4950
              INSPECTION PROCEDURE….4950
            WITHOUT ACCS : Temperature Setting Trimmer….4951
              DESCRIPTION….4951
            WITHOUT ACCS : Foot Position Setting Trimmer….4952
              DESCRIPTION….4952
            WITHOUT ACCS : Inlet Port Memory Function….4953
              DESCRIPTION….4953
          WITH ACCS….4953
            WITH ACCS : Description & Inspection….4953
              DESCRIPTION….4953
              INSPECTION PROCEDURE….4953
            WITH ACCS : Temperature Setting Trimmer….4956
              DESCRIPTION….4956
            WITH ACCS : Foot Position Setting Trimmer….4957
              DESCRIPTION….4957
            WITH ACCS : Inlet Port Memory Function….4958
              DESCRIPTION….4958
            WITH ACCS : Exhaust exhaust gas/outside odor detecting/Outside Odor Detecting Sensor Sensitivity Adjustment Function….4958
              DESCRIPTION….4958
            WITH ACCS : Auto Intake Interlocking Movement Change Function….4959
              DESCRIPTION….4959
      SYSTEM DESCRIPTION….4960
        COMPRESSOR CONTROL FUNCTION….4960
          COMPRESSOR CONTROL FUNCTION….4960
          WITHOUT ACCS….4960
            WITHOUT ACCS : Description….4960
              PRINCIPLE OF OPERATION….4960
                Functional circuit diagram….4960
                Functional initial inspection chart….4960
            WITHOUT ACCS : Fail-safe….4960
              FAIL-SAFE FUNCTION….4960
            WITHOUT ACCS : Component Part Location….4961
              ENGINE COMPARTMENT….4961
              PASSENGER COMPARTMENT….4962
            WITHOUT ACCS : Component Description….4964
          WITH ACCS….4964
            WITH ACCS : Description….4964
              PRINCIPLE OF OPERATION….4964
                Functional circuit diagram….4964
                Functional initial inspection chart….4965
            WITH ACCS : Fail-safe….4965
              FAIL-SAFE FUNCTION….4965
            WITH ACCS : Component Part Location….4965
              ENGINE COMPARTMENT….4965
              PASSENGER COMPARTMENT….4966
            WITH ACCS : Component Description….4967
        AUTOMATIC AIR CONDITIONER SYSTEM….4969
          AUTOMATIC AIR CONDITIONER SYSTEM….4969
          WITHOUT ACCS….4969
            WITHOUT ACCS : System Diagram….4969
              CONTROL SYSTEM….4969
            WITHOUT ACCS : System Description….4969
              CONTROL OPERATION….4969
                Display Screen….4969
                Preset Switch….4970
                MODE Switch….4970
                Temperature Control Dial (Potentio Temperature Control) (Driver Side) ….4970
                Temperature Control Dial (Potentio Temperature Control) (Passenger Side) ….4970
                AUTO Switch ….4970
                Defroster (DEF) Switch….4970
                A/C Switch….4970
                FAN Switches….4970
                OFF Switch….4970
                Rear Window Defogger Switch….4970
                Intake Switch….4970
                DUAL Switch….4970
              DISCHARGE AIR FLOW….4971
              SWITCHES AND THEIR CONTROL FUNCTION….4972
              AIR CONDITIONER LAN CONTROL SYSTEM….4972
              SYSTEM CONSTRUCTION….4973
                Operation….4973
                Transmission Data and Transmission Order….4973
            WITHOUT ACCS : Component Part Location….4974
              ENGINE COMPARTMENT….4974
              PASSENGER COMPARTMENT….4975
            WITHOUT ACCS : Component Description….4977
          WITH ACCS….4977
            WITH ACCS : System Diagram….4977
              CONTROL SYSTEM….4977
            WITH ACCS : System Description….4978
              CONTROL OPERATION….4978
                Display Screen….4978
                Preset Switch….4979
                MODE Switch….4979
                Temperature Control Dial (Potentio Temperature Control) (Driver Side) ….4979
                Temperature Control Dial (Potentio Temperature Control) (Passenger Side) ….4979
                AUTO Switch ….4979
                Defroster (DEF) Switch….4979
                A/C Switch….4979
                FAN Switches….4979
                OFF Switch….4979
                Rear Window Defogger Switch….4979
                Intake Switch….4979
                DUAL Switch….4979
              DISCHARGE AIR FLOW….4980
              SWITCHES AND THEIR CONTROL FUNCTION….4981
              AIR CONDITIONER LAN CONTROL SYSTEM….4981
              SYSTEM CONSTRUCTION….4982
                Operation….4982
                Transmission Data and Transmission Order….4982
            WITH ACCS : Component Part Location….4983
              ENGINE COMPARTMENT….4983
              PASSENGER COMPARTMENT….4984
            WITH ACCS : Component Description….4985
        PLASMACLUSTER SYSTEM….4987
          PLASMACLUSTER SYSTEM….4987
          System Diagram….4987
          System Description….4987
            OPERATION DESCRIPTION….4987
          Component Part Location….4988
          Component Description….4989
        CAN COMMUNICATION SYSTEM….4990
          CAN COMMUNICATION SYSTEM….4990
          System Description….4990
        MODE DOOR CONTROL SYSTEM….4991
          MODE DOOR CONTROL SYSTEM….4991
          System Diagram….4991
          System Description….4991
            SYSTEM OPERATION….4991
              Door Motor Circuit….4991
              Mode Door Control Specification….4991
        AIR MIX DOOR CONTROL SYSTEM….4993
          AIR MIX DOOR CONTROL SYSTEM….4993
          System Diagram….4993
          System Description….4993
            SYSTEM OPERATION….4993
              Door Motor Circuit….4993
              Air Mix Door Control Specification….4993
              Potentio Temperature Control (PTC)….4994
        INTAKE DOOR CONTROL SYSTEM….4995
          INTAKE DOOR CONTROL SYSTEM….4995
          WITHOUT ACCS….4995
            WITHOUT ACCS : System Diagram….4995
            WITHOUT ACCS : System Description….4995
              SYSTEM OPERATION….4995
                Door Motor Circuit….4995
                Intake Door Control Specification….4995
          WITH ACCS….4996
            WITH ACCS : System Diagram….4996
            WITH ACCS : System Description….4996
              SYSTEM OPERATION….4996
                Door Motor Circuit….4997
                Intake Door Control Specification….4997
                Automatic intake control (exhaust gas/outside odor detecting mechanism)….4997
        BLOWER MOTOR CONTROL SYSTEM….4998
          BLOWER MOTOR CONTROL SYSTEM….4998
          System Diagram….4998
          System Description….4998
            SYSTEM OPERATION….4998
              Automatic Mode….4998
              Starting Fan Speed Control….4998
              Blower Speed Compensation….4998
              Fan Speed Control Specification….4999
        MAGNET CLUTCH CONTROL SYSTEM….5000
          MAGNET CLUTCH CONTROL SYSTEM….5000
          System Diagram….5000
          System Description….5000
            SYSTEM OPERATION….5000
              Compressor Protection Control….5000
              Low Temperature Protection Control….5000
        DIAGNOSIS SYSTEM (UNIFIED METER & A/C AMP.)….5002
          DIAGNOSIS SYSTEM (UNIFIED METER & A/C AMP.)….5002
          WITHOUT ACCS….5002
            WITHOUT ACCS : Diagnosis Description….5002
              SELF-DIAGNOSIS SYSTEM….5002
              SELF-DIAGNOSIS FUNCTION….5002
              CONFORMATION METHOD….5003
            WITHOUT ACCS : CONSULT Function….5007
              CONSULT APPLICATION ITEMS….5007
              DATA MONITOR….5007
          WITH ACCS….5007
            WITH ACCS : Diagnosis Description….5007
              SELF-DIAGNOSIS SYSTEM….5007
              SELF-DIAGNOSIS FUNCTION….5007
              CONFORMATION METHOD….5008
            WITH ACCS : CONSULT Function….5012
              CONSULT APPLICATION ITEMS….5012
              DATA MONITOR….5012
      DTC/CIRCUIT DIAGNOSIS….5013
        POWER SUPPLY AND GROUND CIRCUIT….5013
          POWER SUPPLY AND GROUND CIRCUIT….5013
          UNIFIED METER AND A/C AMP…5013
            UNIFIED METER AND A/C AMP. : Diagnosis Procedure….5013
        UNIFIED METER AND A/C AMP…5014
          UNIFIED METER AND A/C AMP…5014
          Description….5014
            COMPONENT DESCRIPTION….5014
              Unified Meter and A/C Amp. (Automatic Amplifier)….5014
          Component Function Check….5014
          Diagnosis Procedure….5014
        MODE DOOR MOTOR….5015
          MODE DOOR MOTOR….5015
          Description….5015
            COMPONENT DESCRIPTION….5015
              Mode Door Motor….5015
          Component Function Check….5015
          Diagnosis Procedure….5015
        AIR MIX DOOR MOTOR (DRIVER SIDE)….5017
          AIR MIX DOOR MOTOR (DRIVER SIDE)….5017
          Description….5017
            COMPONENT DESCRIPTION….5017
              Air Mix Door Motor….5017
          Component Function Check….5017
          Diagnosis Procedure….5017
        AIR MIX DOOR MOTOR (PASSENGER SIDE)….5019
          AIR MIX DOOR MOTOR (PASSENGER SIDE)….5019
          Description….5019
            COMPONENT DESCRIPTION….5019
              Air Mix Door Motor….5019
          Component Function Check….5019
          Diagnosis Procedure….5019
        INTAKE DOOR MOTOR….5021
          INTAKE DOOR MOTOR….5021
          WITHOUT ACCS….5021
            WITHOUT ACCS : Description….5021
              COMPONENT DESCRIPTION….5021
                Intake Door Motor….5021
            WITHOUT ACCS : Component Function Check….5021
            WITHOUT ACCS : Diagnosis Procedure….5021
          WITH ACCS….5022
            WITH ACCS : Description….5022
              COMPONENT DESCRIPTION….5022
                Intake Door Motor….5022
            WITH ACCS : Component Function Check….5022
            WITH ACCS : Diagnosis Procedure….5023
        BLOWER MOTOR….5025
          BLOWER MOTOR….5025
          Description….5025
            COMPONENT DESCRIPTION….5025
              Brush-less Motor….5025
          Component Function Check….5025
          Diagnosis Procedure….5025
          Component Inspection….5028
        MAGNET CLUTCH….5029
          MAGNET CLUTCH….5029
          Description….5029
          Component Function Check….5029
          Diagnosis Procedure….5029
        ECV (ELECTRICAL CONTROL VALVE)….5031
          ECV (ELECTRICAL CONTROL VALVE)….5031
          Description….5031
          Diagnosis Procedure….5031
        AMBIENT SENSOR….5033
          AMBIENT SENSOR….5033
          Description….5033
            COMPONENT DESCRIPTION….5033
              Ambient Sensor….5033
            AMBIENT TEMPERATURE INPUT PROCESS….5033
          Component Function Check….5033
          Diagnosis Procedure….5033
          Component Inspection….5034
        IN-VEHICLE SENSOR….5036
          IN-VEHICLE SENSOR….5036
          Description….5036
          Component Function Check….5036
          Diagnosis Procedure….5036
          Component Inspection….5037
        SUNLOAD SENSOR….5039
          SUNLOAD SENSOR….5039
          Description….5039
            COMPONENT DESCRIPTION….5039
              Sunload Sensor….5039
            SUNLOAD INPUT PROCESS….5039
          Component Function Check….5039
          Diagnosis Procedure….5039
          Component Inspection….5040
        INTAKE SENSOR….5042
          INTAKE SENSOR….5042
          Description….5042
          Component Function Check….5042
          Diagnosis Procedure….5042
          Component Inspection….5043
        EXHAUST GAS/OUTSIDE ODOR DETECTING SENSOR….5044
          EXHAUST GAS/OUTSIDE ODOR DETECTING SENSOR….5044
          Description….5044
            COMPONENT DESCRIPTION….5044
            STRUCTURE AND OPERATION….5044
          Component Function Check….5044
          Diagnosis Procedure….5044
        IONIZER….5047
          IONIZER….5047
          Description….5047
          Component Function Check….5047
          Diagnosis Procedure….5047
      ECU DIAGNOSIS INFORMATION….5049
        UNIFIED METER AND A/C AMP…5049
          UNIFIED METER AND A/C AMP…5049
          Reference Value….5049
            TERMINAL LAYOUT….5049
            PHYSICAL VALUES….5049
          Wiring Diagram – AIR CONDITIONER CONTROL SYSTEM -….5051
          Fail-safe….5060
            FAIL-SAFE FUNCTION….5060
        ECM….5062
          ECM….5062
          VQ37VHR FOR USA AND CANADA….5062
            VQ37VHR FOR USA AND CANADA : Reference Value….5062
              VALUES ON THE DIAGNOSIS TOOL….5062
              TERMINAL LAYOUT….5067
              PHYSICAL VALUES….5067
          VQ37VHR FOR MEXICO….5078
            VQ37VHR FOR MEXICO : Reference Value….5078
              VALUES ON THE DIAGNOSIS TOOL….5078
              TERMINAL LAYOUT….5083
              PHYSICAL VALUES….5083
          VK50VE….5093
            VK50VE : Reference Value….5093
              VALUES ON THE DIAGNOSIS TOOL….5093
              TERMINAL LAYOUT….5099
              PHYSICAL VALUES….5099
      SYMPTOM DIAGNOSIS….5112
        AIR CONDITIONER CONTROL….5112
          AIR CONDITIONER CONTROL….5112
          Diagnosis Chart By Symptom….5112
        INSUFFICIENT COOLING….5113
          INSUFFICIENT COOLING….5113
          Description….5113
          Inspection procedure….5113
        INSUFFICIENT HEATING….5115
          INSUFFICIENT HEATING….5115
          Description….5115
          Inspection procedure….5115
        NOISE….5117
          NOISE….5117
          Description….5117
          Inspection procedure….5117
        SELF-DIAGNOSIS CANNOT BE PERFORMED….5119
          SELF-DIAGNOSIS CANNOT BE PERFORMED….5119
          Description….5119
          Inspection procedure….5119
        MEMORY FUNCTION DOES NOT OPERATE….5120
          MEMORY FUNCTION DOES NOT OPERATE….5120
          Description….5120
          Inspection procedure….5120
      PRECAUTION….5121
        PRECAUTIONS….5121
          PRECAUTIONS….5121
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….5121
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….5121
          Precautions Necessary for Steering Wheel Rotation After Battery Disconnection….5121
            OPERATION PROCEDURE….5121
          Precaution for Procedure without Cowl Top Cover….5122
          Working with HFC-134a (R-134a)….5122
            CONTAMINATED REFRIGERANT….5122
          General Refrigerant Precaution….5122
          Refrigerant Connection….5123
            ABOUT ONE-TOUCH JOINT….5123
              Description….5123
            O-RING AND REFRIGERANT CONNECTION….5125
              O-Ring Part Numbers and Specifications….5126
          Service Equipment….5127
            RECOVERY/RECYCLING RECHARGING EQUIPMENT….5127
            ELECTRICAL LEAK DETECTOR….5127
            VACUUM PUMP….5127
            MANIFOLD GAUGE SET….5128
            SERVICE HOSES….5128
            SERVICE COUPLERS….5128
            REFRIGERANT WEIGHT SCALE….5129
            CHARGING CYLINDER….5129
        COMPRESSOR….5130
          COMPRESSOR….5130
          VQ37VHR….5130
            VQ37VHR : General Precautions….5130
          VK50VE….5130
            VK50VE : General Precautions….5130
        LEAK DETECTION DYE….5131
          LEAK DETECTION DYE….5131
          General Precautions….5131
            IDENTIFICATION….5131
            IDENTIFICATION LABEL FOR VEHICLE….5131
      PREPARATION….5132
        PREPARATION….5132
          PREPARATION….5132
          Special Service Tool….5132
          Commercial Service Tool….5135
          Sealant or/and Lubricant….5135
      REMOVAL AND INSTALLATION….5136
        PRESET SWITCH….5136
          PRESET SWITCH….5136
          Exploded View….5136
          Removal and Installation….5136
            REMOVAL….5136
            INSTALLATION….5136
        UNIFIED METER AND A/C AMP…5137
          UNIFIED METER AND A/C AMP…5137
          Exploded View….5137
          Removal and Installation….5137
            REMOVAL….5137
            INSTALLATION….5137
        AMBIENT SENSOR….5138
          AMBIENT SENSOR….5138
          Exploded View….5138
          Removal and Installation….5138
            REMOVAL….5138
            INSTALLATION….5138
        IN-VEHICLE SENSOR….5139
          IN-VEHICLE SENSOR….5139
          Exploded View….5139
          Removal and Installation….5139
            REMOVAL….5139
            INSTALLATION….5139
        SUNLOAD SENSOR….5140
          SUNLOAD SENSOR….5140
          Exploded View….5140
          Removal and Installation….5140
            REMOVAL….5140
            INSTALLATION….5140
        INTAKE SENSOR….5141
          INTAKE SENSOR….5141
          Exploded View….5141
          Removal and Installation….5142
            REMOVAL….5142
            INSTALLATION….5142
        EXHAUST GAS/OUTSIDE ODOR DETECTING SENSOR….5143
          EXHAUST GAS/OUTSIDE ODOR DETECTING SENSOR….5143
          Exploded View….5143
          Removal and Installation….5143
            REMOVAL….5143
            INSTALLATION….5143
        REFRIGERANT PRESSURE SENSOR….5144
          REFRIGERANT PRESSURE SENSOR….5144
          Exploded View….5144
          Removal and Installation….5144
            REMOVAL….5144
            INSTALLATION….5144
        DOOR MOTOR….5145
          DOOR MOTOR….5145
          Exploded View….5145
          MODE DOOR MOTOR….5145
            MODE DOOR MOTOR : Removal and Installation….5145
              REMOVAL….5145
              INSTALLATION….5146
          AIR MIX DOOR MOTOR….5146
            AIR MIX DOOR MOTOR : Removal and Installation….5146
              REMOVAL….5146
                Driver Side….5146
                Passenger Side….5146
              INSTALLATION….5146
          INTAKE DOOR MOTOR….5147
            INTAKE DOOR MOTOR : Removal and Installation….5147
              REMOVAL….5147
              INSTALLATION….5147
        IONIZER….5148
          IONIZER….5148
          Exploded View….5148
          Removal and Installation….5148
            REMOVAL….5148
            INSTALLATION….5148
hrn….5149
  Table of Contents….5149
    DTC/CIRCUIT DIAGNOSIS….5150
      HORN….5150
        HORN….5150
        Wiring Diagram – HORN -….5150
    PRECAUTION….5154
      PRECAUTIONS….5154
        PRECAUTIONS….5154
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….5154
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….5154
        Precautions for Removing Battery Terminal….5154
    REMOVAL AND INSTALLATION….5155
      HORN….5155
        HORN….5155
        Exploded View….5155
        Removal and Installation….5155
          REMOVAL….5155
            Horn (LOW)….5155
            Horn (HIGH)….5155
          INSTALLATION….5155
inl….5156
  Table of Contents….5156
    BASIC INSPECTION….5159
      DIAGNOSIS AND REPAIR WORK FLOW….5159
        DIAGNOSIS AND REPAIR WORK FLOW….5159
        Work Flow….5159
          OVERALL SEQUENCE….5159
          DETAILED FLOW….5159
    SYSTEM DESCRIPTION….5162
      INTERIOR ROOM LAMP CONTROL SYSTEM….5162
        INTERIOR ROOM LAMP CONTROL SYSTEM….5162
        System Diagram….5162
        System Description….5162
          OUTLINE….5162
            Total Illumination Control Unit….5163
            BCM….5163
          HOSPITALITY LIGHTING SYSTEM….5163
          TOTAL ILLUMINATION CONTROL UNIT….5165
          INTERIOR ROOM LAMP TIMER CONTROL….5165
          STEP LAMP CONTROL….5165
        Component Parts Location….5166
        Component Description….5167
      INTERIOR ROOM LAMP BATTERY SAVER SYSTEM….5168
        INTERIOR ROOM LAMP BATTERY SAVER SYSTEM….5168
        System Diagram….5168
        System Description….5168
          OUTLINE….5168
            Applicable lamps….5168
          INTERIOR ROOM LAMP BATTERY SAVER FUNCTION….5168
        Component Parts Location….5169
        Component Description….5170
      ILLUMINATION CONTROL SYSTEM….5171
        ILLUMINATION CONTROL SYSTEM….5171
        System Diagram….5171
        System Description….5171
          OUTLINE….5171
          ILLUMINATION CONTROL….5171
        Component Parts Location….5172
        Component Description….5173
      DIAGNOSIS SYSTEM (TOTAL ILLUMINATION CONTROL UNIT)….5174
        DIAGNOSIS SYSTEM (TOTAL ILLUMINATION CONTROL UNIT)….5174
        CONSULT Function (TOTAL ILLUM C/U)….5174
          APPLICATION ITEM….5174
          WORK SUPPORT….5174
          DATA MONITOR….5174
          ACTIVE TEST….5175
      DIAGNOSIS SYSTEM (BCM)….5177
        DIAGNOSIS SYSTEM (BCM)….5177
        COMMON ITEM….5177
          COMMON ITEM : CONSULT Function (BCM – COMMON ITEM)….5177
            APPLICATION ITEM….5177
            SYSTEM APPLICATION….5177
            FREEZE FRAME DATA (FFD)….5177
        INT LAMP….5178
          INT LAMP : CONSULT Function (BCM – INT LAMP)….5178
            WORK SUPPORT….5178
            DATA MONITOR….5179
            ACTIVE TEST….5180
        BATTERY SAVER….5180
          BATTERY SAVER : CONSULT Function (BCM – BATTERY SAVER)….5180
            WORK SUPPORT….5180
            DATA MONITOR….5180
            ACTIVE TEST….5181
    DTC/CIRCUIT DIAGNOSIS….5182
      POWER SUPPLY AND GROUND CIRCUIT….5182
        POWER SUPPLY AND GROUND CIRCUIT….5182
        TOTAL ILLUMINATION CONTROL UNIT….5182
          TOTAL ILLUMINATION CONTROL UNIT : Diagnosis Procedure….5182
        BCM….5182
          BCM : Diagnosis Procedure….5182
      INTERIOR ROOM LAMP POWER SUPPLY CIRCUIT….5184
        INTERIOR ROOM LAMP POWER SUPPLY CIRCUIT….5184
        Description….5184
        Diagnosis Procedure….5184
      BATTERY SAVER SIGNAL CIRCUIT….5186
        BATTERY SAVER SIGNAL CIRCUIT….5186
        Description….5186
        Diagnosis Procedure….5186
      HOSPITALITY LIGHTING POWER SUPPLY CIRCUIT 1….5187
        HOSPITALITY LIGHTING POWER SUPPLY CIRCUIT 1….5187
        Description….5187
        Diagnosis Procedure….5187
      HOSPITALITY LIGHTING POWER SUPPLY CIRCUIT 2….5190
        HOSPITALITY LIGHTING POWER SUPPLY CIRCUIT 2….5190
        Description….5190
        Diagnosis Procedure….5190
      HOSPITALITY LIGHTING POWER SUPPLY CIRCUIT 3….5192
        HOSPITALITY LIGHTING POWER SUPPLY CIRCUIT 3….5192
        Description….5192
        Diagnosis Procedure….5192
      MAP LAMP CIRCUIT….5194
        MAP LAMP CIRCUIT….5194
        Description….5194
        Component Function Check….5194
        Diagnosis Procedure….5194
      PERSONAL LAMP CIRCUIT….5196
        PERSONAL LAMP CIRCUIT….5196
        Description….5196
        Component Function Check….5196
        Diagnosis Procedure….5196
      CENTER CONSOLE INDIRECT ILLUMINATION CIRCUIT….5198
        CENTER CONSOLE INDIRECT ILLUMINATION CIRCUIT….5198
        Description….5198
        Component Function Check….5198
        Diagnosis Procedure….5198
      FOOT LAMP CIRCUIT….5200
        FOOT LAMP CIRCUIT….5200
        Description….5200
        Component Function Check….5200
        Diagnosis Procedure….5200
      PUDDLE LAMP CIRCUIT….5203
        PUDDLE LAMP CIRCUIT….5203
        Description….5203
        Component Function Check….5203
        Diagnosis Procedure….5203
      MOOD LAMP (FRONT DOOR ARMREST) CIRCUIT ….5205
        MOOD LAMP (FRONT DOOR ARMREST) CIRCUIT ….5205
        Description….5205
        Component Function Check….5205
        Diagnosis Procedure….5205
      PUSH-BUTTON IGNITION SWITCH ILLUMINATION CIRCUIT….5207
        PUSH-BUTTON IGNITION SWITCH ILLUMINATION CIRCUIT….5207
        Description….5207
        Component Function Check….5207
        Diagnosis Procedure….5207
      MOOD LAMP (REAR DOOR ARMREST) CIRCUIT ….5209
        MOOD LAMP (REAR DOOR ARMREST) CIRCUIT ….5209
        Description….5209
        Component Function Check….5209
        Diagnosis Procedure….5209
      HOSPITALITY ILLUMINATION CIRCUIT….5211
        HOSPITALITY ILLUMINATION CIRCUIT….5211
        Description….5211
        Component Function Check….5211
        Diagnosis Procedure….5211
      STEP LAMP CIRCUIT….5214
        STEP LAMP CIRCUIT….5214
        Description….5214
        Component Function Check….5214
        Diagnosis Procedure….5214
      TAIL LAMP SIGNAL CIRCUIT….5216
        TAIL LAMP SIGNAL CIRCUIT….5216
        Description….5216
        Component Function Check….5216
        Diagnosis Procedure….5216
      ILLUMINATION CONTROL SIGNAL CIRCUIT….5218
        ILLUMINATION CONTROL SIGNAL CIRCUIT….5218
        Component Function Check….5218
        Diagnosis Procedure….5218
      MAP LAMP SWITCH CIRCUIT….5220
        MAP LAMP SWITCH CIRCUIT….5220
        Component Function Check….5220
        Diagnosis Procedure….5220
      DOOR SWITCH CIRCUIT….5222
        DOOR SWITCH CIRCUIT….5222
        Component Function Check….5222
        Diagnosis Procedure….5222
      ROOM LAMP REQUEST SIGNAL CIRCUIT….5226
        ROOM LAMP REQUEST SIGNAL CIRCUIT….5226
        Component Function Check….5226
        Diagnosis Procedure….5226
        Diagnosis Procedure….5227
      INTERIOR ROOM LAMP CONTROL SYSTEM….5228
        INTERIOR ROOM LAMP CONTROL SYSTEM….5228
        Wiring Diagram – INTERIOR ROOM LAMP -….5228
      ILLUMINATION….5245
        ILLUMINATION….5245
        Wiring Diagram – ILLUMINATION -….5245
    ECU DIAGNOSIS INFORMATION….5260
      TOTAL ILLUMINATION CONTROL UNIT….5260
        TOTAL ILLUMINATION CONTROL UNIT….5260
        Reference Value….5260
          VALUES ON THE DIAGNOSIS TOOL….5260
          TERMINAL LAYOUT….5261
          PHYSICAL VALUES….5261
        Wiring Diagram – INTERIOR ROOM LAMP -….5268
        Wiring Diagram – ILLUMINATION -….5285
      BCM (BODY CONTROL MODULE)….5300
        BCM (BODY CONTROL MODULE)….5300
        Reference Value….5300
          VALUES ON THE DIAGNOSIS TOOL….5300
          TERMINAL LAYOUT….5305
          PHYSICAL VALUES….5305
        Wiring Diagram – BCM -….5322
        Fail-safe….5337
          FAIL-SAFE CONTROL BY DTC….5337
          FAIL-SAFE CONTROL BY RAIN SENSOR MALFUNCTION….5338
          REAR WIPER MOTOR PROTECTION….5338
        DTC Inspection Priority Chart….5338
        DTC Index….5339
    SYMPTOM DIAGNOSIS….5341
      INTERIOR LIGHTING SYSTEM SYMPTOMS….5341
        INTERIOR LIGHTING SYSTEM SYMPTOMS….5341
        Symptom Table….5341
          SYMPTOMS BY ITEM….5341
          SYMPTOMS BY FUNCTION….5342
    PRECAUTION….5343
      PRECAUTIONS….5343
        PRECAUTIONS….5343
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….5343
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….5343
        Precautions For Xenon Headlamp Service….5343
        Precautions for Removing Battery Terminal….5344
    REMOVAL AND INSTALLATION….5345
      MAP LAMP….5345
        MAP LAMP….5345
        Exploded View….5345
        Removal and Installation….5345
        Replacement….5345
          MAP LAMP BULB….5345
      VANITY MIRROR LAMP….5346
        VANITY MIRROR LAMP….5346
        Exploded View….5346
        Replacement….5346
          VANITY MIRROR LAMP BULB….5346
      ASHTRAY ILLUMINATION….5347
        ASHTRAY ILLUMINATION….5347
        Exploded View….5347
        Replacement….5347
          ASHTRAY ILLUMINATION BULB….5347
      GLOVE BOX LAMP….5348
        GLOVE BOX LAMP….5348
        Exploded View….5348
        Replacement….5348
          GLOVE BOX LAMP BULB….5348
      TOTAL ILLUMINATION CONTROL UNIT….5349
        TOTAL ILLUMINATION CONTROL UNIT….5349
        Exploded View….5349
        Removal and Installation….5349
          REMOVAL….5349
          INSTALLATION….5349
      FOOT LAMP….5350
        FOOT LAMP….5350
        DRIVER SIDE….5350
          DRIVER SIDE : Exploded View….5350
          DRIVER SIDE : Removal and Installation….5350
            REMOVAL….5350
            INSTALLATION….5350
          DRIVER SIDE : Replacement….5350
            FOOT LAMP BULB (DRIVER SIDE)….5350
        PASSENGER SIDE….5350
          PASSENGER SIDE : Exploded View….5351
          PASSENGER SIDE : Removal and Installation….5351
            REMOVAL….5351
            INSTALLATION….5351
          PASSENGER SIDE : Replacement….5351
            FOOT LAMP BULB (PASSENGER SIDE)….5351
      MOOD LAMP….5352
        MOOD LAMP….5352
        FRONT DOOR ARMREST….5352
          FRONT DOOR ARMREST : Exploded View….5352
          FRONT DOOR ARMREST : Replacement….5352
            MOOD LAMP (FRONT DOOR ARMREST)….5352
        REAR DOOR ARMREST….5352
          REAR DOOR ARMREST : Exploded View….5352
          REAR DOOR ARMREST : Replacement….5353
            MOOD LAMP (REAR DOOR ARMREST)….5353
      STEP LAMP….5354
        STEP LAMP….5354
        Exploded View….5354
        Removal and Installation….5354
          REMOVAL….5354
          INSTALLATION….5354
        Replacement….5354
          STEP LAMP BULB….5354
      PERSONAL LAMP….5355
        PERSONAL LAMP….5355
        Exploded View….5355
        Removal and Installation….5355
          REMOVAL….5355
          INSTALLATION….5355
        Replacement….5356
          PERSONAL LAMP BULB….5356
      PUDDLE LAMP….5357
        PUDDLE LAMP….5357
        Exploded View….5357
      LUGGAGE ROOM LAMP….5358
        LUGGAGE ROOM LAMP….5358
        LUGGAGE SIDE….5358
          LUGGAGE SIDE : Exploded View….5358
          LUGGAGE SIDE : Removal and Installation….5358
            REMOVAL….5358
            INSTALLATION….5358
          LUGGAGE SIDE : Replacement….5358
            LUGGAGE ROOM LAMP (LUGGAGE SIDE) BULB….5358
        BACK DOOR SIDE….5358
          BACK DOOR SIDE : Exploded View….5359
          BACK DOOR SIDE : Removal and Installation….5359
            REMOVAL….5359
            INSTALLATION….5359
          BACK DOOR SIDE : Replacement….5359
            LUGGAGE ROOM LAMP BULB….5359
    SERVICE DATA AND SPECIFICATIONS (SDS)….5360
      SERVICE DATA AND SPECIFICATIONS (SDS)….5360
        SERVICE DATA AND SPECIFICATIONS (SDS)….5360
        Bulb Specifications….5360
int….5361
  Table of Contents….5361
    SYMPTOM DIAGNOSIS….5362
      SQUEAK AND RATTLE TROUBLE DIAGNOSES….5362
        SQUEAK AND RATTLE TROUBLE DIAGNOSES….5362
        Work Flow….5362
          CUSTOMER INTERVIEW….5362
          DUPLICATE THE NOISE AND TEST DRIVE….5362
          CHECK RELATED SERVICE BULLETINS….5363
          LOCATE THE NOISE AND IDENTIFY THE ROOT CAUSE….5363
          REPAIR THE CAUSE….5363
          CONFIRM THE REPAIR….5364
        Inspection Procedure….5364
          INSTRUMENT PANEL….5364
          CENTER CONSOLE….5364
          DOORS….5364
          TRUNK….5364
          SUNROOF/HEADLINING….5365
          SEATS….5365
          UNDERHOOD….5365
        Diagnostic Worksheet….5366
    PRECAUTION….5368
      PRECAUTIONS….5368
        PRECAUTIONS….5368
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….5368
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….5368
        Precaution for Procedure without Cowl Top Cover….5368
        Precautions for Removing Battery Terminal….5369
        Precaution for Work….5369
    PREPARATION….5370
      PREPARATION….5370
        PREPARATION….5370
        Special Service Tools….5370
        Commercial Service Tools….5370
      CLIP LIST….5371
        CLIP LIST….5371
        Clip List….5371
    REMOVAL AND INSTALLATION….5372
      FRONT DOOR FINISHER….5372
        FRONT DOOR FINISHER….5372
        Exploded View….5372
        Removal and Installation….5372
          REMOVAL….5372
          INSTALLATION….5374
        Disassembly and Assembly….5374
          DISASSEMBLY….5374
          ASSEMBLY….5374
      REAR DOOR FINISHER….5375
        REAR DOOR FINISHER….5375
        Exploded View….5375
        Removal and Installation….5375
          REMOVAL….5375
          INSTALLATION….5377
        Disassembly and Assembly….5377
          DISASSEMBLY….5377
          ASSEMBLY….5377
      BODY SIDE TRIM….5378
        BODY SIDE TRIM….5378
        Exploded View….5378
        Removal and Installation….5378
          REMOVAL….5378
            FRONT PILLAR GARNISH….5378
            FRONT KICKING PLATE INNER….5379
            FRONT KICKING PLATE OUTER….5380
            DASH SIDE FINISHER….5380
            REAR KICKING PLATE INNER ….5380
            REAR KICKING PLATE OUTER….5381
            CENTER PILLAR LOWER GARNISH….5381
            CENTER PILLAR UPPER GARNISH….5381
          INSTALLATION….5382
      FLOOR TRIM….5383
        FLOOR TRIM….5383
        Exploded View….5383
        Removal and Installation….5383
          REMOVAL….5383
          INSTALLATION….5384
      HEADLINING….5385
        HEADLINING….5385
        Exploded View….5385
        Removal and Installation….5386
          REMOVAL….5386
          INSTALLATION….5389
      LUGGAGE FLOOR TRIM….5390
        LUGGAGE FLOOR TRIM….5390
        Exploded View….5390
        Removal and Installation….5391
          REMOVAL….5391
            LUGGAGE REAR PLATE….5391
            LUGGAGE FLOOR SPACER….5391
            LUGGAGE SIDE FINISHER LOWER ….5392
            LUGGAGE SIDE FINISHER UPPER….5393
          INSTALLATION….5393
      BACK DOOR TRIM….5394
        BACK DOOR TRIM….5394
        Exploded View….5394
        Removal and Installation….5394
          REMOVAL….5394
            BACK DOOR FINISHER INNER….5394
          INSTALLATION….5396
ip….5397
  Table of Contents….5397
    PRECAUTION….5398
      PRECAUTIONS….5398
        PRECAUTIONS….5398
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….5398
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….5398
        Precaution for Procedure without Cowl Top Cover….5398
        Precautions for Removing Battery Terminal….5399
        Precaution….5399
    PREPARATION….5400
      PREPARATION….5400
        PREPARATION….5400
        Special Service Tools….5400
        Commercial Service Tools….5400
      CLIP LIST….5401
        CLIP LIST….5401
        Clip List….5401
    SYMPTOM DIAGNOSIS….5402
      SQUEAK AND RATTLE TROUBLE DIAGNOSES….5402
        SQUEAK AND RATTLE TROUBLE DIAGNOSES….5402
        Work Flow….5402
          CUSTOMER INTERVIEW….5402
          DUPLICATE THE NOISE AND TEST DRIVE….5402
          CHECK RELATED SERVICE BULLETINS….5403
          LOCATE THE NOISE AND IDENTIFY THE ROOT CAUSE….5403
          REPAIR THE CAUSE….5403
          CONFIRM THE REPAIR….5404
        Inspection Procedure….5404
          INSTRUMENT PANEL….5404
          CENTER CONSOLE….5404
          DOORS….5404
          TRUNK….5404
          SUNROOF/HEADLINING….5405
          SEATS….5405
          UNDERHOOD….5405
        Diagnostic Worksheet….5406
    REMOVAL AND INSTALLATION….5408
      INSTRUMENT PANEL ASSEMBLY….5408
        INSTRUMENT PANEL ASSEMBLY….5408
        Exploded View….5408
        Removal and Installation….5409
          WORK STEP….5409
          REMOVAL….5410
          INSTALLATION….5418
      CENTER CONSOLE ASSEMBLY….5419
        CENTER CONSOLE ASSEMBLY….5419
        Exploded View….5419
        Removal and Installation….5419
          REMOVAL….5420
          INSTALLATION….5421
        Disassembly and Assembly….5422
          DISASSEMBLY….5422
          ASSEMBLY….5423
lan….5424
  Table of Contents….5424
    CAN FUNDAMENTAL….5438
      CAN FUNDAMENTAL….5438
      PRECAUTION….5438
        PRECAUTIONS….5438
          PRECAUTIONS….5438
          Precautions for Trouble Diagnosis….5438
          Precautions for Harness Repair….5438
      SYSTEM DESCRIPTION….5439
        CAN COMMUNICATION SYSTEM….5439
          CAN COMMUNICATION SYSTEM….5439
          System Description….5439
          System Diagram….5439
          CAN Communication Control Circuit….5440
        DIAG ON CAN….5441
          DIAG ON CAN….5441
          Description….5441
          System Diagram….5441
        TROUBLE DIAGNOSIS….5442
          TROUBLE DIAGNOSIS….5442
          Condition of Error Detection….5442
            CAN COMMUNICATION SYSTEM ERROR….5442
            WHEN DTC OF CAN COMMUNICATION IS INDICATED EVEN THOUGH CAN COMMUNICATION SYSTEM IS NORMAL….5442
          Symptom When Error Occurs in CAN Communication System….5442
            ERROR EXAMPLE….5442
              Example: TCM branch line open circuit….5442
              Example: Data link connector branch line open circuit….5443
              Example: Main Line Between Data Link Connector and ABS Actuator and Electric Unit (Control Unit) Open Circuit….5444
              Example: CAN-H, CAN-L Harness Short Circuit….5444
          CAN Diagnosis with CONSULT….5445
          Self-Diagnosis….5445
          CAN Diagnostic Support Monitor….5445
            MONITOR ITEM (CONSULT)….5445
              Without PAST….5446
              With PAST….5446
            MONITOR ITEM (ON-BOARD DIAGNOSIS)….5446
          How to Use CAN Communication Signal Chart….5447
      BASIC INSPECTION….5448
        DIAGNOSIS AND REPAIR WORKFLOW….5448
          DIAGNOSIS AND REPAIR WORKFLOW….5448
          Trouble Diagnosis Flow Chart….5448
          Trouble Diagnosis Procedure….5448
            INTERVIEW WITH CUSTOMER….5448
            INSPECTION OF VEHICLE CONDITION….5449
            CHECK OF CAN SYSTEM TYPE (HOW TO USE CAN SYSTEM TYPE SPECIFICATION CHART)….5449
              CAN System Type Specification Chart (Style A)….5449
              CAN System Type Specification Chart (Style B)….5450
            CREATE INTERVIEW SHEET….5451
              Interview Sheet (Example)….5452
            DETECT THE ROOT CAUSE….5452
    CAN….5453
      CAN….5453
      HOW TO USE THIS MANUAL….5453
        HOW TO USE THIS SECTION….5453
          HOW TO USE THIS SECTION….5453
          Caution….5453
          Abbreviation List….5453
      PRECAUTION….5454
        PRECAUTIONS….5454
          PRECAUTIONS….5454
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….5454
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….5454
          Precautions for Trouble Diagnosis….5454
          Precautions for Harness Repair….5454
          Precautions for Removing Battery Terminal….5455
      BASIC INSPECTION….5456
        DIAGNOSIS AND REPAIR WORKFLOW….5456
          DIAGNOSIS AND REPAIR WORKFLOW….5456
          Interview Sheet….5456
      SYSTEM DESCRIPTION….5457
        CAN COMMUNICATION SYSTEM….5457
          CAN COMMUNICATION SYSTEM….5457
          CAN System Specification Chart….5457
            VEHICLE EQUIPMENT IDENTIFICATION INFORMATION….5457
          CAN Communication Signal Chart….5458
      DTC/CIRCUIT DIAGNOSIS….5465
        CAN COMMUNICATION SYSTEM….5465
          CAN COMMUNICATION SYSTEM….5465
          Component Parts Location….5465
          Wiring Diagram – CAN SYSTEM (VQ37VHR WITHOUT AROWND VIEW MONITOR OR VK50VE) -….5465
          Wiring Diagram – CAN SYSTEM (VQ37VHR WITH AROUND VIEW MONITOR) -….5476
        MALFUNCTION AREA CHART….5487
          MALFUNCTION AREA CHART….5487
          System Diagram….5487
          CAN Communication Circuit….5487
            MAIN LINE….5487
            BRANCH LINE….5488
            SHORT CIRCUIT….5488
          ITS Communication Circuit….5488
            BRANCH LINE….5488
            SHORT CIRCUIT OR OPEN CIRCUIT….5489
        MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5490
          MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5490
          Diagnosis Procedure….5490
        MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5491
          MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5491
          Diagnosis Procedure….5491
        MAIN LINE BETWEEN PWBD AND TPMS CIRCUIT….5492
          MAIN LINE BETWEEN PWBD AND TPMS CIRCUIT….5492
          Diagnosis Procedure….5492
        MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5493
          MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5493
          Diagnosis Procedure….5493
        MAIN LINE BETWEEN ADP AND TPMS CIRCUIT….5494
          MAIN LINE BETWEEN ADP AND TPMS CIRCUIT….5494
          Diagnosis Procedure….5494
        MAIN LINE BETWEEN ADP AND CGW CIRCUIT….5495
          MAIN LINE BETWEEN ADP AND CGW CIRCUIT….5495
          Diagnosis Procedure….5495
        MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5496
          MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5496
          Diagnosis Procedure….5496
        MAIN LINE BETWEEN AV AND AFS CIRCUIT….5497
          MAIN LINE BETWEEN AV AND AFS CIRCUIT….5497
          Diagnosis Procedure….5497
        MAIN LINE BETWEEN AV AND SONAR CIRCUIT….5498
          MAIN LINE BETWEEN AV AND SONAR CIRCUIT….5498
          Diagnosis Procedure….5498
        MAIN LINE BETWEEN AV AND ABS CIRCUIT….5499
          MAIN LINE BETWEEN AV AND ABS CIRCUIT….5499
          Diagnosis Procedure….5499
        MAIN LINE BETWEEN AFS AND ABS CIRCUIT….5500
          MAIN LINE BETWEEN AFS AND ABS CIRCUIT….5500
          Diagnosis Procedure….5500
      REMOVAL AND INSTALLATION….4863
        COMPRESSOR….4863
          COMPRESSOR….4863
          Exploded View….4863
            REMOVAL….4863
            DISASSEMBLY….4863
          COMPRESSOR….4864
            COMPRESSOR : Removal and Installation….4864
              REMOVAL….4864
              INSTALLATION….4864
          MAGNET CLUTCH….4865
            MAGNET CLUTCH : Removal and Installation of Compressor Clutch….4865
              REMOVAL….4865
                Overhaul….4865
              INSTALLATION….4865
                Break-in Operation….4865
          Inspection….4865
            CHECK DISC TO PULLEY CLEARANCE….4865
        COOLER PIPE AND HOSE….4867
          COOLER PIPE AND HOSE….4867
          Exploded View….4867
          LOW-PRESSURE FLEXIBLE HOSE….4867
            LOW-PRESSURE FLEXIBLE HOSE : Removal and Installation….4867
              REMOVAL….4867
              INSTALLATION….4868
          HIGH-PRESSURE FLEXIBLE HOSE….4868
            HIGH-PRESSURE FLEXIBLE HOSE : Removal and Installation….4868
              REMOVAL….4868
              INSTALLATION….486
…
                Intake Switch….4970
                DUAL Switch….4970
              DISCHARGE AIR FLOW….4971
              SWITCHES AND THEIR CONTROL FUNCTION….4972
              AIR CONDITIONER LAN CONTROL SYSTEM….4972
              SYSTEM CONSTRUCTION….4973
                Operation….4973
                Transmission Data and Transmission Order….4973
            WITHOUT ACCS : Component Part Location….4974
              ENGINE COMPARTMENT….4974
              PASSENGER COMPARTMENT….4975
            WITHOUT ACCS : Component Description….4977
          WITH ACCS….4977
            WITH ACCS : System Diagram….4977
              CONTROL SYSTEM….4977
            WITH ACCS : System Description….4978
              CONTROL OPERATION….4978
                Display Screen….4978
                Preset Switch….4979
                MODE Switch….4979
                Temperature Control Dial (Potentio Temperature Control) (Driver Side) ….4979
                Temperature Control Dial (Potentio Temperature Control) (Passenger Side) ….4979
                AUTO Switch ….4979
                Defroster (DEF) Switch….4979
                A/C Switch….4979
                FAN Switches….4979
                OFF Switch….4979
                Rear Window Defogger Switch….4979
                Intake Switch….4979
                DUAL Switch….4979
              DISCHARGE AIR FLOW….4980
              SWITCHES AND THEIR CONTROL FUNCTION….4981
              AIR CONDITIONER LAN CONTROL SYSTEM….4981
              SYSTEM CONSTRUCTION….4982
                Operation….4982
                Transmission Data and Transmission Order….4982
            WITH ACCS : Component Part Location….4983
              ENGINE COMPARTMENT….4983
              PASSENGER COMPARTMENT….4984
            WITH ACCS : Component Description….4985
        PLASMACLUSTER SYSTEM….4987
          PLASMACLUSTER SYSTEM….4987
          System Diagram….4987
          System Description….4987
            OPERATION DESCRIPTION….4987
          Component Part Location….4988
          Component Description….4989
        CAN COMMUNICATION SYSTEM….4990
          CAN COMMUNICATION SYSTEM….4990
          System Description….4990
        MODE DOOR CONTROL SYSTEM….4991
          MODE DOOR CONTROL SYSTEM….4991
          System Diagram….4991
          System Description….4991
            SYSTEM OPERATION….4991
              Door Motor Circuit….4991
              Mode Door Control Specification….4991
        AIR MIX DOOR CONTROL SYSTEM….4993
          AIR MIX DOOR CONTROL SYSTEM….4993
          System Diagram….4993
          System Description….4993
            SYSTEM OPERATION….4993
              Door Motor Circuit….4993
              Air Mix Door Control Specification….4993
              Potentio Temperature Control (PTC)….4994
        INTAKE DOOR CONTROL SYSTEM….4995
          INTAKE DOOR CONTROL SYSTEM….4995
          WITHOUT ACCS….4995
            WITHOUT ACCS : System Diagram….4995
            WITHOUT ACCS : System Description….4995
              SYSTEM OPERATION….4995
                Door Motor Circuit….4995
                Intake Door Control Specification….4995
          WITH ACCS….4996
            WITH ACCS : System Diagram….4996
            WITH ACCS : System Description….4996
              SYSTEM OPERATION….4996
                Door Motor Circuit….4997
                Intake Door Control Specification….4997
                Automatic intake control (exhaust gas/outside odor detecting mechanism)….4997
        BLOWER MOTOR CONTROL SYSTEM….4998
          BLOWER MOTOR CONTROL SYSTEM….4998
          System Diagram….4998
          System Description….4998
            SYSTEM OPERATION….4998
              Automatic Mode….4998
              Starting Fan Speed Control….4998
              Blower Speed Compensation….4998
              Fan Speed Control Specification….4999
        MAGNET CLUTCH CONTROL SYSTEM….5000
          MAGNET CLUTCH CONTROL SYSTEM….5000
          System Diagram….5000
          System Description….5000
            SYSTEM OPERATION….5000
              Compressor Protection Control….5000
              Low Temperature Protection Control….5000
        DIAGNOSIS SYSTEM (UNIFIED METER & A/C AMP.)….5002
          DIAGNOSIS SYSTEM (UNIFIED METER & A/C AMP.)….5002
          WITHOUT ACCS….5002
            WITHOUT ACCS : Diagnosis Description….5002
              SELF-DIAGNOSIS SYSTEM….5002
              SELF-DIAGNOSIS FUNCTION….5002
              CONFORMATION METHOD….5003
            WITHOUT ACCS : CONSULT Function….5007
              CONSULT APPLICATION ITEMS….5007
              DATA MONITOR….5007
          WITH ACCS….5007
            WITH ACCS : Diagnosis Description….5007
              SELF-DIAGNOSIS SYSTEM….5007
              SELF-DIAGNOSIS FUNCTION….5007
              CONFORMATION METHOD….5008
            WITH ACCS : CONSULT Function….5012
              CONSULT APPLICATION ITEMS….5012
              DATA MONITOR….5012
      DTC/CIRCUIT DIAGNOSIS….5013
        POWER SUPPLY AND GROUND CIRCUIT….5013
          POWER SUPPLY AND GROUND CIRCUIT….5013
          UNIFIED METER AND A/C AMP…5013
            UNIFIED METER AND A/C AMP. : Diagnosis Procedure….5013
        UNIFIED METER AND A/C AMP…5014
          UNIFIED METER AND A/C AMP…5014
          Description….5014
            COMPONENT DESCRIPTION….5014
              Unified Meter and A/C Amp. (Automatic Amplifier)….5014
          Component Function Check….5014
          Diagnosis Procedure….5014
        MODE DOOR MOTOR….5015
          MODE DOOR MOTOR….5015
          Description….5015
            COMPONENT DESCRIPTION….5015
              Mode Door Motor….5015
          Component Function Check….5015
          Diagnosis Procedure….5015
        AIR MIX DOOR MOTOR (DRIVER SIDE)….5017
          AIR MIX DOOR MOTOR (DRIVER SIDE)….5017
          Description….5017
            COMPONENT DESCRIPTION….5017
              Air Mix Door Motor….5017
          Component Function Check….5017
          Diagnosis Procedure….5017
        AIR MIX DOOR MOTOR (PASSENGER SIDE)….5019
          AIR MIX DOOR MOTOR (PASSENGER SIDE)….5019
          Description….5019
            COMPONENT DESCRIPTION….5019
              Air Mix Door Motor….5019
          Component Function Check….5019
          Diagnosis Procedure….5019
        INTAKE DOOR MOTOR….5021
          INTAKE DOOR MOTOR….5021
          WITHOUT ACCS….5021
            WITHOUT ACCS : Description….5021
              COMPONENT DESCRIPTION….5021
                Intake Door Motor….5021
            WITHOUT ACCS : Component Function Check….5021
            WITHOUT ACCS : Diagnosis Procedure….5021
          WITH ACCS….5022
            WITH ACCS : Description….5022
              COMPONENT DESCRIPTION….5022
                Intake Door Motor….5022
            WITH ACCS : Component Function Check….5022
            WITH ACCS : Diagnosis Procedure….5023
        BLOWER MOTOR….5025
          BLOWER MOTOR….5025
          Description….5025
            COMPONENT DESCRIPTION….5025
              Brush-less Motor….5025
          Component Function Check….5025
          Diagnosis Procedure….5025
          Component Inspection….5028
        MAGNET CLUTCH….5029
          MAGNET CLUTCH….5029
          Description….5029
          Component Function Check….5029
          Diagnosis Procedure….5029
        ECV (ELECTRICAL CONTROL VALVE)….5031
          ECV (ELECTRICAL CONTROL VALVE)….5031
          Description….5031
          Diagnosis Procedure….5031
        AMBIENT SENSOR….5033
          AMBIENT SENSOR….5033
          Description….5033
            COMPONENT DESCRIPTION….5033
              Ambient Sensor….5033
            AMBIENT TEMPERATURE INPUT PROCESS….5033
          Component Function Check….5033
          Diagnosis Procedure….5033
          Component Inspection….5034
        IN-VEHICLE SENSOR….5036
          IN-VEHICLE SENSOR….5036
          Description….5036
          Component Function Check….5036
          Diagnosis Procedure….5036
          Component Inspection….5037
        SUNLOAD SENSOR….5039
          SUNLOAD SENSOR….5039
          Description….5039
            COMPONENT DESCRIPTION….5039
              Sunload Sensor….5039
            SUNLOAD INPUT PROCESS….5039
          Component Function Check….5039
          Diagnosis Procedure….5039
          Component Inspection….5040
        INTAKE SENSOR….5042
          INTAKE SENSOR….5042
          Description….5042
          Component Function Check….5042
          Diagnosis Procedure….5042
          Component Inspection….5043
        EXHAUST GAS/OUTSIDE ODOR DETECTING SENSOR….5044
          EXHAUST GAS/OUTSIDE ODOR DETECTING SENSOR….5044
          Description….5044
            COMPONENT DESCRIPTION….5044
            STRUCTURE AND OPERATION….5044
          Component Function Check….5044
          Diagnosis Procedure….5044
        IONIZER….5047
          IONIZER….5047
          Description….5047
          Component Function Check….5047
          Diagnosis Procedure….5047
      ECU DIAGNOSIS INFORMATION….5049
        UNIFIED METER AND A/C AMP…5049
          UNIFIED METER AND A/C AMP…5049
          Reference Value….5049
            TERMINAL LAYOUT….5049
            PHYSICAL VALUES….5049
          Wiring Diagram – AIR CONDITIONER CONTROL SYSTEM -….5051
          Fail-safe….5060
            FAIL-SAFE FUNCTION….5060
        ECM….5062
          ECM….5062
          VQ37VHR FOR USA AND CANADA….5062
            VQ37VHR FOR USA AND CANADA : Reference Value….5062
              VALUES ON THE DIAGNOSIS TOOL….5062
              TERMINAL LAYOUT….5067
              PHYSICAL VALUES….5067
          VQ37VHR FOR MEXICO….5078
            VQ37VHR FOR MEXICO : Reference Value….5078
              VALUES ON THE DIAGNOSIS TOOL….5078
              TERMINAL LAYOUT….5083
              PHYSICAL VALUES….5083
          VK50VE….5093
            VK50VE : Reference Value….5093
              VALUES ON THE DIAGNOSIS TOOL….5093
              TERMINAL LAYOUT….5099
              PHYSICAL VALUES….5099
      SYMPTOM DIAGNOSIS….5112
        AIR CONDITIONER CONTROL….5112
          AIR CONDITIONER CONTROL….5112
          Diagnosis Chart By Symptom….5112
        INSUFFICIENT COOLING….5113
          INSUFFICIENT COOLING….5113
          Description….5113
          Inspection procedure….5113
        INSUFFICIENT HEATING….5115
          INSUFFICIENT HEATING….5115
          Description….5115
          Inspection procedure….5115
        NOISE….5117
          NOISE….5117
          Description….5117
          Inspection procedure….5117
        SELF-DIAGNOSIS CANNOT BE PERFORMED….5119
          SELF-DIAGNOSIS CANNOT BE PERFORMED….5119
          Description….5119
          Inspection procedure….5119
        MEMORY FUNCTION DOES NOT OPERATE….5120
          MEMORY FUNCTION DOES NOT OPERATE….5120
          Description….5120
          Inspection procedure….5120
      PRECAUTION….5121
        PRECAUTIONS….5121
          PRECAUTIONS….5121
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….5121
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….5121
          Precautions Necessary for Steering Wheel Rotation After Battery Disconnection….5121
            OPERATION PROCEDURE….5121
          Precaution for Procedure without Cowl Top Cover….5122
          Working with HFC-134a (R-134a)….5122
            CONTAMINATED REFRIGERANT….5122
          General Refrigerant Precaution….5122
          Refrigerant Connection….5123
            ABOUT ONE-TOUCH JOINT….5123
              Description….5123
            O-RING AND REFRIGERANT CONNECTION….5125
              O-Ring Part Numbers and Specifications….5126
          Service Equipment….5127
            RECOVERY/RECYCLING RECHARGING EQUIPMENT….5127
            ELECTRICAL LEAK DETECTOR….5127
            VACUUM PUMP….5127
            MANIFOLD GAUGE SET….5128
            SERVICE HOSES….5128
            SERVICE COUPLERS….5128
            REFRIGERANT WEIGHT SCALE….5129
            CHARGING CYLINDER….5129
        COMPRESSOR….5130
          COMPRESSOR….5130
          VQ37VHR….5130
            VQ37VHR : General Precautions….5130
          VK50VE….5130
            VK50VE : General Precautions….5130
        LEAK DETECTION DYE….5131
          LEAK DETECTION DYE….5131
          General Precautions….5131
            IDENTIFICATION….5131
            IDENTIFICATION LABEL FOR VEHICLE….5131
      PREPARATION….5132
        PREPARATION….5132
          PREPARATION….5132
          Special Service Tool….5132
          Commercial Service Tool….5135
          Sealant or/and Lubricant….5135
      REMOVAL AND INSTALLATION….5136
        PRESET SWITCH….5136
          PRESET SWITCH….5136
          Exploded View….5136
          Removal and Installation….5136
            REMOVAL….5136
            INSTALLATION….5136
        UNIFIED METER AND A/C AMP…5137
          UNIFIED METER AND A/C AMP…5137
          Exploded View….5137
          Removal and Installation….5137
            REMOVAL….5137
            INSTALLATION….5137
        AMBIENT SENSOR….5138
          AMBIENT SENSOR….5138
          Exploded View….5138
          Removal and Installation….5138
            REMOVAL….5138
            INSTALLATION….5138
        IN-VEHICLE SENSOR….5139
          IN-VEHICLE SENSOR….5139
          Exploded View….5139
          Removal and Installation….5139
            REMOVAL….5139
            INSTALLATION….5139
        SUNLOAD SENSOR….5140
          SUNLOAD SENSOR….5140
          Exploded View….5140
          Removal and Installation….5140
            REMOVAL….5140
            INSTALLATION….5140
        INTAKE SENSOR….5141
          INTAKE SENSOR….5141
          Exploded View….5141
          Removal and Installation….5142
            REMOVAL….5142
            INSTALLATION….5142
        EXHAUST GAS/OUTSIDE ODOR DETECTING SENSOR….5143
          EXHAUST GAS/OUTSIDE ODOR DETECTING SENSOR….5143
          Exploded View….5143
          Removal and Installation….5143
            REMOVAL….5143
            INSTALLATION….5143
        REFRIGERANT PRESSURE SENSOR….5144
          REFRIGERANT PRESSURE SENSOR….5144
          Exploded View….5144
          Removal and Installation….5144
            REMOVAL….5144
            INSTALLATION….5144
        DOOR MOTOR….5145
          DOOR MOTOR….5145
          Exploded View….5145
          MODE DOOR MOTOR….5145
            MODE DOOR MOTOR : Removal and Installation….5145
              REMOVAL….5145
              INSTALLATION….5146
          AIR MIX DOOR MOTOR….5146
            AIR MIX DOOR MOTOR : Removal and Installation….5146
              REMOVAL….5146
                Driver Side….5146
                Passenger Side….5146
              INSTALLATION….5146
          INTAKE DOOR MOTOR….5147
            INTAKE DOOR MOTOR : Removal and Installation….5147
              REMOVAL….5147
              INSTALLATION….5147
        IONIZER….5148
          IONIZER….5148
          Exploded View….5148
          Removal and Installation….5148
            REMOVAL….5148
            INSTALLATION….5148
hrn….5149
  Table of Contents….5149
    DTC/CIRCUIT DIAGNOSIS….5150
      HORN….5150
        HORN….5150
        Wiring Diagram – HORN -….5150
    PRECAUTION….5154
      PRECAUTIONS….5154
        PRECAUTIONS….5154
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….5154
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….5154
        Precautions for Removing Battery Terminal….5154
    REMOVAL AND INSTALLATION….5155
      HORN….5155
        HORN….5155
        Exploded View….5155
        Removal and Installation….5155
          REMOVAL….5155
            Horn (LOW)….5155
            Horn (HIGH)….5155
          INSTALLATION….5155
inl….5156
  Table of Contents….5156
    BASIC INSPECTION….5159
      DIAGNOSIS AND REPAIR WORK FLOW….5159
        DIAGNOSIS AND REPAIR WORK FLOW….5159
        Work Flow….5159
          OVERALL SEQUENCE….5159
          DETAILED FLOW….5159
    SYSTEM DESCRIPTION….5162
      INTERIOR ROOM LAMP CONTROL SYSTEM….5162
        INTERIOR ROOM LAMP CONTROL SYSTEM….5162
        System Diagram….5162
        System Description….5162
          OUTLINE….5162
            Total Illumination Control Unit….5163
            BCM….5163
          HOSPITALITY LIGHTING SYSTEM….5163
          TOTAL ILLUMINATION CONTROL UNIT….5165
          INTERIOR ROOM LAMP TIMER CONTROL….5165
          STEP LAMP CONTROL….5165
        Component Parts Location….5166
        Component Description….5167
      INTERIOR ROOM LAMP BATTERY SAVER SYSTEM….5168
        INTERIOR ROOM LAMP BATTERY SAVER SYSTEM….5168
        System Diagram….5168
        System Description….5168
          OUTLINE….5168
            Applicable lamps….5168
          INTERIOR ROOM LAMP BATTERY SAVER FUNCTION….5168
        Component Parts Location….5169
        Component Description….5170
      ILLUMINATION CONTROL SYSTEM….5171
        ILLUMINATION CONTROL SYSTEM….5171
        System Diagram….5171
        System Description….5171
          OUTLINE….5171
          ILLUMINATION CONTROL….5171
        Component Parts Location….5172
        Component Description….5173
      DIAGNOSIS SYSTEM (TOTAL ILLUMINATION CONTROL UNIT)….5174
        DIAGNOSIS SYSTEM (TOTAL ILLUMINATION CONTROL UNIT)….5174
        CONSULT Function (TOTAL ILLUM C/U)….5174
          APPLICATION ITEM….5174
          WORK SUPPORT….5174
          DATA MONITOR….5174
          ACTIVE TEST….5175
      DIAGNOSIS SYSTEM (BCM)….5177
        DIAGNOSIS SYSTEM (BCM)….5177
        COMMON ITEM….5177
          COMMON ITEM : CONSULT Function (BCM – COMMON ITEM)….5177
            APPLICATION ITEM….5177
            SYSTEM APPLICATION….5177
            FREEZE FRAME DATA (FFD)….5177
        INT LAMP….5178
          INT LAMP : CONSULT Function (BCM – INT LAMP)….5178
            WORK SUPPORT….5178
            DATA MONITOR….5179
            ACTIVE TEST….5180
        BATTERY SAVER….5180
          BATTERY SAVER : CONSULT Function (BCM – BATTERY SAVER)….5180
            WORK SUPPORT….5180
            DATA MONITOR….5180
            ACTIVE TEST….5181
    DTC/CIRCUIT DIAGNOSIS….5182
      POWER SUPPLY AND GROUND CIRCUIT….5182
        POWER SUPPLY AND GROUND CIRCUIT….5182
        TOTAL ILLUMINATION CONTROL UNIT….5182
          TOTAL ILLUMINATION CONTROL UNIT : Diagnosis Procedure….5182
        BCM….5182
          BCM : Diagnosis Procedure….5182
      INTERIOR ROOM LAMP POWER SUPPLY CIRCUIT….5184
        INTERIOR ROOM LAMP POWER SUPPLY CIRCUIT….5184
        Description….5184
        Diagnosis Procedure….5184
      BATTERY SAVER SIGNAL CIRCUIT….5186
        BATTERY SAVER SIGNAL CIRCUIT….5186
        Description….5186
        Diagnosis Procedure….5186
      HOSPITALITY LIGHTING POWER SUPPLY CIRCUIT 1….5187
        HOSPITALITY LIGHTING POWER SUPPLY CIRCUIT 1….5187
        Description….5187
        Diagnosis Procedure….5187
      HOSPITALITY LIGHTING POWER SUPPLY CIRCUIT 2….5190
        HOSPITALITY LIGHTING POWER SUPPLY CIRCUIT 2….5190
        Description….5190
        Diagnosis Procedure….5190
      HOSPITALITY LIGHTING POWER SUPPLY CIRCUIT 3….5192
        HOSPITALITY LIGHTING POWER SUPPLY CIRCUIT 3….5192
        Description….5192
        Diagnosis Procedure….5192
      MAP LAMP CIRCUIT….5194
        MAP LAMP CIRCUIT….5194
        Description….5194
        Component Function Check….5194
        Diagnosis Procedure….5194
      PERSONAL LAMP CIRCUIT….5196
        PERSONAL LAMP CIRCUIT….5196
        Description….5196
        Component Function Check….5196
        Diagnosis Procedure….5196
      CENTER CONSOLE INDIRECT ILLUMINATION CIRCUIT….5198
        CENTER CONSOLE INDIRECT ILLUMINATION CIRCUIT….5198
        Description….5198
        Component Function Check….5198
        Diagnosis Procedure….5198
      FOOT LAMP CIRCUIT….5200
        FOOT LAMP CIRCUIT….5200
        Description….5200
        Component Function Check….5200
        Diagnosis Procedure….5200
      PUDDLE LAMP CIRCUIT….5203
        PUDDLE LAMP CIRCUIT….5203
        Description….5203
        Component Function Check….5203
        Diagnosis Procedure….5203
      MOOD LAMP (FRONT DOOR ARMREST) CIRCUIT ….5205
        MOOD LAMP (FRONT DOOR ARMREST) CIRCUIT ….5205
        Description….5205
        Component Function Check….5205
        Diagnosis Procedure….5205
      PUSH-BUTTON IGNITION SWITCH ILLUMINATION CIRCUIT….5207
        PUSH-BUTTON IGNITION SWITCH ILLUMINATION CIRCUIT….5207
        Description….5207
        Component Function Check….5207
        Diagnosis Procedure….5207
      MOOD LAMP (REAR DOOR ARMREST) CIRCUIT ….5209
        MOOD LAMP (REAR DOOR ARMREST) CIRCUIT ….5209
        Description….5209
        Component Function Check….5209
        Diagnosis Procedure….5209
      HOSPITALITY ILLUMINATION CIRCUIT….5211
        HOSPITALITY ILLUMINATION CIRCUIT….5211
        Description….5211
        Component Function Check….5211
        Diagnosis Procedure….5211
      STEP LAMP CIRCUIT….5214
        STEP LAMP CIRCUIT….5214
        Description….5214
        Component Function Check….5214
        Diagnosis Procedure….5214
      TAIL LAMP SIGNAL CIRCUIT….5216
        TAIL LAMP SIGNAL CIRCUIT….5216
        Description….5216
        Component Function Check….5216
        Diagnosis Procedure….5216
      ILLUMINATION CONTROL SIGNAL CIRCUIT….5218
        ILLUMINATION CONTROL SIGNAL CIRCUIT….5218
        Component Function Check….5218
        Diagnosis Procedure….5218
      MAP LAMP SWITCH CIRCUIT….5220
        MAP LAMP SWITCH CIRCUIT….5220
        Component Function Check….5220
        Diagnosis Procedure….5220
      DOOR SWITCH CIRCUIT….5222
        DOOR SWITCH CIRCUIT….5222
        Component Function Check….5222
        Diagnosis Procedure….5222
      ROOM LAMP REQUEST SIGNAL CIRCUIT….5226
        ROOM LAMP REQUEST SIGNAL CIRCUIT….5226
        Component Function Check….5226
        Diagnosis Procedure….5226
        Diagnosis Procedure….5227
      INTERIOR ROOM LAMP CONTROL SYSTEM….5228
        INTERIOR ROOM LAMP CONTROL SYSTEM….5228
        Wiring Diagram – INTERIOR ROOM LAMP -….5228
      ILLUMINATION….5245
        ILLUMINATION….5245
        Wiring Diagram – ILLUMINATION -….5245
    ECU DIAGNOSIS INFORMATION….5260
      TOTAL ILLUMINATION CONTROL UNIT….5260
        TOTAL ILLUMINATION CONTROL UNIT….5260
        Reference Value….5260
          VALUES ON THE DIAGNOSIS TOOL….5260
          TERMINAL LAYOUT….5261
          PHYSICAL VALUES….5261
        Wiring Diagram – INTERIOR ROOM LAMP -….5268
        Wiring Diagram – ILLUMINATION -….5285
      BCM (BODY CONTROL MODULE)….5300
        BCM (BODY CONTROL MODULE)….5300
        Reference Value….5300
          VALUES ON THE DIAGNOSIS TOOL….5300
          TERMINAL LAYOUT….5305
          PHYSICAL VALUES….5305
        Wiring Diagram – BCM -….5322
        Fail-safe….5337
          FAIL-SAFE CONTROL BY DTC….5337
          FAIL-SAFE CONTROL BY RAIN SENSOR MALFUNCTION….5338
          REAR WIPER MOTOR PROTECTION….5338
        DTC Inspection Priority Chart….5338
        DTC Index….5339
    SYMPTOM DIAGNOSIS….5341
      INTERIOR LIGHTING SYSTEM SYMPTOMS….5341
        INTERIOR LIGHTING SYSTEM SYMPTOMS….5341
        Symptom Table….5341
          SYMPTOMS BY ITEM….5341
          SYMPTOMS BY FUNCTION….5342
    PRECAUTION….5343
      PRECAUTIONS….5343
        PRECAUTIONS….5343
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….5343
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….5343
        Precautions For Xenon Headlamp Service….5343
        Precautions for Removing Battery Terminal….5344
    REMOVAL AND INSTALLATION….5345
      MAP LAMP….5345
        MAP LAMP….5345
        Exploded View….5345
        Removal and Installation….5345
        Replacement….5345
          MAP LAMP BULB….5345
      VANITY MIRROR LAMP….5346
        VANITY MIRROR LAMP….5346
        Exploded View….5346
        Replacement….5346
          VANITY MIRROR LAMP BULB….5346
      ASHTRAY ILLUMINATION….5347
        ASHTRAY ILLUMINATION….5347
        Exploded View….5347
        Replacement….5347
          ASHTRAY ILLUMINATION BULB….5347
      GLOVE BOX LAMP….5348
        GLOVE BOX LAMP….5348
        Exploded View….5348
        Replacement….5348
          GLOVE BOX LAMP BULB….5348
      TOTAL ILLUMINATION CONTROL UNIT….5349
        TOTAL ILLUMINATION CONTROL UNIT….5349
        Exploded View….5349
        Removal and Installation….5349
          REMOVAL….5349
          INSTALLATION….5349
      FOOT LAMP….5350
        FOOT LAMP….5350
        DRIVER SIDE….5350
          DRIVER SIDE : Exploded View….5350
          DRIVER SIDE : Removal and Installation….5350
            REMOVAL….5350
            INSTALLATION….5350
          DRIVER SIDE : Replacement….5350
            FOOT LAMP BULB (DRIVER SIDE)….5350
        PASSENGER SIDE….5350
          PASSENGER SIDE : Exploded View….5351
          PASSENGER SIDE : Removal and Installation….5351
            REMOVAL….5351
            INSTALLATION….5351
          PASSENGER SIDE : Replacement….5351
            FOOT LAMP BULB (PASSENGER SIDE)….5351
      MOOD LAMP….5352
        MOOD LAMP….5352
        FRONT DOOR ARMREST….5352
          FRONT DOOR ARMREST : Exploded View….5352
          FRONT DOOR ARMREST : Replacement….5352
            MOOD LAMP (FRONT DOOR ARMREST)….5352
        REAR DOOR ARMREST….5352
          REAR DOOR ARMREST : Exploded View….5352
          REAR DOOR ARMREST : Replacement….5353
            MOOD LAMP (REAR DOOR ARMREST)….5353
      STEP LAMP….5354
        STEP LAMP….5354
        Exploded View….5354
        Removal and Installation….5354
          REMOVAL….5354
          INSTALLATION….5354
        Replacement….5354
          STEP LAMP BULB….5354
      PERSONAL LAMP….5355
        PERSONAL LAMP….5355
        Exploded View….5355
        Removal and Installation….5355
          REMOVAL….5355
          INSTALLATION….5355
        Replacement….5356
          PERSONAL LAMP BULB….5356
      PUDDLE LAMP….5357
        PUDDLE LAMP….5357
        Exploded View….5357
      LUGGAGE ROOM LAMP….5358
        LUGGAGE ROOM LAMP….5358
        LUGGAGE SIDE….5358
          LUGGAGE SIDE : Exploded View….5358
          LUGGAGE SIDE : Removal and Installation….5358
            REMOVAL….5358
            INSTALLATION….5358
          LUGGAGE SIDE : Replacement….5358
            LUGGAGE ROOM LAMP (LUGGAGE SIDE) BULB….5358
        BACK DOOR SIDE….5358
          BACK DOOR SIDE : Exploded View….5359
          BACK DOOR SIDE : Removal and Installation….5359
            REMOVAL….5359
            INSTALLATION….5359
          BACK DOOR SIDE : Replacement….5359
            LUGGAGE ROOM LAMP BULB….5359
    SERVICE DATA AND SPECIFICATIONS (SDS)….5360
      SERVICE DATA AND SPECIFICATIONS (SDS)….5360
        SERVICE DATA AND SPECIFICATIONS (SDS)….5360
        Bulb Specifications….5360
int….5361
  Table of Contents….5361
    SYMPTOM DIAGNOSIS….5362
      SQUEAK AND RATTLE TROUBLE DIAGNOSES….5362
        SQUEAK AND RATTLE TROUBLE DIAGNOSES….5362
        Work Flow….5362
          CUSTOMER INTERVIEW….5362
          DUPLICATE THE NOISE AND TEST DRIVE….5362
          CHECK RELATED SERVICE BULLETINS….5363
          LOCATE THE NOISE AND IDENTIFY THE ROOT CAUSE….5363
          REPAIR THE CAUSE….5363
          CONFIRM THE REPAIR….5364
        Inspection Procedure….5364
          INSTRUMENT PANEL….5364
          CENTER CONSOLE….5364
          DOORS….5364
          TRUNK….5364
          SUNROOF/HEADLINING….5365
          SEATS….5365
          UNDERHOOD….5365
        Diagnostic Worksheet….5366
    PRECAUTION….5368
      PRECAUTIONS….5368
        PRECAUTIONS….5368
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….5368
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….5368
        Precaution for Procedure without Cowl Top Cover….5368
        Precautions for Removing Battery Terminal….5369
        Precaution for Work….5369
    PREPARATION….5370
      PREPARATION….5370
        PREPARATION….5370
        Special Service Tools….5370
        Commercial Service Tools….5370
      CLIP LIST….5371
        CLIP LIST….5371
        Clip List….5371
    REMOVAL AND INSTALLATION….5372
      FRONT DOOR FINISHER….5372
        FRONT DOOR FINISHER….5372
        Exploded View….5372
        Removal and Installation….5372
          REMOVAL….5372
          INSTALLATION….5374
        Disassembly and Assembly….5374
          DISASSEMBLY….5374
          ASSEMBLY….5374
      REAR DOOR FINISHER….5375
        REAR DOOR FINISHER….5375
        Exploded View….5375
        Removal and Installation….5375
          REMOVAL….5375
          INSTALLATION….5377
        Disassembly and Assembly….5377
          DISASSEMBLY….5377
          ASSEMBLY….5377
      BODY SIDE TRIM….5378
        BODY SIDE TRIM….5378
        Exploded View….5378
        Removal and Installation….5378
          REMOVAL….5378
            FRONT PILLAR GARNISH….5378
            FRONT KICKING PLATE INNER….5379
            FRONT KICKING PLATE OUTER….5380
            DASH SIDE FINISHER….5380
            REAR KICKING PLATE INNER ….5380
            REAR KICKING PLATE OUTER….5381
            CENTER PILLAR LOWER GARNISH….5381
            CENTER PILLAR UPPER GARNISH….5381
          INSTALLATION….5382
      FLOOR TRIM….5383
        FLOOR TRIM….5383
        Exploded View….5383
        Removal and Installation….5383
          REMOVAL….5383
          INSTALLATION….5384
      HEADLINING….5385
        HEADLINING….5385
        Exploded View….5385
        Removal and Installation….5386
          REMOVAL….5386
          INSTALLATION….5389
      LUGGAGE FLOOR TRIM….5390
        LUGGAGE FLOOR TRIM….5390
        Exploded View….5390
        Removal and Installation….5391
          REMOVAL….5391
            LUGGAGE REAR PLATE….5391
            LUGGAGE FLOOR SPACER….5391
            LUGGAGE SIDE FINISHER LOWER ….5392
            LUGGAGE SIDE FINISHER UPPER….5393
          INSTALLATION….5393
      BACK DOOR TRIM….5394
        BACK DOOR TRIM….5394
        Exploded View….5394
        Removal and Installation….5394
          REMOVAL….5394
            BACK DOOR FINISHER INNER….5394
          INSTALLATION….5396
ip….5397
  Table of Contents….5397
    PRECAUTION….5398
      PRECAUTIONS….5398
        PRECAUTIONS….5398
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….5398
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….5398
        Precaution for Procedure without Cowl Top Cover….5398
        Precautions for Removing Battery Terminal….5399
        Precaution….5399
    PREPARATION….5400
      PREPARATION….5400
        PREPARATION….5400
        Special Service Tools….5400
        Commercial Service Tools….5400
      CLIP LIST….5401
        CLIP LIST….5401
        Clip List….5401
    SYMPTOM DIAGNOSIS….5402
      SQUEAK AND RATTLE TROUBLE DIAGNOSES….5402
        SQUEAK AND RATTLE TROUBLE DIAGNOSES….5402
        Work Flow….5402
          CUSTOMER INTERVIEW….5402
          DUPLICATE THE NOISE AND TEST DRIVE….5402
          CHECK RELATED SERVICE BULLETINS….5403
          LOCATE THE NOISE AND IDENTIFY THE ROOT CAUSE….5403
          REPAIR THE CAUSE….5403
          CONFIRM THE REPAIR….5404
        Inspection Procedure….5404
          INSTRUMENT PANEL….5404
          CENTER CONSOLE….5404
          DOORS….5404
          TRUNK….5404
          SUNROOF/HEADLINING….5405
          SEATS….5405
          UNDERHOOD….5405
        Diagnostic Worksheet….5406
    REMOVAL AND INSTALLATION….5408
      INSTRUMENT PANEL ASSEMBLY….5408
        INSTRUMENT PANEL ASSEMBLY….5408
        Exploded View….5408
        Removal and Installation….5409
          WORK STEP….5409
          REMOVAL….5410
          INSTALLATION….5418
      CENTER CONSOLE ASSEMBLY….5419
        CENTER CONSOLE ASSEMBLY….5419
        Exploded View….5419
        Removal and Installation….5419
          REMOVAL….5420
          INSTALLATION….5421
        Disassembly and Assembly….5422
          DISASSEMBLY….5422
          ASSEMBLY….5423
lan….5424
  Table of Contents….5424
    CAN FUNDAMENTAL….5438
      CAN FUNDAMENTAL….5438
      PRECAUTION….5438
        PRECAUTIONS….5438
          PRECAUTIONS….5438
          Precautions for Trouble Diagnosis….5438
          Precautions for Harness Repair….5438
      SYSTEM DESCRIPTION….5439
        CAN COMMUNICATION SYSTEM….5439
          CAN COMMUNICATION SYSTEM….5439
          System Description….5439
          System Diagram….5439
          CAN Communication Control Circuit….5440
        DIAG ON CAN….5441
          DIAG ON CAN….5441
          Description….5441
          System Diagram….5441
        TROUBLE DIAGNOSIS….5442
          TROUBLE DIAGNOSIS….5442
          Condition of Error Detection….5442
            CAN COMMUNICATION SYSTEM ERROR….5442
            WHEN DTC OF CAN COMMUNICATION IS INDICATED EVEN THOUGH CAN COMMUNICATION SYSTEM IS NORMAL….5442
          Symptom When Error Occurs in CAN Communication System….5442
            ERROR EXAMPLE….5442
              Example: TCM branch line open circuit….5442
              Example: Data link connector branch line open circuit….5443
              Example: Main Line Between Data Link Connector and ABS Actuator and Electric Unit (Control Unit) Open Circuit….5444
              Example: CAN-H, CAN-L Harness Short Circuit….5444
          CAN Diagnosis with CONSULT….5445
          Self-Diagnosis….5445
          CAN Diagnostic Support Monitor….5445
            MONITOR ITEM (CONSULT)….5445
              Without PAST….5446
              With PAST….5446
            MONITOR ITEM (ON-BOARD DIAGNOSIS)….5446
          How to Use CAN Communication Signal Chart….5447
      BASIC INSPECTION….5448
        DIAGNOSIS AND REPAIR WORKFLOW….5448
          DIAGNOSIS AND REPAIR WORKFLOW….5448
          Trouble Diagnosis Flow Chart….5448
          Trouble Diagnosis Procedure….5448
            INTERVIEW WITH CUSTOMER….5448
            INSPECTION OF VEHICLE CONDITION….5449
            CHECK OF CAN SYSTEM TYPE (HOW TO USE CAN SYSTEM TYPE SPECIFICATION CHART)….5449
              CAN System Type Specification Chart (Style A)….5449
              CAN System Type Specification Chart (Style B)….5450
            CREATE INTERVIEW SHEET….5451
              Interview Sheet (Example)….5452
            DETECT THE ROOT CAUSE….5452
    CAN….5453
      CAN….5453
      HOW TO USE THIS MANUAL….5453
        HOW TO USE THIS SECTION….5453
          HOW TO USE THIS SECTION….5453
          Caution….5453
          Abbreviation List….5453
      PRECAUTION….5454
        PRECAUTIONS….5454
          PRECAUTIONS….5454
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….5454
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….5454
          Precautions for Trouble Diagnosis….5454
          Precautions for Harness Repair….5454
          Precautions for Removing Battery Terminal….5455
      BASIC INSPECTION….5456
        DIAGNOSIS AND REPAIR WORKFLOW….5456
          DIAGNOSIS AND REPAIR WORKFLOW….5456
          Interview Sheet….5456
      SYSTEM DESCRIPTION….5457
        CAN COMMUNICATION SYSTEM….5457
          CAN COMMUNICATION SYSTEM….5457
          CAN System Specification Chart….5457
            VEHICLE EQUIPMENT IDENTIFICATION INFORMATION….5457
          CAN Communication Signal Chart….5458
      DTC/CIRCUIT DIAGNOSIS….5465
        CAN COMMUNICATION SYSTEM….5465
          CAN COMMUNICATION SYSTEM….5465
          Component Parts Location….5465
          Wiring Diagram – CAN SYSTEM (VQ37VHR WITHOUT AROWND VIEW MONITOR OR VK50VE) -….5465
          Wiring Diagram – CAN SYSTEM (VQ37VHR WITH AROUND VIEW MONITOR) -….5476
        MALFUNCTION AREA CHART….5487
          MALFUNCTION AREA CHART….5487
          System Diagram….5487
          CAN Communication Circuit….5487
        MAIN LINE BETWEEN SONAR AND ABS CIRCUIT….5501
          MAIN LINE BETWEEN SONAR AND ABS CIRCUIT….5501
          Diagnosis Procedure….5501
        MAIN LINE BETWEEN CGW AND ABS CIRCUIT….5502
          MAIN LINE BETWEEN CGW AND ABS CIRCUIT….5502
          Diagnosis Procedure….5502
        MAIN LINE BETWEEN DLC AND TPMS CIRCUIT….5503
          MAIN LINE BETWEEN DLC AND TPMS CIRCUIT….5503
          Diagnosis Procedure….5503
        ECM BRANCH LINE CIRCUIT….5504
          ECM BRANCH LINE CIRCUIT….5504
          Diagnosis Procedure….5504
        4WD BRANCH LINE CIRCUIT….5505
          4WD BRANCH LINE CIRCUIT….5505
          Diagnosis Procedure….5505
        DLC BRANCH LINE CIRCUIT….5506
          DLC BRANCH LINE CIRCUIT….5506
          Diagnosis Procedure….5506
        DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5507
          DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5507
          Diagnosis Procedure….5507
        DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5508
          DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5508
          Diagnosis Procedure….5508
        TCM BRANCH LINE CIRCUIT….5509
          TCM BRANCH LINE CIRCUIT….5509
          Diagnosis Procedure….5509
        BCM BRANCH LINE CIRCUIT….5510
          BCM BRANCH LINE CIRCUIT….5510
          Diagnosis Procedure….5510
        M&A BRANCH LINE CIRCUIT….5511
          M&A BRANCH LINE CIRCUIT….5511
          Diagnosis Procedure….5511
        STRG BRANCH LINE CIRCUIT….5512
          STRG BRANCH LINE CIRCUIT….5512
          Diagnosis Procedure….5512
        PWBD BRANCH LINE CIRCUIT….5513
          PWBD BRANCH LINE CIRCUIT….5513
          Diagnosis Procedure….5513
        ADP BRANCH LINE CIRCUIT….5514
          ADP BRANCH LINE CIRCUIT….5514
          Diagnosis Procedure….5514
        AVM BRANCH LINE CIRCUIT….5515
          AVM BRANCH LINE CIRCUIT….5515
          Diagnosis Procedure….5515
        CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5516
          CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5516
          Diagnosis Procedure….5516
        CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5517
          CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5517
          Diagnosis Procedure….5517
        ABS BRANCH LINE CIRCUIT….5518
          ABS BRANCH LINE CIRCUIT….5518
          Diagnosis Procedure….5518
        ICC BRANCH LINE CIRCUIT….5519
          ICC BRANCH LINE CIRCUIT….5519
          Diagnosis Procedure….5519
        IPDM-E BRANCH LINE CIRCUIT….5520
          IPDM-E BRANCH LINE CIRCUIT….5520
          Diagnosis Procedure….5520
        A-BAG BRANCH LINE CIRCUIT….5521
          A-BAG BRANCH LINE CIRCUIT….5521
          Diagnosis Procedure….5521
        TPMS BRANCH LINE CIRCUIT….5522
          TPMS BRANCH LINE CIRCUIT….5522
          Diagnosis Procedure….5522
        AV BRANCH LINE CIRCUIT….5523
          AV BRANCH LINE CIRCUIT….5523
          Diagnosis Procedure….5523
        AFS BRANCH LINE CIRCUIT….5525
          AFS BRANCH LINE CIRCUIT….5525
          Diagnosis Procedure….5525
        LANE BRANCH LINE CIRCUIT….5526
          LANE BRANCH LINE CIRCUIT….5526
          Diagnosis Procedure….5526
        PSB BRANCH LINE CIRCUIT….5527
          PSB BRANCH LINE CIRCUIT….5527
          Diagnosis Procedure….5527
        SONAR BRANCH LINE CIRCUIT….5528
          SONAR BRANCH LINE CIRCUIT….5528
          Diagnosis Procedure….5528
        APA BRANCH LINE CIRCUIT….5529
          APA BRANCH LINE CIRCUIT….5529
          Diagnosis Procedure….5529
        BCU BRANCH LINE CIRCUIT….5530
          BCU BRANCH LINE CIRCUIT….5530
          Diagnosis Procedure….5530
        CAN COMMUNICATION CIRCUIT….5531
          CAN COMMUNICATION CIRCUIT….5531
          Diagnosis Procedure….5531
        CAN COMMUNICATION CIRCUIT 1….5533
          CAN COMMUNICATION CIRCUIT 1….5533
          Diagnosis Procedure….5533
        CAN COMMUNICATION CIRCUIT 2….5535
          CAN COMMUNICATION CIRCUIT 2….5535
          Diagnosis Procedure….5535
        ITS COMMUNICATION CIRCUIT….5537
          ITS COMMUNICATION CIRCUIT….5537
          Diagnosis Procedure….5537
    CAN GATEWAY….5539
      CAN GATEWAY….5539
      BASIC INSPECTION….5539
        INSPECTION AND ADJUSTMENT….5539
          INSPECTION AND ADJUSTMENT….5539
          ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (CAN GATEWAY)….5539
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (CAN GATEWAY) :  Description….5539
              BEFORE REPLACEMENT….5539
              AFTER REPLACEMENT….5539
            ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (CAN GATEWAY) :  Special Repair Requirement….5539
          CONFIGURATION (CAN GATEWAY)….5539
            CONFIGURATION (CAN GATEWAY) : Description….5540
            CONFIGURATION (CAN GATEWAY) : Special Repair Requirement….5540
      SYSTEM DESCRIPTION….5541
        CAN GATEWAY SYSTEM….5541
          CAN GATEWAY SYSTEM….5541
          System Diagram….5541
          System Description….5541
            OUTLINE….5541
          Component Parts Location….5541
        DIAGNOSIS SYSTEM (CAN GATEWAY)….5543
          DIAGNOSIS SYSTEM (CAN GATEWAY)….5543
          CONSULT Function (CAN gateway)….5543
            APPLICATION ITEM….5543
            SELF DIAGNOSTIC RESULT….5543
      DTC/CIRCUIT DIAGNOSIS….5544
        U1000 CAN COMM CIRCUIT….5544
          U1000 CAN COMM CIRCUIT….5544
          Description….5544
          DTC Logic….5544
            DTC DETECTION LOGIC….5544
          Diagnosis Procedure….5544
        U1010 CONTROL UNIT (CAN)….5545
          U1010 CONTROL UNIT (CAN)….5545
          Description….5545
          DTC Logic….5545
            DTC DETECTION LOGIC….5545
          Diagnosis Procedure….5545
        B2600 CONFIG ERROR….5546
          B2600 CONFIG ERROR….5546
          Description….5546
          DTC Logic….5546
            DTC DETECTION LOGIC….5546
          Diagnosis Procedure….5546
        POWER SUPPLY AND GROUND CIRCUIT….5547
          POWER SUPPLY AND GROUND CIRCUIT….5547
          Diagnosis Procedure….5547
      ECU DIAGNOSIS INFORMATION….5548
        CAN GATEWAY….5548
          CAN GATEWAY….5548
          Reference Value….5548
            TERMINAL LAYOUT….5548
            PHYSICAL VALUES….5548
          Wiring Diagram – CAN GATEWAY SYSTEM -….5549
          DTC Inspection Priority Chart….5550
          DTC Index….5551
      PRECAUTION….5552
        PRECAUTIONS….5552
          PRECAUTIONS….5552
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….5552
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….5552
          Precautions for Removing Battery Terminal….5552
      REMOVAL AND INSTALLATION….5553
        CAN GATEWAY….5553
          CAN GATEWAY….5553
          Exploded View….5553
          Removal and Installation….5553
            REMOVAL….5553
            INSTALLATION….5553
    CAN SYSTEM (TYPE 1)….5554
      CAN SYSTEM (TYPE 1)….5554
      DTC/CIRCUIT DIAGNOSIS….5554
        MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5554
          MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5554
          Diagnosis Procedure….5554
        MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5555
          MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5555
          Diagnosis Procedure….5555
        MAIN LINE BETWEEN PWBD AND TPMS CIRCUIT….5556
          MAIN LINE BETWEEN PWBD AND TPMS CIRCUIT….5556
          Diagnosis Procedure….5556
        MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5557
          MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5557
          Diagnosis Procedure….5557
        MAIN LINE BETWEEN AV AND ABS CIRCUIT….5558
          MAIN LINE BETWEEN AV AND ABS CIRCUIT….5558
          Diagnosis Procedure….5558
        ECM BRANCH LINE CIRCUIT….5559
          ECM BRANCH LINE CIRCUIT….5559
          Diagnosis Procedure….5559
        DLC BRANCH LINE CIRCUIT….5560
          DLC BRANCH LINE CIRCUIT….5560
          Diagnosis Procedure….5560
        TCM BRANCH LINE CIRCUIT….5561
          TCM BRANCH LINE CIRCUIT….5561
          Diagnosis Procedure….5561
        BCM BRANCH LINE CIRCUIT….5562
          BCM BRANCH LINE CIRCUIT….5562
          Diagnosis Procedure….5562
        M&A BRANCH LINE CIRCUIT….5563
          M&A BRANCH LINE CIRCUIT….5563
          Diagnosis Procedure….5563
        STRG BRANCH LINE CIRCUIT….5564
          STRG BRANCH LINE CIRCUIT….5564
          Diagnosis Procedure….5564
        PWBD BRANCH LINE CIRCUIT….5565
          PWBD BRANCH LINE CIRCUIT….5565
          Diagnosis Procedure….5565
        ABS BRANCH LINE CIRCUIT….5566
          ABS BRANCH LINE CIRCUIT….5566
          Diagnosis Procedure….5566
        IPDM-E BRANCH LINE CIRCUIT….5567
          IPDM-E BRANCH LINE CIRCUIT….5567
          Diagnosis Procedure….5567
        A-BAG BRANCH LINE CIRCUIT….5568
          A-BAG BRANCH LINE CIRCUIT….5568
          Diagnosis Procedure….5568
        TPMS BRANCH LINE CIRCUIT….5569
          TPMS BRANCH LINE CIRCUIT….5569
          Diagnosis Procedure….5569
        AV BRANCH LINE CIRCUIT….5570
          AV BRANCH LINE CIRCUIT….5570
          Diagnosis Procedure….5570
        CAN COMMUNICATION CIRCUIT….5572
          CAN COMMUNICATION CIRCUIT….5572
          Diagnosis Procedure….5572
    CAN SYSTEM (TYPE 2)….5574
      CAN SYSTEM (TYPE 2)….5574
      DTC/CIRCUIT DIAGNOSIS….5574
        MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5574
          MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5574
          Diagnosis Procedure….5574
        MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5575
          MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5575
          Diagnosis Procedure….5575
        MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5576
          MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5576
          Diagnosis Procedure….5576
        MAIN LINE BETWEEN ADP AND TPMS CIRCUIT….5577
          MAIN LINE BETWEEN ADP AND TPMS CIRCUIT….5577
          Diagnosis Procedure….5577
        MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5578
          MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5578
          Diagnosis Procedure….5578
        MAIN LINE BETWEEN AV AND ABS CIRCUIT….5579
          MAIN LINE BETWEEN AV AND ABS CIRCUIT….5579
          Diagnosis Procedure….5579
        ECM BRANCH LINE CIRCUIT….5580
          ECM BRANCH LINE CIRCUIT….5580
          Diagnosis Procedure….5580
        DLC BRANCH LINE CIRCUIT….5581
          DLC BRANCH LINE CIRCUIT….5581
          Diagnosis Procedure….5581
        TCM BRANCH LINE CIRCUIT….5582
          TCM BRANCH LINE CIRCUIT….5582
          Diagnosis Procedure….5582
        BCM BRANCH LINE CIRCUIT….5583
          BCM BRANCH LINE CIRCUIT….5583
          Diagnosis Procedure….5583
        M&A BRANCH LINE CIRCUIT….5584
          M&A BRANCH LINE CIRCUIT….5584
          Diagnosis Procedure….5584
        STRG BRANCH LINE CIRCUIT….5585
          STRG BRANCH LINE CIRCUIT….5585
          Diagnosis Procedure….5585
        PWBD BRANCH LINE CIRCUIT….5586
          PWBD BRANCH LINE CIRCUIT….5586
          Diagnosis Procedure….5586
        ADP BRANCH LINE CIRCUIT….5587
          ADP BRANCH LINE CIRCUIT….5587
          Diagnosis Procedure….5587
        ABS BRANCH LINE CIRCUIT….5588
          ABS BRANCH LINE CIRCUIT….5588
          Diagnosis Procedure….5588
        IPDM-E BRANCH LINE CIRCUIT….5589
          IPDM-E BRANCH LINE CIRCUIT….5589
          Diagnosis Procedure….5589
        A-BAG BRANCH LINE CIRCUIT….5590
          A-BAG BRANCH LINE CIRCUIT….5590
          Diagnosis Procedure….5590
        TPMS BRANCH LINE CIRCUIT….5591
          TPMS BRANCH LINE CIRCUIT….5591
          Diagnosis Procedure….5591
        AV BRANCH LINE CIRCUIT….5592
          AV BRANCH LINE CIRCUIT….5592
          Diagnosis Procedure….5592
        CAN COMMUNICATION CIRCUIT….5594
          CAN COMMUNICATION CIRCUIT….5594
          Diagnosis Procedure….5594
    CAN SYSTEM (TYPE 3)….5596
      CAN SYSTEM (TYPE 3)….5596
      DTC/CIRCUIT DIAGNOSIS….5596
        MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5596
          MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5596
          Diagnosis Procedure….5596
        MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5597
          MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5597
          Diagnosis Procedure….5597
        MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5598
          MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5598
          Diagnosis Procedure….5598
        MAIN LINE BETWEEN ADP AND TPMS CIRCUIT….5599
          MAIN LINE BETWEEN ADP AND TPMS CIRCUIT….5599
          Diagnosis Procedure….5599
        MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5600
          MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5600
          Diagnosis Procedure….5600
        MAIN LINE BETWEEN AV AND AFS CIRCUIT….5601
          MAIN LINE BETWEEN AV AND AFS CIRCUIT….5601
          Diagnosis Procedure….5601
        MAIN LINE BETWEEN AFS AND ABS CIRCUIT….5602
          MAIN LINE BETWEEN AFS AND ABS CIRCUIT….5602
          Diagnosis Procedure….5602
        ECM BRANCH LINE CIRCUIT….5603
          ECM BRANCH LINE CIRCUIT….5603
          Diagnosis Procedure….5603
        DLC BRANCH LINE CIRCUIT….5604
          DLC BRANCH LINE CIRCUIT….5604
          Diagnosis Procedure….5604
        TCM BRANCH LINE CIRCUIT….5605
          TCM BRANCH LINE CIRCUIT….5605
          Diagnosis Procedure….5605
        BCM BRANCH LINE CIRCUIT….5606
          BCM BRANCH LINE CIRCUIT….5606
          Diagnosis Procedure….5606
        M&A BRANCH LINE CIRCUIT….5607
          M&A BRANCH LINE CIRCUIT….5607
          Diagnosis Procedure….5607
        STRG BRANCH LINE CIRCUIT….5608
          STRG BRANCH LINE CIRCUIT….5608
          Diagnosis Procedure….5608
        PWBD BRANCH LINE CIRCUIT….5609
          PWBD BRANCH LINE CIRCUIT….5609
          Diagnosis Procedure….5609
        ADP BRANCH LINE CIRCUIT….5610
          ADP BRANCH LINE CIRCUIT….5610
          Diagnosis Procedure….5610
        ABS BRANCH LINE CIRCUIT….5611
          ABS BRANCH LINE CIRCUIT….5611
          Diagnosis Procedure….5611
        IPDM-E BRANCH LINE CIRCUIT….5612
          IPDM-E BRANCH LINE CIRCUIT….5612
          Diagnosis Procedure….5612
        A-BAG BRANCH LINE CIRCUIT….5613
          A-BAG BRANCH LINE CIRCUIT….5613
          Diagnosis Procedure….5613
        TPMS BRANCH LINE CIRCUIT….5614
          TPMS BRANCH LINE CIRCUIT….5614
          Diagnosis Procedure….5614
        AV BRANCH LINE CIRCUIT….5615
          AV BRANCH LINE CIRCUIT….5615
          Diagnosis Procedure….5615
        AFS BRANCH LINE CIRCUIT….5617
          AFS BRANCH LINE CIRCUIT….5617
          Diagnosis Procedure….5617
        CAN COMMUNICATION CIRCUIT….5618
          CAN COMMUNICATION CIRCUIT….5618
          Diagnosis Procedure….5618
    CAN SYSTEM (TYPE 4)….5620
      CAN SYSTEM (TYPE 4)….5620
      DTC/CIRCUIT DIAGNOSIS….5620
        MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5620
          MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5620
          Diagnosis Procedure….5620
        MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5621
          MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5621
          Diagnosis Procedure….5621
        MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5622
          MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5622
          Diagnosis Procedure….5622
        MAIN LINE BETWEEN ADP AND CGW CIRCUIT….5623
          MAIN LINE BETWEEN ADP AND CGW CIRCUIT….5623
          Diagnosis Procedure….5623
        MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5624
          MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5624
          Diagnosis Procedure….5624
        MAIN LINE BETWEEN AV AND SONAR CIRCUIT….5625
          MAIN LINE BETWEEN AV AND SONAR CIRCUIT….5625
          Diagnosis Procedure….5625
        MAIN LINE BETWEEN CGW AND ABS CIRCUIT….5626
          MAIN LINE BETWEEN CGW AND ABS CIRCUIT….5626
          Diagnosis Procedure….5626
        MAIN LINE BETWEEN DLC AND TPMS CIRCUIT….5627
          MAIN LINE BETWEEN DLC AND TPMS CIRCUIT….5627
          Diagnosis Procedure….5627
        ECM BRANCH LINE CIRCUIT….5628
          ECM BRANCH LINE CIRCUIT….5628
          Diagnosis Procedure….5628
        DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5629
          DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5629
          Diagnosis Procedure….5629
        DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5630
          DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5630
          Diagnosis Procedure….5630
        TCM BRANCH LINE CIRCUIT….5631
          TCM BRANCH LINE CIRCUIT….5631
          Diagnosis Procedure….5631
        BCM BRANCH LINE CIRCUIT….5632
          BCM BRANCH LINE CIRCUIT….5632
          Diagnosis Procedure….5632
        M&A BRANCH LINE CIRCUIT….5633
          M&A BRANCH LINE CIRCUIT….5633
          Diagnosis Procedure….5633
        STRG BRANCH LINE CIRCUIT….5634
          STRG BRANCH LINE CIRCUIT….5634
          Diagnosis Procedure….5634
        PWBD BRANCH LINE CIRCUIT….5635
          PWBD BRANCH LINE CIRCUIT….5635
          Diagnosis Procedure….5635
        ADP BRANCH LINE CIRCUIT….5636
          ADP BRANCH LINE CIRCUIT….5636
          Diagnosis Procedure….5636
        AVM BRANCH LINE CIRCUIT….5637
          AVM BRANCH LINE CIRCUIT….5637
          Diagnosis Procedure….5637
        CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5638
          CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5638
          Diagnosis Procedure….5638
        CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5639
          CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5639
          Diagnosis Procedure….5639
        ABS BRANCH LINE CIRCUIT….5640
          ABS BRANCH LINE CIRCUIT….5640
          Diagnosis Procedure….5640
        IPDM-E BRANCH LINE CIRCUIT….5641
          IPDM-E BRANCH LINE CIRCUIT….5641
          Diagnosis Procedure….5641
        A-BAG BRANCH LINE CIRCUIT….5642
          A-BAG BRANCH LINE CIRCUIT….5642
          Diagnosis Procedure….5642
        TPMS BRANCH LINE CIRCUIT….5643
          TPMS BRANCH LINE CIRCUIT….5643
          Diagnosis Procedure….5643
        AV BRANCH LINE CIRCUIT….5644
          AV BRANCH LINE CIRCUIT….5644
          Diagnosis Procedure….5644
        SONAR BRANCH LINE CIRCUIT….5646
          SONAR BRANCH LINE CIRCUIT….5646
          Diagnosis Procedure….5646
        CAN COMMUNICATION CIRCUIT 1….5647
          CAN COMMUNICATION CIRCUIT 1….5647
          Diagnosis Procedure….5647
        CAN COMMUNICATION CIRCUIT 2….5649
          CAN COMMUNICATION CIRCUIT 2….5649
          Diagnosis Procedure….5649
    CAN SYSTEM (TYPE 5)….5651
      CAN SYSTEM (TYPE 5)….5651
      DTC/CIRCUIT DIAGNOSIS….5651
        MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5651
          MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5651
          Diagnosis Procedure….5651
        MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5652
          MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5652
          Diagnosis Procedure….5652
        MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5653
          MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5653
          Diagnosis Procedure….5653
        MAIN LINE BETWEEN ADP AND CGW CIRCUIT….5654
          MAIN LINE BETWEEN ADP AND CGW CIRCUIT….5654
          Diagnosis Procedure….5654
        MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5655
          MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5655
          Diagnosis Procedure….5655
        MAIN LINE BETWEEN AV AND SONAR CIRCUIT….5656
          MAIN LINE BETWEEN AV AND SONAR CIRCUIT….5656
          Diagnosis Procedure….5656
        MAIN LINE BETWEEN CGW AND ABS CIRCUIT….5657
          MAIN LINE BETWEEN CGW AND ABS CIRCUIT….5657
          Diagnosis Procedure….5657
        MAIN LINE BETWEEN DLC AND TPMS CIRCUIT….5658
          MAIN LINE BETWEEN DLC AND TPMS CIRCUIT….5658
          Diagnosis Procedure….5658
        ECM BRANCH LINE CIRCUIT….5659
          ECM BRANCH LINE CIRCUIT….5659
          Diagnosis Procedure….5659
        DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5660
          DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5660
          Diagnosis Procedure….5660
        DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5661
          DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5661
          Diagnosis Procedure….5661
        TCM BRANCH LINE CIRCUIT….5662
          TCM BRANCH LINE CIRCUIT….5662
          Diagnosis Procedure….5662
        BCM BRANCH LINE CIRCUIT….5663
          BCM BRANCH LINE CIRCUIT….5663
          Diagnosis Procedure….5663
        M&A BRANCH LINE CIRCUIT….5664
          M&A BRANCH LINE CIRCUIT….5664
          Diagnosis Procedure….5664
        STRG BRANCH LINE CIRCUIT….5665
          STRG BRANCH LINE CIRCUIT….5665
          Diagnosis Procedure….5665
        PWBD BRANCH LINE CIRCUIT….5666
          PWBD BRANCH LINE CIRCUIT….5666
          Diagnosis Procedure….5666
        ADP BRANCH LINE CIRCUIT….5667
          ADP BRANCH LINE CIRCUIT….5667
          Diagnosis Procedure….5667
        AVM BRANCH LINE CIRCUIT….5668
          AVM BRANCH LINE CIRCUIT….5668
          Diagnosis Procedure….5668
        CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5669
          CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5669
          Diagnosis Procedure….5669
        CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5670
          CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5670
          Diagnosis Procedure….5670
        ABS BRANCH LINE CIRCUIT….5671
          ABS BRANCH LINE CIRCUIT….5671
          Diagnosis Procedure….5671
        IPDM-E BRANCH LINE CIRCUIT….5672
          IPDM-E BRANCH LINE CIRCUIT….5672
          Diagnosis Procedure….5672
        A-BAG BRANCH LINE CIRCUIT….5673
          A-BAG BRANCH LINE CIRCUIT….5673
          Diagnosis Procedure….5673
        TPMS BRANCH LINE CIRCUIT….5674
          TPMS BRANCH LINE CIRCUIT….5674
          Diagnosis Procedure….5674
        AV BRANCH LINE CIRCUIT….5675
          AV BRANCH LINE CIRCUIT….5675
          Diagnosis Procedure….5675
        AFS BRANCH LINE CIRCUIT….5677
          AFS BRANCH LINE CIRCUIT….5677
          Diagnosis Procedure….5677
        SONAR BRANCH LINE CIRCUIT….5678
          SONAR BRANCH LINE CIRCUIT….5678
          Diagnosis Procedure….5678
        CAN COMMUNICATION CIRCUIT 1….5679
          CAN COMMUNICATION CIRCUIT 1….5679
          Diagnosis Procedure….5679
        CAN COMMUNICATION CIRCUIT 2….5681
          CAN COMMUNICATION CIRCUIT 2….5681
          Diagnosis Procedure….5681
    CAN SYSTEM (TYPE 6)….5683
      CAN SYSTEM (TYPE 6)….5683
      DTC/CIRCUIT DIAGNOSIS….5683
        MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5683
          MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5683
          Diagnosis Procedure….5683
        MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5684
          MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5684
          Diagnosis Procedure….5684
        MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5685
          MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5685
          Diagnosis Procedure….5685
        MAIN LINE BETWEEN ADP AND CGW CIRCUIT….5686
          MAIN LINE BETWEEN ADP AND CGW CIRCUIT….5686
          Diagnosis Procedure….5686
        MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5687
          MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5687
          Diagnosis Procedure….5687
        MAIN LINE BETWEEN AV AND SONAR CIRCUIT….5688
          MAIN LINE BETWEEN AV AND SONAR CIRCUIT….5688
          Diagnosis Procedure….5688
        MAIN LINE BETWEEN CGW AND ABS CIRCUIT….5689
          MAIN LINE BETWEEN CGW AND ABS CIRCUIT….5689
          Diagnosis Procedure….5689
        MAIN LINE BETWEEN DLC AND TPMS CIRCUIT….5690
          MAIN LINE BETWEEN DLC AND TPMS CIRCUIT….5690
          Diagnosis Procedure….5690
        ECM BRANCH LINE CIRCUIT….5691
          ECM BRANCH LINE CIRCUIT….5691
          Diagnosis Procedure….5691
        DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5692
          DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5692
          Diagnosis Procedure….5692
        DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5693
          DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5693
          Diagnosis Procedure….5693
        TCM BRANCH LINE CIRCUIT….5694
          TCM BRANCH LINE CIRCUIT….5694
          Diagnosis Procedure….5694
        BCM BRANCH LINE CIRCUIT….5695
          BCM BRANCH LINE CIRCUIT….5695
          Diagnosis Procedure….5695
        M&A BRANCH LINE CIRCUIT….5696
          M&A BRANCH LINE CIRCUIT….5696
          Diagnosis Procedure….5696
        STRG BRANCH LINE CIRCUIT….5697
          STRG BRANCH LINE CIRCUIT….5697
          Diagnosis Procedure….5697
        PWBD BRANCH LINE CIRCUIT….5698
          PWBD BRANCH LINE CIRCUIT….5698
          Diagnosis Procedure….5698
        ADP BRANCH LINE CIRCUIT….5699
          ADP BRANCH LINE CIRCUIT….5699
          Diagnosis Procedure….5699
        AVM BRANCH LINE CIRCUIT….5700
          AVM BRANCH LINE CIRCUIT….5700
          Diagnosis Procedure….5700
        CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5701
          CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5701
          Diagnosis Procedure….5701
        CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5702
          CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5702
          Diagnosis Procedure….5702
        ABS BRANCH LINE CIRCUIT….5703
          ABS BRANCH LINE CIRCUIT….5703
          Diagnosis Procedure….5703
        ICC BRANCH LINE CIRCUIT….5704
          ICC BRANCH LINE CIRCUIT….5704
          Diagnosis Procedure….5704
        IPDM-E BRANCH LINE CIRCUIT….5705
          IPDM-E BRANCH LINE CIRCUIT….5705
          Diagnosis Procedure….5705
        A-BAG BRANCH LINE CIRCUIT….5706
          A-BAG BRANCH LINE CIRCUIT….5706
          Diagnosis Procedure….5706
        TPMS BRANCH LINE CIRCUIT….5707
          TPMS BRANCH LINE CIRCUIT….5707
          Diagnosis Procedure….5707
        AV BRANCH LINE CIRCUIT….5708
          AV BRANCH LINE CIRCUIT….5708
          Diagnosis Procedure….5708
        LANE BRANCH LINE CIRCUIT….5710
          LANE BRANCH LINE CIRCUIT….5710
          Diagnosis Procedure….5710
        PSB BRANCH LINE CIRCUIT….5711
          PSB BRANCH LINE CIRCUIT….5711
          Diagnosis Procedure….5711
        SONAR BRANCH LINE CIRCUIT….5712
          SONAR BRANCH LINE CIRCUIT….5712
          Diagnosis Procedure….5712
        APA BRANCH LINE CIRCUIT….5713
          APA BRANCH LINE CIRCUIT….5713
          Diagnosis Procedure….5713
        BCU BRANCH LINE CIRCUIT….5714
          BCU BRANCH LINE CIRCUIT….5714
          Diagnosis Procedure….5714
        CAN COMMUNICATION CIRCUIT 1….5715
          CAN COMMUNICATION CIRCUIT 1….5715
          Diagnosis Procedure….5715
        CAN COMMUNICATION CIRCUIT 2….5717
          CAN COMMUNICATION CIRCUIT 2….5717
          Diagnosis Procedure….5717
        ITS COMMUNICATION CIRCUIT….5719
          ITS COMMUNICATION CIRCUIT….5719
          Diagnosis Procedure….5719
    CAN SYSTEM (TYPE 7)….5721
      CAN SYSTEM (TYPE 7)….5721
      DTC/CIRCUIT DIAGNOSIS….5721
        MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5721
          MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5721
          Diagnosis Procedure….5721
        MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5722
          MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5722
          Diagnosis Procedure….5722
        MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5723
          MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5723
          Diagnosis Procedure….5723
        MAIN LINE BETWEEN ADP AND CGW CIRCUIT….5724
          MAIN LINE BETWEEN ADP AND CGW CIRCUIT….5724
          Diagnosis Procedure….5724
        MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5725
          MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5725
          Diagnosis Procedure….5725
        MAIN LINE BETWEEN AV AND SONAR CIRCUIT….5726
          MAIN LINE BETWEEN AV AND SONAR CIRCUIT….5726
          Diagnosis Procedure….5726
        MAIN LINE BETWEEN CGW AND ABS CIRCUIT….5727
          MAIN LINE BETWEEN CGW AND ABS CIRCUIT….5727
          Diagnosis Procedure….5727
        MAIN LINE BETWEEN DLC AND TPMS CIRCUIT….5728
          MAIN LINE BETWEEN DLC AND TPMS CIRCUIT….5728
          Diagnosis Procedure….5728
        ECM BRANCH LINE CIRCUIT….5729
          ECM BRANCH LINE CIRCUIT….5729
          Diagnosis Procedure….5729
        DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5730
          DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5730
          Diagnosis Procedure….5730
        DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5731
          DLC BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5731
          Diagnosis Procedure….5731
        TCM BRANCH LINE CIRCUIT….5732
          TCM BRANCH LINE CIRCUIT….5732
          Diagnosis Procedure….5732
        BCM BRANCH LINE CIRCUIT….5733
          BCM BRANCH LINE CIRCUIT….5733
          Diagnosis Procedure….5733
        M&A BRANCH LINE CIRCUIT….5734
          M&A BRANCH LINE CIRCUIT….5734
          Diagnosis Procedure….5734
        STRG BRANCH LINE CIRCUIT….5735
          STRG BRANCH LINE CIRCUIT….5735
          Diagnosis Procedure….5735
        PWBD BRANCH LINE CIRCUIT….5736
          PWBD BRANCH LINE CIRCUIT….5736
          Diagnosis Procedure….5736
        ADP BRANCH LINE CIRCUIT….5737
          ADP BRANCH LINE CIRCUIT….5737
          Diagnosis Procedure….5737
        AVM BRANCH LINE CIRCUIT….5738
          AVM BRANCH LINE CIRCUIT….5738
          Diagnosis Procedure….5738
        CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5739
          CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 1)….5739
          Diagnosis Procedure….5739
        CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5740
          CGW BRANCH LINE CIRCUIT (CAN COMMUNICATION CIRCUIT 2)….5740
          Diagnosis Procedure….5740
        ABS BRANCH LINE CIRCUIT….5741
          ABS BRANCH LINE CIRCUIT….5741
          Diagnosis Procedure….5741
        ICC BRANCH LINE CIRCUIT….5742
          ICC BRANCH LINE CIRCUIT….5742
          Diagnosis Procedure….5742
        IPDM-E BRANCH LINE CIRCUIT….5743
          IPDM-E BRANCH LINE CIRCUIT….5743
          Diagnosis Procedure….5743
        A-BAG BRANCH LINE CIRCUIT….5744
          A-BAG BRANCH LINE CIRCUIT….5744
          Diagnosis Procedure….5744
        TPMS BRANCH LINE CIRCUIT….5745
          TPMS BRANCH LINE CIRCUIT….5745
          Diagnosis Procedure….5745
        AV BRANCH LINE CIRCUIT….5746
          AV BRANCH LINE CIRCUIT….5746
          Diagnosis Procedure….5746
        AFS BRANCH LINE CIRCUIT….5748
          AFS BRANCH LINE CIRCUIT….5748
          Diagnosis Procedure….5748
        LANE BRANCH LINE CIRCUIT….5749
          LANE BRANCH LINE CIRCUIT….5749
          Diagnosis Procedure….5749
        PSB BRANCH LINE CIRCUIT….5750
          PSB BRANCH LINE CIRCUIT….5750
          Diagnosis Procedure….5750
        SONAR BRANCH LINE CIRCUIT….5751
          SONAR BRANCH LINE CIRCUIT….5751
          Diagnosis Procedure….5751
        APA BRANCH LINE CIRCUIT….5752
          APA BRANCH LINE CIRCUIT….5752
          Diagnosis Procedure….5752
        BCU BRANCH LINE CIRCUIT….5753
          BCU BRANCH LINE CIRCUIT….5753
          Diagnosis Procedure….5753
        CAN COMMUNICATION CIRCUIT 1….5754
          CAN COMMUNICATION CIRCUIT 1….5754
          Diagnosis Procedure….5754
        CAN COMMUNICATION CIRCUIT 2….5756
          CAN COMMUNICATION CIRCUIT 2….5756
          Diagnosis Procedure….5756
        ITS COMMUNICATION CIRCUIT….5758
          ITS COMMUNICATION CIRCUIT….5758
          Diagnosis Procedure….5758
    CAN SYSTEM (TYPE 8)….5760
      CAN SYSTEM (TYPE 8)….5760
      DTC/CIRCUIT DIAGNOSIS….5760
        MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5760
          MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5760
          Diagnosis Procedure….5760
        MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5761
          MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5761
          Diagnosis Procedure….5761
        MAIN LINE BETWEEN PWBD AND TPMS CIRCUIT….5762
          MAIN LINE BETWEEN PWBD AND TPMS CIRCUIT….5762
          Diagnosis Procedure….5762
        MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5763
          MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5763
          Diagnosis Procedure….5763
        MAIN LINE BETWEEN AV AND ABS CIRCUIT….5764
          MAIN LINE BETWEEN AV AND ABS CIRCUIT….5764
          Diagnosis Procedure….5764
        ECM BRANCH LINE CIRCUIT….5765
          ECM BRANCH LINE CIRCUIT….5765
          Diagnosis Procedure….5765
        4WD BRANCH LINE CIRCUIT….5766
          4WD BRANCH LINE CIRCUIT….5766
          Diagnosis Procedure….5766
        DLC BRANCH LINE CIRCUIT….5767
          DLC BRANCH LINE CIRCUIT….5767
          Diagnosis Procedure….5767
        TCM BRANCH LINE CIRCUIT….5768
          TCM BRANCH LINE CIRCUIT….5768
          Diagnosis Procedure….5768
        BCM BRANCH LINE CIRCUIT….5769
          BCM BRANCH LINE CIRCUIT….5769
          Diagnosis Procedure….5769
        M&A BRANCH LINE CIRCUIT….5770
          M&A BRANCH LINE CIRCUIT….5770
          Diagnosis Procedure….5770
        STRG BRANCH LINE CIRCUIT….5771
          STRG BRANCH LINE CIRCUIT….5771
          Diagnosis Procedure….5771
        PWBD BRANCH LINE CIRCUIT….5772
          PWBD BRANCH LINE CIRCUIT….5772
          Diagnosis Procedure….5772
        ABS BRANCH LINE CIRCUIT….5773
          ABS BRANCH LINE CIRCUIT….5773
          Diagnosis Procedure….5773
        IPDM-E BRANCH LINE CIRCUIT….5774
          IPDM-E BRANCH LINE CIRCUIT….5774
          Diagnosis Procedure….5774
        A-BAG BRANCH LINE CIRCUIT….5775
          A-BAG BRANCH LINE CIRCUIT….5775
          Diagnosis Procedure….5775
        TPMS BRANCH LINE CIRCUIT….5776
          TPMS BRANCH LINE CIRCUIT….5776
          Diagnosis Procedure….5776
        AV BRANCH LINE CIRCUIT….5777
          AV BRANCH LINE CIRCUIT….5777
          Diagnosis Procedure….5777
        CAN COMMUNICATION CIRCUIT….5779
          CAN COMMUNICATION CIRCUIT….5779
          Diagnosis Procedure….5779
    CAN SYSTEM (TYPE 9)….5781
      CAN SYSTEM (TYPE 9)….5781
      DTC/CIRCUIT DIAGNOSIS….5781
        MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5781
          MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5781
          Diagnosis Procedure….5781
        MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5782
          MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5782
          Diagnosis Procedure….5782
        MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5783
          MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5783
          Diagnosis Procedure….5783
        MAIN LINE BETWEEN ADP AND TPMS CIRCUIT….5784
          MAIN LINE BETWEEN ADP AND TPMS CIRCUIT….5784
          Diagnosis Procedure….5784
        MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5785
          MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5785
          Diagnosis Procedure….5785
        MAIN LINE BETWEEN AV AND ABS CIRCUIT….5786
          MAIN LINE BETWEEN AV AND ABS CIRCUIT….5786
          Diagnosis Procedure….5786
        ECM BRANCH LINE CIRCUIT….5787
          ECM BRANCH LINE CIRCUIT….5787
          Diagnosis Procedure….5787
        4WD BRANCH LINE CIRCUIT….5788
          4WD BRANCH LINE CIRCUIT….5788
          Diagnosis Procedure….5788
        DLC BRANCH LINE CIRCUIT….5789
          DLC BRANCH LINE CIRCUIT….5789
          Diagnosis Procedure….5789
        TCM BRANCH LINE CIRCUIT….5790
          TCM BRANCH LINE CIRCUIT….5790
          Diagnosis Procedure….5790
        BCM BRANCH LINE CIRCUIT….5791
          BCM BRANCH LINE CIRCUIT….5791
          Diagnosis Procedure….5791
        M&A BRANCH LINE CIRCUIT….5792
          M&A BRANCH LINE CIRCUIT….5792
          Diagnosis Procedure….5792
        STRG BRANCH LINE CIRCUIT….5793
          STRG BRANCH LINE CIRCUIT….5793
          Diagnosis Procedure….5793
        PWBD BRANCH LINE CIRCUIT….5794
          PWBD BRANCH LINE CIRCUIT….5794
          Diagnosis Procedure….5794
        ADP BRANCH LINE CIRCUIT….5795
          ADP BRANCH LINE CIRCUIT….5795
          Diagnosis Procedure….5795
        ABS BRANCH LINE CIRCUIT….5796
          ABS BRANCH LINE CIRCUIT….5796
          Diagnosis Procedure….5796
        IPDM-E BRANCH LINE CIRCUIT….5797
          IPDM-E BRANCH LINE CIRCUIT….5797
          Diagnosis Procedure….5797
        A-BAG BRANCH LINE CIRCUIT….5798
          A-BAG BRANCH LINE CIRCUIT….5798
          Diagnosis Procedure….5798
        TPMS BRANCH LINE CIRCUIT….5799
          TPMS BRANCH LINE CIRCUIT….5799
          Diagnosis Procedure….5799
        AV BRANCH LINE CIRCUIT….5800
          AV BRANCH LINE CIRCUIT….5800
          Diagnosis Procedure….5800
        CAN COMMUNICATION CIRCUIT….5802
          CAN COMMUNICATION CIRCUIT….5802
          Diagnosis Procedure….5802
    CAN SYSTEM (TYPE 10)….5804
      CAN SYSTEM (TYPE 10)….5804
      DTC/CIRCUIT DIAGNOSIS….5804
        MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5804
          MAIN LINE BETWEEN DLC AND M&A CIRCUIT….5804
          Diagnosis Procedure….5804
        MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5805
          MAIN LINE BETWEEN M&A AND PWBD CIRCUIT….5805
          Diagnosis Procedure….5805
        MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5806
          MAIN LINE BETWEEN PWBD AND ADP CIRCUIT….5806
          Diagnosis Procedure….5806
        MAIN LINE BETWEEN ADP AND TPMS CIRCUIT….5807
          MAIN LINE BETWEEN ADP AND TPMS CIRCUIT….5807
          Diagnosis Procedure….5807
        MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5808
          MAIN LINE BETWEEN TPMS AND AV CIRCUIT….5808
          Diagnosis Procedure….5808
        MAIN LINE BETWEEN AV AND AFS CIRCUIT….5809
          MAIN LINE BETWEEN AV AND AFS CIRCUIT….5809
          Diagnosis Procedure….5809
        MAIN LINE BETWEEN AFS AND ABS CIRCUIT….5810
          MAIN LINE BETWEEN AFS AND ABS CIRCUIT….5810
          Diagnosis Procedure….5810
        ECM BRANCH LINE CIRCUIT….5811
          ECM BRANCH LINE CIRCUIT….5811
          Diagnosis Procedure….5811
        4WD BRANCH LINE CIRCUIT….5812
          4WD BRANCH LINE CIRCUIT….5812
          Diagnosis Procedure….5812
…
          Oil Pump….6018
          Regulator Valve….6018
    VK50VE….6019
      VK50VE….6019
      SYSTEM DESCRIPTION….6019
        DESCRIPTION….6019
          DESCRIPTION….6019
          Engine Lubrication System….6019
          Engine Lubrication System Schematic….6020
      PRECAUTION….6021
        PRECAUTIONS….6021
          PRECAUTIONS….6021
          Precautions for Removing Battery Terminal….6021
          Liquid Gasket….6021
            LIQUID GASKET APPLICATION PROCEDURE….6021
          Precautions For Engine Service….6021
            DISCONNECTING FUEL PIPING….6021
            DRAINING ENGINE COOLANT….6021
            INSPECTION, REPAIR AND REPLACEMENT….6021
            REMOVAL AND DISASSEMBLY….6021
            ASSEMBLY AND INSTALLATION….6022
      PREPARATION….6023
        PREPARATION….6023
          PREPARATION….6023
          Special Service Tools….6023
          Commercial Service Tools….6023
      PERIODIC MAINTENANCE….6024
        ENGINE OIL….6024
          ENGINE OIL….6024
          Inspection….6024
            ENGINE OIL LEVEL….6024
            ENGINE OIL APPEARANCE….6024
            ENGINE OIL LEAKAGE….6024
            OIL PRESSURE CHECK….6024
          Draining….6025
          Refilling….6026
        OIL FILTER….6027
          OIL FILTER….6027
          Removal and Installation….6027
            REMOVAL….6027
            INSTALLATION….6027
          Inspection….6027
            INSPECTION AFTER INSTALLATION….6027
      REMOVAL AND INSTALLATION….6028
        OIL COOLER….6028
          OIL COOLER….6028
          Exploded View….6028
          Removal and Installation….6028
            REMOVAL….6028
            INSTALLATION….6029
          Inspection….6029
            INSPECTION AFTER REMOVAL….6029
              Oil Cooler….6029
              Relief Valve….6029
            INSPECTION AFTER INSTALLATION….6029
      UNIT DISASSEMBLY AND ASSEMBLY….6030
        OIL PUMP….6030
          OIL PUMP….6030
          Exploded View….6030
          Disassembly and Assembly….6030
            DISASSEMBLY….6030
            ASSEMBLY….6030
          Inspection….6030
            INSPECTION AFTER INSTALLATION….6030
      SERVICE DATA AND SPECIFICATIONS (SDS)….6032
        SERVICE DATA AND SPECIFICATIONS (SDS)….6032
          SERVICE DATA AND SPECIFICATIONS (SDS)….6032
          Periodical Maintenance Specification….6032
            ENGINE OIL CAPACITY (APPROXIMATELY)….6032
          Engine Oil Pressure….6032
ma….6033
  Table of Contents….6033
    PREPARATION….6036
      PREPARATION….6036
        PREPARATION….6036
        Special Service Tool….6036
        Commercial Service Tool….6036
          VQ37VHR ENGINE MODELS….6036
          VK50VE ENGINE MODELS….6036
    PERIODIC MAINTENANCE….6038
      GENERAL MAINTENANCE….6038
        GENERAL MAINTENANCE….6038
        FOR NORTH AMERICA….6038
          FOR NORTH AMERICA : Explanation of General Maintenance….6038
            OUTSIDE THE VEHICLE….6038
            INSIDE THE VEHICLE….6038
            UNDER THE HOOD AND VEHICLE….6039
        FOR MEXICO….6039
          FOR MEXICO : General Maintenance….6040
            OUTSIDE THE VEHICLE….6040
            INSIDE THE VEHICLE….6040
            UNDER THE HOOD AND VEHICLE….6041
      PERIODIC MAINTENANCE….6042
        PERIODIC MAINTENANCE….6042
        FOR NORTH AMERICA….6042
          FOR NORTH AMERICA : Introduction of Periodic Maintenance….6042
            Emission Control System Maintenance….6042
            Chassis and Body Maintenance….6043
            MAINTENANCE UNDER SEVERE DRIVING CONDITIONS….6044
        FOR MEXICO….6045
          FOR MEXICO : Introduction of Periodic Maintenance….6045
            ENGINE AND EMISSION CONTROL MAINTENANCE….6045
            CHASSIS AND BODY MAINTENANCE….6046
            MAINTENANCE UNDER SEVERE DRIVING CONDITIONS….6047
      RECOMMENDED FLUIDS AND LUBRICANTS….6049
        RECOMMENDED FLUIDS AND LUBRICANTS….6049
        FOR NORTH AMERICA….6049
          FOR NORTH AMERICA : Fluids and Lubricants….6049
          FOR NORTH AMERICA : Engine Oil Recommendation….6049
          FOR NORTH AMERICA : Anti-Freeze Coolant Mixture Ratio….6050
        FOR MEXICO….6050
          FOR MEXICO : Fluids and Lubricants….6050
          FOR MEXICO : SAE Viscosity Number….6051
            DIFFERENTIAL GEAR OIL….6051
          FOR MEXICO : Engine Coolant Mixture Ratio….6052
      ENGINE MAINTENANCE (VQ37VHR)….6053
        ENGINE MAINTENANCE (VQ37VHR)….6053
        DRIVE BELT….6053
          DRIVE BELT : Exploded View….6053
          DRIVE BELT : Checking….6053
          DRIVE BELT : Tension Adjustment….6053
        ENGINE COOLANT….6053
          ENGINE COOLANT : Draining….6053
          ENGINE COOLANT : Refilling….6054
          ENGINE COOLANT : Flushing….6056
        FUEL LINES….6057
          FUEL LINES : Inspection….6057
        AIR CLEANER FILTER….6057
          AIR CLEANER FILTER : Removal and Installation….6057
            REMOVAL….6057
            INSTALLATION….6057
          AIR CLEANER FILTER : Inspection (Viscous Paper Type)….6058
            INSPECTION AFTER REMOVAL….6058
            MAINTENANCE INTERVAL….6058
        ENGINE OIL….6058
          ENGINE OIL : Draining….6058
          ENGINE OIL : Refilling….6058
        OIL FILTER….6058
          OIL FILTER : Removal and Installation….6059
            REMOVAL….6059
            INSTALLATION….6059
          OIL FILTER : Inspection….6060
            INSPECTION AFTER INSTALLATION….6060
        SPARK PLUG….6060
          SPARK PLUG : Removal and Installation….6060
            REMOVAL….6060
            INSTALLATION….6060
          SPARK PLUG : Inspection….6060
            INSPECTION AFTER REMOVAL….6060
        EVAP VAPOR LINES….6061
          EVAP VAPOR LINES : Inspection….6061
      ENGINE MAINTENANCE (VK50VE)….6062
        ENGINE MAINTENANCE (VK50VE)….6062
        DRIVE BELTS….6062
          DRIVE BELTS : Exploded View….6062
          DRIVE BELTS : Checking….6062
          DRIVE BELTS : Tension Adjustment….6063
        ENGINE COOLANT….6063
          ENGINE COOLANT : Draining….6063
          ENGINE COOLANT : Refilling….6063
          ENGINE COOLANT : Flushing….6065
        FUEL LINES….6066
          FUEL LINES : Inspection….6066
        AIR CLEANER FILTER….6066
          AIR CLEANER FILTER : Removal and Installation….6066
            REMOVAL….6066
            INSTALLATION….6067
          AIR CLEANER FILTER : Inspection (Viscous Paper Type)….6067
            INSPECTION AFTER REMOVAL….6067
            MAINTENANCE INTERVAL….6067
        ENGINE OIL….6067
          ENGINE OIL : Draining….6067
          ENGINE OIL : Refilling….6067
        OIL FILTER….6068
          OIL FILTER : Removal and Installation….6068
            REMOVAL….6068
            INSTALLATION….6068
          OIL FILTER : Inspection….6069
            INSPECTION AFTER INSTALLATION….6069
        SPARK PLUG….6069
          SPARK PLUG : Removal and Installation….6069
            REMOVAL….6069
            INSTALLATION….6069
          SPARK PLUG : Inspection….6069
            INSPECTION AFTER REMOVAL….6069
        EVAP VAPOR LINES….6070
          EVAP VAPOR LINES : Inspection….6070
      CHASSIS MAINTENANCE….6071
        CHASSIS MAINTENANCE….6071
        EXHAUST SYSTEM….6071
          EXHAUST SYSTEM : Inspection….6071
        A/T FLUID: RE7R01A….6071
          A/T FLUID: RE7R01A : Inspection….6071
            FLUID LEAKAGE….6071
          A/T FLUID: RE7R01A : Changing….6071
          A/T FLUID: RE7R01A : Adjustment….6073
        A/T FLUID: RE7R01B….6073
          A/T FLUID: RE7R01B : Inspection….6073
            FLUID LEAKAGE….6073
          A/T FLUID: RE7R01B : Changing….6074
          A/T FLUID: RE7R01B : Adjustment….6075
        TRANSFER FLUID….6076
          TRANSFER FLUID : Inspection….6076
            FLUID LEAKAGE….6076
            FLUID LEVEL….6076
          TRANSFER FLUID : Draining….6076
          TRANSFER FLUID : Refilling….6077
        FRONT PROPELLER SHAFT: 2S56A….6077
          FRONT PROPELLER SHAFT: 2S56A : Inspection….6077
            NOISE….6077
            VIBRATION….6077
        REAR PROPELLER SHAFT: 3S80A-R….6078
          REAR PROPELLER SHAFT: 3S80A-R : Inspection….6078
            NOISE….6078
            VIBRATION….6078
        REAR PROPELLER SHAFT: 3F80A-1VL107….6078
          REAR PROPELLER SHAFT: 3F80A-1VL107 : Inspection….6078
            NOISE….6078
            VIBRATION….6078
        REAR PROPELLER SHAFT: 3F-R-2VL107….6079
          REAR PROPELLER SHAFT: 3F-R-2VL107 : Inspection….6079
            NOISE….6079
            VIBRATION….6079
        FRONT DIFFERENTIAL GEAR OIL: F160A….6080
          FRONT DIFFERENTIAL GEAR OIL: F160A : Inspection….6080
            OIL LEAKAGE….6080
            OIL LEVEL….6080
          FRONT DIFFERENTIAL GEAR OIL: F160A : Draining….6080
          FRONT DIFFERENTIAL GEAR OIL: F160A : Refilling….6081
        REAR DIFFERENTIAL GEAR OIL: R200….6081
          REAR DIFFERENTIAL GEAR OIL: R200 : Inspection….6081
            OIL LEAKAGE….6081
            OIL LEVEL….6081
          REAR DIFFERENTIAL GEAR OIL: R200 : Draining….6081
          REAR DIFFERENTIAL GEAR OIL: R200 : Refilling….6082
        REAR DIFFERENTIAL GEAR OIL: R230….6082
          REAR DIFFERENTIAL GEAR OIL: R230 : Inspection….6082
            OIL LEAKAGE….6082
            OIL LEVEL….6082
          REAR DIFFERENTIAL GEAR OIL: R230 : Draining….6082
          REAR DIFFERENTIAL GEAR OIL: R230 : Refilling….6083
        WHEELS (BONDING WEIGHT TYPE)….6083
          WHEELS (BONDING WEIGHT TYPE) : Adjustment….6083
            BALANCING WHEELS (BONDING WEIGHT TYPE)….6083
              Preparation Before Adjustment….6083
              Wheel Balance Adjustment….6083
            TIRE ROTATION….6084
        BRAKE FLUID LEVEL AND LEAKS….6085
          BRAKE FLUID LEVEL AND LEAKS : Inspection….6085
        BRAKE LINES AND CABLES….6085
          BRAKE LINES AND CABLES : Inspection….6085
        BRAKE FLUID….6085
          BRAKE FLUID : Changing….6085
        DISC BRAKE….6085
          DISC BRAKE : Inspection….6085
            DISC ROTOR….6085
            CALIPER….6085
            BRAKE PAD….6086
          DISC BRAKE : Front Disc Brake….6086
            2 PISTON TYPE….6086
              FOR MEXICO….6086
              EXPECT FOR MEXICO….6086
            4 PISTON TYPE….6086
          DISC BRAKE : Rear Disc Brake….6087
            1 PISTON TYPE….6087
            2 PISTON TYPE….6087
        STEERING GEAR AND LINKAGE….6087
          STEERING GEAR AND LINKAGE : Inspection….6087
            STEERING GEAR….6087
            STEERING LINKAGE….6087
        POWER STEERING FLUID AND LINES….6087
          POWER STEERING FLUID AND LINES : Inspection….6087
        AXLE AND SUSPENSION PARTS….6088
          AXLE AND SUSPENSION PARTS : Inspection….6088
        DRIVE SHAFT….6088
          DRIVE SHAFT : Inspection….6088
      BODY MAINTENANCE….6089
        BODY MAINTENANCE….6089
        LOCKS, HINGES AND HOOD LATCH….6089
          LOCKS, HINGES AND HOOD LATCH : Lubricating….6089
        SEAT BELT, BUCKLES, RETRACTORS, ANCHORS AND ADJUSTERS….6089
          SEAT BELT, BUCKLES, RETRACTORS, ANCHORS AND ADJUSTERS : Inspection….6089
    SERVICE DATA AND SPECIFICATIONS (SDS)….6090
      SERVICE DATA AND SPECIFICATIONS (SDS)….6090
        SERVICE DATA AND SPECIFICATIONS (SDS)….6090
        DRIVE BELT (VQ37VHR)….6090
          DRIVE BELT (VQ37VHR) : Drive Belt….6090
            DRIVE BELT….6090
        DRIVE BELTS (VK50VE)….6090
          DRIVE BELTS (VK50VE) : Drive Belts….6090
            DRIVE BELT….6090
        ENGINE COOLANT (VQ37VHR)….6090
          ENGINE COOLANT (VQ37VHR) : Periodical Maintenance Specification….6090
            ENGINE COOLANT CAPACITY (APPROXIMATELY)….6090
        ENGINE COOLANT (VK50VE)….6090
          ENGINE COOLANT (VK50VE) : Periodical Maintenance Specification….6090
            ENGINE COOLANT CAPACITY (APPROXIMATELY)….6090
        ENGINE OIL (VQ37VHR)….6090
          ENGINE OIL (VQ37VHR) : Periodical Maintenance Specification….6090
            ENGINE OIL CAPACITY (APPROXIMATELY)….6090
        ENGINE OIL (VK50VE)….6090
          ENGINE OIL (VK50VE) : Periodical Maintenance Specification….6090
            ENGINE OIL CAPACITY (APPROXIMATELY)….6090
        SPARK PLUG (VQ37VHR)….6091
          SPARK PLUG (VQ37VHR) : Spark Plug….6091
            SPARK PLUG….6091
        SPARK PLUG (VK50VE)….6091
          SPARK PLUG (VK50VE) : Spark Plug….6091
            SPARK PLUG….6091
        ROAD WHEEL….6091
          ROAD WHEEL : Road Wheel….6091
            ALUMINUM WHEEL (CONVENTIONAL)….6091
            STEEL WHEEL (FOR EMERGENCY USE)….6091
mir….6092
  Table of Contents….6092
    WITH ADP….6094
      WITH ADP….6094
      BASIC INSPECTION….6094
        DIAGNOSIS AND REPAIR WORKFLOW….6094
          DIAGNOSIS AND REPAIR WORKFLOW….6094
          Work Flow….6094
            DETAILED FLOW….6094
      SYSTEM DESCRIPTION….6095
        DOOR MIRROR SYSTEM….6095
          DOOR MIRROR SYSTEM….6095
          System Diagram….6095
          System Description….6095
            MANUAL FUNCTION….6095
              Description….6095
              Operation Conditions….6095
            REVERSE INTERLOCK DOOR MIRROR SYSTEM….6095
              Description….6095
              Operation Conditions….6095
              Mirror Angle Memory Function….6095
              Memory Procedure….6096
            AUTOMATIC DRIVE POSITIONER SYSTEM LINKED OPERATION….6096
              Description….6096
          Component Parts Location….6096
          Component Description….6097
        INSIDE MIRROR SYSTEM….6098
          INSIDE MIRROR SYSTEM….6098
          System Description….6098
          Component Description….6098
        DIAGNOSIS SYSTEM (DRIVER SEAT CONTROL UNIT)….6099
          DIAGNOSIS SYSTEM (DRIVER SEAT CONTROL UNIT)….6099
          CONSULT Function….6099
            APPLICATION ITEM….6099
            SELF-DIAGNOSIS RESULTS….6099
            DATA MONITOR….6099
            ACTIVE TEST….6100
            WORK SUPPORT….6100
      DTC/CIRCUIT DIAGNOSIS….6102
        DOOR MIRROR REMOTE CONTROL SWITCH….6102
          DOOR MIRROR REMOTE CONTROL SWITCH….6102
          MIRROR SWITCH….6102
            MIRROR SWITCH : Description….6102
            MIRROR SWITCH : Component Function Check….6102
            MIRROR SWITCH : Diagnosis Procedure….6102
            MIRROR SWITCH : Component Inspection….6103
          CHANGEOVER SWITCH….6104
            CHANGEOVER SWITCH : Description….6104
            CHANGEOVER SWITCH : Component Function Check….6104
            CHANGEOVER SWITCH : Diagnosis Procedure….6104
            CHANGEOVER SWITCH : Component Inspection….6105
        AUTO ANTI-DAZZLING INSIDE MIRROR SYSTEM….6107
          AUTO ANTI-DAZZLING INSIDE MIRROR SYSTEM….6107
          Wiring Diagram – INSIDE MIRROR SYSTEM -….6107
        MIRROR SYSTEM….6110
          MIRROR SYSTEM….6110
          Wiring Diagram – MIRROR SYSTEM -….6110
      ECU DIAGNOSIS INFORMATION….6119
        DRIVER SEAT CONTROL UNIT….6119
          DRIVER SEAT CONTROL UNIT….6119
          Reference Value….6119
            VALUES ON THE DIAGNOSIS TOOL….6119
            TERMINAL LAYOUT….6120
            PHYSICAL VALUES….6120
          Wiring Diagram – AUTOMATIC DRIVE POSITIONER CONTROL SYSTEM -….6124
          Fail Safe….6135
          DTC Index….6136
        AUTOMATIC DRIVE POSITIONER CONTROL UNIT….6137
          AUTOMATIC DRIVE POSITIONER CONTROL UNIT….6137
          Reference Value….6137
            TERMINAL LAYOUT….6137
            PHYSICAL VALUES….6137
          Wiring Diagram – AUTOMATIC DRIVE POSITIONER CONTROL SYSTEM -….6141
      SYMPTOM DIAGNOSIS….6153
        DOOR MIRROR DOES NOT OPERATE….6153
          DOOR MIRROR DOES NOT OPERATE….6153
          Diagnosis Procedure….6153
        REVERSE INTERLOCK DOOR MIRROR DOES NOT OPERATE….6154
          REVERSE INTERLOCK DOOR MIRROR DOES NOT OPERATE….6154
          Diagnosis Procedure….6154
        SQUEAK AND RATTLE TROUBLE DIAGNOSES….6155
          SQUEAK AND RATTLE TROUBLE DIAGNOSES….6155
          Work Flow….6155
            CUSTOMER INTERVIEW….6155
            DUPLICATE THE NOISE AND TEST DRIVE….6155
            CHECK RELATED SERVICE BULLETINS….6156
            LOCATE THE NOISE AND IDENTIFY THE ROOT CAUSE….6156
            REPAIR THE CAUSE….6156
            CONFIRM THE REPAIR….6157
          Inspection Procedure….6157
            INSTRUMENT PANEL….6157
            CENTER CONSOLE….6157
            DOORS….6157
            TRUNK….6157
            SUNROOF/HEADLINING….6158
            SEATS….6158
            UNDERHOOD….6158
          Diagnostic Worksheet….6159
      PRECAUTION….6161
        PRECAUTIONS….6161
          PRECAUTIONS….6161
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….6161
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….6161
          Precaution for Procedure without Cowl Top Cover….6161
          Precautions for Removing Battery Terminal….6162
      PREPARATION….6163
        PREPARATION….6163
          PREPARATION….6163
          Commercial Service Tools….6163
      REMOVAL AND INSTALLATION….6164
        INSIDE MIRROR….6164
          INSIDE MIRROR….6164
          Exploded View….6164
            Base model….6164
            Option model….6164
          Removal and Installation….6165
            REMOVAL….6165
              Base model….6165
              Option model….6165
            INSTALLATION….6165
        DOOR MIRROR….6166
          DOOR MIRROR….6166
          Exploded View….6166
          DOOR MIRROR ASSEMBLY….6166
            DOOR MIRROR ASSEMBLY : Removal and Installation….6166
              REMOVAL….6166
              INSTALLATION….6166
            DOOR MIRROR ASSEMBLY : Disassembly and Assembly….6166
              DISASSEMBLY….6166
              ASSEMBLY….6167
          GLASS MIRROR….6167
            GLASS MIRROR : Removal and Installation….6167
              DISASSEMBLY….6167
              ASSEMBLY….6167
          DOOR MIRROR COVER….6167
            DOOR MIRROR COVER : Removal and Installation….6167
              DISASSEMBLY….6167
              ASSEMBLY….6168
        DOOR MIRROR REMOTE CONTROL SWITCH….6169
          DOOR MIRROR REMOTE CONTROL SWITCH….6169
          Exploded View….6169
          Removal and Installation….6169
            REMOVAL….6169
            INSTALLATION….6169
    WITHOUT ADP….6170
      WITHOUT ADP….6170
      SYSTEM DESCRIPTION….6170
        DOOR MIRROR SYSTEM….6170
          DOOR MIRROR SYSTEM….6170
          Component Description….6170
        INSIDE MIRROR SYSTEM….6171
          INSIDE MIRROR SYSTEM….6171
          System Description….6171
          Component Description….6171
      DTC/CIRCUIT DIAGNOSIS….6172
        AUTO ANTI-DAZZLING INSIDE MIRROR SYSTEM….6172
          AUTO ANTI-DAZZLING INSIDE MIRROR SYSTEM….6172
          Wiring Diagram – INSIDE MIRROR SYSTEM -….6172
        MIRROR SYSTEM….6175
          MIRROR SYSTEM….6175
          Wiring Diagram – MIRROR SYSTEM -….6175
      SYMPTOM DIAGNOSIS….6179
        SQUEAK AND RATTLE TROUBLE DIAGNOSES….6179
          SQUEAK AND RATTLE TROUBLE DIAGNOSES….6179
          Work Flow….6179
            CUSTOMER INTERVIEW….6179
            DUPLICATE THE NOISE AND TEST DRIVE….6179
            CHECK RELATED SERVICE BULLETINS….6180
            LOCATE THE NOISE AND IDENTIFY THE ROOT CAUSE….6180
            REPAIR THE CAUSE….6180
            CONFIRM THE REPAIR….6181
          Inspection Procedure….6181
            INSTRUMENT PANEL….6181
            CENTER CONSOLE….6181
            DOORS….6181
            TRUNK….6181
            SUNROOF/HEADLINING….6182
            SEATS….6182
            UNDERHOOD….6182
          Diagnostic Worksheet….6183
      PRECAUTION….6185
        PRECAUTIONS….6185
          PRECAUTIONS….6185
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….6185
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….6185
          Precaution for Procedure without Cowl Top Cover….6185
          Precautions for Removing Battery Terminal….6186
      PREPARATION….6187
        PREPARATION….6187
          PREPARATION….6187
          Commercial Service Tools….6187
      REMOVAL AND INSTALLATION….6188
        INSIDE MIRROR….6188
          INSIDE MIRROR….6188
          Exploded View….6188
            Base model….6188
            Option model….6188
          Removal and Installation….6189
            REMOVAL….6189
              Base model….6189
              Option model….6189
            INSTALLATION….6189
        DOOR MIRROR….6190
          DOOR MIRROR….6190
          Exploded View….6190
          DOOR MIRROR ASSEMBLY….6190
            DOOR MIRROR ASSEMBLY : Removal and Installation….6190
              REMOVAL….6190
              INSTALLATION….6190
            DOOR MIRROR ASSEMBLY : Disassembly and Assembly….6190
              DISASSEMBLY….6190
              ASSEMBLY….6191
          GLASS MIRROR….6191
            GLASS MIRROR : Removal and Installation….6191
              DISASSEMBLY….6191
              ASSEMBLY….6191
          DOOR MIRROR COVER….6191
            DOOR MIRROR COVER : Removal and Installation….6191
              DISASSEMBLY….6191
              ASSEMBLY….6192
        DOOR MIRROR REMOTE CONTROL SWITCH….6193
          DOOR MIRROR REMOTE CONTROL SWITCH….6193
          Exploded View….6193
          Removal and Installation….6193
            REMOVAL….6193
            INSTALLATION….6193
mwi….6194
  Table of Contents….6194
    BASIC INSPECTION….6197
      DIAGNOSIS AND REPAIR WORKFLOW….6197
        DIAGNOSIS AND REPAIR WORKFLOW….6197
        Work flow….6197
          OVERALL SEQUENCE….6197
          DETAILED FLOW….6197
    SYSTEM DESCRIPTION….6199
      METER SYSTEM….6199
        METER SYSTEM….6199
        METER SYSTEM….6199
          METER SYSTEM : System Diagram….6199
          METER SYSTEM : System Description….6199
            COMBINATION METER….6199
            UNIFIED METER AND A/C AMP…6199
            IPDM E/R….6200
            METER CONTROL FUNCTION LIST….6200
            ARRANGEMENT OF COMBINATION METER….6202
          METER SYSTEM : Component Parts Location….6203
          METER SYSTEM : Component Description….6204
        SPEEDOMETER….6205
          SPEEDOMETER : System Diagram….6205
          SPEEDOMETER : System Description….6205
          SPEEDOMETER : Component Parts Location….6206
          SPEEDOMETER : Component Description….6207
        TACHOMETER….6207
          TACHOMETER : System Diagram….6207
          TACHOMETER : System Description….6207
          TACHOMETER : Component Parts Location….6208
          TACHOMETER : Component Description….6209
        ENGINE COOLANT TEMPERATURE GAUGE….6209
          ENGINE COOLANT TEMPERATURE GAUGE : System Diagram….6209
          ENGINE COOLANT TEMPERATURE GAUGE : System Description….6209
          ENGINE COOLANT TEMPERATURE GAUGE : Component Parts Location….6210
          ENGINE COOLANT TEMPERATURE GAUGE : Component Description….6211
        FUEL GAUGE….6211
          FUEL GAUGE : System Diagram….6211
          FUEL GAUGE : System Description….6211
            CONTROL OUTLINE….6211
            REFUEL CONTROL….6211
          FUEL GAUGE : Component Parts Location….6212
          FUEL GAUGE : Component Description….6213
        ODO/TRIP METER….6213
          ODO/TRIP METER : System Diagram….6213
          ODO/TRIP METER : System Description….6213
          ODO/TRIP METER : Component Parts Location….6214
          ODO/TRIP METER : Component Description….6215
        SHIFT POSITION INDICATOR….6215
          SHIFT POSITION INDICATOR : System Diagram….6215
          SHIFT POSITION INDICATOR : System Description….6215
            MANUAL MODE….6215
              When Operated with A/T Shift Selector….6215
              When Operated with Paddle Shifter….6216
            NON-MANUAL MODE….6216
          SHIFT POSITION INDICATOR : Component Parts Location….6217
          SHIFT POSITION INDICATOR : Component Description….6218
        WARNING LAMPS/INDICATOR LAMPS….6218
          WARNING LAMPS/INDICATOR LAMPS : System Diagram….6218
          WARNING LAMPS/INDICATOR LAMPS : System Description….6218
            OIL PRESSURE WARNING LAMP….6218
          WARNING LAMPS/INDICATOR LAMPS : Component Parts Location….6219
          WARNING LAMPS/INDICATOR LAMPS : Component Description….6220
        METER ILLUMINATION CONTROL….6220
          METER ILLUMINATION CONTROL : System Diagram….6220
          METER ILLUMINATION CONTROL : System Description….6220
            SYSTEM DESCRIPTION….6220
              Daytime Mode….6221
              Nighttime Mode….6221
              Driver Welcome Function….6221
          METER ILLUMINATION CONTROL : Component Parts Location….6222
          METER ILLUMINATION CONTROL : Component Description….6223
        METER EFFECT FUNCTION….6223
          METER EFFECT FUNCTION : System Diagram….6223
          METER EFFECT FUNCTION : System Description….6223
            SYSTEM DESCRIPTION….6223
              Engine-start Effect function….6224
              Ignition Switch OFF Effect Function….6224
          METER EFFECT FUNCTION : Component Parts Location….6225
          METER EFFECT FUNCTION : Component Description….6226
        INFORMATION DISPLAY….6226
          INFORMATION DISPLAY : System Diagram….6226
          INFORMATION DISPLAY : System Description….6226
            DESCRIPTION….6226
            PARKING BRAKE RELEASE WARNING….6227
              Warning Operation Condition….6227
            LOW FUEL WARNING….6227
              Warning Operation Condition….6227
            LOW WASHER FLUID WARNING….6227
              Warning Operation Condition….6227
            LOW OUTSIDE TEMPERATURE WARNING….6227
            DOOR OPEN WARNING….6227
            LOW TIRE PRESSURE WARNING….6227
            FUEL FILLER CAP WARNING….6227
            INSTANTANEOUS FUEL CONSUMPTION….6228
            AVERAGE FUEL CONSUMPTION….6228
            AVERAGE VEHICLE SPEED….6228
            TRAVEL TIME….6228
            TRAVEL DISTANCE….6228
            POSSIBLE DRIVING DISTANCE….6228
            AMBIENT AIR TEMPERATURE….6228
            SETTING….6229
          INFORMATION DISPLAY : Component Parts Location….6230
          INFORMATION DISPLAY : Component Description….6231
      COMPASS….6232
        COMPASS….6232
        Description….6232
          DESCRIPTION….6232
          ZONE VARIATION SETTING PROCEDURE….6232
          CALIBRATION PROCEDURE….6233
        Component Parts Location….6234
        Special Repair Requirement….6234
      CLOCK….6235
        CLOCK….6235
        Component Parts Location….6235
      DIAGNOSIS SYSTEM (METER)….6236
        DIAGNOSIS SYSTEM (METER)….6236
        Diagnosis Description….6236
          SELF-DIAGNOSIS MODE….6236
          OPERATION PROCEDURE….6236
      DIAGNOSIS SYSTEM (UNIFIED METER AND A/C AMP.)….6238
        DIAGNOSIS SYSTEM (UNIFIED METER AND A/C AMP.)….6238
        CONSULT Function (METER/M&A)….6238
          CONSULT APPLICATION ITEMS….6238
          SELF DIAG RESULT….6238
          DATA MONITOR….6238
            Display Item List….6238
    DTC/CIRCUIT DIAGNOSIS….6242
      U1000 CAN COMM CIRCUIT….6242
        U1000 CAN COMM CIRCUIT….6242
        Description….6242
        DTC Logic….6242
          DTC DETECTION LOGIC….6242
        Diagnosis Procedure….6242
      U1010 CONTROL UNIT (CAN)….6243
        U1010 CONTROL UNIT (CAN)….6243
        Description….6243
        DTC Logic….6243
          DTC DETECTION LOGIC….6243
        Diagnosis Procedure….6243
      B2201 COMMUNICATION ERROR 1….6244
        B2201 COMMUNICATION ERROR 1….6244
        Description….6244
        DTC Logic….6244
          DTC DETECTION LOGIC….6244
        Diagnosis Procedure….6244
      B2202 COMMUNICATION ERROR 2….6246
        B2202 COMMUNICATION ERROR 2….6246
        Description….6246
        DTC Logic….6246
          DTC DETECTION LOGIC….6246
        Diagnosis Procedure….6246
      B2205 VEHICLE SPEED….6248
        B2205 VEHICLE SPEED….6248
        Description….6248
        DTC Logic….6248
          DTC DETECTION LOGIC….6248
        Diagnosis Procedure….6248
      B2267 ENGINE SPEED….6249
        B2267 ENGINE SPEED….6249
        Description….6249
        DTC Logic….6249
          DTC DETECTION LOGIC….6249
        Diagnosis Procedure….6249
      B2268 WATER TEMP….6250
        B2268 WATER TEMP….6250
        Description….6250
        DTC Logic….6250
          DTC DETECTION LOGIC….6250
        Diagnosis Procedure….6250
      POWER SUPPLY AND GROUND CIRCUIT….6251
        POWER SUPPLY AND GROUND CIRCUIT….6251
        COMBINATION METER….6251
          COMBINATION METER : Diagnosis Procedure….6251
        UNIFIED METER AND A/C AMP…6251
          UNIFIED METER AND A/C AMP. : Diagnosis Procedure….6251
        IPDM E/R (INTELLIGENT POWER DISTRIBUTION MODULE ENGINE ROOM)….6252
          IPDM E/R (INTELLIGENT POWER DISTRIBUTION MODULE ENGINE ROOM) : Diagnosis Procedure….6252
      FUEL LEVEL SENSOR SIGNAL CIRCUIT….6254
        FUEL LEVEL SENSOR SIGNAL CIRCUIT….6254
        Description….6254
        Component Function Check….6254
        Diagnosis Procedure….6255
        Component Inspection….6256
      METER CONTROL SWITCH SIGNAL CIRCUIT….6258
        METER CONTROL SWITCH SIGNAL CIRCUIT….6258
        Description….6258
        Diagnosis Procedure….6258
        Component Inspection….6259
      TRIP A/B RESET SWITCH SIGNAL CIRCUIT….6260
        TRIP A/B RESET SWITCH SIGNAL CIRCUIT….6260
        Description….6260
        Diagnosis Procedure….6260
        Component Inspection….6260
      OIL PRESSURE SWITCH SIGNAL CIRCUIT….6262
        OIL PRESSURE SWITCH SIGNAL CIRCUIT….6262
        Description….6262
        Component Function Check….6262
        Diagnosis Procedure….6262
        Component Inspection….6262
      PARKING BRAKE SWITCH SIGNAL CIRCUIT….6263
        PARKING BRAKE SWITCH SIGNAL CIRCUIT….6263
        Description….6263
        Diagnosis Procedure….6263
        Component Inspection….6263
      WASHER LEVEL SWITCH SIGNAL CIRCUIT….6265
        WASHER LEVEL SWITCH SIGNAL CIRCUIT….6265
        Description….6265
        Diagnosis Procedure….6265
        Component Inspection….6265
      COMPASS….6266
        COMPASS….6266
        Wiring Diagram – COMPASS -….6266
      CLOCK….6269
        CLOCK….6269
        Wiring Diagram – CLOCK -….6269
    ECU DIAGNOSIS INFORMATION….6271
      COMBINATION METER….6271
        COMBINATION METER….6271
        Reference Value….6271
          VALUES ON THE DIAGNOSIS TOOL….6271
          TERMINAL LAYOUT….6271
          PHYSICAL VALUES….6271
        Wiring Diagram – METER -….6274
        Fail-Safe….6287
          FAIL-SAFE….6287
        DTC Index….6288
      UNIFIED METER AND A/C AMP…6289
        UNIFIED METER AND A/C AMP…6289
        Reference Value….6289
          VALUES ON THE DIAGNOSIS TOOL….6289
          TERMINAL LAYOUT….6293
          PHYSICAL VALUES….6293
        Wiring Diagram – METER -….6296
        Fail-Safe….6309
          FAIL-SAFE….6309
        DTC Index….6310
      IPDM E/R (INTELLIGENT POWER DISTRIBUTION MODULE ENGINE ROOM)….6311
        IPDM E/R (INTELLIGENT POWER DISTRIBUTION MODULE ENGINE ROOM)….6311
        Reference Value….6311
          VALUES ON THE DIAGNOSIS TOOL….6311
          TERMINAL LAYOUT….6313
          PHYSICAL VALUES….6313
        Wiring Diagram – IPDM E/R -….6318
        Fail-safe….6321
          CAN COMMUNICATION CONTROL….6321
            If No CAN Communication Is Available With ECM….6321
            If No CAN Communication Is Available With BCM….6322
          IGNITION RELAY MALFUNCTION DETECTION FUNCTION….6322
          FRONT WIPER CONTROL….6322
          STARTER MOTOR PROTECTION FUNCTION….6323
        DTC Index….6323
    SYMPTOM DIAGNOSIS….6324
      THE FUEL GAUGE POINTER DOES NOT MOVE….6324
        THE FUEL GAUGE POINTER DOES NOT MOVE….6324
        Description….6324
        Diagnosis Procedure….6324
      THE METER CONTROL SWITCH IS INOPERATIVE….6325
        THE METER CONTROL SWITCH IS INOPERATIVE….6325
        Description….6325
        Diagnosis Procedure….6325
      THE TRIP A/B RESET SWITCH IS INOPERATIVE….6326
        THE TRIP A/B RESET SWITCH IS INOPERATIVE….6326
        Description….6326
        Diagnosis Procedure….6326
      THE OIL PRESSURE WARNING LAMP DOES NOT TURN ON….6327
        THE OIL PRESSURE WARNING LAMP DOES NOT TURN ON….6327
        Description….6327
        Diagnosis Procedure….6327
      THE OIL PRESSURE WARNING LAMP DOES NOT TURN OFF….6328
        THE OIL PRESSURE WARNING LAMP DOES NOT TURN OFF….6328
        Description….6328
        Diagnosis Procedure….6328
      THE PARKING BRAKE RELEASE WARNING CONTINUES DISPLAYING, OR DOES NOT DISPLAY….6329
        THE PARKING BRAKE RELEASE WARNING CONTINUES DISPLAYING, OR DOES NOT DISPLAY….6329
        Description….6329
        Diagnosis Procedure….6329
      THE LOW WASHER FLUID WARNING CONTINUES DISPLAYING, or DOES NOT DISPLAY….6330
        THE LOW WASHER FLUID WARNING CONTINUES DISPLAYING, or DOES NOT DISPLAY….6330
        Description….6330
        Diagnosis Procedure….6330
      THE DOOR OPEN WARNING CONTINUES DISPLAYING, OR DOES NOT DISPLAY….6331
        THE DOOR OPEN WARNING CONTINUES DISPLAYING, OR DOES NOT DISPLAY….6331
        Description….6331
        Diagnosis Procedure….6331
      THE AMBIENT TEMPERATURE DISPLAY IS INCORRECT….6332
        THE AMBIENT TEMPERATURE DISPLAY IS INCORRECT….6332
        Description….6332
        Diagnosis Procedure….6332
      NORMAL OPERATING CONDITION….6333
        NORMAL OPERATING CONDITION….6333
        COMPASS….6333
          COMPASS : Description….6333
            COMPASS….6333
        INFORMATION DISPLAY….6333
          INFORMATION DISPLAY : Description….6333
            AMBIENT AIR TEMPERATURE….6333
            POSSIBLE DRIVING DISTANCE….6333
    PRECAUTION….6334
      PRECAUTIONS….6334
        PRECAUTIONS….6334
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….6334
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….6334
        Precautions for Removing Battery Terminal….6334
    PREPARATION….6335
      PREPARATION….6335
        PREPARATION….6335
        Commercial Service Tools….6335
    REMOVAL AND INSTALLATION….6336
      COMBINATION METER….6336
        COMBINATION METER….6336
        Exploded View….6336
          REMOVAL….6336
          DISASSEMBLY….6336
        Removal and Installation….6336
          REMOVAL….6336
          INSTALLATION….6336
        Disassembly and Assembly….6336
          DISASSEMBLY….6336
          ASSEMBLY….6336
      UNIFIED METER AND A/C AMP…6337
        UNIFIED METER AND A/C AMP…6337
        Exploded View….6337
          REMOVAL….6337
          DISASSEMBLY….6337
        Removal and Installation….6337
          REMOVAL….6337
          INSTALLATION….6337
      METER CONTROL SWITCH….6338
        METER CONTROL SWITCH….6338
        Exploded View….6338
          REMOVAL….6338
          DISASSEMBLY….6338
        Removal and Installation….6338
          REMOVAL….6338
          INSTALLATION….6338
      TRIP A/B RESET SWITCH….6339
        TRIP A/B RESET SWITCH….6339
        Exploded View….6339
        Removal and Installation….6339
          REMOVAL….6339
          INSTALLATION….6339
      COMPASS….6340
        COMPASS….6340
        Exploded View….6340
        Removal and Installation….6340
      CLOCK….6341
        CLOCK….6341
        Exploded View….6341
          REMOVAL….6341
          DISASSEMBLY….6341
        Removal and Installation….6341
          REMOVAL….6341
          INSTALLATION….6341
pb….6342
  Table of Contents….6342
    PRECAUTION….6343
      PRECAUTIONS….6343
        PRECAUTIONS….6343
        Precautions for Removing Battery Terminal….6343
    PREPARATION….6344
      PREPARATION….6344
        PREPARATION….6344
        Commercial Service Tool….6344
    PERIODIC MAINTENANCE….6345
      PARKING BRAKE SYSTEM….6345
        PARKING BRAKE SYSTEM….6345
        Inspection and Adjustment….6345
          INSPECTION….6345
            Pedal Stroke….6345
            Inspect Components….6345
          ADJUSTMENT….6345
      PARKING BRAKE SHOE….6346
        PARKING BRAKE SHOE….6346
        Adjustment….6346
    REMOVAL AND INSTALLATION….6347
      PARKING BRAKE CONTROL….6347
        PARKING BRAKE CONTROL….6347
        Exploded View….6347
        Removal and Installation….6347
          REMOVAL….6347
          INSTALLATION….6348
        Adjustment….6348
          ADJUSTMENT AFTER INSTALLATION….6348
      PARKING BRAKE SHOE….6349
        PARKING BRAKE SHOE….6349
        Exploded View….6349
        Removal and Installation….6349
          REMOVAL….6349
          INSTALLATION….6349
        Inspection and Adjustment….6350
          INSPECTION AFTER REMOVAL….6350
            Lining Thickness Inspection….6350
            Drum Inner Diameter Inspection….6350
            Other Inspections….6350
          ADJUSTMENT AFTER INSTALLATION….6350
    SERVICE DATA AND SPECIFICATIONS (SDS)….6352
      SERVICE DATA AND SPECIFICATIONS (SDS)….6352
        SERVICE DATA AND SPECIFICATIONS (SDS)….6352
        Parking Drum Brake….6352
        Parking Brake Control….6352
pcs….6353
  Table of Contents….6353
    IPDM E/R….6356
      IPDM E/R….6356
      SYSTEM DESCRIPTION….6356
        RELAY CONTROL SYSTEM….6356
          RELAY CONTROL SYSTEM….6356
          System Diagram….6356
          System Description….6356
          Component Parts Location….6357
        POWER CONTROL SYSTEM….6358
          POWER CONTROL SYSTEM….6358
          System Diagram….6358
          System Description….6358
            COOLING FAN CONTROL….6358
            ALTERNATOR CONTROL….6358
          Component Parts Location….6358
        SIGNAL BUFFER SYSTEM….6359
          SIGNAL BUFFER SYSTEM….6359
          System Diagram….6359
          System Description….6359
          Component Parts Location….6359
        POWER CONSUMPTION CONTROL SYSTEM….6360
          POWER CONSUMPTION CONTROL SYSTEM….6360
          System Diagram….6360
          System Description….6360
            OUTLINE….6360
            SLEEP MODE ACTIVATION….6360
            WAKE-UP OPERATION….6360
          Component Parts Location….6361
        DIAGNOSIS SYSTEM (IPDM E/R)….6362
          DIAGNOSIS SYSTEM (IPDM E/R)….6362
          Diagnosis Description….6362
            AUTO ACTIVE TEST….6362
              Description….6362
              Operation Procedure….6362
              Inspection in Auto Active Test Mode….6362
              Concept of auto active test….6363
              Diagnosis chart in auto active test mode….6363
          CONSULT Function (IPDM E/R)….6364
            APPLICATION ITEM….6364
            SELF DIAGNOSTIC RESULT….6364
            DATA MONITOR….6364
            ACTIVE TEST….6365
      DTC/CIRCUIT DIAGNOSIS….6367
        U1000 CAN COMM CIRCUIT….6367
          U1000 CAN COMM CIRCUIT….6367
          Description….6367
          DTC Logic….6367
            DTC DETECTION LOGIC….6367
          Diagnosis Procedure….6367
        B2098 IGNITION RELAY ON STUCK….6368
          B2098 IGNITION RELAY ON STUCK….6368
          Description….6368
          DTC Logic….6368
            DTC DETECTION LOGIC….6368
            DTC CONFIRMATION PROCEDURE….6368
          Diagnosis Procedure….6368
        B2099 IGNITION RELAY OFF STUCK….6370
          B2099 IGNITION RELAY OFF STUCK….6370
          Description….6370
          DTC Logic….6370
            DTC DETECTION LOGIC….6370
            DTC CONFIRMATION PROCEDURE….6370
          Diagnosis Procedure….6370
        POWER SUPPLY AND GROUND CIRCUIT….6372
          POWER SUPPLY AND GROUND CIRCUIT….6372
          Diagnosis Procedure….6372
      ECU DIAGNOSIS INFORMATION….6373
        IPDM E/R (INTELLIGENT POWER DISTRIBUTION MODULE ENGINE ROOM)….6373
          IPDM E/R (INTELLIGENT POWER DISTRIBUTION MODULE ENGINE ROOM)….6373
          Reference Value….6373
            VALUES ON THE DIAGNOSIS TOOL….6373
            TERMINAL LAYOUT….6375
            PHYSICAL VALUES….6375
          Wiring Diagram – IPDM E/R -….6380
          Fail-safe….6383
            CAN COMMUNICATION CONTROL….6383
              If No CAN Communication Is Available With ECM….6383
              If No CAN Communication Is Available With BCM….6384
            IGNITION RELAY MALFUNCTION DETECTION FUNCTION….6384
            FRONT WIPER CONTROL….6384
            STARTER MOTOR PROTECTION FUNCTION….6385
          DTC Index….6385
      PRECAUTION….6386
        PRECAUTIONS….6386
          PRECAUTIONS….6386
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….6386
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….6386
          Precautions for Removing Battery Terminal….6386
          Precaution for Procedure without Cowl Top Cover….6387
      REMOVAL AND INSTALLATION….6388
        IPDM E/R (INTELLIGENT POWER DISTRIBUTION MODULE ENGINE ROOM)….6388
          IPDM E/R (INTELLIGENT POWER DISTRIBUTION MODULE ENGINE ROOM)….6388
          Exploded View….6388
          Removal and Installation….6388
            REMOVAL….6388
            INSTALLATION….6389
    POWER DISTRIBUTION SYSTEM….6390
      POWER DISTRIBUTION SYSTEM….6390
      BASIC INSPECTION….6390
        DIAGNOSIS AND REPAIR WORK FLOW….6390
          DIAGNOSIS AND REPAIR WORK FLOW….6390
          Work Flow….6390
            OVERALL SEQUENCE….6390
            DETAILED FLOW….6390
      SYSTEM DESCRIPTION….6393
        POWER DISTRIBUTION SYSTEM….6393
          POWER DISTRIBUTION SYSTEM….6393
          System Description….6393
            BATTERY SAVER SYSTEM….6393
              Reset Condition of Battery Saver System….6393
            PUSH-BUTTON IGNITION SWITCH OPERATION PROCEDURE….6393
              Operation Enable Condition….6393
              Operation Condition….6393
          Component Parts Location….6394
          Component Description….6395
        DIAGNOSIS SYSTEM (BCM)….6396
          DIAGNOSIS SYSTEM (BCM)….6396
          COMMON ITEM….6396
            COMMON ITEM : CONSULT Function (BCM – COMMON ITEM)….6396
              APPLICATION ITEM….6396
              SYSTEM APPLICATION….6396
              FREEZE FRAME DATA (FFD)….6396
          INTELLIGENT KEY….6397
            INTELLIGENT KEY : CONSULT Function (BCM – INTELLIGENT KEY)….6397
              WORK SUPPORT….6397
              SELF-DIAG RESULT….6398
              DATA MONITOR….6399
              ACTIVE TEST….6400
      DTC/CIRCUIT DIAGNOSIS….6402
        U1000 CAN COMM CIRCUIT….6402
          U1000 CAN COMM CIRCUIT….6402
          BCM….6402
            BCM : Description….6402
            BCM : DTC Logic….6402
              DTC DETECTION LOGIC….6402
            BCM : Diagnosis Procedure….6402
          IPDM E/R….6402
            IPDM E/R : Description….6402
            IPDM E/R : DTC Logic….6402
              DTC DETECTION LOGIC….6402
            IPDM E/R : Diagnosis Procedure….6402
        U1010 CONTROL UNIT (CAN)….6404
          U1010 CONTROL UNIT (CAN)….6404
          BCM….6404
            BCM : DTC Logic….6404
              DTC DETECTION LOGIC….6404
            BCM : Diagnosis Procedure….6404
        B2553 IGNITION RELAY….6405
          B2553 IGNITION RELAY….6405
          Description….6405
          DTC Logic….6405
            DTC DETECTION LOGIC….6405
            DTC CONFIRMATION PROCEDURE….6405
          Diagnosis Procedure….6405
        B260A IGNITION RELAY….6407
          B260A IGNITION RELAY….6407
          Description….6407
          DTC Logic….6407
            DTC DETECTION LOGIC….6407
            DTC CONFIRMATION PROCEDURE….6407
          Diagnosis Procedure….6407
        B2614 ACC RELAY….6409
          B2614 ACC RELAY….6409
          Description….6409
          DTC Logic….6409
            DTC DETECTION LOGIC….6409
            DTC CONFIRMATION PROCEDURE….6409
          Diagnosis Procedure….6409
          Component Inspection….6410
        B2615 BLOWER RELAY CIRCUIT….6411
          B2615 BLOWER RELAY CIRCUIT….6411
          Description….6411
          DTC Logic….6411
            DTC DETECTION LOGIC….6411
            DTC CONFIRMATION PROCEDURE….6411
          Diagnosis Procedure….6411
          Component Inspection….6412
        B2616 IGNITION RELAY CIRCUIT….6413
          B2616 IGNITION RELAY CIRCUIT….6413
          Description….6413
          DTC Logic….6413
            DTC DETECTION LOGIC….6413
            DTC CONFIRMATION PROCEDURE….6413
          Diagnosis Procedure….6413
          Component Inspection….6414
        B2618 BCM….6415
          B2618 BCM….6415
          Description….6415
          DTC Logic….6415
            DTC DETECTION LOGIC….6415
            DTC CONFIRMATION PROCEDURE….6415
          Diagnosis Procedure….6415
        B261A PUSH-BUTTON IGNITION SWITCH….6416
          B261A PUSH-BUTTON IGNITION SWITCH….6416
          Description….6416
          DTC Logic….6416
            DTC DETECTION LOGIC….6416
            DTC CONFIRMATION PROCEDURE….6416
          Diagnosis Procedure….6416
        POWER SUPPLY AND GROUND CIRCUIT….6418
          POWER SUPPLY AND GROUND CIRCUIT….6418
          BCM….6418
            BCM : Diagnosis Procedure….6418
        PUSH-BUTTON IGNITION SWITCH….6419
          PUSH-BUTTON IGNITION SWITCH….6419
          Description….6419
          Component Function Check….6419
          Diagnosis Procedure….6419
          Component Inspection….6421
        PUSH-BUTTON IGNITION SWITCH POSITION INDICATOR….6422
          PUSH-BUTTON IGNITION SWITCH POSITION INDICATOR….6422
          Description….6422
          Component Function Check….6422
          Diagnosis Procedure….6422
        POWER DISTRIBUTION SYSTEM….6424
          POWER DISTRIBUTION SYSTEM….6424
          Wiring Diagram – PDS (POWER DISTRIBUTION SYSTEM) -….6424
      ECU DIAGNOSIS INFORMATION….6433
        BCM (BODY CONTROL MODULE)….6433
          BCM (BODY CONTROL MODULE)….6433
          Reference Value….6433
            VALUES ON THE DIAGNOSIS TOOL….6433
            TERMINAL LAYOUT….6438
            PHYSICAL VALUES….6438
          Wiring Diagram – BCM -….6455
          Fail-safe….6470
            FAIL-SAFE CONTROL BY DTC….6470
            FAIL-SAFE CONTROL BY RAIN SENSOR MALFUNCTION….6471
            REAR WIPER MOTOR PROTECTION….6471
          DTC Inspection Priority Chart….6471
          DTC Index….6472
        IPDM E/R (INTELLIGENT POWER DISTRIBUTION MODULE ENGINE ROOM)….6474
          IPDM E/R (INTELLIGENT POWER DISTRIBUTION MODULE ENGINE ROOM)….6474
          Reference Value….6474
            VALUES ON THE DIAGNOSIS TOOL….6474
            TERMINAL LAYOUT….6476
            PHYSICAL VALUES….6476
          Wiring Diagram – IPDM E/R -….6481
          Fail-safe….6484
            CAN COMMUNICATION CONTROL….6484
              If No CAN Communication Is Available With ECM….6484
              If No CAN Communication Is Available With BCM….6485
            IGNITION RELAY MALFUNCTION DETECTION FUNCTION….6485
            FRONT WIPER CONTROL….6485
            STARTER MOTOR PROTECTION FUNCTION….6486
          DTC Index….6486
      PRECAUTION….6487
        PRECAUTIONS….6487
          PRECAUTIONS….6487
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….6487
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….6487
          Precautions for Removing Battery Terminal….6487
          Precaution for Procedure without Cowl Top Cover….6488
      SYMPTOM DIAGNOSIS….6489
        PUSH-BUTTON IGNITION SWITCH DOES NOT OPERATE….6489
          PUSH-BUTTON IGNITION SWITCH DOES NOT OPERATE….6489
          Description….6489
            Conditions of Vehicle (Operating Conditions)….6489
          Diagnosis Procedure….6489
        PUSH-BUTTON IGNITION SWITCH POSITION INDICATOR DOES NOT ILLUMINATE….6490
          PUSH-BUTTON IGNITION SWITCH POSITION INDICATOR DOES NOT ILLUMINATE….6490
          Diagnosis Procedure….6490
      REMOVAL AND INSTALLATION….6491
        PUSH BUTTON IGNITION SWITCH….6491
          PUSH BUTTON IGNITION SWITCH….6491
          Removal and Installation….6491
            REMOVAL….6491
            INSTALLATION….6491
pg….6492
  Table of Contents….6492
    POWER SUPPLY & GROUND CIRCUIT….6494
      POWER SUPPLY & GROUND CIRCUIT….6494
      BASIC INSPECTION….6494
        BATTERY….6494
          BATTERY….6494
          How to Handle Battery….6494
            METHODS OF PREVENTING OVER-DISCHARGE….6494
          Work Flow….6494
            BATTERY DIAGNOSIS WITH EXP-800 NI OR GR8-1200 NI….6494
            BATTERY DIAGNOSIS WITHOUT EXP-800 NI OR GR8-1200 NI….6494
              Check Electrolyte Level….6494
              Specific Gravity Check….6495
              Charging The Battery….6496
      DTC/CIRCUIT DIAGNOSIS….6498
        POWER SUPPLY ROUTING CIRCUIT….6498
          POWER SUPPLY ROUTING CIRCUIT….6498
          Wiring Diagram – BATTERY POWER SUPPLY -….6498
          Wiring Diagram – BATTERY POWER SUPPLY FUSIBLE LINK No. L -….6525
          Wiring Diagram – BATTERY POWER SUPPLY FUSE No. 6 -….6526
          Wiring Diagram – BATTERY POWER SUPPLY FUSE No. 7 -….6527
          Wiring Diagram – BATTERY POWER SUPPLY FUSE No. 10 -….6528
          Wiring Diagram – BATTERY POWER SUPPLY FUSE No. 34 -….6529
          Wiring Diagram – BATTERY POWER SUPPLY FUSE No. 50 -….6530
          Wiring Diagram – BATTERY POWER SUPPLY FUSE No. 53 -….6532
          Wiring Diagram – ACCESSORY POWER SUPPLY -….6533
          Wiring Diagram – ACCESSORY POWER SUPPLY FUSE No. 19 -….6540
          Wiring Diagram – IGNITION POWER SUPPLY -….6541
          Wiring Diagram – IGNITION POWER SUPPLY FUSE No. 3 -….6564
          Wiring Diagram – IGNITION POWER SUPPLY FUSE No. 4 -….6566
          Wiring Diagram – IGNITION POWER SUPPLY FUSE No. 44 -….6567
          Wiring Diagram – IGNITION POWER SUPPLY FUSE No. 45 -….6568
          Wiring Diagram – IGNITION POWER SUPPLY FUSE No. 46 -….6569
          Fuse….6570
            EXTENDED STORAGE FUSE SWITCH (IF EQUIPPED)….6570
              How To Extended Storage Fuse Switch ON/OFF ….6570
              How To Remove Extended Storage Fuse Switch….6571
          Fusible Link….6573
          Circuit Breaker….6573
        GROUND DISTRIBUTION….6574
          GROUND DISTRIBUTION….6574
          Engine Room Harness….6574
          Engine Control Harness….6576
          Main Harness….6577
          Body Harness….6582
          Door Harness….6585
            BACK DOOR HARNESS….6585
        OPTION HARNESS….6586
          OPTION HARNESS….6586
          Wiring Diagram – OPTION HARNESS -….6586
        HARNESS LAYOUT….6590
          HARNESS LAYOUT….6590
          Outline….6590
          Engine Room Harness….6591
            ENGINE COMPARTMENT….6591
            PASSENGER COMPARTMENT….6592
          Engine Control Harness….6592
            VQ37VHR….6592
              Engine Compartment….6593
              Passenger Compartment….6594
            VK50VE….6594
              Engine Compartment….6595
              Passenger Compartment….6596
          Main Harness….6597
          Body Harness….6598
            BODY HARNESS….6598
            BODY No.2 HARNESS….6599
          Door Harness….6600
…
          DRIVER SIDE : Component Inspection….7012
        PASSENGER SIDE….7013
          PASSENGER SIDE : Description….7013
          PASSENGER SIDE : Component Function Check….7013
          PASSENGER SIDE : Diagnosis Procedure….7013
          PASSENGER SIDE : Component Inspection….7015
      SEAT CUSHION HEATER….7016
        SEAT CUSHION HEATER….7016
        DRIVER SIDE….7016
          DRIVER SIDE : Description….7016
          DRIVER SIDE : Component Function Check….7016
          DRIVER SIDE : Diagnosis Procedure….7016
          DRIVER SIDE : Component Inspection….7017
        PASSENGER SIDE….7017
          PASSENGER SIDE : Description….7017
          PASSENGER SIDE : Component Function Check….7017
          PASSENGER SIDE : Diagnosis Procedure….7017
          PASSENGER SIDE : Component Inspection….7019
      SEATBACK HEATER….7020
        SEATBACK HEATER….7020
        DRIVER SIDE….7020
          DRIVER SIDE : Description….7020
          DRIVER SIDE : Component Function Check….7020
          DRIVER SIDE : Diagnosis Procedure….7020
        PASSENGER SIDE….7020
          PASSENGER SIDE : Description….7020
          PASSENGER SIDE : Component Function Check….7020
          PASSENGER SIDE : Diagnosis Procedure….7020
      HEATED SEAT SWITCH INDICATOR….7022
        HEATED SEAT SWITCH INDICATOR….7022
        DRIVER SIDE….7022
          DRIVER SIDE : Description….7022
          DRIVER SIDE : Component Function Check….7022
          DRIVER SIDE : Diagnosis Procedure….7022
          DRIVER SIDE : Component Inspection….7022
        PASSENGER SIDE….7023
          PASSENGER SIDE : Description….7023
          PASSENGER SIDE : Component Function Check….7023
          PASSENGER SIDE : Diagnosis Procedure….7023
          PASSENGER SIDE : Component Inspection….7023
      POWER SEAT….7025
        POWER SEAT….7025
…
          VEHICLE SECURITY ALARM DOES NOT ACTIVATE….7312
          Description….7312
          Diagnosis Procedure….7312
        INTELLIGENT KEY INSERT INFORMATION DOES NOT OPERATE….7313
          INTELLIGENT KEY INSERT INFORMATION DOES NOT OPERATE….7313
          Diagnosis Procedure….7313
      PRECAUTION….7314
        PRECAUTIONS….7314
          PRECAUTIONS….7314
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….7314
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….7314
          Precaution for Procedure without Cowl Top Cover….7314
          Precautions For Xenon Headlamp Service….7314
          Precautions for Removing Battery Terminal….7315
      REMOVAL AND INSTALLATION….7316
        KEY SLOT….7316
          KEY SLOT….7316
          Exploded View….7316
          Removal and Installation….7316
            REMOVAL….7316
            INSTALLATION….7316
        PUSH-BUTTON IGNITION SWITCH….7317
          PUSH-BUTTON IGNITION SWITCH….7317
          Removal and Installation….7317
            REMOVAL….7317
            INSTALLATION….7317
…
        Relief Oil Pressure….7492
stc….7493
  Table of Contents….7493
    BASIC INSPECTION….7494
      DIAGNOSIS AND REPAIR WORK FLOW….7494
        DIAGNOSIS AND REPAIR WORK FLOW….7494
        Work Flow….7494
          DETAILED FLOW….7494
    SYSTEM DESCRIPTION….7495
      EPS SYSTEM….7495
        EPS SYSTEM….7495
        System Diagram….7495
          CONTROL DIAGRAM….7495
          CROSS-SECTIONAL VIEW….7495
        System Description….7495
          OPERATION PRINCIPLE….7496
            During Parking (When Turning The Steering Wheel To The Right.)….7496
            During High-speed Operation….7496
        Component Parts Location….7497
        Component Description….7497
    DTC/CIRCUIT DIAGNOSIS….7498
      POWER SUPPLY AND GROUND CIRCUIT….7498
        POWER SUPPLY AND GROUND CIRCUIT….7498
        Description….7498
        Diagnosis Procedure….7498
      POWER STEERING SOLENOID VALVE….7499
        POWER STEERING SOLENOID VALVE….7499
        Description….7499
        Diagnosis Procedure….7499
        Component Inspection….7500
      ENGINE SPEED SIGNAL CIRCUIT….7501
        ENGINE SPEED SIGNAL CIRCUIT….7501
        Description….7501
        Diagnosis Procedure….7501
      VEHICLE SPEED SIGNAL CIRCUIT….7504
        VEHICLE SPEED SIGNAL CIRCUIT….7504
        Description….7504
        Diagnosis Procedure….7504
    ECU DIAGNOSIS INFORMATION….7506
      POWER STEERING CONTROL UNIT….7506
        POWER STEERING CONTROL UNIT….7506
        Reference Value….7506
…
            REVERSE INHIBIT CONTROL….7698
            1ST ENGINE BRAKE PROTECTION CONTROL….7698
            TCM HIGH TEMPERATURE PROTECTION CONTROL….7699
          DTC Inspection Priority Chart….7699
          DTC Index….7700
      SYMPTOM DIAGNOSIS….7702
        SYSTEM SYMPTOM….7702
          SYSTEM SYMPTOM….7702
          Symptom Table….7702
            SYMPTOM TABLE 1….7702
            SYMPTOM TABLE 2….7706
      PRECAUTION….7712
        PRECAUTIONS….7712
          PRECAUTIONS….7712
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….7712
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….7712
          Precaution for Procedure without Cowl Top Cover….7712
          General Precautions….7713
          Service Notice or Precaution….7713
            ATF COOLER SERVICE….7713
          Precautions for Removing Battery Terminal….7714
      PREPARATION….7715
        PREPARATION….7715
          PREPARATION….7715
          Special Service Tool….7715
          Commercial Service Tool….7716
      PERIODIC MAINTENANCE….7717
        A/T FLUID….7717
          A/T FLUID….7717
          Inspection….7717
            FLUID LEAKAGE….7717
          Changing….7717
          Adjustment….7719
        A/T FLUID COOLER….7720
          A/T FLUID COOLER….7720
          Cleaning….7720
            CLEANING PROCEDURE….7720
            DIAGNOSIS PROCEDURE….7721
            INSPECTION PROCEDURE….7721
          Inspection….7722
        STALL TEST….7723
          STALL TEST….7723
          Inspection and Judgment….7723
            INSPECTION….7723
            JUDGMENT OF STALL TEST….7723
        A/T POSITION….7724
          A/T POSITION….7724
          Inspection and Adjustment….7724
            INSPECTION….7724
            ADJUSTMENT….7724
      REMOVAL AND INSTALLATION….7725
        A/T SHIFT SELECTOR….7725
          A/T SHIFT SELECTOR….7725
          Exploded View….7725
          Removal and Installation….7726
            REMOVAL….7726
            INSTALLATION….7726
          Inspection and Adjustment….7727
            INSPECTION AFTER INSTALLATION….7727
            ADJUSTMENT AFTER INSTALLATION….7727
        CONTROL ROD….7728
          CONTROL ROD….7728
          Exploded View….7728
          Removal and Installation….7728
            REMOVAL….7728
            INSTALLATION….7728
          Inspection and Adjustment….7728
            INSPECTION AFTER INSTALLATION….7728
            ADJUSTMENT AFTER INSTALLATION….7728
        CONTROL VALVE & TCM….7729
          CONTROL VALVE & TCM….7729
          Exploded View….7729
          Removal and Installation….7729
            REMOVAL….7729
            INSTALLATION….7731
          Inspection….7733
            INSPECTION AFTER REMOVAL….7733
            INSPECTION AFTER INSTALLATION….7733
        PARKING COMPONENTS….7734
          PARKING COMPONENTS….7734
          2WD….7734
            2WD : Exploded View….7734
            2WD : Removal and Installation….7734
              REMOVAL….7734
              INSTALLATION….7737
            2WD : Inspection….7737
              INSPECTION AFTER REMOVAL….7737
              INSPECTION AFTER INSTALLATION….7738
              ADJUSTMENT AFTER INSTALLATION….7738
        REAR OIL SEAL….7739
          REAR OIL SEAL….7739
          2WD….7739
            2WD : Exploded View….7739
            2WD : Removal and Installation….7739
              REMOVAL….7739
              INSTALLATION….7739
            2WD : Inspection….7740
              INSPECTION AFTER INSTALLATION….7740
          AWD….7740
            AWD : Exploded View….7740
            AWD : Removal and Installation….7740
              REMOVAL….7740
              INSTALLATION….7740
            AWD : Inspection….7741
              INSPECTION AFTER INSTALLATION….7741
        OUTPUT SPEED SENSOR….7742
          OUTPUT SPEED SENSOR….7742
          2WD….7742
            2WD : Exploded View….7742
            2WD : Removal and Installation….7742
              REMOVAL….7742
              INSTALLATION….7744
            2WD : Inspection and Adjustment….7746
              INSPECTION AFTER REMOVAL….7746
              INSPECTION AFTER INSTALLATION….7746
              ADJUSTMENT AFTER INSTALLATION….7746
        AIR BREATHER HOSE….7747
          AIR BREATHER HOSE….7747
          2WD….7747
            2WD : Exploded View….7747
            2WD : Removal and Installation….7747
              REMOVAL….7747
              INSTALLATION….7747
          AWD….7748
            AWD : Exploded View….7748
            AWD : Removal and Installation….7748
              REMOVAL….7748
              INSTALLATION….7748
        FLUID COOLER SYSTEM….7749
          FLUID COOLER SYSTEM….7749
          2WD….7749
            2WD : Exploded View….7749
            2WD : Removal and Installation….7749
              REMOVAL….7749
              INSTALLATION….7749
            2WD : Inspection and Adjustment….7750
              INSPECTION AFTER INSTALLATION….7750
              ADJUSTMENT AFTER INSTALLATION….7751
          AWD….7751
            AWD : Exploded View….7751
            AWD : Removal and Installation….7751
              REMOVAL….7751
              INSTALLATION….7752
            AWD : Inspection and Adjustment….7753
              INSPECTION AFTER INSTALLATION….7753
              ADJUSTMENT AFTER INSTALLATION….7753
      UNIT REMOVAL AND INSTALLATION….7754
        TRANSMISSION ASSEMBLY….7754
          TRANSMISSION ASSEMBLY….7754
          2WD….7754
            2WD : Exploded View….7754
            2WD : Removal and Installation….7754
              REMOVAL….7754
              INSTALLATION….7755
            2WD : Inspection and Adjustment….7756
              INSPECTION BEFORE INSTALLATION….7756
              INSPECTION AFTER INSTALLATION….7756
              ADJUSTMENT AFTER INSTALLATION….7756
          AWD….7756
            AWD : Exploded View….7757
            AWD : Removal and Installation….7757
              REMOVAL….7757
              INSTALLATION….7758
            AWD : Inspection and Adjustment….7759
              INSPECTION BEFORE INSTALLATION….7759
              INSPECTION AFTER INSTALLATION….7759
              ADJUSTMENT AFTER INSTALLATION….7759
      UNIT DISASSEMBLY AND ASSEMBLY….7760
        TRANSMISSION ASSEMBLY….7760
          TRANSMISSION ASSEMBLY….7760
          Exploded View….7760
            2WD MODELS….7760
            AWD MODELS….7765
          Oil Channel….7771
          Location of Needle Bearings and Bearing Races….7771
            2WD MODELS….7771
            AWD MODELS….7773
          Location of Snap Rings….7774
            2WD MODELS….7774
            AWD MODELS….7775
          Disassembly….7775
          Assembly….7792
          Inspection….7816
            INSPECTION AFTER DISASSEMBLY….7816
              Oil Pan….7816
              Torque Converter….7816
              1st One-way Clutch….7817
              Under Drive Sun Gear….7817
              Mid Carrier Assembly….7817
              Rear Carrier Assembly….7817
              Reverse Brake Retaining Plate/Drive Plates/Driven Plates/Dish Plates….7817
              Front Brake Retaining Plates/Drive Plates/Driven Plate….7817
              Each Snap Ring….7817
              Parking Actuator Support and Parking Pawl….7817
        OIL PUMP, 2346 BRAKE, FRONT BRAKE PISTON….7819
          OIL PUMP, 2346 BRAKE, FRONT BRAKE PISTON….7819
          Exploded View….7819
          Disassembly….7819
          Assembly….7823
          Inspection and Adjustment….7826
            INSPECTION AFTER DISASSEMBLY….7826
              Each Snap Ring….7826
              Each Spring Retainer….7826
              2346 Brake Retaining Plate/Drive Plates/Driven Plate/Dish Plate….7826
            INSPECTION AFTER ASSEMBLY….7827
              2346 Brake Clearance….7827
        UNDER DRIVE CARRIER, FRONT BRAKE HUB….7828
          UNDER DRIVE CARRIER, FRONT BRAKE HUB….7828
          Exploded View….7828
          Disassembly….7828
          Assembly….7829
          Inspection….7829
            INSPECTION AFTER DISASSEMBLY….7829
        FRONT CARRIER, INPUT CLUTCH, REAR INTERNAL GEAR….7831
          FRONT CARRIER, INPUT CLUTCH, REAR INTERNAL GEAR….7831
          Exploded View….7831
          Disassembly….7832
          Assembly….7833
          Inspection….7835
            INSPECTION AFTER DISASSEMBLY….7835
              Front Carrier Snap Ring….7835
              Input Clutch Snap Ring….7835
              Input Clutch Drum….7835
              Input Clutch Retaining Plate/Drive Plates/Driven Plates/Dish Plate….7835
              Front Carrier….7835
              Rear Internal Gear….7835
        MID SUN GEAR, REAR SUN GEAR, HIGH AND LOW REVERSE CLUTCH HUB….7836
          MID SUN GEAR, REAR SUN GEAR, HIGH AND LOW REVERSE CLUTCH HUB….7836
          Exploded View….7836
          Disassembly….7836
          Assembly….7838
          Inspection….7840
            INSPECTION AFTER DISASSEMBLY….7840
              2nd One-way Clutch….7840
              High and Low Reverse Clutch Hub Snap Ring, Rear Sun Gear Snap Ring….7840
              2nd One-way Clutch….7840
              Mid Sun Gear….7840
              Rear Sun Gear….7840
              High and Low Reverse Clutch Hub….7840
        HIGH AND LOW REVERSE CLUTCH….7841
          HIGH AND LOW REVERSE CLUTCH….7841
          Exploded View….7841
          Disassembly….7841
          Assembly….7841
          Inspection….7842
            INSPECTION AFTER DISASSEMBLY….7842
              Snap Ring….7842
              High and Low Reverse Clutch Retaining Plate/Drive Plates/Driven Plates/Dish Plate….7842
              High and Low Reverse Clutch Drum….7842
        DIRECT CLUTCH….7843
          DIRECT CLUTCH….7843
          Exploded View….7843
          Disassembly….7843
          Assembly….7843
          Inspection….7844
            INSPECTION AFTER DISASSEMBLY….7844
              Snap Ring….7844
              Direct Clutch Retaining Plate/Drive Plates/Driven Plates/Dish Plate….7844
              Direct Clutch Drum….7844
      SERVICE DATA AND SPECIFICATIONS (SDS)….7845
        SERVICE DATA AND SPECIFICATIONS (SDS)….7845
          SERVICE DATA AND SPECIFICATIONS (SDS)….7845
          General Specification….7845
          Vehicle Speed at Which Gear Shifting Occurs….7845
            2WD MODELS….7845
            AWD MODELS….7845
          Vehicle Speed at Which Lock-up Occurs/Releases….7846
            2WD MODELS….7846
            AWD MODELS….7846
          Stall Speed….7846
          Torque Converter….7846
          Total End Play….7846
          Reverse Brake Clearance….7847
          Front Brake Clearance….7847
          2346 Brake Clearance….7847
    7AT: RE7R01B (VK50VE)….7848
      7AT: RE7R01B (VK50VE)….7848
      BASIC INSPECTION….7848
        DIAGNOSIS AND REPAIR WORK FLOW….7848
          DIAGNOSIS AND REPAIR WORK FLOW….7848
          Work Flow….7848
          Diagnostic Work Sheet….7849
            DESCRIPTION….7849
            WORKSHEET SAMPLE….7849
      SYSTEM DESCRIPTION….7851
        A/T CONTROL SYSTEM….7851
          A/T CONTROL SYSTEM….7851
          System Diagram….7851
          System Description….7851
            INPUT/OUTPUT SIGNAL CHART….7851
            SYSTEM DESCRIPTION….7851
          Component Parts Location….7852
          Component Description….7853
        LINE PRESSURE CONTROL….7854
          LINE PRESSURE CONTROL….7854
          System Diagram….7854
          System Description….7854
            INPUT/OUTPUT SIGNAL CHART….7854
            SYSTEM DESCRIPTION….7854
              Normal Control….7854
              Back-up Control (Engine Brake)….7855
              During Shift Change….7855
              At Low Fluid Temperature….7855
          Component Parts Location….7856
          Component Description….7857
        SHIFT CHANGE CONTROL….7858
          SHIFT CHANGE CONTROL….7858
          System Diagram….7858
          System Description….7858
            INPUT/OUTPUT SIGNAL CHART….7858
            SYSTEM DESCRIPTION….7858
              Shift Change….7859
              Blipping Control….7859
          Component Parts Location….7861
          Component Description….7862
        SHIFT PATTERN CONTROL….7863
          SHIFT PATTERN CONTROL….7863
          ASC (ADAPTIVE SHIFT CONTROL)….7863
            ASC (ADAPTIVE SHIFT CONTROL) : System Diagram….7863
            ASC (ADAPTIVE SHIFT CONTROL) : System Description….7863
              INPUT/OUTPUT SIGNAL CHART….7863
              SYSTEM DESCRIPTION….7863
                DS Mode….7864
            ASC (ADAPTIVE SHIFT CONTROL) : Component Parts Location….7865
            ASC (ADAPTIVE SHIFT CONTROL) : Component Description….7866
          MANUAL MODE….7866
            MANUAL MODE : System Diagram….7867
            MANUAL MODE : System Description….7867
              INPUT/OUTPUT SIGNAL CHART….7867
              SYSTEM DESCRIPTION….7867
                Manual Mode….7867
            MANUAL MODE : Component Parts Location….7868
            MANUAL MODE : Component Description….7869
        LOCK-UP CONTROL….7870
          LOCK-UP CONTROL….7870
          System Diagram….7870
          System Description….7870
            INPUT/OUTPUT SIGNAL CHART….7870
            SYSTEM DESCRIPTION….7870
              Torque Converter Clutch Control Valve Control….7870
              Smooth Lock-up Control….7871
          Component Parts Location….7872
          Component Description….7873
        SHIFT MECHANISM….7874
          SHIFT MECHANISM….7874
          Cross-Sectional View….7874
          System Diagram….7875
          System Description….7875
            DESCRIPTION….7875
            CLUTCH AND BAND CHART….7876
            POWER TRANSMISSION….7876
              “N” Position….7876
              “P” Position….7877
              “D1” and “DS1” Positions….7878
              “M1” Position….7880
              “D2” and “DS2” Positions….7882
              “M2” Position….7884
              “D3”, “DS3” and “M3” Positions….7886
              “D4”, “DS4” and “M4” Positions….7888
              “D5”, “DS5” and “M5” Positions….7890
              “D6”, “DS6” and “M6” Positions….7892
              “D7”, “DS7” and “M7” Positions….7894
              “R” Position….7896
          Component Parts Location….7898
          Component Description….7898
        SHIFT LOCK SYSTEM….7899
          SHIFT LOCK SYSTEM….7899
          System Description….7899
            SHIFT LOCK OPERATION AT “P” POSITION….7899
              When Brake Pedal Is Not Depressed (No Shift Operation Allowed)….7899
              When Brake Pedal Is Depressed (Shift Operation Allowed)….7899
            OPERATION AT OTHER THAN “P” POSITION….7899
            “P” POSITION RETAINING MECHANISM (IGNITION SWITCH LOCK)….7899
          Component Parts Location….7900
          Component Description….7900
        ON BOARD DIAGNOSTIC (OBD) SYSTEM….7901
          ON BOARD DIAGNOSTIC (OBD) SYSTEM….7901
          Diagnosis Description….7901
            OBD FUNCTION….7901
        DIAGNOSIS SYSTEM (TCM)….7902
          DIAGNOSIS SYSTEM (TCM)….7902
          CONSULT Function (TRANSMISSION)….7902
            CONSULT APPLICATION ITEMS….7902
            SELF-DIAGNOSTIC RESULTS….7902
              IGN Counter….7902
            DATA MONITOR….7902
              Display Items List….7902
            DTC WORK SUPPORT….7907
      DTC/CIRCUIT DIAGNOSIS….7908
        U0100 LOST COMMUNICATION (ECM A)….7908
          U0100 LOST COMMUNICATION (ECM A)….7908
          DTC Logic….7908
            DTC DETECTION LOGIC….7908
            DTC CONFIRMATION PROCEDURE….7908
          Diagnosis Procedure….7908
        U0300 CAN COMMUNICATION DATA….7909
          U0300 CAN COMMUNICATION DATA….7909
          Description….7909
          DTC Logic….7909
            DTC DETECTION LOGIC….7909
            DTC CONFIRMATION PROCEDURE….7909
          Diagnosis Procedure….7909
        U1000 CAN COMM CIRCUIT….7910
          U1000 CAN COMM CIRCUIT….7910
          Description….7910
          DTC Logic….7910
            DTC DETECTION LOGIC….7910
            DTC CONFIRMATION PROCEDURE….7910
          Diagnosis Procedure….7910
        P0615 STARTER RELAY….7911
          P0615 STARTER RELAY….7911
          Description….7911
          DTC Logic….7911
            DTC DETECTION LOGIC….7911
            DTC CONFIRMATION PROCEDURE….7911
          Diagnosis Procedure….7911
        P0705 TRANSMISSION RANGE SWITCH A….7913
          P0705 TRANSMISSION RANGE SWITCH A….7913
          Description….7913
          DTC Logic….7913
            DTC DETECTION LOGIC….7913
            DTC CONFIRMATION PROCEDURE….7913
          Diagnosis Procedure….7913
        P0710 TRANSMISSION FLUID TEMPERATURE SENSOR A….7914
          P0710 TRANSMISSION FLUID TEMPERATURE SENSOR A….7914
          Description….7914
          DTC Logic….7914
            DTC DETECTION LOGIC….7914
            DTC CONFIRMATION PROCEDURE….7914
          Diagnosis Procedure….7915
        P0717 INPUT SPEED SENSOR A….7917
          P0717 INPUT SPEED SENSOR A….7917
          Description….7917
          DTC Logic….7917
            DTC DETECTION LOGIC….7917
            DTC CONFIRMATION PROCEDURE….7917
          Diagnosis Procedure….7917
        P0720 OUTPUT SPEED SENSOR….7919
          P0720 OUTPUT SPEED SENSOR….7919
          Description….7919
          DTC Logic….7919
            DTC DETECTION LOGIC….7919
            DTC CONFIRMATION PROCEDURE….7919
          Diagnosis Procedure….7920
        P0725 ENGINE SPEED….7921
          P0725 ENGINE SPEED….7921
          Description….7921
          DTC Logic….7921
            DTC DETECTION LOGIC….7921
            DTC CONFIRMATION PROCEDURE….7921
          Diagnosis Procedure….7921
        P0729 6GR INCORRECT RATIO….7923
          P0729 6GR INCORRECT RATIO….7923
          Description….7923
          DTC Logic….7923
            DTC DETECTION LOGIC….7923
            DTC CONFIRMATION PROCEDURE….7923
          Diagnosis Procedure….7924
        P0730 INCORRECT GEAR RATIO….7925
          P0730 INCORRECT GEAR RATIO….7925
          Description….7925
          DTC Logic….7925
            DTC DETECTION LOGIC….7925
            DTC CONFIRMATION PROCEDURE….7925
          Diagnosis Procedure….7925
        P0731 1GR INCORRECT RATIO….7927
          P0731 1GR INCORRECT RATIO….7927
          Description….7927
          DTC Logic….7927
            DTC DETECTION LOGIC….7927
            DTC CONFIRMATION PROCEDURE….7927
          Diagnosis Procedure….7928
        P0732 2GR INCORRECT RATIO….7929
          P0732 2GR INCORRECT RATIO….7929
          Description….7929
          DTC Logic….7929
            DTC DETECTION LOGIC….7929
            DTC CONFIRMATION PROCEDURE….7929
          Diagnosis Procedure….7930
        P0733 3GR INCORRECT RATIO….7931
          P0733 3GR INCORRECT RATIO….7931
          Description….7931
          DTC Logic….7931
            DTC DETECTION LOGIC….7931
            DTC CONFIRMATION PROCEDURE….7931
          Diagnosis Procedure….7932
        P0734 4GR INCORRECT RATIO….7933
          P0734 4GR INCORRECT RATIO….7933
          Description….7933
          DTC Logic….7933
            DTC DETECTION LOGIC….7933
            DTC CONFIRMATION PROCEDURE….7933
          Diagnosis Procedure….7934
        P0735 5GR INCORRECT RATIO….7935
          P0735 5GR INCORRECT RATIO….7935
          Description….7935
          DTC Logic….7935
            DTC DETECTION LOGIC….7935
            DTC CONFIRMATION PROCEDURE….7935
          Diagnosis Procedure….7936
        P0740 TORQUE CONVERTER….7937
          P0740 TORQUE CONVERTER….7937
          Description….7937
          DTC Logic….7937
            DTC DETECTION LOGIC….7937
            DTC CONFIRMATION PROCEDURE….7937
          Diagnosis Procedure….7937
        P0744 TORQUE CONVERTER….7939
          P0744 TORQUE CONVERTER….7939
          Description….7939
          DTC Logic….7939
            DTC DETECTION LOGIC….7939
            DTC CONFIRMATION PROCEDURE….7939
          Diagnosis Procedure….7939
        P0745 PRESSURE CONTROL SOLENOID A….7941
          P0745 PRESSURE CONTROL SOLENOID A….7941
          Description….7941
          DTC Logic….7941
            DTC DETECTION LOGIC….7941
            DTC CONFIRMATION PROCEDURE….7941
          Diagnosis Procedure….7941
        P0750 SHIFT SOLENOID A….7942
          P0750 SHIFT SOLENOID A….7942
          Description….7942
          DTC Logic….7942
            DTC DETECTION LOGIC….7942
            DTC CONFIRMATION PROCEDURE….7942
          Diagnosis Procedure….7942
        P0775 PRESSURE CONTROL SOLENOID B….7943
          P0775 PRESSURE CONTROL SOLENOID B….7943
          Description….7943
          DTC Logic….7943
            DTC DETECTION LOGIC….7943
            DTC CONFIRMATION PROCEDURE….7943
          Diagnosis Procedure….7943
        P0780 SHIFT….7944
          P0780 SHIFT….7944
          Description….7944
          DTC Logic….7944
            DTC DETECTION LOGIC….7944
            DTC CONFIRMATION PROCEDURE….7944
          Diagnosis Procedure….7944
        P0795 PRESSURE CONTROL SOLENOID C….7946
          P0795 PRESSURE CONTROL SOLENOID C….7946
          Description….7946
          DTC Logic….7946
            DTC DETECTION LOGIC….7946
            DTC CONFIRMATION PROCEDURE….7946
          Diagnosis Procedure….7946
        P1705 TP SENSOR….7947
          P1705 TP SENSOR….7947
          Description….7947
          DTC Logic….7947
            DTC DETECTION LOGIC….7947
            DTC CONFIRMATION PROCEDURE….7947
          Diagnosis Procedure….7947
        P1721 VEHICLE SPEED SIGNAL….7949
          P1721 VEHICLE SPEED SIGNAL….7949
          Description….7949
          DTC Logic….7949
            DTC DETECTION LOGIC….7949
            DTC CONFIRMATION PROCEDURE….7949
          Diagnosis Procedure….7950
        P1730 INTERLOCK….7951
          P1730 INTERLOCK….7951
          Description….7951
          DTC Logic….7951
            DTC DETECTION LOGIC….7951
            DTC CONFIRMATION PROCEDURE….7951
          Judgment of A/T Interlock….7951
          Diagnosis Procedure….7952
        P1734 7GR INCORRECT RATIO….7953
          P1734 7GR INCORRECT RATIO….7953
          Description….7953
          DTC Logic….7953
            DTC DETECTION LOGIC….7953
            DTC CONFIRMATION PROCEDURE….7953
          Diagnosis Procedure….7954
        P1815 M-MODE SWITCH….7955
          P1815 M-MODE SWITCH….7955
          Description….7955
          DTC Logic….7955
            DTC DETECTION LOGIC….7955
            DTC CONFIRMATION PROCEDURE….7955
          Diagnosis Procedure….7956
          Component Inspection (Manual Mode Switch)….7959
          Component Inspection [Paddle Shifter (Shift-up)]….7959
          Component Inspection [Paddle Shifter (Shift-down)]….7960
        P2713 PRESSURE CONTROL SOLENOID D….7961
          P2713 PRESSURE CONTROL SOLENOID D….7961
          Description….7961
          DTC Logic….7961
            DTC DETECTION LOGIC….7961
            DTC CONFIRMATION PROCEDURE….7961
          Diagnosis Procedure….7961
        P2722 PRESSURE CONTROL SOLENOID E….7962
          P2722 PRESSURE CONTROL SOLENOID E….7962
          Description….7962
          DTC Logic….7962
            DTC DETECTION LOGIC….7962
            DTC CONFIRMATION PROCEDURE….7962
          Diagnosis Procedure….7962
        P2731 PRESSURE CONTROL SOLENOID F….7963
          P2731 PRESSURE CONTROL SOLENOID F….7963
          Description….7963
          DTC Logic….7963
            DTC DETECTION LOGIC….7963
            DTC CONFIRMATION PROCEDURE….7963
          Diagnosis Procedure….7963
        P2807 PRESSURE CONTROL SOLENOID G….7964
          P2807 PRESSURE CONTROL SOLENOID G….7964
          Description….7964
          DTC Logic….7964
            DTC DETECTION LOGIC….7964
            DTC CONFIRMATION PROCEDURE….7964
          Diagnosis Procedure….7964
        MAIN POWER SUPPLY AND GROUND CIRCUIT….7966
          MAIN POWER SUPPLY AND GROUND CIRCUIT….7966
          Description….7966
          Diagnosis Procedure….7966
        SHIFT POSITION INDICATOR CIRCUIT….7969
          SHIFT POSITION INDICATOR CIRCUIT….7969
          Description….7969
          Component Function Check….7969
          Diagnosis Procedure….7969
        SHIFT LOCK SYSTEM….7970
          SHIFT LOCK SYSTEM….7970
          Description….7970
          Wiring Diagram – A/T SHIFT LOCK SYSTEM -….7970
          Component Function Check….7972
          Diagnosis Procedure….7973
          Component Inspection (Shift Lock Solenoid)….7975
          Component Inspection (Stop Lamp Switch)….7975
        SELECTOR LEVER POSITION INDICATOR….7977
          SELECTOR LEVER POSITION INDICATOR….7977
          Description….7977
          Component Function Check….7977
          Diagnosis Procedure….7977
          Component Inspection (Selector Lever Position Indicator)….7980
      ECU DIAGNOSIS INFORMATION….7981
        TCM….7981
          TCM….7981
          Reference Value….7981
            VALUES ON DIAGNOSIS TOOL….7981
            TERMINAL LAYOUT….7985
            PHYSICAL VALUES….7985
          Wiring Diagram – A/T CONTROL SYSTEM -….7987
          Fail-Safe….7993
            FAIL-SAFE FUNCTION….7994
          Protection Control….7996
            REVERSE INHIBIT CONTROL….7996
            1ST ENGINE BRAKE PROTECTION CONTROL….7996
            TCM HIGH TEMPERATURE PROTECTION CONTROL….7997
          DTC Inspection Priority Chart….7997
          DTC Index….7998
      SYMPTOM DIAGNOSIS….8000
        SYSTEM SYMPTOM….8000
          SYSTEM SYMPTOM….8000
          Symptom Table….8000
            SYMPTOM TABLE 1….8000
            SYMPTOM TABLE 2….8004
      PRECAUTION….8010
        PRECAUTIONS….8010
          PRECAUTIONS….8010
          Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….8010
            PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….8010
          Precaution for Procedure without Cowl Top Cover….8010
          General Precautions….8011
          Service Notice or Precaution….8011
            ATF COOLER SERVICE….8011
          Precautions for Removing Battery Terminal….8012
      PREPARATION….8013
        PREPARATION….8013
          PREPARATION….8013
          Special Service Tool….8013
          Commercial Service Tool….8014
      PERIODIC MAINTENANCE….8015
        A/T FLUID….8015
          A/T FLUID….8015
          Inspection….8015
            FLUID LEAKAGE….8015
          Changing….8015
          Adjustment….8017
        A/T FLUID COOLER….8018
          A/T FLUID COOLER….8018
          Cleaning….8018
            CLEANING PROCEDURE….8018
            DIAGNOSIS PROCEDURE….8019
            INSPECTION PROCEDURE….8019
          Inspection….8020
        STALL TEST….8021
          STALL TEST….8021
          Inspection and Judgment….8021
            INSPECTION….8021
            JUDGMENT OF STALL TEST….8021
        A/T POSITION….8022
          A/T POSITION….8022
          Inspection and Adjustment….8022
            INSPECTION….8022
            ADJUSTMENT….8022
      REMOVAL AND INSTALLATION….8023
        A/T SHIFT SELECTOR….8023
          A/T SHIFT SELECTOR….8023
          Exploded View….8023
          Removal and Installation….8024
            REMOVAL….8024
            INSTALLATION….8024
          Inspection and Adjustment….8025
            INSPECTION AFTER INSTALLATION….8025
            ADJUSTMENT AFTER INSTALLATION….8025
        CONTROL ROD….8026
          CONTROL ROD….8026
          Exploded View….8026
          Removal and Installation….8026
            REMOVAL….8026
            INSTALLATION….8026
          Inspection….8026
            INSPECTION AFTER INSTALLATION….8026
            ADJUSTMENT AFTER INSTALLATION….8026
        PADDLE SHIFTER….8027
          PADDLE SHIFTER….8027
          Exploded View….8027
          Removal and Installation….8027
            REMOVAL….8027
            INSTALLATION….8027
        CONTROL VALVE & TCM….8028
          CONTROL VALVE & TCM….8028
          Exploded View….8028
          Removal and Installation….8028
            REMOVAL….8028
            INSTALLATION….8031
          Inspection….8032
            INSPECTION AFTER REMOVAL….8032
            INSPECTION AFTER INSTALLATION….8032
        REAR OIL SEAL….8033
          REAR OIL SEAL….8033
          Exploded View….8033
          Removal and Installation….8033
            REMOVAL….8033
            INSTALLATION….8033
          Inspection….8033
            INSPECTION AFTER INSTALLATION….8033
        AIR BREATHER HOSE….8034
          AIR BREATHER HOSE….8034
          Exploded View….8034
          Removal and Installation….8034
            REMOVAL….8034
            INSTALLATION….8035
        FLUID COOLER SYSTEM….8036
          FLUID COOLER SYSTEM….8036
          Exploded View….8036
          Removal and Installation….8036
            REMOVAL….8036
            INSTALLATION….8037
          Inspection and Adjustment….8038
            INSPECTION AFTER INSTALLATION….8038
            ADJUSTMENT AFTER INSTALLATION….8038
      UNIT REMOVAL AND INSTALLATION….8039
        TRANSMISSION ASSEMBLY….8039
          TRANSMISSION ASSEMBLY….8039
          Exploded View….8039
          Removal and Installation….8039
            REMOVAL….8039
            INSTALLATION….8040
          Inspection and Adjustment….8041
            INSPECTION BEFORE INSTALLATION….8041
            INSPECTION AFTER INSTALLATION….8041
            ADJUSTMENT AFTER INSTALLATION….8041
      UNIT DISASSEMBLY AND ASSEMBLY….8042
        TRANSMISSION ASSEMBLY….8042
          TRANSMISSION ASSEMBLY….8042
          Exploded View….8042
          Oil Channel….8048
          Location of Needle Bearings and Bearing Races….8049
          Location of Snap Rings….8050
          Disassembly….8050
          Assembly….8065
          Inspection….8087
            INSPECTION AFTER DISASSEMBLY….8087
              Oil Pan….8087
              Torque Converter….8087
              1st One-way Clutch….8088
              Under Drive Sun Gear….8088
              Mid Carrier Assembly….8088
              Rear Carrier Assembly….8088
              Reverse Brake Retaining Plate/Drive Plates/Driven Plates/Dish Plates….8088
              Front Brake Retaining Plates/Drive Plates/Driven Plate….8088
              Each Snap Ring….8088
              Parking Actuator Support and Parking Pawl….8088
        OIL PUMP, 2346 BRAKE, FRONT BRAKE PISTON….8090
          OIL PUMP, 2346 BRAKE, FRONT BRAKE PISTON….8090
          Exploded View….8090
          Disassembly….8090
          Assembly….8094
          Inspection and Adjustment….8097
            INSPECTION AFTER DISASSEMBLY….8097
              Each Snap Ring….8097
              Each Spring Retainer….8097
              2346 Brake Retaining Plate/Drive Plates/Driven Plates/Dish Plate….8097
            INSPECTION AFTER ASSEMBLY….8098
              2346 Brake Clearance….8098
        UNDER DRIVE CARRIER, FRONT BRAKE HUB….8099
          UNDER DRIVE CARRIER, FRONT BRAKE HUB….8099
          Exploded View….8099
          Disassembly….8099
          Assembly….8100
          Inspection….8100
            INSPECTION AFTER DISASSEMBLY….8100
        FRONT CARRIER, INPUT CLUTCH, REAR INTERNAL GEAR….8102
          FRONT CARRIER, INPUT CLUTCH, REAR INTERNAL GEAR….8102
          Exploded View….8102
          Disassembly….8103
          Assembly….8104
          Inspection….8106
            INSPECTION AFTER DISASSEMBLY….8106
              Front Carrier Snap Ring….8106
              Input Clutch Snap Ring….8106
              Input Clutch Drum….8106
              Input Clutch Retaining Plate/Drive Plates/Driven Plates/Dish Plate….8106
              Front Carrier….8106
              Rear Internal Gear….8106
        MID SUN GEAR, REAR SUN GEAR, HIGH AND LOW REVERSE CLUTCH HUB….8107
          MID SUN GEAR, REAR SUN GEAR, HIGH AND LOW REVERSE CLUTCH HUB….8107
          Exploded View….8107
          Disassembly….8107
          Assembly….8109
          Inspection….8111
            INSPECTION AFTER DISASSEMBLY….8111
              2nd One-way Clutch….8111
              High and Low Reverse Clutch Hub Snap Ring, Rear Sun Gear Snap Ring….8111
              2nd One-way Clutch….8111
              Mid Sun Gear….8111
              Rear Sun Gear….8111
              High and Low Reverse Clutch Hub….8111
        HIGH AND LOW REVERSE CLUTCH….8112
          HIGH AND LOW REVERSE CLUTCH….8112
          Exploded View….8112
          Disassembly….8112
          Assembly….8112
          Inspection….8113
            INSPECTION AFTER DISASSEMBLY….8113
              High and Low Reverse Clutch Snap Ring….8113
              High and Low Reverse Clutch Drum….8113
              High and Low Reverse Clutch Retaining Plate/Drive Plates/Driven Plates/Dish Plate….8113
        DIRECT CLUTCH….8114
          DIRECT CLUTCH….8114
          Exploded View….8114
          Disassembly….8114
          Assembly….8114
          Inspection….8115
            INSPECTION AFTER DISASSEMBLY….8115
              Direct Clutch Snap Ring….8115
              Direct Clutch Drum….8115
              Direct Clutch Retaining Plate/Drive Plates/Driven Plates/Dish Plate….8115
      SERVICE DATA AND SPECIFICATIONS (SDS)….8116
        SERVICE DATA AND SPECIFICATIONS (SDS)….8116
          SERVICE DATA AND SPECIFICATIONS (SDS)….8116
          General Specification….8116
          Vehicle Speed at Which Gear Shifting Occurs….8116
          Vehicle Speed at Which Lock-up Occurs/Releases….8116
          Stall Speed….8117
          Torque Converter….8117
          Total End Play….8117
          Reverse Brake Clearance….8117
          Front Brake Clearance….8117
          2346 Brake Clearance….8117
vtl….8118
  Table of Contents….8118
    SYSTEM DESCRIPTION….8120
      SWITCHES AND THEIR CONTROL FUNCTION….8120
        SWITCHES AND THEIR CONTROL FUNCTION….8120
        WITHOUT ACCS….8120
          WITHOUT ACCS : System Description….8120
        WITH ACCS….8121
          WITH ACCS : System Description….8121
      AIR DISTRIBUTION….8122
        AIR DISTRIBUTION….8122
        System Description….8122
    PRECAUTION….8123
      PRECAUTIONS….8123
        PRECAUTIONS….8123
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….8123
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….8123
        Precaution for Procedure without Cowl Top Cover….8123
        Precautions for Removing Battery Terminal….8124
    PREPARATION….8125
      PREPARATION….8125
        PREPARATION….8125
        Commercial Service Tool….8125
    PERIODIC MAINTENANCE….8126
      IN-CABIN MICROFILTER….8126
        IN-CABIN MICROFILTER….8126
        Exploded View….8126
        Removal and Installation….8126
          REMOVAL….8126
          INSTALLATION….8126
        Replacement….8126
    REMOVAL AND INSTALLATION….8127
      DUCT AND GRILLE….8127
        DUCT AND GRILLE….8127
        Exploded View….8127
          FRONT….8127
          REAR….8127
        CENTER VENTILATOR GRILLE….8128
          CENTER VENTILATOR GRILLE : Removal and Installation….8128
            REMOVAL….8128
            INSTALLATION….8128
        SIDE VENTILATOR GRILLE….8128
          SIDE VENTILATOR GRILLE : Removal and Installation….8128
            REMOVAL….8128
              Driver Side….8128
              Passenger Side….8129
            INSTALLATION….8129
        FRONT DEFROSTER GRILLE….8129
          FRONT DEFROSTER GRILLE : Removal and Installation….8129
            REMOVAL….8129
            INSTALLATION….8129
        SIDE DEFROSTER GRILLE….8129
          SIDE DEFROSTER GRILLE : Removal and Installation….8129
            REMOVAL….8129
            INSTALLATION….8130
        VENTILATOR DUCT….8130
          VENTILATOR DUCT : Removal and Installation….8130
            REMOVAL….8130
            INSTALLATION….8130
        ADAPTOR DUCT….8130
          ADAPTOR DUCT : Removal and Installation….8130
            REMOVAL….8130
            INSTALLATION….8131
        DEFROSTER NOZZLE….8131
          DEFROSTER NOZZLE : Removal and Installation….8131
            REMOVAL….8131
            INSTALLATION….8131
        SIDE DEFROSTER NOZZLE….8131
          SIDE DEFROSTER NOZZLE : Removal and Installation….8131
            REMOVAL….8131
              Driver Side….8131
              Passenger Side….8131
            INSTALLATION….8131
        SIDE DEFROSTER DUCT….8132
          SIDE DEFROSTER DUCT : Removal and Installation….8132
            REMOVAL….8132
            INSTALLATION….8132
        REAR VENTILATOR GRILLE….8132
          REAR VENTILATOR GRILLE : Removal and Installation….8132
            REMOVAL….8132
            INSTALLATION….8132
        REAR VENTILATOR DUCT 1….8132
          REAR VENTILATOR DUCT 1 : Removal and Installation….8132
            REMOVAL….8132
            INSTALLATION….8133
        REAR VENTILATOR DUCT 2….8133
          REAR VENTILATOR DUCT 2 : Removal and Installation….8133
            REMOVAL….8133
            INSTALLATION….8133
        FOOT GRILLE….8133
          FOOT GRILLE : Removal and Installation….8133
            REMOVAL….8133
              Driver Side….8133
              Passenger Side….8133
            INSTALLATION….8133
        FOOT DUCT….8133
          FOOT DUCT : Removal and Installation….8134
            REMOVAL….8134
              Driver Side….8134
              Passenger Side….8134
            INSTALLATION….8134
        HEATER DUCT….8134
          HEATER DUCT : Removal and Installation….8134
            REMOVAL….8134
            INSTALLATION….8135
        REAR FLOOR DUCT 1….8135
          REAR FLOOR DUCT 1 : Removal and Installation….8135
            REMOVAL….8135
            INSTALLATION….8135
      BLOWER UNIT….8136
        BLOWER UNIT….8136
        Exploded View….8136
        BLOWER UNIT….8136
          BLOWER UNIT : Removal and Installation….8136
            REMOVAL….8136
            INSTALLATION….8137
        BLOWER MOTOR….8137
          BLOWER MOTOR : Removal and Installation….8137
            REMOVAL….8137
            INSTALLATION….8137
wcs….8138
  Table of Contents….8138
    BASIC INSPECTION….8140
      DIAGNOSIS AND REPAIR WORKFLOW….8140
        DIAGNOSIS AND REPAIR WORKFLOW….8140
        Work Flow….8140
          OVERALL SEQUENCE….8140
          DETAILED FLOW….8140
    SYSTEM DESCRIPTION….8142
      WARNING CHIME SYSTEM….8142
        WARNING CHIME SYSTEM….8142
        WARNING CHIME SYSTEM….8142
          WARNING CHIME SYSTEM : System Diagram….8142
          WARNING CHIME SYSTEM : System Description….8142
            COMBINATION METER….8142
            UNIFIED METER AND A/C AMP…8142
            BCM….8142
          WARNING CHIME SYSTEM : Component Parts Location….8143
          WARNING CHIME SYSTEM : Component Description….8143
        LIGHT REMINDER WARNING CHIME….8144
          LIGHT REMINDER WARNING CHIME : System Diagram….8144
          LIGHT REMINDER WARNING CHIME : System Description….8144
            DESCRIPTION….8144
            WARNING OPERATION CONDITIONS….8144
            WARNING CANCEL CONDITIONS….8144
          LIGHT REMINDER WARNING CHIME : Component Parts Location….8145
          LIGHT REMINDER WARNING CHIME : Component Description….8145
        SEAT BELT WARNING CHIME….8145
          SEAT BELT WARNING CHIME : System Diagram….8146
          SEAT BELT WARNING CHIME : System Description….8146
            DESCRIPTION….8146
            WARNING OPERATION CONDITIONS….8146
            WARNING CANCEL CONDITIONS….8146
          SEAT BELT WARNING CHIME : Component Parts Location….8147
          SEAT BELT WARNING CHIME : Component Description….8147
        PARKING BRAKE RELEASE WARNING CHIME….8147
          PARKING BRAKE RELEASE WARNING CHIME : System Diagram….8148
          PARKING BRAKE RELEASE WARNING CHIME : System Description….8148
            DESCRIPTION….8148
            WARNING OPERATION CONDITIONS….8148
            WARNING CANCEL CONDITIONS….8148
          PARKING BRAKE RELEASE WARNING CHIME : Component Parts Location….8149
          PARKING BRAKE RELEASE WARNING CHIME : Component Description….8149
      DIAGNOSIS SYSTEM (UNIFIED METER AND A/C AMP.)….8150
        DIAGNOSIS SYSTEM (UNIFIED METER AND A/C AMP.)….8150
        CONSULT Function (METER/M&A)….8150
          CONSULT APPLICATION ITEMS….8150
          SELF DIAG RESULT….8150
          DATA MONITOR….8150
            Display Item List….8150
      DIAGNOSIS SYSTEM (BCM)….8154
        DIAGNOSIS SYSTEM (BCM)….8154
        COMMON ITEM….8154
          COMMON ITEM : CONSULT Function (BCM – COMMON ITEM)….8154
            APPLICATION ITEM….8154
            SYSTEM APPLICATION….8154
            FREEZE FRAME DATA (FFD)….8154
        BUZZER….8155
          BUZZER : CONSULT Function (BCM – BUZZER)….8155
            CONSULT APPLICATION ITEMS….8155
            DATA MONITOR….8156
            ACTIVE TEST….8156
    DTC/CIRCUIT DIAGNOSIS….8157
      POWER SUPPLY AND GROUND CIRCUIT….8157
        POWER SUPPLY AND GROUND CIRCUIT….8157
        COMBINATION METER….8157
          COMBINATION METER : Diagnosis Procedure….8157
        UNIFIED METER AND A/C AMP…8157
          UNIFIED METER AND A/C AMP. : Diagnosis Procedure….8157
        BCM (BODY CONTROL MODULE)….8158
          BCM (BODY CONTROL MODULE) : Diagnosis Procedure….8158
      METER BUZZER CIRCUIT….8160
        METER BUZZER CIRCUIT….8160
        Description….8160
        Component Function Check….8160
        Diagnosis Procedure….8160
      SEAT BELT BUCKLE SWITCH SIGNAL CIRCUIT….8161
        SEAT BELT BUCKLE SWITCH SIGNAL CIRCUIT….8161
        Description….8161
        Component Function Check….8161
        Diagnosis Procedure….8161
        Component Inspection….8162
      WARNING CHIME SYSTEM….8163
        WARNING CHIME SYSTEM….8163
        Wiring Diagram – WARNING CHIME -….8163
    ECU DIAGNOSIS INFORMATION….8169
      COMBINATION METER….8169
        COMBINATION METER….8169
        Reference Value….8169
          VALUES ON THE DIAGNOSIS TOOL….8169
          TERMINAL LAYOUT….8169
          PHYSICAL VALUES….8169
        Wiring Diagram – METER -….8172
        Fail-Safe….8185
          FAIL-SAFE….8185
        DTC Index….8186
      UNIFIED METER AND A/C AMP…8187
        UNIFIED METER AND A/C AMP…8187
        Reference Value….8187
          VALUES ON THE DIAGNOSIS TOOL….8187
          TERMINAL LAYOUT….8191
          PHYSICAL VALUES….8191
        Wiring Diagram – METER -….8194
        Fail-Safe….8207
          FAIL-SAFE….8207
        DTC Index….8208
      BCM (BODY CONTROL MODULE)….8209
        BCM (BODY CONTROL MODULE)….8209
        Reference Value….8209
          VALUES ON THE DIAGNOSIS TOOL….8209
          TERMINAL LAYOUT….8214
          PHYSICAL VALUES….8214
        Wiring Diagram – BCM -….8231
        Fail-safe….8246
          FAIL-SAFE CONTROL BY DTC….8246
          FAIL-SAFE CONTROL BY RAIN SENSOR MALFUNCTION….8247
          REAR WIPER MOTOR PROTECTION….8247
        DTC Inspection Priority Chart….8247
        DTC Index….8248
    SYMPTOM DIAGNOSIS….8250
      THE PARKING BRAKE RELEASE WARNING CONTINUES SOUNDING, OR DOES NOT SOUND….8250
        THE PARKING BRAKE RELEASE WARNING CONTINUES SOUNDING, OR DOES NOT SOUND….8250
        Description….8250
        Diagnosis Procedure….8250
      THE LIGHT REMINDER WARNING DOES NOT SOUND….8251
        THE LIGHT REMINDER WARNING DOES NOT SOUND….8251
        Description….8251
        Diagnosis Procedure….8251
      THE SEAT BELT WARNING CONTINUES SOUNDING, OR DOES NOT SOUND….8252
        THE SEAT BELT WARNING CONTINUES SOUNDING, OR DOES NOT SOUND….8252
        Description….8252
        Diagnosis Procedure….8252
    PRECAUTION….8253
      PRECAUTIONS….8253
        PRECAUTIONS….8253
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….8253
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….8253
        Precautions for Removing Battery Terminal….8253
wt….8254
  Table of Contents….8254
    BASIC INSPECTION….8256
      DIAGNOSIS AND REPAIR WORK FLOW….8256
        DIAGNOSIS AND REPAIR WORK FLOW….8256
        Work Flow ….8256
          DETAILED FLOW….8256
      TIRE PRESSURE SENSOR WAKE UP OPERATION….8258
        TIRE PRESSURE SENSOR WAKE UP OPERATION….8258
        Description….8258
        Work Procedure….8258
      TIRE PRESSURE SENSOR ID REGISTRATION….8259
        TIRE PRESSURE SENSOR ID REGISTRATION….8259
        Description….8259
        Work Procedure….8259
    SYSTEM DESCRIPTION….8260
      SYSTEM….8260
        SYSTEM….8260
        System Diagram….8260
        System Description….8260
        Component Parts Location….8261
        Component Description….8261
        Information Display….8262
      DIAGNOSIS SYSTEM (LOW TIRE PRESSURE WARNING CONTROL UNIT)….8263
        DIAGNOSIS SYSTEM (LOW TIRE PRESSURE WARNING CONTROL UNIT)….8263
        CONSULT Function….8263
          FUNCTION….8263
          WORK SUPPORT….8263
          SELF-DIAGNOSTIC RESULT….8263
          DATA MONITOR….8263
          ACTIVE TEST….8263
          ECU IDENTIFICATION….8264
    DTC/CIRCUIT DIAGNOSIS….8265
      C1704, C1705, C1706, C1707 LOW TIRE PRESSURE….8265
        C1704, C1705, C1706, C1707 LOW TIRE PRESSURE….8265
        Description….8265
        DTC Logic….8265
          DTC DETECTION LOGIC….8265
          DTC REPRODUCTION PROCEDURE….8265
        Diagnosis Procedure….8265
      C1708, C1709, C1710, C1711 TIRE PRESSURE SENSOR….8267
        C1708, C1709, C1710, C1711 TIRE PRESSURE SENSOR….8267
        Description….8267
        DTC Logic….8267
          DTC logic….8267
          DTC REPRODUCTION PROCEDURE….8267
        Diagnosis Procedure….8267
        Special Repair Requirement….8270
      C1716, C1717, C1718, C1719 TIRE PRESSURE SENSOR….8271
        C1716, C1717, C1718, C1719 TIRE PRESSURE SENSOR….8271
        Description….8271
        DTC Logic….8271
          DTC logic….8271
          DTC REPRODUCTION PROCEDURE….8271
        Diagnosis Procedure….8271
        Component Inspection….8272
        Special Repair Requirement….8272
      C1720, C1721, C1722, C1723 TIRE PRESSURE SENSOR….8273
        C1720, C1721, C1722, C1723 TIRE PRESSURE SENSOR….8273
        Description….8273
        DTC Logic….8273
          DTC logic….8273
          DTC REPRODUCTION PROCEDURE….8273
        Diagnosis Procedure….8273
        Special Repair Requirement….8276
      C1728 RECEIVER ID….8277
        C1728 RECEIVER ID….8277
        Description….8277
        DTC Logic….8277
          DTC DETECTION LOGIC….8277
          DTC REPRODUCTION PROCEDURE….8277
        Diagnosis Procedure….8277
      C1729 VEHICLE SPEED SIG ERR….8280
        C1729 VEHICLE SPEED SIG ERR….8280
        Description….8280
        DTC Logic….8280
          DTC logic….8280
          DTC REPRODUCTION PROCEDURE….8280
        Diagnosis Procedure….8280
      C1750, C1751, C1752, C1753 RECEIVER….8281
        C1750, C1751, C1752, C1753 RECEIVER….8281
        Description….8281
        DTC Logic….8281
          DTC DETECTION LOGIC….8281
          DTC REPRODUCTION PROCEDURE….8281
        Diagnosis Procedure….8281
      C1754 LOW TIRE PRESSURE WARNING CONTROL UNIT….8283
        C1754 LOW TIRE PRESSURE WARNING CONTROL UNIT….8283
        Description….8283
        DTC Logic….8283
          DTC logic….8283
          DTC REPRODUCTION PROCEDURE….8283
        Diagnosis Procedure….8283
        Special Repair Requirement….8285
      C1755, C1756, C1757, C1758 POOR RECEIVING CONDITIONS….8286
        C1755, C1756, C1757, C1758 POOR RECEIVING CONDITIONS….8286
        Description….8286
        DTC Logic….8286
          DTC logic….8286
          DTC REPRODUCTION PROCEDURE….8286
        Diagnosis Procedure….8286
      U1000 CAN COMM CIRCUIT….8288
        U1000 CAN COMM CIRCUIT….8288
        Description….8288
        DTC Logic….8288
          DTC DETECTION LOGIC….8288
          DTC CONFIRMATION PROCEDURE….8288
        Diagnosis Procedure….8288
      U1010 CONTROL UNIT (CAN)….8289
        U1010 CONTROL UNIT (CAN)….8289
        Description….8289
        DTC Logic….8289
          DTC DETECTION LOGIC….8289
          DTC CONFIRMATION PROCEDURE….8289
        Diagnosis Procedure….8289
      POWER SUPPLY AND GROUND CIRCUIT….8290
        POWER SUPPLY AND GROUND CIRCUIT….8290
        Description….8290
        Diagnosis Procedure….8290
      LOW TIRE PRESSURE WARNING LAMP….8292
        LOW TIRE PRESSURE WARNING LAMP….8292
        Description….8292
        Component Function Check….8292
        Diagnosis Procedure….8292
    ECU DIAGNOSIS INFORMATION….8294
      LOW TIRE PRESSURE WARNING CONTROL UNIT….8294
        LOW TIRE PRESSURE WARNING CONTROL UNIT….8294
        Reference Value….8294
          VALUES ON THE DIAGNOSIS TOOL….8294
          TERMINAL LAYOUT….8294
          PHYSICAL VALUES….8294
        Wiring Diagram – TIRE PRESSURE MONITORING SYSTEM -….8296
        DTC Inspection Priority Chart….8302
        DTC Index….8303
    SYMPTOM DIAGNOSIS….8305
      TPMS….8305
        TPMS….8305
        Symptom Table….8305
          LOW TIRE PRESSURE WARNING LAMP SYMPTOM CHART….8305
      LOW TIRE PRESSURE WARNING LAMP DOES NOT TURN ON….8307
        LOW TIRE PRESSURE WARNING LAMP DOES NOT TURN ON….8307
        Description….8307
        Diagnosis Procedure….8307
      LOW TIRE PRESSURE WARNING LAMP DOES NOT TURN OFF….8308
        LOW TIRE PRESSURE WARNING LAMP DOES NOT TURN OFF….8308
        Description….8308
        Diagnosis Procedure….8308
      LOW TIRE PRESSURE WARNING LAMP BLINKS….8309
        LOW TIRE PRESSURE WARNING LAMP BLINKS….8309
        Description….8309
        Diagnosis Procedure….8309
      TURN SIGNAL LAMP BLINKS….8310
        TURN SIGNAL LAMP BLINKS….8310
        Description….8310
          DESCRIPTION….8310
        Diagnosis Procedure….8310
      ID REGISTRATION CANNOT BE COMPLETED….8311
        ID REGISTRATION CANNOT BE COMPLETED….8311
        Description….8311
          DESCRIPTION….8311
        Diagnosis Procedure….8311
      NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….8312
        NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….8312
        NVH Troubleshooting Chart….8312
    PRECAUTION….8313
      PRECAUTIONS….8313
        PRECAUTIONS….8313
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….8313
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….8313
        Service Notice and Precautions….8313
        Precautions for Removing Battery Terminal….8313
    PREPARATION….8315
      PREPARATION….8315
        PREPARATION….8315
        Special Service Tool….8315
        Commercial Service Tool….8315
    PERIODIC MAINTENANCE….8316
      ROAD WHEEL….8316
        ROAD WHEEL….8316
        Adjustment….8316
          BALANCING WHEELS (BONDING WEIGHT TYPE)….8316
            Preparation Before Adjustment….8316
            Wheel Balance Adjustment….8316
          TIRE ROTATION….8317
    REMOVAL AND INSTALLATION….8318
      ROAD WHEEL TIRE ASSEMBLY….8318
        ROAD WHEEL TIRE ASSEMBLY….8318
        Exploded View….8318
        Removal and Installation….8318
          REMOVAL….8318
          INSTALLATION….8318
        Inspection….8318
          ALUMINUM WHEEL….8318
          STEEL WHEEL….8318
      TPMS CONTROL UNIT….8320
        TPMS CONTROL UNIT….8320
        Exploded View….8320
        Removal and Installation….8320
          REMOVAL….8320
          INSTALLATION….8320
      TIRE PRESSURE SENSOR….8321
        TIRE PRESSURE SENSOR….8321
        Exploded View….8321
        Removal and Installation….8321
          REMOVAL….8321
          INSTALLATION….8322
      TIRE PRESSURE RECEIVER….8323
        TIRE PRESSURE RECEIVER….8323
        Exploded View….8323
        FRONT TIRE PRESSURE RECEIVER….8323
          FRONT TIRE PRESSURE RECEIVER : Removal and Installation….8323
            REMOVAL….8323
            INSTALLATION….8323
        REAR TIRE PRESSURE RECEIVER….8323
          REAR TIRE PRESSURE RECEIVER : Removal and Installation….8323
            REMOVAL….8323
            INSTALLATION….8323
    SERVICE DATA AND SPECIFICATIONS (SDS)….8324
      SERVICE DATA AND SPECIFICATIONS (SDS)….8324
        SERVICE DATA AND SPECIFICATIONS (SDS)….8324
        Road Wheel….8324
          CONVENTIONAL….8324
          EMERGENCY (ALUMINUM WHEEL)….8324
          EMERGENCY (STEEL WHEEL)….8324
        Tire Air Pressure….8324
ww….8325
  Table of Contents….8325
    BASIC INSPECTION….8327
      DIAGNOSIS AND REPAIR WORK FLOW….8327
        DIAGNOSIS AND REPAIR WORK FLOW….8327
        Work Flow….8327
          OVERALL SEQUENCE….8327
          DETAILED FLOW….8327
    SYSTEM DESCRIPTION….8330
      FRONT WIPER AND WASHER SYSTEM….8330
        FRONT WIPER AND WASHER SYSTEM….8330
        WITH RAIN SENSOR….8330
          WITH RAIN SENSOR : System Diagram….8330
          WITH RAIN SENSOR : System Description….8330
            OUTLINE….8330
            FRONT WIPER BASIC OPERATION….8330
            FRONT WIPER LO OPERATION….8330
            FRONT WIPER HI OPERATION….8330
            FRONT WIPER AUTO OPERATION….8331
              Rain Sensing….8331
              Auto Wiping Operation ….8331
              Rain Sensor Sensitivity Setting….8331
            FRONT WIPER AUTO STOP OPERATION….8331
            FRONT WIPER OPERATION LINKED WITH WASHER….8332
            FAIL-SAFE FUNCTION….8332
              Front Wiper control….8332
              Rain Sensor Malfunction….8332
          WITH RAIN SENSOR : Component Parts Location….8333
          WITH RAIN SENSOR : Component Description….8333
        WITHOUT RAIN SENSOR….8334
          WITHOUT RAIN SENSOR : System Diagram….8334
          WITHOUT RAIN SENSOR : System Description….8334
            OUTLINE….8334
            FRONT WIPER BASIC OPERATION….8334
            FRONT WIPER LO OPERATION….8334
            FRONT WIPER HI OPERATION….8334
            FRONT WIPER INT OPERATION….8335
            FRONT WIPER AUTO STOP OPERATION….8335
            FRONT WIPER OPERATION LINKED WITH WASHER….8336
            FRONT WIPER FAIL-SAFE OPERATION….8336
          WITHOUT RAIN SENSOR : Component Parts Location….8337
          WITHOUT RAIN SENSOR : Component Description….8337
      REAR WIPER AND WASHER SYSTEM….8339
        REAR WIPER AND WASHER SYSTEM….8339
        System Diagram….8339
        System Description….8339
          OUTLINE….8339
          REAR WIPER BASIC OPERATION….8339
          REAR WIPER ON OPERATION….8339
          REAR WIPER INT OPERATION….8339
          REAR WIPER AUTO STOP OPERATION….8339
          REAR WIPER OPERATION LINKED WITH WASHER ….8340
          REAR WIPER FAIL-SAFE OPERATION….8340
        Component Parts Location….8341
        Component Description….8341
      DIAGNOSIS SYSTEM (BCM)….8342
        DIAGNOSIS SYSTEM (BCM)….8342
        COMMON ITEM….8342
          COMMON ITEM : CONSULT Function (BCM – COMMON ITEM)….8342
            APPLICATION ITEM….8342
            SYSTEM APPLICATION….8342
            FREEZE FRAME DATA (FFD)….8342
        WIPER….8343
          WIPER : CONSULT Function (BCM – WIPER)….8343
            WORK SUPPORT….8343
            DATA MONITOR….8344
            ACTIVE TEST….8344
      DIAGNOSIS SYSTEM (IPDM E/R)….8345
        DIAGNOSIS SYSTEM (IPDM E/R)….8345
        Diagnosis Description….8345
          AUTO ACTIVE TEST….8345
            Description….8345
            Operation Procedure….8345
            Inspection in Auto Active Test Mode….8345
            Concept of auto active test….8346
            Diagnosis chart in auto active test mode….8346
        CONSULT Function (IPDM E/R)….8347
          APPLICATION ITEM….8347
          SELF DIAGNOSTIC RESULT….8347
          DATA MONITOR….8347
          ACTIVE TEST….8348
    DTC/CIRCUIT DIAGNOSIS….8350
      WIPER AND WASHER FUSE….8350
        WIPER AND WASHER FUSE….8350
        Description….8350
        Diagnosis Procedure….8350
      POWER SUPPLY AND GROUND CIRCUIT….8351
        POWER SUPPLY AND GROUND CIRCUIT….8351
        BCM (BODY CONTROL MODULE)….8351
          BCM (BODY CONTROL MODULE) : Diagnosis Procedure….8351
        IPDM E/R (INTELLIGENT POWER DISTRIBUTION MODULE ENGINE ROOM)….8351
          IPDM E/R (INTELLIGENT POWER DISTRIBUTION MODULE ENGINE ROOM) : Diagnosis Procedure….8351
      FRONT WIPER MOTOR LO CIRCUIT….8353
        FRONT WIPER MOTOR LO CIRCUIT….8353
        Component Function Check….8353
        Diagnosis Procedure….8353
      FRONT WIPER MOTOR HI CIRCUIT….8355
        FRONT WIPER MOTOR HI CIRCUIT….8355
        Component Function Check….8355
        Diagnosis Procedure….8355
      FRONT WIPER STOP POSITION SIGNAL CIRCUIT….8357
        FRONT WIPER STOP POSITION SIGNAL CIRCUIT….8357
        Component Function Check….8357
        Diagnosis Procedure….8357
      FRONT WIPER MOTOR GROUND CIRCUIT….8359
        FRONT WIPER MOTOR GROUND CIRCUIT….8359
        Diagnosis Procedure….8359
      WASHER SWITCH….8360
        WASHER SWITCH….8360
        Description….8360
        Component Inspection….8360
      RAIN SENSOR….8361
        RAIN SENSOR….8361
        Description….8361
        Component Function Check….8361
        Diagnosis Procedure….8361
      REAR WIPER MOTOR CIRCUIT….8363
        REAR WIPER MOTOR CIRCUIT….8363
        Component Function Check….8363
        Diagnosis Procedure….8363
      REAR WIPER STOP POSITION SIGNAL CIRCUIT….8365
        REAR WIPER STOP POSITION SIGNAL CIRCUIT….8365
        Component Function Check….8365
        Diagnosis Procedure….8365
      FRONT WIPER AND WASHER SYSTEM….8367
        FRONT WIPER AND WASHER SYSTEM….8367
        Wiring Diagram – FRONT WIPER AND WASHER SYSTEM -….8367
      REAR WIPER AND WASHER SYSTEM….8372
        REAR WIPER AND WASHER SYSTEM….8372
        Wiring Diagram – REAR WIPER AND WASHER SYSTEM -….8372
    ECU DIAGNOSIS INFORMATION….8378
      BCM (BODY CONTROL MODULE)….8378
        BCM (BODY CONTROL MODULE)….8378
        Reference Value….8378
          VALUES ON THE DIAGNOSIS TOOL….8378
          TERMINAL LAYOUT….8383
          PHYSICAL VALUES….8383
        Wiring Diagram – BCM -….8400
        Fail-safe….8415
          FAIL-SAFE CONTROL BY DTC….8415
          FAIL-SAFE CONTROL BY RAIN SENSOR MALFUNCTION….8416
          REAR WIPER MOTOR PROTECTION….8416
        DTC Inspection Priority Chart….8416
        DTC Index….8417
      IPDM E/R (INTELLIGENT POWER DISTRIBUTION MODULE ENGINE ROOM)….8419
        IPDM E/R (INTELLIGENT POWER DISTRIBUTION MODULE ENGINE ROOM)….8419
        Reference Value….8419
          VALUES ON THE DIAGNOSIS TOOL….8419
          TERMINAL LAYOUT….8421
          PHYSICAL VALUES….8421
        Wiring Diagram – IPDM E/R -….8426
        Fail-safe….8429
          CAN COMMUNICATION CONTROL….8429
            If No CAN Communication Is Available With ECM….8429
            If No CAN Communication Is Available With BCM….8430
          IGNITION RELAY MALFUNCTION DETECTION FUNCTION….8430
          FRONT WIPER CONTROL….8430
          STARTER MOTOR PROTECTION FUNCTION….8431
        DTC Index….8431
    SYMPTOM DIAGNOSIS….8432
      WIPER AND WASHER SYSTEM SYMPTOMS….8432
        WIPER AND WASHER SYSTEM SYMPTOMS….8432
        WITH RAIN SENSOR….8432
          WITH RAIN SENSOR : Symptom Table….8432
        WITHOUT RAIN SENSOR….8434
          WITHOUT RAIN SENSOR : Symptom Table….8434
      NORMAL OPERATING CONDITION….8437
        NORMAL OPERATING CONDITION….8437
        Description….8437
          FRONT WIPER MOTOR PROTECTION FUNCTION….8437
          REAR WIPER MOTOR PROTECTION FUNCTION….8437
      FRONT WIPER DOES NOT OPERATE….8438
        FRONT WIPER DOES NOT OPERATE….8438
        Description….8438
        Diagnosis Procedure….8438
    PRECAUTION….8440
      PRECAUTIONS….8440
        PRECAUTIONS….8440
        Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….8440
          PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….8440
        Precaution for Procedure without Cowl Top Cover….8440
        Precautions for Removing Battery Terminal….8441
    REMOVAL AND INSTALLATION….8442
      WASHER TANK….8442
        WASHER TANK….8442
        Exploded View….8442
        Removal and Installation….8442
          REMOVAL….8442
          INSTALLATION….8442
      WASHER PUMP….8443
        WASHER PUMP….8443
        Exploded View….8443
        Removal and Installation….8443
          REMOVAL….8443
          INSTALLATION….8443
      WASHER LEVEL SWITCH….8444
        WASHER LEVEL SWITCH….8444
        Removal and Installation….8444
      FRONT WASHER NOZZLE AND TUBE….8445
        FRONT WASHER NOZZLE AND TUBE….8445
        Hydraulic Layout….8445
        Removal and Installation….8445
          REMOVAL….8445
          INSTALLATION….8445
        Inspection and Adjustment….8445
          INSPECTION….8445
            Washer Nozzle Inspection….8445
          ADJUSTMENT….8446
            Washer Nozzle Spray Position Adjustment….8446
      FRONT WIPER ARM….8448
        FRONT WIPER ARM….8448
        Exploded View….8448
        Removal and Installation….8448
          REMOVAL….8448
          INSTALLATION….8448
        Adjustment….8448
          WIPER BLADE POSITION ADJUSTMENT….8448
      WIPER BLADE….8450
        WIPER BLADE….8450
        Exploded View….8450
        Removal and Installation….8450
          REMOVAL….8450
          INSTALLATION….8450
        Replacement….8451
      FRONT WIPER DRIVE ASSEMBLY….8452
        FRONT WIPER DRIVE ASSEMBLY….8452
        Exploded View….8452
          REMOVAL….8452
          DISASSEMBLY….8452
        Removal and Installation….8452
          REMOVAL….8452
          INSTALLATION….8453
        Disassembly and Assembly….8453
          DISASSEMBLY….8453
          ASSEMBLY….8453
      RAIN SENSOR….8454
        RAIN SENSOR….8454
        Exploded View….8454
          REMOVAL….8454
        Removal and Installation….8454
          REMOVAL….8454
          INSTALLATION….8454
      WIPER AND WASHER SWITCH….8455
        WIPER AND WASHER SWITCH….8455
        Exploded View….8455
      REAR WIPER ARM….8456
        REAR WIPER ARM….8456
        Exploded View….8456
        Removal and Installation….8456
          REMOVAL….8456
          INSTALLATION….8456
        Adjustment….8456
          REAR WIPER BLADE POSITION ADJUSTMENT….8456
      REAR WIPER MOTOR….8458
        REAR WIPER MOTOR….8458
        Exploded View….8458
        Removal and Installation….8458
          REMOVAL….8458
          INSTALLATION….8458
      REAR WASHER NOZZLE AND TUBE….8459
        REAR WASHER NOZZLE AND TUBE….8459
        Hydraulic Layout….8459
        Removal and Installation….8459
          REMOVAL….8459
          INSTALLATION….8460
        Inspection and Adjustment….8460
          INSPECTION….8460
            Washer Nozzle Inspection….8460
          ADJUSTMENT….8460
            Washer Nozzle Spray Position adjustment….8460

BODY INTERIOR
BODY SIDE TRIM
Removal and Installation
CAUTION: Wrap the tip of flat-bladed screwdriver with a shop cloth when removing metal clips from garnishes.
REMOVAL
FRONT PILLAR GARNISH
1. Remove front body side welt partially.
2. Disengage front pillar garnish (1) fixing clip and metal clip with remover tool (A).
3. Pull the front pillar garnish partially toward the vehicle.
4. Insert the remover tool (A) between fixing clip bottom side and body side to disengage front pillar garnish (1) fixing clip and then cut the clip with a cutter tool.
5. Once free, pull front pillar garnish (1) upwards to disengage the lower locating tab from instrument panel.
6. Remove front pillar garnish.
FRONT KICKING PLATE INNER
1. Move front seat to the foremost position.
2. Lift up rear end lower of front kicking plate inner while pulling it
toward inside of the vehicle, and disengage front kicking plate
inner fixing pawls.
…
Infiniti FX/QX70 (S51) Workshop Repair Service Manual 2009-2016

---

INSTANT DOWNLOAD

---