Complete digital official shop manual contains service, maintenance, and troubleshooting information for the Infiniti QX/QX56/QX80 (Z62) 2011-2016. Diagnostic and repair procedures are covered in great detail to repair, maintain, rebuild, refurbish or restore your vehicle like a professional mechanic in local service/repair workshop. This cost-effective quality manual is 100% complete and intact as should be without any missing pages. It is the same factory shop manual used by dealers that guaranteed to be fully functional to save your precious time.
This manual for Infiniti QX56/QX80 (Z62) 2011-2016 is divided into different sections. Each section covers a specific component or system and, in addition to the standard service procedures, includes disassembling, inspecting, and assembling instructions. A table of contents is placed at the beginning of each section. Pages are easily found by category, and each page is expandable for great detail. It is in the cross-platform PDF document format so that it works like a charm on all kinds of devices. You do not need to be skilled with a computer to use the manual.
Table of Contents
PRECAUTION….4
PRECAUTIONS….4
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….4
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….4
Precautions for Removing Battery Terminal….4
REMOVAL AND INSTALLATION….5
ACCELERATOR CONTROL SYSTEM….5
MODELS WITHOUT DISTANCE CONTROL ASSIST SYSTEM….5
MODELS WITHOUT DISTANCE CONTROL ASSIST SYSTEM : Exploded View….5
MODELS WITHOUT DISTANCE CONTROL ASSIST SYSTEM : Removal and Installation….5
REMOVAL….5
INSTALLATION….5
MODELS WITHOUT DISTANCE CONTROL ASSIST SYSTEM : Inspection….5
INSPECTION AFTER INSTALLATION….5
MODELS WITH DISTANCE CONTROL ASSIST SYSTEM….6
MODELS WITH DISTANCE CONTROL ASSIST SYSTEM : Exploded View….6
MODELS WITH DISTANCE CONTROL ASSIST SYSTEM : Removal and Installation….6
REMOVAL….6
INSTALLATION….7
MODELS WITH DISTANCE CONTROL ASSIST SYSTEM : Inspection….7
INSPECTION AFTER INSTALLATION….7
adp….8
Table of Contents….8
PRECAUTION….12
PRECAUTIONS….12
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….12
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….12
Precautions for Removing Battery Terminal….12
PREPARATION….13
PREPARATION….13
Commercial Service Tools….13
SYSTEM DESCRIPTION….14
COMPONENT PARTS….14
Component Parts Location….14
Component Description….15
SYSTEM….18
AUTOMATIC DRIVE POSITIONER SYSTEM….18
AUTOMATIC DRIVE POSITIONER SYSTEM : System Diagram….18
AUTOMATIC DRIVE POSITIONER SYSTEM : System Description….18
Sleep control….19
Wake-up control ….19
MANUAL FUNCTION….19
MANUAL FUNCTION : System Diagram….20
MANUAL FUNCTION : System Description….20
OPERATION PROCEDURE….20
DETAIL FLOW….21
Seat ….21
Tilt & Telescopic….21
Door Mirror….21
MEMORY FUNCTION….21
MEMORY FUNCTION : System Diagram….22
MEMORY FUNCTION : System Description….22
OPERATION PROCEDURE….22
OPERATION CONDITION….23
DETAIL FLOW….23
TIMER FUNCTION….23
EXIT ASSIST FUNCTION….23
EXIT ASSIST FUNCTION : System Diagram….24
EXIT ASSIST FUNCTION : System Description….24
OPERATION PROCEDURE….24
OPERATION CONDITION….24
DETAIL FLOW….25
ENTRY ASSIST FUNCTION….25
ENTRY ASSIST FUNCTION : System Diagram….25
ENTRY ASSIST FUNCTION : System Description….25
OPERATION PROCEDURE….25
OPERATION CONDITION….26
DETAIL FLOW….26
INTELLIGENT KEY INTERLOCK FUNCTION….26
INTELLIGENT KEY INTERLOCK FUNCTION : System Diagram….27
INTELLIGENT KEY INTERLOCK FUNCTION : System Description….27
OPERATION PROCEDURE….27
OPERATION CONDITION….27
DETAIL FLOW….28
Fail Safe….28
DIAGNOSIS SYSTEM (DRIVER SEAT CONTROL UNIT)….29
CONSULT Function….29
APPLICATION ITEMS….29
SELF-DIAGNOSIS RESULTS….29
DATA MONITOR….29
ACTIVE TEST….31
WORK SUPPORT….31
ECU DIAGNOSIS INFORMATION….32
DRIVER SEAT CONTROL UNIT….32
Reference Value….32
VALUES ON THE DIAGNOSIS TOOL….32
TERMINAL LAYOUT….34
PHYSICAL VALUES….34
Fail Safe….37
DTC Index….38
AUTOMATIC DRIVE POSITIONER CONTROL UNIT….39
Reference Value….39
TERMINAL LAYOUT….39
PHYSICAL VALUES….39
BCM (BODY CONTROL MODULE)….42
List of ECU Reference….42
WIRING DIAGRAM….43
AUTOMATIC DRIVE POSITIONER SYSTEM….43
Wiring Diagram….43
BASIC INSPECTION….55
DIAGNOSIS AND REPAIR WORK FLOW….55
Work Flow….55
OVERALL SEQUENCE….55
DETAILED FLOW….55
INSPECTION AND ADJUSTMENT….58
ADDITIONAL SERVICE WHEN REMOVING BATTERY NEGATIVE TERMINAL….58
ADDITIONAL SERVICE WHEN REMOVING BATTERY NEGATIVE TERMINAL : Description….58
ADDITIONAL SERVICE WHEN REMOVING BATTERY NEGATIVE TERMINAL : Special Repair Requirement….58
ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT….58
ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT : Description….58
ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT : Special Repair Requirement….59
SYSTEM INITIALIZATION….59
SYSTEM INITIALIZATION : Description….59
SYSTEM INITIALIZATION : Special Repair Requirement….59
INITIALIZATION PROCEDURE….59
MEMORY STORING….60
MEMORY STORING : Description….60
MEMORY STORING : Special Repair Requirement….60
Memory Storage Procedure….60
INTELLIGENT KEY INTERLOCK STORING….60
INTELLIGENT KEY INTERLOCK STORING : Description….61
INTELLIGENT KEY INTERLOCK STORING : Special Repair Requirement….61
Intelligent Key Interlock Storage Procedure….61
SYSTEM SETTING….61
SYSTEM SETTING : Description….61
Setting Change….61
SYSTEM SETTING : Special Repair Requirement….62
DTC/CIRCUIT DIAGNOSIS….63
U1000 CAN COMM CIRCUIT….63
Description….63
DTC Logic….63
DTC DETECTION LOGIC….63
DTC CONFIRMATION PROCEDURE….63
Diagnosis Procedure….63
Special Repair Requirement….63
U1010 CONTROL UNIT (CAN)….64
DTC Logic….64
DTC DETECTION LOGIC….64
Diagnosis Procedure….64
B2112 SLIDING MOTOR….65
DTC Logic….65
DTC DETECTION LOGIC….65
DTC CONFIRMATION PROCEDURE….65
Diagnosis Procedure….65
B2113 RECLINING MOTOR….67
DTC Logic….67
DTC DETECTION LOGIC….67
DTC CONFIRMATION PROCEDURE….67
Diagnosis Procedure….67
B2116 TILT MOTOR….69
DTC Logic….69
DTC DETECTION LOGIC….69
DTC CONFIRMATION PROCEDURE….69
Diagnosis Procedure….69
B2128 UART COMMUNICATION LINE….71
Description….71
DTC Logic….71
DTC DETECTION LOGIC….71
DTC CONFIRMATION PROCEDURE….71
Diagnosis Procedure….71
B2130 EEPROM….73
DTC Logic….73
DTC DETECTION LOGIC….73
DTC CONFIRMATION PROCEDURE….73
Diagnosis Procedure….73
POWER SUPPLY AND GROUND CIRCUIT….74
DRIVER SEAT CONTROL UNIT….74
DRIVER SEAT CONTROL UNIT : Diagnosis Procedure….74
DRIVER SEAT CONTROL UNIT : Special Repair Requirement….74
AUTOMATIC DRIVE POSITIONER CONTROL UNIT….74
AUTOMATIC DRIVE POSITIONER CONTROL UNIT : Diagnosis Procedure….74
AUTOMATIC DRIVE POSITIONER CONTROL UNIT : Special Repair Requirement….75
SLIDING SWITCH….76
Component Function Check….76
Diagnosis Procedure….76
Component Inspection….77
RECLINING SWITCH….78
Component Function Check….78
Diagnosis Procedure….78
Component Inspection….79
LIFTING SWITCH (FRONT)….80
Component Function Check….80
Diagnosis Procedure….80
Component Inspection….81
LIFTING SWITCH (REAR)….82
Component Function Check….82
Diagnosis Procedure….82
Component Inspection….83
TILT SWITCH….84
Component Function Check….84
Diagnosis Procedure….84
Component Inspection….85
TELESCOPIC SWITCH….86
Component Function Check….86
Diagnosis Procedure….86
Component Inspection….87
SEAT MEMORY SWITCH….88
Component Function Check….88
Diagnosis Procedure….88
Component Inspection….89
DOOR MIRROR REMOTE CONTROL SWITCH….90
CHANGEOVER SWITCH….90
CHANGEOVER SWITCH : Component Function Check….90
CHANGEOVER SWITCH : Diagnosis Procedure….90
CHANGEOVER SWITCH : Component Inspection….91
MIRROR SWITCH….91
MIRROR SWITCH : Component Function Check….91
MIRROR SWITCH : Diagnosis Procedure….92
MIRROR SWITCH : Component Inspection….93
POWER SEAT SWITCH GROUND CIRCUIT….94
Diagnosis Procedure….94
TILT &TELESCOPIC SWITCH GROUND CIRCUIT….95
Diagnosis Procedure….95
SLIDING SENSOR….96
Component Function Check….96
Diagnosis Procedure….96
RECLINING SENSOR….98
Component Function Check….98
Diagnosis Procedure….98
LIFTING SENSOR (FRONT)….100
Component Function Check….100
Diagnosis Procedure….100
LIFTING SENSOR (REAR)….102
Component Function Check….102
Diagnosis Procedure….102
TILT SENSOR….104
Component Function Check….104
Diagnosis Procedure….104
TELESCOPIC SENSOR….106
Component Function Check….106
Diagnosis Procedure….106
MIRROR SENSOR….109
DRIVER SIDE….109
DRIVER SIDE : Component Function Check….109
DRIVER SIDE : Diagnosis Procedure….109
PASSENGER SIDE….110
PASSENGER SIDE : Component Function Check….110
PASSENGER SIDE : Diagnosis Procedure….111
SLIDING MOTOR….113
Component Function Check….113
Diagnosis Procedure….113
RECLINING MOTOR….115
Component Function Check….115
Diagnosis Procedure….115
LIFTING MOTOR (FRONT)….117
Component Function Check….117
Diagnosis Procedure….117
LIFTING MOTOR (REAR)….119
Component Function Check….119
Diagnosis Procedure….119
TILT MOTOR….121
Component Function Check….121
Diagnosis Procedure….121
TELESCOPIC MOTOR….123
Component Function Check….123
Diagnosis Procedure….123
DOOR MIRROR MOTOR….125
Component Function Check….125
Diagnosis Procedure….125
Component Inspection….126
SEAT MEMORY INDICATOR….127
Component Function Check….127
Diagnosis Procedure….127
SYMPTOM DIAGNOSIS….129
MANUAL FUNCTION DOES NOT OPERATE….129
ALL COMPONENT….129
ALL COMPONENT : Diagnosis Procedure….129
POWER SEAT….129
POWER SEAT : Diagnosis Procedure….129
TILT & TELESCOPIC….129
TILT & TELESCOPIC : Diagnosis Procedure….129
SEAT SLIDING….130
SEAT SLIDING : Diagnosis Procedure….130
SEAT RECLINING….130
SEAT RECLINING : Diagnosis Procedure….130
SEAT LIFTING (FRONT)….131
SEAT LIFTING (FRONT) : Diagnosis Procedure….131
SEAT LIFTING (REAR)….131
SEAT LIFTING (REAR) : Diagnosis Procedure….131
STEERING TILT….132
STEERING TILT : Diagnosis Procedure….132
STEERING TELESCOPIC….132
STEERING TELESCOPIC : Diagnosis Procedure….132
DOOR MIRROR….133
DOOR MIRROR : Diagnosis Procedure….133
MEMORY FUNCTION DOES NOT OPERATE….134
ALL COMPONENT….134
ALL COMPONENT : Diagnosis Procedure….134
SEAT SLIDING….134
SEAT SLIDING : Diagnosis Procedure….134
SEAT RECLINING….135
SEAT RECLINING : Diagnosis Procedure….135
SEAT LIFTING (FRONT)….135
SEAT LIFTING (FRONT) : Diagnosis Procedure….135
SEAT LIFTING (REAR)….135
SEAT LIFTING (REAR) : Diagnosis Procedure….135
STEERING TILT….136
STEERING TILT : Diagnosis Procedure….136
STEERING TELESCOPIC….136
STEERING TELESCOPIC : Diagnosis Procedure….136
DOOR MIRROR….137
DOOR MIRROR : Diagnosis Procedure….137
ENTRY/EXIT ASSIST FUNCTION DOES NOT OPERATE….138
Diagnosis Procedure….138
INTELLIGENT KEY INTERLOCK FUNCTION DOES NOT OPERATE….139
Diagnosis Procedure….139
MEMORY INDICATE DOES NOT OPERATE….140
Diagnosis Procedure….140
NORMAL OPERATING CONDITION….141
Description….141
REMOVAL AND INSTALLATION….142
DRIVER SEAT CONTROL UNIT….142
Removal and Installation….142
REMOVAL….142
INSTALLATION….142
AUTOMATIC DRIVE POSITIONER CONTROL UNIT….143
Removal and Installation….143
REMOVAL….143
INSTALLATION….143
SEAT MEMORY SWITCH….144
Removal and Installation….144
REMOVAL….144
INSTALLATION….144
POWER SEAT SWITCH….145
Removal and Installation….145
REMOVAL….145
INSTALLATION….145
TILT&TELESCOPIC SWITCH….146
Removal and Installation….146
REMOVAL….146
INSTALLATION….146
av….147
Table of Contents….147
BOSE AUDIO WITH NAVIGATION….155
PRECAUTION….155
PRECAUTIONS….155
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….155
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….155
Precautions for Removing Battery Terminal….155
Precaution for Trouble Diagnosis….155
AV COMMUNICATION SYSTEM….155
Precaution for Harness Repair….156
AV COMMUNICATION SYSTEM….156
PREPARATION….157
PREPARATION….157
Commercial Service Tools….157
Lubricant or/and Sealant….157
SYSTEM DESCRIPTION….158
COMPONENT PARTS….158
Component Parts Location….158
Component Description….159
SYSTEM….162
MULTI AV SYSTEM….162
MULTI AV SYSTEM : System Diagram….162
MULTI AV SYSTEM : System Description….163
COMMUNICATION SIGNAL….163
NAVIGATION SYSTEM FUNCTION….163
Description….163
Position Detection Principle….163
Map-matching….164
GPS (Global Positioning System)….165
AUDIO FUNCTION….165
Description….165
Operating Signal….166
Screen Display….166
AM/FM Radio Mode….166
Satellite Radio Mode….166
CD Mode….166
Bluetooth® Audio Mode….167
Music Box Mode (For Mexico)….167
Speed Sensitive Volume….167
Driver's Audio Stage….167
BOSE® Centerpoint® 2 (BOSE® Studio Surround® Sound System)….167
DVD PLAY FUNCTION….167
USB CONNECTION FUNCTION….167
FRONT AUXILIARY INPUT FUNCTION….168
MOBILE ENTERTAINMENT SYSTEM….168
Operating Signal….168
Headphone Sound….168
Screen headrest display….168
HANDS-FREE PHONE FUNCTION….168
When A Call Is Originated….168
When Receiving A Call….168
TOUCH PANEL SYSTEM….169
AROUND VIEW MONITOR FUNCTION….169
Around View Monitor Screen….169
Operation Description….170
Camera Image Operation Principle….176
CAMERA ASSISTANCE SONAR FUNCTION….176
System Operation Description….176
Obstacle Detection Distance….176
Sonar Indicator Display….177
Sonar Buzzer Operation….178
VEHICLE INFORMATION FUNCTION….178
INTELLIGENT KEY INTERLOCKING FUNCTION….178
AUTO LIGHT ADJUSTMENT SYSTEM….179
MULTI AV SYSTEM : Fail-Safe (AV Control Unit)….179
FAIL-SAFE CONDITIONS….179
Display….179
DESCRIPTION OF CONTROLS….179
Ability Operation Mode ….179
RELEASE CONDITIONS OF FAIL-SAFE ….179
When The Temperature of HDD Is Low or High….179
MULTI AV SYSTEM : Fail-Safe (Around View Monitor Control Unit)….180
DIAGNOSIS SYSTEM (AV CONTROL UNIT)….183
Description….183
On Board Diagnosis Function….183
MULTIFUNCTION SWITCH AND PRESET SWITCH SELF-DIAGNOSIS FUNCTION….183
Self-diagnosis Mode….183
Finishing Self-diagnosis Mode….183
ON BOARD DIAGNOSIS….183
Description….183
On Board Diagnosis Item….183
METHOD OF STARTING….184
SELF-DIAGNOSIS MODE….185
Detection Range of Self-diagnosis Mode….185
SELF-DIAGNOSIS RESULTS….185
Only Unit Part Is Displayed In Red….185
A Connecting Cable Between Units Is Displayed In Yellow….186
CONFIRMATION/ADJUSTMENT MODE….187
Display Diagnosis….188
Vehicle Signals….188
Speaker Test….189
Navigation….189
Error History….190
Vehicle CAN Diagnosis….195
AV COMM Diagnosis….195
Hands-Free Phone….195
XM….196
Delete Unit Connection Log….196
Initialize Settings….196
Version Information….197
CONSULT Function….197
APPLICATION ITEMS….197
AV Communication….197
ECU IDENTIFICATION….197
SELF DIAGNOSIS RESULT….197
DATA MONITOR….197
ALL SIGNALS….198
SELECTION FROM MENU….198
WORK SUPPORT….198
CONFIGURATION….198
DIAGNOSIS SYSTEM (AROUND VIEW MONITOR CONTROL UNIT)….200
CONSULT Function….200
CONSULT FUNCTIONS….200
ECU IDENTIFICATION….200
SELF DIAGNOSIS RESULT….200
Freeze Frame Data (FFD)….200
DATA MONITOR….200
WORK SUPPORT….201
CONFIGURATION….202
DIAGNOSIS SYSTEM (SONAR CONTROL UNIT)….204
CONSULT Function….204
CONSULT FUNCTIONS….204
ECU IDENTIFICATION INFORMATION….204
SELF DIAGNOSIS RESULT….204
Freeze Frame Data (FFD)….204
DATA MONITOR….204
ACTIVE TEST….206
Work Support….206
CONFIGURATION….206
DIAGNOSIS SYSTEM (HEADREST DISPLAY UNIT)….207
Description….207
On Board Diagnosis Function….207
METHOD OF STARTING….207
ECU DIAGNOSIS INFORMATION….208
AV CONTROL UNIT….208
Reference Value….208
VALUES ON THE DIAGNOSIS TOOL….208
TERMINAL LAYOUT….208
PHYSICAL VALUES….208
Fail-Safe….215
FAIL-SAFE CONDITIONS….215
Display….215
DESCRIPTION OF CONTROLS….215
Ability Operation Mode ….215
RELEASE CONDITIONS OF FAIL-SAFE ….215
When The Temperature of HDD Is Low or High….215
DTC Index….215
SELF-DIAGNOSIS RESULTS DISPLAY ITEM….215
FRONT DISPLAY UNIT….218
Reference Value….218
TERMINAL LAYOUT….218
PHYSICAL VALUES….218
HEADREST DISPLAY UNIT….220
Reference Value….220
TERMINAL LAYOUT….220
PHYSICAL VALUES….220
VIDEO DISTRIBUTOR….222
Reference Value….222
TERMINAL LAYOUT….222
PHYSICAL VALUES….222
BOSE AMP….226
Reference Value….226
TERMINAL LAYOUT….226
PHYSICAL VALUES (13 SPEAKERS MODELS)….226
PHYSICAL VALUES (15 SPEAKERS MODELS)….228
AROUND VIEW MONITOR CONTROL UNIT….232
Reference Value….232
VALUES ON THE DIAGNOSIS TOOL….232
TERMINAL LAYOUT….233
PHYSICAL VALUES….233
Fail-Safe….237
DTC Index….239
SONAR CONTROL UNIT (WITH AROUND VIEW MONITOR)….240
Reference Value….240
VALUES ON THE DIAGNOSIS TOOL….240
TERMINAL LAYOUT….241
PHYSICAL VALUES….241
Without Backup Collision Intervention….242
With Backup Collision Intervention….243
DTC Index….245
WIRING DIAGRAM….246
BOSE AUDIO WITH NAVIGATION….246
Wiring Diagram….246
BASIC INSPECTION….277
DIAGNOSIS AND REPAIR WORK FLOW….277
Work Flow (Multi AV)….277
OVERALL SEQUENCE….277
DETAILED FLOW….277
Work Flow (Around View Monitor)….279
OVERALL SEQUENCE….279
DETAILED FLOW….279
Work Flow (Camera Assistance Sonar)….281
OVERALL SEQUENCE….281
DETAILED FLOW….281
INSPECTION AND ADJUSTMENT….283
ADDITIONAL SERVICE WHEN REPLACING AV CONTROL UNIT….283
ADDITIONAL SERVICE WHEN REPLACING AV CONTROL UNIT : Description….283
ADDITIONAL SERVICE WHEN REPLACING AROUND VIEW MONITOR CONTROL UNIT….283
ADDITIONAL SERVICE WHEN REPLACING AROUND VIEW MONITOR CONTROL UNIT : Description….283
ADDITIONAL SERVICE WHEN REPLACING SONAR CONTROL UNIT….283
ADDITIONAL SERVICE WHEN REPLACING SONAR CONTROL UNIT : Description….283
CONFIGURATION (AV CONTROL UNIT)….283
CONFIGURATION (AV CONTROL UNIT) : Special Repair Requirement….283
CONFIGURATION (AROUND VIEW MONITOR CONTROL UNIT)….285
CONFIGURATION (AROUND VIEW MONITOR CONTROL UNIT) : Special Repair Requirement….285
CONFIGURATION (SONAR CONTROL UNIT)….286
CONFIGURATION (SONAR CONTROL UNIT) : Special Repair Requirement….286
PREDICTIVE COURSE LINE CENTER POSITION ADJUSTMENT….287
PREDICTIVE COURSE LINE CENTER POSITION ADJUSTMENT : Description….287
PREDICTIVE COURSE LINE CENTER POSITION ADJUSTMENT : Special Repair Requirement….287
CALIBRATING CAMERA IMAGE (AROUND VIEW MONITOR)….287
CALIBRATING CAMERA IMAGE (AROUND VIEW MONITOR) : Description….287
CALIBRATING CAMERA IMAGE (AROUND VIEW MONITOR) : Special Repair Requirement….288
DTC/CIRCUIT DIAGNOSIS….293
U0428 STEERING ANGLE SENSOR….293
DTC Logic….293
Diagnosis Procedure….293
U1000 CAN COMM CIRCUIT….294
AV CONTROL UNIT….294
AV CONTROL UNIT : Description….294
AV CONTROL UNIT : DTC Logic….294
DTC DETECTION LOGIC….294
AV CONTROL UNIT : Diagnosis Procedure….294
AROUND VIEW MONITOR CONTROL UNIT….294
AROUND VIEW MONITOR CONTROL UNIT : Description….294
AROUND VIEW MONITOR CONTROL UNIT : DTC Logic….294
DTC DETECTION LOGIC….294
AROUND VIEW MONITOR CONTROL UNIT : Diagnosis Procedure….294
SONAR CONTROL UNIT (WITH AROUND VIEW MONITOR)….295
SONAR CONTROL UNIT (WITH AROUND VIEW MONITOR) : Description….295
SONAR CONTROL UNIT (WITH AROUND VIEW MONITOR) : DTC Logic….295
DTC DETECTION LOGIC….295
SONAR CONTROL UNIT (WITH AROUND VIEW MONITOR) : Diagnosis Procedure….295
U1010 CONTROL UNIT (CAN)….296
AV CONTROL UNIT….296
AV CONTROL UNIT : DTC Logic….296
DTC DETECTION LOGIC….296
AROUND VIEW MONITOR CONTROL UNIT….296
AROUND VIEW MONITOR CONTROL UNIT : DTC Logic….296
DTC DETECTION LOGIC….296
SONAR CONTROL UNIT (WITH AROUND VIEW MONITOR)….296
SONAR CONTROL UNIT (WITH AROUND VIEW MONITOR) : DTC Logic….296
DTC DETECTION LOGIC….296
U111A REAR CAMERA IMAGE SIGNAL CIRCUIT….297
DTC Logic….297
Diagnosis Procedure….297
U111B SIDE CAMERA RH IMAGE SIGNAL CIRCUIT….299
DTC Logic….299
Diagnosis Procedure….299
U111C FRONT CAMERA IMAGE SIGNAL CIRCUIT….301
DTC Logic….301
Diagnosis Procedure….301
U111D SIDE CAMERA LH IMAGE SIGNAL CIRCUIT….303
DTC Logic….303
Diagnosis Procedure….303
U1200 AV CONTROL UNIT….305
DTC Logic….305
U1201 AV CONTROL UNIT….306
DTC Logic….306
U1202 AV CONTROL UNIT….307
DTC Logic….307
U1204 AV CONTROL UNIT….308
Description….308
DTC Logic….308
Diagnosis Procedure….308
U1205 AV CONTROL UNIT….309
Description….309
DTC Logic….309
Diagnosis Procedure….309
U1206 AV CONTROL UNIT….310
Description….310
DTC Logic….310
Diagnosis Procedure….310
U1207 AV CONTROL UNIT….311
Description….311
DTC Logic….311
Diagnosis Procedure….311
U1216 AV CONTROL UNIT….312
DTC Logic….312
U1217 AV CONTROL UNIT….313
DTC Logic….313
U1218 AV CONTROL UNIT….314
DTC Logic….314
Diagnosis Procedure….314
U1219 AV CONTROL UNIT….315
DTC Logic….315
Diagnosis Procedure….315
U121A AV CONTROL UNIT….316
DTC Logic….316
Diagnosis Procedure….316
U121B AV CONTROL UNIT….317
DTC Logic….317
Diagnosis Procedure….317
U121C AV CONTROL UNIT….318
DTC Logic….318
Diagnosis Procedure….318
U121D AV CONTROL UNIT….319
DTC Logic….319
Diagnosis Procedure….319
U121E AV CONTROL UNIT….320
DTC Logic….320
Diagnosis Procedure….320
U1225 AV CONTROL UNIT….321
DTC Logic….321
DTC DETECTION LOGIC….321
U1227 AV CONTROL UNIT….322
DTC Logic….322
Diagnosis Procedure….322
U1228 AV CONTROL UNIT….323
DTC Logic….323
DTC DETECTION LOGIC….323
U1229 AV CONTROL UNIT….324
DTC Logic….324
DTC DETECTION LOGIC….324
U122A AV CONTROL UNIT….325
DTC Logic….325
Diagnosis Procedure….325
U122E AV CONTROL UNIT….326
DTC Logic….326
DTC DETECTION LOGIC….326
U1231 BOSE AMP….327
DTC Logic….327
U1232 STEERING ANGLE SENSOR….328
AV CONTROL UNIT….328
AV CONTROL UNIT : DTC Logic….328
AV CONTROL UNIT : Diagnosis Procedure….328
AROUND VIEW MONITOR CONTROL UNIT….328
AROUND VIEW MONITOR CONTROL UNIT : DTC Logic….328
AROUND VIEW MONITOR CONTROL UNIT : Diagnosis Procedure….328
U1243 FRONT DISPLAY UNIT….329
DTC Logic….329
Diagnosis Procedure….329
U1244 GPS ANTENNA….331
DTC Logic….331
Diagnosis Procedure….331
U1258 SATELLITE RADIO ANTENNA….332
DTC Logic….332
Diagnosis Procedure….332
U125A HEADREST DISPLAY UNIT….333
DTC Logic….333
Diagnosis Procedure….333
U1263 USB….334
DTC Logic….334
Diagnosis Procedure….334
U1264 ANTENNA AMP….335
DTC Logic….335
Diagnosis Procedure….335
U1265 BOSE AMP….336
DTC Logic….336
Diagnosis Procedure….336
U1300 AV COMM CIRCUIT….337
Description….337
SELF-DIAGNOSIS RESULTS DISPLAY ITEM….337
U1302 CAMERA POWER VOLT….339
DTC Logic….339
Diagnosis Procedure….339
U1303 LED POWER SUPPLY VOLT….343
DTC Logic….343
Diagnosis Procedure….343
U1304 CAMERA IMAGE CALIBRATION….344
DTC Logic….344
Diagnosis Procedure….344
U1305 CONFIG UNFINISH….345
DTC Logic….345
Diagnosis Procedure….345
U1310 AV CONTROL UNIT….346
DTC Logic….346
U1601, U1603, U1609, U160B FRONT DOOR SPEAKER/TWEETER….347
DTC Logic….347
DTC DETECTION LOGIC….347
Diagnosis Procedure….347
U1627, U162F SQUAWKER….348
DTC Logic….348
DTC DETECTION LOGIC….348
Diagnosis Procedure….348
U162A CENTER SPEAKER….349
DTC Logic….349
DTC DETECTION LOGIC….349
Diagnosis Procedure….349
U1684, U1687, U168C, U168F REAR DOOR SPEAKER/TWEETER….350
DTC Logic….350
DTC DETECTION LOGIC….350
Diagnosis Procedure….350
U175D WOOFER….351
DTC Logic….351
DTC DETECTION LOGIC….351
Diagnosis Procedure….351
U176A, U1772 ROOF SPEAKER….352
DTC Logic….352
DTC DETECTION LOGIC….352
Diagnosis Procedure….352
B2720 CORNER SENSOR [RL]….353
DTC Logic….353
DTC DETECTION LOGIC….353
DTC CONFIRMATION PROCEDURE….353
SHORT-BAT….353
SHORT-BAT : Diagnosis Procedure….353
OPEN/SHORT-GND….354
OPEN/SHORT-GND : Diagnosis Procedure….354
SENSOR….354
SENSOR : Diagnosis Procedure….354
CONFIG ERROR….355
CONFIG ERROR : Diagnosis Procedure….355
B2721 CENTER SENSOR [RL]….356
DTC Logic….356
DTC DETECTION LOGIC….356
DTC CONFIRMATION PROCEDURE….356
SHORT-BAT….356
SHORT-BAT : Diagnosis Procedure….356
OPEN/SHORT-GND….357
OPEN/SHORT-GND : Diagnosis Procedure….357
SENSOR….357
SENSOR : Diagnosis Procedure….357
CONFIG ERROR….358
CONFIG ERROR : Diagnosis Procedure….358
B2722 CENTER SENSOR [RR]….359
DTC Logic….359
DTC DETECTION LOGIC….359
DTC CONFIRMATION PROCEDURE….359
SHORT-BAT….359
SHORT-BAT : Diagnosis Procedure….359
OPEN/SHORT-GND….360
OPEN/SHORT-GND : Diagnosis Procedure….360
SENSOR….360
SENSOR : Diagnosis Procedure….360
CONFIG ERROR….361
CONFIG ERROR : Diagnosis Procedure….361
B2723 CORNER SENSOR [RR]….362
DTC Logic….362
DTC DETECTION LOGIC….362
DTC CONFIRMATION PROCEDURE….362
SHORT-BAT….362
SHORT-BAT : Diagnosis Procedure….362
OPEN/SHORT-GND….363
OPEN/SHORT-GND : Diagnosis Procedure….363
SENSOR….363
SENSOR : Diagnosis Procedure….363
CONFIG ERROR….364
CONFIG ERROR : Diagnosis Procedure….364
B2724 SONAR CONTROL UNIT….365
DTC Logic….365
DTC DETECTION LOGIC….365
DTC CONFIRMATION PROCEDURE….365
Diagnosis Procedure….365
B2729 CORNER SENSOR [FL]….366
DTC Logic….366
DTC DETECTION LOGIC….366
DTC CONFIRMATION PROCEDURE….366
SHORT-BAT….366
SHORT-BAT : Diagnosis Procedure….366
OPEN/SHORT-GND….367
OPEN/SHORT-GND : Diagnosis Procedure….367
SENSOR….367
SENSOR : Diagnosis Procedure….367
CONFIG ERROR….368
CONFIG ERROR : Diagnosis Procedure….368
B272A CENTER SENSOR [FL]….369
DTC Logic….369
DTC DETECTION LOGIC….369
DTC CONFIRMATION PROCEDURE….369
SHORT-BAT….369
SHORT-BAT : Diagnosis Procedure….369
OPEN/SHORT-GND….370
OPEN/SHORT-GND : Diagnosis Procedure….370
SENSOR….370
SENSOR : Diagnosis Procedure….370
CONFIG ERROR….371
CONFIG ERROR : Diagnosis Procedure….371
B272B CENTER SENSOR [FR]….372
DTC Logic….372
DTC DETECTION LOGIC….372
DTC CONFIRMATION PROCEDURE….372
SHORT-BAT….372
SHORT-BAT : Diagnosis Procedure….372
OPEN/SHORT-GND….373
OPEN/SHORT-GND : Diagnosis Procedure….373
SENSOR….373
SENSOR : Diagnosis Procedure….373
CONFIG ERROR….374
CONFIG ERROR : Diagnosis Procedure….374
B272C CORNER SENSOR [FR]….375
DTC Logic….375
DTC DETECTION LOGIC….375
DTC CONFIRMATION PROCEDURE….375
SHORT-BAT….375
SHORT-BAT : Diagnosis Procedure….375
OPEN/SHORT-GND….376
OPEN/SHORT-GND : Diagnosis Procedure….376
SENSOR….376
SENSOR : Diagnosis Procedure….376
CONFIG ERROR….377
CONFIG ERROR : Diagnosis Procedure….377
POWER SUPPLY AND GROUND CIRCUIT….378
AV CONTROL UNIT….378
AV CONTROL UNIT : Diagnosis Procedure….378
FRONT DISPLAY UNIT….378
FRONT DISPLAY UNIT : Diagnosis Procedure….379
HEADREST DISPLAY UNIT….379
HEADREST DISPLAY UNIT : Diagnosis Procedure….379
VIDEO DISTRIBUTOR….380
VIDEO DISTRIBUTOR : Diagnosis Procedure….380
BOSE AMP….381
BOSE AMP. : Diagnosis Procedure….381
AROUND VIEW MONITOR CONTROL UNIT….382
AROUND VIEW MONITOR CONTROL UNIT : Diagnosis Procedure….382
SONAR CONTROL UNIT (WITH AROUND VIEW MONITOR)….383
SONAR CONTROL UNIT (WITH AROUND VIEW MONITOR) : Diagnosis Procedure….383
RGB DIGITAL IMAGE SIGNAL CIRCUIT….384
Description….384
Diagnosis Procedure….384
COMPOSITE IMAGE SIGNAL CIRCUIT (AV CONTROL UNIT TO FRONT DISPLAY UNIT)….385
Description….385
Diagnosis Procedure….385
COMPOSITE IMAGE SIGNAL CIRCUIT (AV CONTROL UNIT TO VIDEO DISTRIBUTOR)….386
Description….386
Diagnosis Procedure….386
COMPOSITE IMAGE SIGNAL CIRCUIT (VIDEO DISTRIBUTOR TO HEADREST DISPLAY UNIT)….387
Description….387
Diagnosis Procedure….387
AUX IMAGE SIGNAL CIRCUIT (FRONT AUXILIARY INPUT JACKS TO AV CONTROL UNIT)….389
Description….389
Diagnosis Procedure….389
AUX IMAGE SIGNAL CIRCUIT (REAR AUXILIARY INPUT JACKS TO VIDEO DISTRIBUTOR)….390
Description….390
Diagnosis Procedure….390
IMAGE SWITCH SIGNAL CIRCUIT….391
Description….391
Diagnosis Procedure….391
LOCATION RECOGNITION SIGNAL CIRCUIT….393
Description….393
Diagnosis Procedure….393
DISK EJECT SIGNAL CIRCUIT….394
Description….394
Diagnosis Procedure….394
MODE CHANGE SIGNAL CIRCUIT….395
Description….395
Diagnosis Procedure….395
MICROPHONE SIGNAL CIRCUIT….396
Description….396
Diagnosis Procedure….396
CAMERA IMAGE SIGNAL CIRCUIT….398
Description….398
Diagnosis Procedure….398
FRONT CAMERA COMMUNICATION SIGNAL CIRCUIT….399
Description….399
Diagnosis Procedure….399
REAR CAMERA COMMUNICATION SIGNAL CIRCUIT….400
Description….400
Diagnosis Procedure….400
SIDE CAMERA LH COMMUNICATION SIGNAL CIRCUIT….401
Description….401
Diagnosis Procedure….401
SIDE CAMERA RH COMMUNICATION SIGNAL CIRCUIT….402
Description….402
Diagnosis Procedure….402
RETRACT MOTOR OPERATION SIGNAL CIRCUIT….403
Diagnosis Procedure….403
STEERING SWITCH SIGNAL A CIRCUIT….404
Description….404
Diagnosis Procedure….404
Component Inspection….404
STEERING SWITCH SIGNAL B CIRCUIT….406
Description….406
Diagnosis Procedure….406
Component Inspection….406
STEERING SWITCH GROUND CIRCUIT….408
Description….408
Diagnosis Procedure….408
Component Inspection….408
SYMPTOM DIAGNOSIS….410
MULTI AV SYSTEM SYMPTOMS….410
Symptom Table….410
RELATED TO NAVIGATION….410
RELATED TO HANDS-FREE PHONE (EXCEPT FOR MEXICO)….410
Check Compatibility….410
RELATED TO HANDS-FREE PHONE (FOR MEXICO)….411
RELATED TO AROUND VIEW MONITOR….412
RELATED TO CAMERA ASSISTANCE SONAR….413
RELATED TO RGB IMAGE….413
RELATED TO AUDIO (13 SPEAKERS MODELS)….413
RELATED TO AUDIO (15 SPEAKERS MODELS)….414
RELATED TO VOICE CONTROL….415
RELATED TO STEERING SWITCH….416
RELATED TO USB….416
RELATED TO DVD MODE….416
RELATED TO FRONT AUXILIARY INPUT….416
RELATED TO REAR DISPLAY….417
RELATED TO HEADPHONE….417
RELATED TO HEADREST DISPLAY UNIT AND REAR AUXILIARY INPUT….418
NORMAL OPERATING CONDITION….420
Description….420
BASIC OPERATIONS….420
RELATED TO VOICE RECOGNITION….420
Related to Basic Operation….420
Related to Item Choice….421
Related to Telephone….421
RELATED TO AUDIO….422
RELATED TO DVD ….423
RELATED TO VEHICLE ICON….423
RELATED TO ROUTE CALCULATION AND VISUAL GUIDANCE ….424
RELATED TO VOICE GUIDANCE….425
RELATED TO TRAFFIC INFORMATION….425
RELATED TO HANDS-FREE PHONE (EXCEPT FOR MEXICO)….426
RELATED TO HANDS-FREE PHONE (FOR MEXICO)….426
RELATED TO SONAR….426
REMOVAL AND INSTALLATION….428
AV CONTROL UNIT….428
Removal and Installation….428
REMOVAL….428
INSTALLATION….428
FRONT DISPLAY UNIT….429
Removal and Installation….429
REMOVAL….429
INSTALLATION….429
HEADREST DISPLAY UNIT….430
Exploded View….430
Removal and Installation….430
REMOVAL….430
INSTALLATION….430
VIDEO DISTRIBUTOR….431
Removal and Installation….431
REMOVAL….431
INSTALLATION….431
FRONT DOOR SPEAKER….432
Removal and Installation….432
REMOVAL….432
INSTALLATION….432
REAR DOOR SPEAKER….433
Removal and Installation….433
REMOVAL….433
INSTALLATION….433
SQUAWKER….434
Removal and Installation….434
REMOVAL….434
INSTALLATION….434
FRONT DOOR TWEETER….435
Removal and Installation….435
REMOVAL….435
INSTALLATION….435
REAR DOOR TWEETER….436
Removal and Installation….436
REMOVAL….436
INSTALLATION….436
ROOF SPEAKER….437
Removal and Installation….437
REMOVAL….437
INSTALLATION….437
CENTER SPEAKER….438
Removal and Installation….438
REMOVAL….438
INSTALLATION….438
WOOFER….439
Removal and Installation….439
REMOVAL….439
INSTALLATION….439
BOSE AMP….440
Removal and Installation….440
REMOVAL….440
INSTALLATION….440
ANTENNA AMP….441
Removal and Installation….441
REMOVAL….441
VALUES ON DIAGNOSIS TOOL….5815
TERMINAL LAYOUT….5819
PHYSICAL VALUES….5820
Fail-Safe….5820
FAIL-SAFE FUNCTION….5821
Protection Control….5823
REVERSE INHIBIT CONTROL….5823
1ST ENGINE BRAKE PROTECTION CONTROL….5823
TCM HIGH TEMPERATURE PROTECTION CONTROL….5824
DTC Inspection Priority Chart….5824
DTC Index….5825
WIRING DIAGRAM….5827
A/T CONTROL SYSTEM….5827
Wiring Diagram….5827
A/T SHIFT LOCK SYSTEM….5832
Wiring Diagram….5832
BASIC INSPECTION….5835
DIAGNOSIS AND REPAIR WORK FLOW….5835
Work Flow….5835
Diagnostic Work Sheet….5836
DESCRIPTION….5836
WORKSHEET SAMPLE….5836
ADDITIONAL SERVICE WHEN REPLACING TRANSMISSION ASSEMBLY….5838
Description….5838
ADDITIONAL SERVICE WHEN REPLACING CONTROL VALVE & TCM….5839
Description….5839
CALIBRATION OF DECEL G SENSOR….5840
Description….5840
Work Procedure….5840
A/T FLUID COOLER….5841
Cleaning….5841
CLEANING PROCEDURE….5841
DIAGNOSIS PROCEDURE….5842
INSPECTION PROCEDURE….5842
Inspection….5843
STALL TEST….5844
Work Procedure….5844
INSPECTION….5844
JUDGMENT OF STALL TEST….5844
A/T POSITION….5845
Inspection….5845
Adjustment….5845
DTC/CIRCUIT DIAGNOSIS….5846
U0100 LOST COMMUNICATION (ECM A)….5846
DTC Logic….5846
DTC DETECTION LOGIC….5846
DTC CONFIRMATION PROCEDURE….5846
Diagnosis Procedure….5846
U0300 CAN COMMUNICATION DATA….5847
Description….5847
DTC Logic….5847
DTC DETECTION LOGIC….5847
DTC CONFIRMATION PROCEDURE….5847
Diagnosis Procedure….5847
U1000 CAN COMM CIRCUIT….5848
Description….5848
DTC Logic….5848
DTC DETECTION LOGIC….5848
DTC CONFIRMATION PROCEDURE….5848
Diagnosis Procedure….5848
P0615 STARTER RELAY….5849
Description….5849
DTC Logic….5849
DTC DETECTION LOGIC….5849
DTC CONFIRMATION PROCEDURE….5849
Diagnosis Procedure….5849
P0705 TRANSMISSION RANGE SENSOR A….5851
DTC Logic….5851
DTC DETECTION LOGIC….5851
DTC CONFIRMATION PROCEDURE….5851
Diagnosis Procedure….5851
P0710 TRANSMISSION FLUID TEMPERATURE SENSOR A….5852
DTC Logic….5852
DTC DETECTION LOGIC….5852
DTC CONFIRMATION PROCEDURE….5852
Diagnosis Procedure….5853
P0717 INPUT SPEED SENSOR A….5855
DTC Logic….5855
DTC DETECTION LOGIC….5855
DTC CONFIRMATION PROCEDURE….5855
Diagnosis Procedure….5855
P0720 OUTPUT SPEED SENSOR….5856
DTC Logic….5856
DTC DETECTION LOGIC….5856
DTC CONFIRMATION PROCEDURE….5856
Diagnosis Procedure….5856
P0725 ENGINE SPEED….5858
Description….5858
DTC Logic….5858
DTC DETECTION LOGIC….5858
DTC CONFIRMATION PROCEDURE….5858
Diagnosis Procedure….5858
P0729 6GR INCORRECT RATIO….5860
Description….5860
DTC Logic….5860
DTC DETECTION LOGIC….5860
DTC CONFIRMATION PROCEDURE….5860
Diagnosis Procedure….5861
P0730 INCORRECT GEAR RATIO….5862
Description….5862
DTC Logic….5862
DTC DETECTION LOGIC….5862
DTC CONFIRMATION PROCEDURE….5862
Diagnosis Procedure….5862
P0731 1GR INCORRECT RATIO….5864
Description….5864
DTC Logic….5864
DTC DETECTION LOGIC….5864
DTC CONFIRMATION PROCEDURE….5864
Diagnosis Procedure….5865
P0732 2GR INCORRECT RATIO….5866
Description….5866
DTC Logic….5866
DTC DETECTION LOGIC….5866
DTC CONFIRMATION PROCEDURE….5866
Diagnosis Procedure….5867
P0733 3GR INCORRECT RATIO….5868
Description….5868
DTC Logic….5868
DTC DETECTION LOGIC….5868
DTC CONFIRMATION PROCEDURE….5868
Diagnosis Procedure….5869
P0734 4GR INCORRECT RATIO….5870
Description….5870
DTC Logic….5870
DTC DETECTION LOGIC….5870
DTC CONFIRMATION PROCEDURE….5870
Diagnosis Procedure….5871
P0735 5GR INCORRECT RATIO….5872
Description….5872
DTC Logic….5872
DTC DETECTION LOGIC….5872
DTC CONFIRMATION PROCEDURE….5872
Diagnosis Procedure….5873
P0740 TORQUE CONVERTER….5874
DTC Logic….5874
DTC DETECTION LOGIC….5874
DTC CONFIRMATION PROCEDURE….5874
Diagnosis Procedure….5874
P0744 TORQUE CONVERTER….5875
Description….5875
DTC Logic….5875
DTC DETECTION LOGIC….5875
DTC CONFIRMATION PROCEDURE….5875
Diagnosis Procedure….5875
P0745 PRESSURE CONTROL SOLENOID A….5877
DTC Logic….5877
DTC DETECTION LOGIC….5877
DTC CONFIRMATION PROCEDURE….5877
Diagnosis Procedure….5877
P0750 SHIFT SOLENOID A….5878
DTC Logic….5878
DTC DETECTION LOGIC….5878
DTC CONFIRMATION PROCEDURE….5878
Diagnosis Procedure….5878
P0775 PRESSURE CONTROL SOLENOID B….5879
DTC Logic….5879
DTC DETECTION LOGIC….5879
DTC CONFIRMATION PROCEDURE….5879
Diagnosis Procedure….5879
P0780 SHIFT….5880
Description….5880
DTC Logic….5880
DTC DETECTION LOGIC….5880
DTC CONFIRMATION PROCEDURE….5880
Diagnosis Procedure….5880
P0795 PRESSURE CONTROL SOLENOID C….5882
DTC Logic….5882
DTC DETECTION LOGIC….5882
DTC CONFIRMATION PROCEDURE….5882
Diagnosis Procedure….5882
P1705 TP SENSOR….5883
DTC Logic….5883
DTC DETECTION LOGIC….5883
DTC CONFIRMATION PROCEDURE….5883
Diagnosis Procedure….5883
P1721 VEHICLE SPEED SIGNAL….5884
Description….5884
DTC Logic….5884
DTC DETECTION LOGIC….5884
DTC CONFIRMATION PROCEDURE….5884
Diagnosis Procedure….5885
P1730 INTERLOCK….5886
Description….5886
DTC Logic….5886
DTC DETECTION LOGIC….5886
DTC CONFIRMATION PROCEDURE….5886
Judgment of Interlock….5886
Diagnosis Procedure….5887
P1734 7GR INCORRECT RATIO….5888
Description….5888
DTC Logic….5888
DTC DETECTION LOGIC….5888
DTC CONFIRMATION PROCEDURE….5888
Diagnosis Procedure….5889
P1815 M-MODE SWITCH….5890
DTC Logic….5890
DTC DETECTION LOGIC….5890
DTC CONFIRMATION PROCEDURE….5890
Diagnosis Procedure….5890
Component Inspection….5892
P2713 PRESSURE CONTROL SOLENOID D….5893
DTC Logic….5893
DTC DETECTION LOGIC….5893
DTC CONFIRMATION PROCEDURE….5893
Diagnosis Procedure….5893
P2722 PRESSURE CONTROL SOLENOID E….5894
DTC Logic….5894
DTC DETECTION LOGIC….5894
DTC CONFIRMATION PROCEDURE….5894
Diagnosis Procedure….5894
P2731 PRESSURE CONTROL SOLENOID F….5895
DTC Logic….5895
DTC DETECTION LOGIC….5895
DTC CONFIRMATION PROCEDURE….5895
Diagnosis Procedure….5895
P2807 PRESSURE CONTROL SOLENOID G….5896
DTC Logic….5896
DTC DETECTION LOGIC….5896
DTC CONFIRMATION PROCEDURE….5896
Diagnosis Procedure….5896
MAIN POWER SUPPLY AND GROUND CIRCUIT….5897
Diagnosis Procedure….5897
TOW MODE SYSTEM….5900
Component Function Check….5900
Diagnosis Procedure….5900
Component Inspection….5902
SHIFT POSITION INDICATOR CIRCUIT….5904
Description….5904
Component Function Check….5904
Diagnosis Procedure….5904
SHIFT LOCK SYSTEM….5905
Component Function Check….5905
Diagnosis Procedure….5905
Component Inspection (Stop Lamp Switch)….5909
Component Inspection (Remote Engine Start Relay)….5910
Component Inspection (Park Position Switch)….5910
Component Inspection (Shift Lock Solenoid)….5910
SELECTOR LEVER POSITION INDICATOR….5911
Component Function Check….5911
Diagnosis Procedure….5911
Component Inspection (Selector Lever Position Indicator)….5913
SYMPTOM DIAGNOSIS….5915
SYSTEM SYMPTOM….5915
Symptom Table….5915
SYMPTOM TABLE 1….5915
SYMPTOM TABLE 2….5919
PERIODIC MAINTENANCE….5925
A/T FLUID….5925
Inspection….5925
FLUID LEAKAGE….5925
Changing….5925
Adjustment….5927
REMOVAL AND INSTALLATION….5928
A/T SHIFT SELECTOR….5928
Exploded View….5928
Removal and Installation….5928
REMOVAL….5928
INSTALLATION….5929
Inspection and Adjustment….5929
INSPECTION AFTER INSTALLATION….5929
ADJUSTMENT AFTER INSTALLATION….5929
CONTROL CABLE….5930
Exploded View….5930
Removal and Installation….5930
REMOVAL….5930
INSTALLATION….5931
Inspection and Adjustment….5931
INSPECTION AFTER INSTALLATION….5931
ADJUSTMENT AFTER INSTALLATION….5931
SELECTOR LEVER POSITION INDICATOR….5932
Removal and Installation….5932
REMOVAL….5932
INSTALLATION….5932
TOW MODE SWITCH….5933
Removal and Installation….5933
REMOVAL….5933
INSTALLATION….5933
CONTROL VALVE & TCM….5934
Exploded View….5934
Removal and Installation….5934
REMOVAL….5934
INSTALLATION….5936
Inspection and Adjustment….5938
INSPECTION AFTER REMOVAL….5938
INSPECTION AFTER INSTALLATION….5938
ADJUSTMENT AFTER INSTALLATION….5938
PARKING COMPONENTS….5939
2WD….5939
2WD : Exploded View….5939
2WD : Removal and Installation….5939
REMOVAL….5939
INSTALLATION….5942
2WD : Inspection….5942
INSPECTION AFTER REMOVAL….5942
INSPECTION AFTER INSTALLATION….5943
REAR OIL SEAL….5944
2WD….5944
2WD : Exploded View….5944
2WD : Removal and Installation….5944
REMOVAL….5944
INSTALLATION….5944
2WD : Inspection….5945
INSPECTION AFTER INSTALLATION….5945
ADJUSTMENT AFTER INSTALLATION….5945
4WD….5945
4WD : Exploded View….5945
4WD : Removal and Installation….5945
REMOVAL….5945
INSTALLATION….5945
4WD : Inspection and Adjustment….5946
INSPECTION AFTER INSTALLATION….5946
ADJUSTMENT AFTER INSTALLATION….5946
OUTPUT SPEED SENSOR….5947
2WD….5947
2WD : Exploded View….5947
2WD : Removal and Installation….5947
REMOVAL….5947
INSTALLATION….5949
2WD : Inspection and Adjustment….5950
INSPECTION AFTER REMOVAL….5950
INSPECTION AFTER INSTALLATION….5950
AIR BREATHER HOSE….5951
2WD….5951
2WD : Exploded View….5951
2WD : Removal and Installation….5951
REMOVAL….5951
INSTALLATION….5951
4WD….5952
4WD : Exploded View….5952
4WD : Removal and Installation….5953
REMOVAL….5953
INSTALLATION….5953
FLUID COOLER SYSTEM….5955
Exploded View….5955
Removal and Installation….5955
REMOVAL….5955
INSTALLATION….5956
Inspection and Adjustment….5957
INSPECTION AFTER INSTALLATION….5957
ADJUSTMENT AFTER INSTALLATION….5957
UNIT REMOVAL AND INSTALLATION….5958
TRANSMISSION ASSEMBLY….5958
2WD….5958
2WD : Exploded View….5958
2WD : Removal and Installation….5958
REMOVAL….5958
INSTALLATION….5959
2WD : Inspection and Adjustment….5960
INSPECTION BEFORE INSTALLATION….5960
INSPECTION AFTER INSTALLATION….5960
ADJUSTMENT AFTER INSTALLATION….5960
4WD….5960
4WD : Exploded View….5961
4WD : Removal and Installation….5961
REMOVAL….5961
INSTALLATION….5962
4WD : Inspection and Adjustment….5963
INSPECTION BEFORE INSTALLATION….5963
INSPECTION AFTER INSTALLATION….5963
ADJUSTMENT AFTER INSTALLATION….5963
UNIT DISASSEMBLY AND ASSEMBLY….5964
TRANSMISSION ASSEMBLY….5964
Exploded View….5964
2WD MODELS….5964
4WD MODELS….5969
Oil Channel….5975
Location of Needle Bearings and Bearing Races….5975
2WD MODELS….5975
4WD MODELS….5977
Location of Snap Rings….5978
2WD MODELS….5978
4WD MODELS….5979
Disassembly….5979
Assembly….5996
Inspection….6020
INSPECTION AFTER DISASSEMBLY….6020
Oil Pan….6020
Torque Converter….6020
1st One-way Clutch….6021
Under Drive Sun Gear….6021
Mid Carrier Assembly….6021
Rear Carrier Assembly….6021
Reverse Brake Retaining Plate/Drive Plates/Driven Plates/Dish Plates….6021
Front Brake Retaining Plates/Drive Plates/Driven Plate….6021
Each Snap Ring….6021
Parking Actuator Support and Parking Pawl….6021
OIL PUMP, 2346 BRAKE, FRONT BRAKE PISTON….6023
Exploded View….6023
Disassembly….6023
Assembly….6027
Inspection and Adjustment….6030
INSPECTION AFTER DISASSEMBLY….6030
Each Snap Ring….6030
Each Spring Retainer….6030
2346 Brake Retaining Plate/Drive Plates/Driven Plates/Dish Plate….6030
ADJSTMENT AFTER ASSEMBLY….6030
2346 Brake Clearance….6030
UNDER DRIVE CARRIER, FRONT BRAKE HUB….6032
Exploded View….6032
Disassembly….6032
Assembly….6033
Inspection….6033
INSPECTION AFTER DISASSEMBLY….6033
FRONT CARRIER, INPUT CLUTCH, REAR INTERNAL GEAR….6035
Exploded View….6035
Disassembly….6036
Assembly….6037
Inspection….6039
INSPECTION AFTER DISASSEMBLY….6039
Front Carrier Snap Ring….6039
Input Clutch Snap Ring….6039
Input Clutch Drum….6039
Input Clutch Retaining Plate/Drive Plates/Driven Plates/Dish Plate….6039
Front Carrier….6039
Rear Internal Gear….6039
MID SUN GEAR, REAR SUN GEAR, HIGH AND LOW REVERSE CLUTCH HUB….6040
Exploded View….6040
Disassembly….6040
Assembly….6042
Inspection….6044
INSPECTION AFTER DISASSEMBLY….6044
2nd One-way Clutch….6044
Each Snap Ring….6044
2nd One-way Clutch….6044
Mid Sun Gear….6044
Rear Sun Gear….6044
High and Low Reverse Clutch Hub….6044
HIGH AND LOW REVERSE CLUTCH….6045
Exploded View….6045
Disassembly….6045
Assembly….6046
Inspection….6046
INSPECTION AFTER DISASSEMBLY….6046
Snap Ring….6046
High and Low Reverse Clutch Retaining Plate/Drive Plates/Driven Plates/Dish Plate….6046
High and Low Reverse Clutch Drum….6046
DIRECT CLUTCH….6047
Exploded View….6047
Disassembly….6047
Assembly….6047
Inspection….6048
INSPECTION AFTER DISASSEMBLY….6048
Snap Ring….6048
Direct Clutch Retaining Plate/Drive Plates/Driven Plates/Dish Plates….6048
Direct Clutch Drum….6048
SERVICE DATA AND SPECIFICATIONS (SDS)….6049
SERVICE DATA AND SPECIFICATIONS (SDS)….6049
General Specification….6049
Vehicle Speed at Which Gear Shifting Occurs….6049
NORMAL MODE….6049
TOW MODE….6049
Vehicle Speed at Which Lock-up Occurs/Releases….6050
Stall Speed….6050
2WD MODELS….6050
4WD MODELS….6050
Torque Converter….6050
Total End Play….6050
Reverse Brake Clearance….6051
Front Brake Clearance….6051
2346 Brake Clearance….6051
vtl….6052
Table of Contents….6052
PRECAUTION….6054
PRECAUTIONS….6054
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….6054
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….6054
Precautions for Removing Battery Terminal….6054
Precaution for Procedure without Cowl Top Cover….6055
PREPARATION….6056
PREPARATION….6056
Commercial Service Tool….6056
SYSTEM DESCRIPTION….6057
VENTILATION SYSTEM….6057
VENTILATION SYSTEM (FRONT AIR CONDITIONING)….6057
VENTILATION SYSTEM (FRONT AIR CONDITIONING) : System Description….6057
OUTLINE….6057
AIR FLOW….6057
Front….6057
Rear….6057
AIR DISTRIBUTION ….6057
Front A/C Unit….6057
VENTILATION SYSTEM (REAR AIR CONDITIONING)….6058
VENTILATION SYSTEM (REAR AIR CONDITIONING) : System Description….6058
OUTLINE….6058
AIR FLOW….6058
AIR DISTRIBUTION ….6058
Rear A/C Unit….6058
REMOVAL AND INSTALLATION….6059
DUCT AND GRILLE….6059
Exploded View….6059
FRONT….6059
REAR….6060
CENTER VENTILATOR GRILLE….6061
CENTER VENTILATOR GRILLE : Removal and Installation….6061
REMOVAL….6061
INSTALLATION….6061
SIDE VENTILATOR GRILLE….6061
SIDE VENTILATOR GRILLE : Removal and Installation….6061
REMOVAL….6061
INSTALLATION….6061
FRONT DEFROSTER GRILLE….6061
FRONT DEFROSTER GRILLE : Removal and Installation….6061
REMOVAL….6061
INSTALLATION….6061
UPPER VENTILATOR GRILLE….6061
UPPER VENTILATOR GRILLE : Removal and Installation….6061
REMOVAL….6061
INSTALLATION….6061
SIDE VENTILATOR DUCT….6061
SIDE VENTILATOR DUCT : Removal and Installation….6061
REMOVAL….6061
INSTALLATION….6061
UPPER VENTILATOR DUCT….6061
UPPER VENTILATOR DUCT : Removal and Installation….6061
REMOVAL….6061
INSTALLATION….6062
FRONT DEFROSTER NOZZLE….6062
FRONT DEFROSTER NOZZLE : Removal and Installation….6062
REMOVAL….6062
INSTALLATION….6062
SIDE DEFROSTER NOZZLE….6062
SIDE DEFROSTER NOZZLE : Removal and Installation….6062
REMOVAL….6062
INSTALLATION….6062
FLOOR DUCT 1….6062
FLOOR DUCT 1 : Removal and Installation….6062
REMOVAL….6062
INSTALLATION….6062
FLOOR DUCT 2….6062
FLOOR DUCT 2 : Removal and Installation….6062
REMOVAL….6062
INSTALLATION….6062
FLOOR DUCT 3….6062
FLOOR DUCT 3 : Removal and Installation….6062
REMOVAL….6062
INSTALLATION….6062
REAR FLOOR GRILLE….6062
REAR FLOOR GRILLE : Removal and Installation….6063
REMOVAL….6063
INSTALLATION….6063
FOOT DUCT….6063
FOOT DUCT : Removal and Installation….6063
REMOVAL….6063
INSTALLATION….6063
FOOT GRILLE….6063
FOOT GRILLE : Removal and Installation….6063
REMOVAL….6063
Driver side….6063
Passenger side….6063
INSTALLATION….6063
REAR VENTILATOR DUCT LOWER….6063
REAR VENTILATOR DUCT LOWER : Removal and Installation….6063
REMOVAL….6063
INSTALLATION….6063
REAR VENTILATOR DUCT UPPER….6063
REAR VENTILATOR DUCT UPPER : Removal and Installation….6063
REMOVAL….6063
INSTALLATION….6063
ROOF DUCT….6063
ROOF DUCT : Removal and Installation….6064
REMOVAL….6064
INSTALLATION….6064
REAR VENTILATOR GRILLE….6064
REAR VENTILATOR GRILLE : Removal and Installation….6064
REMOVAL….6064
INSTALLATION….6064
BLOWER UNIT….6065
Exploded View….6065
REMOVAL….6065
DISASSEMBLY….6065
Removal and Installation….6066
REMOVAL….6066
INSTALLATION….6066
BLOWER MOTOR….6067
FRONT A/C UNIT….6067
FRONT A/C UNIT : Exploded View….6067
FRONT A/C UNIT : Removal and Installation….6067
REMOVAL….6067
INSTALLATION….6067
REAR A/C UNIT ASSEMBLY….6067
REAR A/C UNIT ASSEMBLY : Exploded View….6067
REAR A/C UNIT ASSEMBLY : Removal and Installation….6067
REMOVAL….6067
IN-CABIN MICROFILTER….6068
Exploded View….6068
Removal and Installation….6068
REMOVAL….6068
INSTALLATION….6068
Replacement….6068
SERVICE DATA AND SPECIFICATIONS (SDS)….6069
SERVICE DATA AND SPECIFICATIONS (SDS)….6069
In-cabin microfilter….6069
wcs….6070
Table of Contents….6070
PRECAUTION….6072
PRECAUTIONS….6072
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….6072
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….6072
Precautions for Removing Battery Terminal….6072
SYSTEM DESCRIPTION….6073
COMPONENT PARTS….6073
Component Parts Location….6073
Component Description….6073
Combination Meter….6074
SYSTEM….6075
WARNING CHIME SYSTEM….6075
WARNING CHIME SYSTEM : System Diagram….6075
WARNING CHIME SYSTEM : System Description….6075
COMBINATION METER….6075
BCM….6075
WARNING CHIME FUNCTION LIST….6075
WARNING CHIME SYSTEM : Fail-Safe….6076
FAIL-SAFE….6076
LIGHT REMINDER WARNING CHIME….6077
LIGHT REMINDER WARNING CHIME : System Diagram….6077
LIGHT REMINDER WARNING CHIME : System Description….6077
WARNING CHIME OPERATION CONDITIONS….6077
WARNING CHIME CANCEL CONDITIONS….6078
SIGNAL PATH….6078
TIMING CHART….6078
FRONT FOG LIGHT REMINDER WARNING CHIME….6078
FRONT FOG LIGHT REMINDER WARNING CHIME : System Diagram….6079
FRONT FOG LIGHT REMINDER WARNING CHIME : System Description….6079
WARNING CHIME OPERATION CONDITIONS….6079
SIGNAL PATH….6079
TIMING CHART….6079
SEAT BELT WARNING CHIME….6079
SEAT BELT WARNING CHIME : System Diagram….6080
SEAT BELT WARNING CHIME : System Description….6080
WARNING OPERATION CONDITIONS….6080
WARNING CANCEL CONDITIONS….6080
SIGNAL PATH….6080
TIMING CHART….6081
SOUND SPECIFICATION….6081
PARKING BRAKE RELEASE WARNING CHIME….6081
PARKING BRAKE RELEASE WARNING CHIME : System Diagram….6081
PARKING BRAKE RELEASE WARNING CHIME : System Description….6081
WARNING OPERATION CONDITIONS….6081
WARNING CANCEL CONDITIONS….6081
SIGNAL PATH….6082
TIMING CHART….6082
SOUND SPECIFICATION….6082
DIAGNOSIS SYSTEM (COMBINATION METER)….6083
CONSULT Function….6083
CONSULT APPLICATION ITEMS….6083
SELF DIAG RESULT….6083
DATA MONITOR….6083
Display Item List….6083
WARNING HISTORY….6086
Display Item….6086
DIAGNOSIS SYSTEM (BCM)….6088
COMMON ITEM….6088
COMMON ITEM : CONSULT Function (BCM – COMMON ITEM)….6088
APPLICATION ITEM….6088
SYSTEM APPLICATION….6088
FREEZE FRAME DATA (FFD)….6088
BUZZER….6089
BUZZER : CONSULT Function (BCM – BUZZER)….6089
CONSULT APPLICATION ITEMS….6089
DATA MONITOR….6089
ACTIVE TEST….6090
ECU DIAGNOSIS INFORMATION….6091
COMBINATION METER….6091
Reference Value….6091
VALUES ON THE DIAGNOSIS TOOL….6091
TERMINAL LAYOUT….6096
PHYSICAL VALUES….6096
Fail-Safe….6099
FAIL-SAFE….6099
DTC Index….6100
BCM (BODY CONTROL MODULE)….6101
List of ECU Reference….6101
WIRING DIAGRAM….6102
WARNING CHIME SYSTEM….6102
Wiring Diagram….6102
BASIC INSPECTION….6107
DIAGNOSIS AND REPAIR WORKFLOW….6107
Work Flow….6107
OVERALL SEQUENCE….6107
DETAILED FLOW….6107
DTC/CIRCUIT DIAGNOSIS….6109
POWER SUPPLY AND GROUND CIRCUIT….6109
COMBINATION METER….6109
COMBINATION METER : Diagnosis Procedure….6109
METER BUZZER CIRCUIT….6110
Component Function Check….6110
Diagnosis Procedure….6110
SEAT BELT BUCKLE SWITCH SIGNAL CIRCUIT….6111
Component Function Check….6111
Diagnosis Procedure….6111
Component Inspection….6112
PARKING BRAKE SWITCH SIGNAL CIRCUIT….6113
Diagnosis Procedure….6113
Component Inspection….6113
SYMPTOM DIAGNOSIS….6114
THE LIGHT REMINDER WARNING DOES NOT SOUND….6114
Description….6114
Diagnosis Procedure….6114
THE SEAT BELT WARNING CONTINUES SOUNDING, OR DOES NOT SOUND….6115
Description….6115
Diagnosis Procedure….6115
THE PARKING BRAKE RELEASE WARNING CONTINUES SOUNDING, OR DOES NOT SOUND….6116
Description….6116
Diagnosis Procedure….6116
wt….6117
Table of Contents….6117
PRECAUTION….6119
PRECAUTIONS….6119
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….6119
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….6119
Precautions for Removing Battery Terminal….6119
Service Notice and Precautions for TPMS….6119
Service Notice and Precautions for Road Wheel….6120
PREPARATION….6121
PREPARATION….6121
Special Service Tools….6121
Commercial Service Tools….6121
SYSTEM DESCRIPTION….6122
COMPONENT PARTS….6122
Component Parts Location….6122
Component Description….6123
Low Tire Pressure Warning Control Unit….6123
Tire pressure sensor….6123
Tire Pressure Receiver….6124
SYSTEM….6125
System Description….6125
SYSTEM DIAGRAM….6125
INPUT/OUTPUT SIGNAL….6125
LOW TIRE PRESSURE WARNING LAMP CONTROL CONDITION….6126
HAZARD WARNING LAMP CONTROL CONDITION….6126
HORN CONTROL CONDITION….6126
Tire Inflation Indicator Function….6126
DIAGNOSIS SYSTEM (LOW TIRE PRESSURE WARNING CONTROL UNIT)….6128
CONSULT Function….6128
APPLICATION ITEMS….6128
ECU IDENTIFICATION….6128
SELF DIAGNOSIS RESULTS….6128
DATA MONITOR….6128
ACTIVE TEST….6128
WORK SUPPORT….6129
ECU DIAGNOSIS INFORMATION….6130
LOW TIRE PRESSURE WARNING CONTROL UNIT….6130
Reference Value….6130
VALUES ON THE DIAGNOSIS TOOL….6130
TERMINAL LAYOUT….6130
PHYSICAL VALUES….6130
DTC Inspection Priority Chart….6133
DTC Index….6134
WIRING DIAGRAM….6135
TIRE PRESSURE MONITORING SYSTEM….6135
Wiring Diagram….6135
BASIC INSPECTION….6141
DIAGNOSIS AND REPAIR WORK FLOW….6141
Work Flow ….6141
DETAILED FLOW….6141
ADDITIONAL SERVICE WHEN REPLACING LOW TIRE PRESSURE WARNING CONTROL UNIT….6143
Description….6143
Work Procedure….6143
ADJUST THE NEUTRAL POSITION OF STEERING ANGLE SENSOR….6143
TIRE PRESSURE SENSOR WAKE UP OPERATION….6144
Description….6144
Work Procedure….6144
ID REGISTRATION ….6145
Description….6145
Work Procedure….6145
DTC/CIRCUIT DIAGNOSIS….6146
C1704, C1705, C1706, C1707 LOW TIRE PRESSURE….6146
DTC Logic….6146
DTC DETECTION LOGIC….6146
DTC CONFIRMATION PROCEDURE….6146
Diagnosis Procedure….6146
C1708, C1709, C1710, C1711 TIRE PRESSURE SENSOR….6148
DTC Logic….6148
DTC DETECTION LOGIC….6148
DTC CONFIRMATION PROCEDURE….6148
Diagnosis Procedure….6148
C1716, C1717, C1718, C1719 TIRE PRESSURE SENSOR….6152
DTC Logic….6152
DTC DETECTION LOGIC….6152
DTC CONFIRMATION PROCEDURE….6152
Diagnosis Procedure….6152
C1728 RECEIVER ID….6154
DTC Logic….6154
DTC DETECTION LOGIC….6154
DTC CONFIRMATION PROCEDURE….6154
Diagnosis Procedure….6154
C1729 VEHICLE SPEED SIGNAL….6156
DTC Logic….6156
DTC DETECTION LOGIC….6156
DTC CONFIRMATION PROCEDURE….6156
Diagnosis Procedure….6156
C1750, C1751, C1752, C1753 RECEIVER….6157
DTC Logic….6157
DTC DETECTION LOGIC….6157
DTC CONFIRMATION PROCEDURE….6157
Diagnosis Procedure….6157
C1754 LOW TIRE PRESSURE WARNING CONTROL UNIT….6160
DTC Logic….6160
DTC DETECTION LOGIC….6160
DTC CONFIRMATION PROCEDURE….6160
Diagnosis Procedure….6160
C1755, C1756, C1757, C1758 POOR RECEIVING CONDITIONS….6162
DTC Logic….6162
DTC DETECTION LOGIC….6162
DTC CONFIRMATION PROCEDURE….6162
Diagnosis Procedure….6162
U1000 CAN COMM CIRCUIT….6164
Description….6164
DTC Logic….6164
DTC DETECTION LOGIC….6164
DTC CONFIRMATION PROCEDURE….6164
Diagnosis Procedure….6164
U1010 CONTROL UNIT (CAN)….6165
Description….6165
DTC Logic….6165
DTC DETECTION LOGIC….6165
DTC CONFIRMATION PROCEDURE….6165
Diagnosis Procedure….6165
POWER SUPPLY AND GROUND CIRCUIT….6166
Diagnosis Procedure….6166
LOW TIRE PRESSURE WARNING LAMP….6167
Component Function Check….6167
Diagnosis Procedure….6167
SYMPTOM DIAGNOSIS….6168
TPMS SYMPTOMS….6168
Symptom Table….6168
LOW TIRE PRESSURE WARNING LAMP SYMPTOM CHART….6168
LOW TIRE PRESSURE WARNING LAMP DOES NOT TURN ON….6170
Description….6170
Diagnosis Procedure….6170
LOW TIRE PRESSURE WARNING LAMP DOES NOT TURN OFF….6171
Description….6171
Diagnosis Procedure….6171
LOW TIRE PRESSURE WARNING LAMP BLINKS….6172
Description….6172
Diagnosis Procedure….6172
TIRE INFLATION INDICATOR DOES NOT ACTIVATE….6173
Description….6173
Diagnosis Procedure….6173
ID REGISTRATION CANNOT BE COMPLETED….6174
Description….6174
Diagnosis Procedure….6174
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING….6175
NVH Troubleshooting Chart….6175
PERIODIC MAINTENANCE….6176
ROAD WHEEL….6176
Adjustment….6176
BALANCING WHEELS (BONDING WEIGHT TYPE)….6176
Preparation Before Adjustment….6176
Wheel Balance Adjustment….6176
Tire Rotation….6177
REMOVAL AND INSTALLATION….6178
ROAD WHEEL TIRE ASSEMBLY….6178
Exploded View….6178
Removal and Installation….6178
REMOVAL….6178
INSTALLATION….6178
Inspection….6178
ALUMINUM WHEEL….6178
LOW TIRE PRESSURE WARNING CONTROL UNIT….6179
Exploded View….6179
Removal and Installation….6179
REMOVAL….6179
INSTALLATION….6179
TIRE PRESSURE SENSOR….6180
Exploded View….6180
Removal and Installation….6180
REMOVAL….6180
INSTALLATION….6181
TIRE PRESSURE RECEIVER….6182
Exploded View….6182
FRONT TIRE PRESSURE RECEIVER….6182
FRONT TIRE PRESSURE RECEIVER : Removal and Installation….6182
REMOVAL….6182
INSTALLATION….6182
REAR TIRE PRESSURE RECEIVER….6182
REAR TIRE PRESSURE RECEIVER : Removal and Installation….6182
REMOVAL….6182
INSTALLATION….6182
SERVICE DATA AND SPECIFICATIONS (SDS)….6183
SERVICE DATA AND SPECIFICATIONS (SDS)….6183
Road Wheel….6183
ALUMINUM WHEEL….6183
Tire Air Pressure….6183
ww….6184
Table of Contents….6184
PRECAUTION….6186
PRECAUTIONS….6186
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"….6186
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS….6186
Precautions for Removing Battery Terminal….6186
Precaution for Procedure without Cowl Top Cover….6187
Precaution for Battery Service….6187
SYSTEM DESCRIPTION….6188
COMPONENT PARTS….6188
Component Parts Location….6188
Component Description….6189
Washer Switch….6189
SYSTEM….6190
FRONT WIPER AND WASHER SYSTEM….6190
FRONT WIPER AND WASHER SYSTEM : System Diagram….6190
FRONT WIPER AND WASHER SYSTEM : System Description….6190
OUTLINE….6190
FRONT WIPER BASIC OPERATION….6190
FRONT WIPER LO OPERATION….6190
FRONT WIPER HI OPERATION….6190
FRONT WIPER AUTO OPERATION….6191
Rain Detection….6191
Auto Wiping Operation ….6191
Rain Sensor Sensitivity Setting….6191
Splash mode operation….6191
FRONT WIPER AUTO STOP OPERATION….6191
FRONT WIPER OPERATION LINKED WITH WASHER….6192
FRONT WIPER DROP WIPE OPERATION….6192
WIPER LINKED AUTO LIGHTING FUNCTION….6192
FRONT WIPER AND WASHER SYSTEM : Fail-safe….6192
IPDM E/R….6192
IF NO CAN COMMUNICATION IS AVAILABLE WITH BCM….6192
FRONT WIPER PROTECTION FUNCTION….6193
BCM….6193
REAR WIPER AND WASHER SYSTEM….6193
REAR WIPER AND WASHER SYSTEM : System Diagram….6193
REAR WIPER AND WASHER SYSTEM : System Description….6193
OUTLINE….6193
REAR WIPER BASIC OPERATION….6194
REAR WIPER ON OPERATION….6194
REAR WIPER INT OPERATION….6194
REAR WIPER AUTO STOP OPERATION….6194
REAR WIPER OPERATION LINKED WITH WASHER ….6194
REAR WIPER DROP WIPE OPERATION….6195
REAR WIPER AND WASHER SYSTEM : Fail Safe….6195
REAR WIPER MOTOR PROTECTION….6195
HEADLAMP WASHER SYSTEM….6195
HEADLAMP WASHER SYSTEM : System Diagram….6195
HEADLAMP WASHER SYSTEM : System Description….6195
OUTLINE….6195
HEADLAMP WASHER BASIC OPERATION….6195
DIAGNOSIS SYSTEM (BCM)….6197
COMMON ITEM….6197
COMMON ITEM : CONSULT Function (BCM – COMMON ITEM)….6197
APPLICATION ITEM….6197
SYSTEM APPLICATION….6197
FREEZE FRAME DATA (FFD)….6197
WIPER….6198
WIPER : CONSULT Function (BCM – WIPER)….6198
WORK SUPPORT….6198
DATA MONITOR….6199
ACTIVE TEST….6199
DIAGNOSIS SYSTEM (IPDM E/R)….6201
Diagnosis Description….6201
AUTO ACTIVE TEST….6201
Description….6201
Operation Procedure….6201
Inspection in Auto Active Test….6201
Concept of auto active test….6202
Diagnosis chart in auto active test….6202
CONSULT Function (IPDM E/R)….6203
APPLICATION ITEM….6203
SELF DIAGNOSTIC RESULT….6203
DATA MONITOR….6203
ACTIVE TEST….6204
ECU DIAGNOSIS INFORMATION….6206
BCM, IPDM E/R….6206
List of ECU Reference….6206
WIRING DIAGRAM….6207
WIPER AND WASHER SYSTEM….6207
Wiring Diagram….6207
BASIC INSPECTION….6215
DIAGNOSIS AND REPAIR WORK FLOW….6215
Work Flow….6215
OVERALL SEQUENCE….6215
DETAILED FLOW….6215
DTC/CIRCUIT DIAGNOSIS….6218
FRONT WIPER MOTOR LO CIRCUIT….6218
Component Function Check….6218
Diagnosis Procedure….6218
FRONT WIPER MOTOR HI CIRCUIT….6219
Component Function Check….6219
Diagnosis Procedure….6219
FRONT WIPER STOP POSITION SIGNAL CIRCUIT….6220
Component Function Check….6220
Diagnosis Procedure….6220
FRONT WIPER MOTOR GROUND CIRCUIT….6221
Diagnosis Procedure….6221
RAIN SENSOR….6222
Component Function Check….6222
Diagnosis Procedure….6222
WASHER SWITCH….6224
Component Inspection….6224
REAR WIPER MOTOR CIRCUIT….6225
Component Function Check….6225
Diagnosis Procedure….6225
REAR WIPER STOP POSITION SIGNAL CIRCUIT….6227
Component Function Check….6227
Diagnosis Procedure….6227
HEADLAMP WASHER CIRCUIT….6228
Component Function Check….6228
Diagnosis Procedure….6228
Component Inspection….6230
SYMPTOM DIAGNOSIS….6231
WIPER AND WASHER SYSTEM SYMPTOMS….6231
Symptom Table….6231
NORMAL OPERATING CONDITION….6234
Description….6234
FRONT WIPER MOTOR PROTECTION FUNCTION….6234
REAR WIPER MOTOR PROTECTION FUNCTION….6234
FRONT WIPER DOES NOT OPERATE….6235
Description….6235
Diagnosis Procedure….6235
REMOVAL AND INSTALLATION….6237
HEADLAMP WASHER NOZZLE AND TUBE….6237
Exploded View….6237
Hydraulic Layout….6237
Removal and Installation….6238
REMOVAL….6238
INSTALLATION….6238
Inspection….6238
HEADLAMP WASHER NOZZLE SPRAY POSITION INSPECTION….6238
WASHER TANK….6240
Exploded View….6240
Removal and Installation….6240
REMOVAL….6240
INSTALLATION….6241
WASHER PUMP….6242
Exploded View….6242
Removal and Installation….6242
REMOVAL….6242
INSTALLATION….6242
HEADLAMP WASHER PUMP….6243
Exploded View….6243
Removal and Installation….6243
REMOVAL….6243
INSTALLATION….6243
WASHER LEVEL SWITCH….6244
Removal and Installation….6244
FRONT WASHER NOZZLE AND TUBE….6245
Exploded View….6245
Hydraulic Layout….6245
Removal and Installation….6246
REMOVAL….6246
INSTALLATION….6246
Inspection and Adjustment….6246
INSPECTION….6246
Check valve Inspection….6246
ADJUSTMENT….6246
Washer Nozzle Spray Position Adjustment….6246
FRONT WIPER ARM….6248
Exploded View….6248
Removal and Installation….6248
REMOVAL….6248
INSTALLATION….6248
Adjustment….6248
WIPER BLADE POSITION ADJUSTMENT….6248
FRONT WIPER BLADE….6250
Exploded View….6250
Removal and Installation….6250
REMOVAL….6250
INSTALLATION….6250
Replacement….6250
FRONT WIPER DRIVE ASSEMBLY….6252
Exploded View….6252
REMOVAL….6252
DISASSEMBLY….6252
Removal and Installation….6253
REMOVAL….6253
INSTALLATION….6253
Disassembly and Assembly….6253
DISASSEMBLY….6253
ASSEMBLY….6253
LIGHT & RAIN SENSOR….6254
Exploded View….6254
Removal and Installation….6254
REMOVAL….6254
INSTALLATION….6254
WIPER AND WASHER SWITCH….6255
Exploded View….6255
REAR WIPER ARM….6256
Exploded View….6256
Removal and Installation….6256
REMOVAL….6256
INSTALLATION….6256
Adjustment….6256
REAR WIPER BLADE POSITION ADJUSTMENT….6256
REAR WIPER MOTOR….6258
Exploded View….6258
Removal and Installation….6258
REMOVAL….6258
INSTALLATION….6258
REAR WASHER NOZZLE AND TUBE….6259
Hydraulic Layout….6259
Removal and Installation….6259
REMOVAL….6259
INSTALLATION….6260
Inspection and Adjustment….6260
INSPECTION….6260
Washer Nozzle Inspection….6260
ADJUSTMENT….6260
Washer Nozzle Spray Position adjustment….6260
Infiniti QX56/QX80 (Z62-Series) Workshop Repair & Service Manual 2011-2016
Infiniti QX56/QX80 (Z62-Series) Workshop Repair & Service Manual 2011-2016