BMW Z4 2.8i-3.0i-3.5i-3.5is 2009-2016 Service Manual
Complete digital official shop manual contains service, maintenance, and troubleshooting information for the 2002-2016 BMW Z4 (E85/E86/E89) 2.8i/3.0i/3.5i/3.5is. Diagnostic and repair procedures are covered in great detail to repair, maintain, rebuild, refurbish or restore your vehicle like a professional mechanic in local service/repair workshop. This cost-effective quality manual is 100% complete and intact as should be without any missing pages. It is the same factory shop manual used by dealers that guaranteed to be fully functional to save your precious time.
This manual for 2002-2016 BMW Z4 (E85/E86/E89) 2.8i/3.0i/3.5i/3.5is is divided into different sections. Each section covers a specific component or system and, in addition to the standard service procedures, includes disassembling, inspecting, and assembling instructions. A table of contents is placed at the beginning of each section. Pages are easily found by category, and each page is expandable for great detail. It is in the cross-platform PDF document format so that it works like a charm on all kinds of devices. You do not need to be skilled with a computer to use the manual.
EXCERPT:
SUSPENSION Front Axle – Repair – Z4
3121 WHEEL BEARINGS AND STUB AXLE
31 21 180 REMOVING AND INSTALLING/REPLACING BEARING FOR FRONT WHEEL
Necessary preliminary tasks
Remove BRAKE DISC
NOTE: Check brake pads and replace if necessary!
Release screws (1).
Tightening torque 31 21 1AZ .
Press wheel bearing (2) off swivel bearing with a suitable tool.
Installation:
Replace screws.
When reusing, recut all the threads in the wheel bearing.
Keep contact surface (1) of swivel bearing and wheel bearing clean and free from oil and grease.
…
ENGINE
Engine – Repair Instructions – N51, N52, N52K 6-Cylinder
00 ENGINE, GENERAL
00 DANGER OF POISONING IF OIL IS INGESTED/ABSORBED THROUGH THE SKIN Danger of poisoning!
Ingesting oil or absorbing through the skin may cause poisoning!
Possible symptoms are:
Headaches
Dizziness
Stomach aches
Vomiting
Diarrhoea
Cramps/fits
Unconsciousness
Protective measures/rules of conduct:
Pour oil only into appropriately marked containers
Do not pour oil into drinking vessels (drinks bottles, glasses, cups or mugs)
Observe country-specific safety regulations
First aid measures:
Do not induce vomiting.
If the person affected is still conscious, he/she must rinse out their mouth with water, drink plenty of water and consult a doctor immediately.
If the person affected is unconscious, do not administer anything by mouth, place the person in the recovery position and seek immediate medical attention.
00 RISK OF INJURY IF OIL COMES INTO CONTACT WITH EYES AND SKIN
Danger of injury!
NOTE: Removal and installation procedures apply to 3-Series; 5-Series is similar.
…